← New search

1999 Jeep Grand Cherokee

Owner reports · Recalls · Investigations

More warning signs than most Grand Cherokee years

Owner complaints for the 1999 Jeep Grand Cherokee are substantially higher than the model-year median of 726.

About this comparison →

When problems were reported

Mileage at the reported incident

528 reports with mileage · 1,110 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes, Hydraulic. Review the 595 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 386 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Visibility. Review the 162 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

123 crash reports15 fire reports52 injury reports

Engine And Engine Cooling complaints

121 reports
Clear category filter
25,000 miles · Mar 2, 2005
Engine And Engine CoolingFuel System, GasolinePower Train

CONSUMER COMPLAINED ABOUT A TRANSFER CASE PROBLEM. WHEN DRIVING AT APPROXIMATELY 40 MPH THERE WAS A LOUD CLANKING SOUND COMING FROM THE FRONT UNDERCARRIAGE. CONSUMER TOOK THE VEHICLE BACK TO THE DEALER, AND WAS TOLD THE VEHICLE HAD DUSTY BRAKE PADS, BUT THAT WAS NOT THE ISSUE. THEN, CONSUMER WAS TOLD THAT THE CONSTANT VELOCI…

Read full complaint

CONSUMER COMPLAINED ABOUT A TRANSFER CASE PROBLEM. WHEN DRIVING AT APPROXIMATELY 40 MPH THERE WAS A LOUD CLANKING SOUND COMING FROM THE FRONT UNDERCARRIAGE. CONSUMER TOOK THE VEHICLE BACK TO THE DEALER, AND WAS TOLD THE VEHICLE HAD DUSTY BRAKE PADS, BUT THAT WAS NOT THE ISSUE. THEN, CONSUMER WAS TOLD THAT THE CONSTANT VELOCITY JOINTS WERE LEAKING. ALSO, CONSUMER WAS TOLD THAT THE DRIVESHAFT NEEDED TO BE REPLACED. CONSUMER FELT THAT THE DEALERSHIP DID NOT KNOW WHAT THE PROBLEM WAS, AND PERHAPS WAS COVERING UP THE REAL PROBLEM. *AK RECALL CAMPAIGN; COMPONENT: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS. THE CONSUMER STATED THAT THE VEHICLE WOULD NOT START. THE CONSUMER STATED THAT THE ENGINE HAD AN EXTENDED CRANK BEFORE STARTING. FUEL PUMP ASSEMBLY AND PUMP CRANK REPAIR KIT INSTALLED. THE CONSUMER STATED THAT THERE IS A SHIMMY WHEN THE BRAKES ARE APPLIED. WHEN SITTING AT A STOP LIGHT HAVING THE VEHICLE IN GEAR IT VIBRATES. THE LEFT OUTER CV BOOT WAS LEAKING. THE ENGINE LIGHT CAME ON. THE CONSUMER STATED THAT THE TRANSMISSION SLAMS INTO GEAR. *TC

NHTSA ODI #10103107

87,500 miles · Dec 1, 2004
Engine And Engine Cooling

RECALL 04V112000 CONCERNING CRANK SHAFT POSITION SENSOR WIRING: CONSUMER STATED THAT THIS RECALL INFORMATION FOUND ON NHTSA WEBSITE WAS THE SAME PROBLEM THAT HIS VEHICLE WAS EXPERIENCING WITH STALLING AT ANY SPEED. DEALER WAS NOTIFIED. THEY INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THIS RECALL. *AK

NHTSA ODI #10101948

Mileage unknown · May 6, 2004
Engine And Engine Cooling

THIS PROBLEM HAS BEEN HAPPENING FOR APPROXIMATELY 2-3 MONTHS. THERE HAS BEEN NOTHING SPECIFIC TO CAUSE THE PROBLEM. MY 1999 JEEP GRAND CHEROKEE WILL, WITHOUT WARNING, ACT AS IF IT IS RUNNING OUT OF GAS. I HAVE MORE THAN ONCE ATTEMPTED TO CROSS AN INTERSECTION ONLY TO HAVE THE VEHICLE LOOSE ALL FUEL POWER, THEREFORE LEAVING …

Read full complaint

THIS PROBLEM HAS BEEN HAPPENING FOR APPROXIMATELY 2-3 MONTHS. THERE HAS BEEN NOTHING SPECIFIC TO CAUSE THE PROBLEM. MY 1999 JEEP GRAND CHEROKEE WILL, WITHOUT WARNING, ACT AS IF IT IS RUNNING OUT OF GAS. I HAVE MORE THAN ONCE ATTEMPTED TO CROSS AN INTERSECTION ONLY TO HAVE THE VEHICLE LOOSE ALL FUEL POWER, THEREFORE LEAVING ME IN THE PATH OF OTHER VEHICLES. THIS PROBLEM WILL LAST ANYWHERE FROM 5 TO 15 SECONDS (APPROXIMATELY - I HAVE NOT ACTUALLY TIMED IT) BEFORE IT STRAIGHTENS BACK OUT WHERE I CAN AGAIN ACCELERATE. I HAVE HAD VEHICLES HAVE TO SLAM ON THEIR BRAKES TO KEEP FROM HITTING ME BECAUSE I CAN NOT ACCELERATE. BELOW IS A WHAT I HAVE DONE TO ATTEMPT TO CORRECT THIS PROBLEM (IN THE ORDER IT WAS DONE): 1)PLUGS WERE REPLACED AT HOME 2)FUEL INJECTORS WERE CLEANED BY CERTIFIED MECHANIC (NOT AT DEALERSHIP) 3)POWER TRAIN CONTROL MODULE (COMPUTER) (USED PART) REPLACED AT DEALERSHIP (AT THIS TIME I DID CONTACT JEEP BECAUSE THE COMPUTER WAS ONLY 2,000 MILES PASSED THE WARRANTY - THEY WOULD NOT ASSIST ME THE REPLACEMENT) 4)COIL PACK REPLACED AT HOME THIS VEHICLE HAS SPENT MANY DAYS IN THE SHOP AND WITH ALL THE WORK THAT HAS BEEN PERFORMED AND ALL OF THE DIAGNOSTIC TESTS, THEY STILL CAN NOT TELL ME HOW TO FIX THIS PROBLEM. I HAVE REPLACED $600 WORTH OF PERFECTLY GOOD PARTS. THIS VEHICLE IS EXTREMELY DANGEROUS TO DRIVE. SO MUCH THAT I WILL NO LONGER ALLOW ANYONE TO DRIVE IT. I SPOKE WITH A CUSTOMER SERVICE REP AT JEEP AGAIN TODAY AND BECAUSE THE VEHICLE IS NO LONGER UNDER WARRANTY (APPROX. 83,000 MILES), THEY WILL NOT CONSIDER HELPING ME. HOWEVER, THEIR TECHNICIANS ALSO STATED THAT THEY WERE "STUMPED".

NHTSA ODI #10068403

96,500 miles · Apr 10, 2004
Engine And Engine Cooling

MY WIFE MADE A QUICK STOP AT A LOCAL STORE. UPON RETURNING THE VEHICLE'S ENGINE WOULD NOT TURN OVER. SHE PAUSED FOR A FEW MINUTES AND ATTEMPTED TO START THE ENGINE AGAIN. THERE WAS A LOUD BANG FOLLOWED BY A LOUD RATTLING. AT THE MECHANIC SHOP, THE MECHANIC HOISTED THE JEEP ON THE LIFT AND WE WITNESSED A HOLE AND CRACK IN THE BO…

Read full complaint

MY WIFE MADE A QUICK STOP AT A LOCAL STORE. UPON RETURNING THE VEHICLE'S ENGINE WOULD NOT TURN OVER. SHE PAUSED FOR A FEW MINUTES AND ATTEMPTED TO START THE ENGINE AGAIN. THERE WAS A LOUD BANG FOLLOWED BY A LOUD RATTLING. AT THE MECHANIC SHOP, THE MECHANIC HOISTED THE JEEP ON THE LIFT AND WE WITNESSED A HOLE AND CRACK IN THE BOTTOM OF THE ENGINE ABOUT THE SIZE OF A SOFTBALL. THE CRACKED PIECE WAS ONLY BEING HELD BY A BOLT OR SOME KIND OF RIVET OR ELSE THE HOLE DAMAGE WOULD HAVE BEEN MUCH LARGER. THE 99 JEEP GC HAD 96500 MILES ON IT, REGULAR OIL CHANGES, AND IT WAS NOT LEAKING OIL. IT HAPPENED WITHOUT WARNING, AND I HAVE HEARD NO DECENT EXPLAINATION FOR THIS. COST $1500, AND THIS WAS CONSIDERED A GOOD PRICE. YOURS TRULY, DISGRUNTED CONSUMER

NHTSA ODI #10065875

81,813 miles · Jan 6, 2004
Engine And Engine Cooling

MY 1999 JEEP GRAND CHEROKEE'S RADIATOR FAN FAILED TO WORK, CAUSING THE VEHICLE TO OVERHEAT. THIS WAS DIAGNOSED AS AN INOPERATIVE FAN RELAY BY A JEEP DEALER. THIS ISSUE IS ONE OF MANY INTERMITTENT MECHANICAL PROBLEMS PLAGUING THIS VEHICLE SINCE PURCHASING IT NEW, HOWEVER THIS COMPLAINT IS BEING FILED FOR 4 SPECIFIC REASONS: 1)…

Read full complaint

MY 1999 JEEP GRAND CHEROKEE'S RADIATOR FAN FAILED TO WORK, CAUSING THE VEHICLE TO OVERHEAT. THIS WAS DIAGNOSED AS AN INOPERATIVE FAN RELAY BY A JEEP DEALER. THIS ISSUE IS ONE OF MANY INTERMITTENT MECHANICAL PROBLEMS PLAGUING THIS VEHICLE SINCE PURCHASING IT NEW, HOWEVER THIS COMPLAINT IS BEING FILED FOR 4 SPECIFIC REASONS: 1) THIS TYPE OF PROBLEM RESULTING IN TOTAL FAILURE SHOULD NOT OCCUR IN SUCH A NEW VEHICLE, 2) A BREAKDOWN OF THIS TYPE (OVERHEAT) MAY CAUSE COLLATERAL DAMAGE TO THE VEHICLE WHICH WILL NOT BE KNOWN ABOUT UNTIL A FUTURE EVENT OCCURS, 3) I AM A WOMEN WHO TRAVELS ALONE OFTEN AND ANY BREAKDOWN PUTS MY PERSONAL SAFETY AT RISK, 4) TO HELP PREVENT OTHERS FROM EXPERIENCING THIS IF THIS REPORT ASSISTS IN DETERMINING THAT THIS ISSUE IS A SYSTEMIC PROBLEM WITH THIS VEHICLE. I UNDERSTAND THAT PROACTIVE RESOLUTION OF THIS PROBLEM WAS NOT LIKELY, HOWEVER I HAVE ATTEMPTED TO FIND OUT INFORMATION ON SYSTEMIC PROBLEMS WITH 1999 JEEP GRAND CHEROKEES IN ORDER TO BE AN INFORMED CONSUMER AND BE PROACTIVE IN MY MAINTENANCE CHECKS OF MY VEHICLE TO AVOID BREAKDOWN. THIS INFORMATION IS NOT READILY AVAILABLE FROM THE DEALERSHIPS, THEREFORE IT PUTS THE CONSUMER AT MORE RISK THAN NECESSARY. DAIMLER CHRYSLER SHOULD TAKE MORE RESPONSIBILITY AND IMPROVE COMMUNICATION ON THESE ISSUES. THIS MODEL YEAR VEHICLE HAS BEEN PLAGUED WITH KNOWN PROBLEMS, TWO OF WHICH COST ME THE LOSS OF MY VEHICLE OVER 2 DIFFERENT WEEKENDS, 2 DIFFERENT BREAKDOWN EVENTS WHILE I WAS DRIVING ALONE, IN ADDITION TO AT LEAST 12 OTHER SERVICE EVENTS. *AK

NHTSA ODI #10052549

42,000 miles · Dec 22, 2003
Engine And Engine CoolingPower TrainService Brakes, Air

WATER PUMP REAR WHEEL BEARINGS. *AK

NHTSA ODI #10050939

94,500 miles · Sep 28, 2003
Engine And Engine Cooling

ELECTRIC COOLING FAN FALURE IN MY 99 JEEP GRAND CHARROKEE WHITCH IN TURN OVER HEATED THE JEEP RUPTURED THE RADIATOR CAUSING $884 IN DAMAGES. COME TO FIND OUT NEW FANS ARE BACK ON ORDER THIS IS A PROBLEM THAT IS ONGOING WITH JEEPS 98-2002 IF I WOULD HAVE KNOWN THIS WOULD HAVE BEEN MORE CARFUL PICKING OUT MY NEW CAR THANKS JO…

Read full complaint

ELECTRIC COOLING FAN FALURE IN MY 99 JEEP GRAND CHARROKEE WHITCH IN TURN OVER HEATED THE JEEP RUPTURED THE RADIATOR CAUSING $884 IN DAMAGES. COME TO FIND OUT NEW FANS ARE BACK ON ORDER THIS IS A PROBLEM THAT IS ONGOING WITH JEEPS 98-2002 IF I WOULD HAVE KNOWN THIS WOULD HAVE BEEN MORE CARFUL PICKING OUT MY NEW CAR THANKS JOHN

NHTSA ODI #10040839

Mileage unknown · Jul 9, 2003
Engine And Engine CoolingPower TrainSeat Belts

BROKEN WINDOW MOTOR, SEAT BELT MOUNTING BOLTS, LEAKING REAR SHOCK ABSORBERS, ETC...*MR THE CONSUMER FELT JEEP SHOULD FIX THE OUTSTANDING PROBLEMS WITH THE AXLES AND THE TRANSMISSION AND GIVE A WARRANTY FOR THE POWER TRAIN. THE VEHICLE EXPERIENCED A NOISE WHILE IN MOTION. ALSO THE BROKEN WINDOW LIFT LEAKED, THE REAR ABSORBERS…

Read full complaint

BROKEN WINDOW MOTOR, SEAT BELT MOUNTING BOLTS, LEAKING REAR SHOCK ABSORBERS, ETC...*MR THE CONSUMER FELT JEEP SHOULD FIX THE OUTSTANDING PROBLEMS WITH THE AXLES AND THE TRANSMISSION AND GIVE A WARRANTY FOR THE POWER TRAIN. THE VEHICLE EXPERIENCED A NOISE WHILE IN MOTION. ALSO THE BROKEN WINDOW LIFT LEAKED, THE REAR ABSORBERS FAILED, THE REAR PASSENGER WINDOW LEAKED AIR, THE SEAT BELT MOUNTING BOLTS FAILED,AND A POTENTIAL FIRE HAZARD ON THE MANIFOLD DEBRIS SHIELD, THE BRAKE PEDAL PULSATED WILDLY(FRONT WERE ROTORS TURNED), THE PASSENGER WINDOW HAD STUCK SHUT, THE EXTERIOR MIRROR HAD BROKEN OFF, AND THE TRANSMISSION SLAMMED INTO REVERSE. THERE WAS A BUZZ IN THE REAR WHICH HAD PROGRESSED TO A HOWL. REFER TO ODI# 10027025 *SCC *JB *JB *JB *CB

NHTSA ODI #10029353

Mileage unknown · Jul 9, 2003
Engine And Engine CoolingPower TrainSeat Belts

PROBLEMS WITH FAILING AXLES AND TRANSMISSION. *MR THE CONSUMER FELT THE MANUFACTURER SHOULD FIX THE OUTSTANDING PROBLEMS WITH AXLES AND TRANSMISSION AND GIVE A WARRANTY FOR THE POWER TRAIN. THE VEHICLE EXPERIENCED A NOISE WHILE THE VEHICLE WAS IN MOTION. ALSO THE WINDOW LIFT LEAKED, THE REAR ABSORBERS, THE REAR PASSENGER WIN…

Read full complaint

PROBLEMS WITH FAILING AXLES AND TRANSMISSION. *MR THE CONSUMER FELT THE MANUFACTURER SHOULD FIX THE OUTSTANDING PROBLEMS WITH AXLES AND TRANSMISSION AND GIVE A WARRANTY FOR THE POWER TRAIN. THE VEHICLE EXPERIENCED A NOISE WHILE THE VEHICLE WAS IN MOTION. ALSO THE WINDOW LIFT LEAKED, THE REAR ABSORBERS, THE REAR PASSENGER WINDOW LEAKED AIR, THE SEAT BELT MOUNTING BOLTS, FIRE HAZARD ON THE MANIFOLD DEBRIS SHIELD, BRAKE PEDAL PULSATED WILDLY(FRONT ROTORS TURNED), THE PASSENGER WINDOW HAD STUCK SHUT, THE EXTERIOR MIRROR HAD BROKEN OFF, AND THE TRANSMISSION SLAMMED INTO REVERSE. THERE WAS A BUZZ IN THE REAR WHICH HAD PROGRESSED TO A HOWL. REFER TO ODI# 10029353 *SCC *JB

NHTSA ODI #10027025

48,038 miles · May 27, 2003
Electrical SystemEngine And Engine Cooling

1999 JEEP GRAND CHEROKEE LIMITED. ONLY 45,000 MILES. VEHICLE STALLED WHEN MAKING TURNS AND NOW STALLS WHEN OPERATING AT HIGH SPEEDS. LAST TIME VEHICLE WAS TRAVELING APPROXIMATELY 65 MILES AN HOUR AND STALLED. USUALLY THE VEHICLE WILL START BACK UP AS SOON AS IT IS PUT IN NEUTRAL AND YOU TURN THE KEY. BUT ON SOME OCCASIONS VEHIC…

Read full complaint

1999 JEEP GRAND CHEROKEE LIMITED. ONLY 45,000 MILES. VEHICLE STALLED WHEN MAKING TURNS AND NOW STALLS WHEN OPERATING AT HIGH SPEEDS. LAST TIME VEHICLE WAS TRAVELING APPROXIMATELY 65 MILES AN HOUR AND STALLED. USUALLY THE VEHICLE WILL START BACK UP AS SOON AS IT IS PUT IN NEUTRAL AND YOU TURN THE KEY. BUT ON SOME OCCASIONS VEHICLE HAS HAD TO SIT FOR APPROXIMATELY 15 MINUTES BEFORE STARTING AGAIN. VEHICLE HAS BEEN TOWED TO A DEALERSHIP ON 2 OCCASIONS AND EACH TIME WHEN IT ARRIVES AND IS CHECKED BY MECHANICS IT STARTS UP. MECHANICS AND COMPUTER CHECKS REVEALED NO PROBLEM AT THE DEALERSHIP. PEOPLE HAVE SAID THAT IS POSSIBLY A COMPUTER PROBLEM IN THE VEHICLE AND THE REASON THE DEALERS FOUND NOTHING WRONG IS THE COMPUTER RESETS ITSELF EACH TIME THE JEEP IS RESTARTED. NOT SURE BUT THE DEALERSHIPS CANNOT GIVE ME ANY ADVICE ON WHAT TO DO TO FIX THE PROBLEM. I CANNOT AFFORD ANOTHER VEHICLE AND I AM WORRIED THAT VEHICLE STALLING AT HIGH SPEEDS IS GOING TO RESULT IN AN ACCIDENT. PLEASE LET ME KNOW IF THIS IS A PROBLEM YOU HAVE FOUND IN OTHER JEEPS AND IF YOU KNOW A REMEDY. JEEP HAS ALSO HAD ELECTRICAL PROBLEMS IN THE PAST SUCH AS TWO AUTO DOOR LOCKS GOING BAD, AIR CONDITIONER WENT BAD, AND THE BATTERY FAILED. NOT SURE IF THIS IS RELATED SOMEHOW OR NOT. CHECK OF PAST OWNER RECORDS SHOWS MAINTENANCE FOR CHECK ENGINE LIGHT AT 21418 MILES (2/19/01) AND 33488 (2/28/02) AND AUTOMATIC TRANSMISSION PROBLEMS AT 33488 MILES. *TT

NHTSA ODI #10020543

Official recalls

4

02V104000 · Fuel System, Gasoline:fuel Injection System:injectors

Apr 8, 2002

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.

Consequence & remedy

Consequence: THIS COULD RESULT IN A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

01V119000 · Seat Belts:front:retractor

Apr 11, 2001

VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.

Consequence & remedy

Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

00V034000 · Seat Belts

Feb 4, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.

Consequence & remedy

Consequence: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.

Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.

98V276000 · Seat Belts:rear/other

Nov 4, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR OUTBOARD SEAT BELT RETRACTOR SPRING CAN DISENGAGE FROM THE REWIND MECHANISM, DISABLING THE RETRACTOR FUNCTION, AND PREVENTING THE BELT FROM FITTING SNUGLY AROUND THE OCCUPANT.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THESE RETRACTORS.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

5

EA12005 · Crash Related Fuel Tank Fires

Opened Jun 12, 2012 · Closed Nov 14, 2014

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

PE10031 · Crash Related Fuel Tank Fires

Opened Aug 23, 2010 · Closed Jun 14, 2012

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

DP09005 · Fuel Storage System Crash Related Fires

Opened Nov 6, 2009 · Closed Aug 23, 2010

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

EA01017 · ROLL-AWAY In Reverse When Parked

Opened Nov 1, 2001 · Closed Dec 18, 2002

Status: closed (inferred from source dates) · Power Train

DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONALITY AND ERGONOMICS, HELPS TO PROVIDE FEEDBACK TO THE DRIVER TO INDICATE WHETHER ?PARK? HAS OR HAS NOT BEEN ACHIEVED.ALTHOUGH THE INVESTIGATOR WAS ABLE TO INDUCE A ?FALSE PARK? IN THE WJ PLATFORM FOR 6 CYL. VEHICLES, THE LEVEL OF DIFFICULTY WAS GREATER THAN THAT REQUIRED FOR ALL ZJ MODELS, AND THE COMPLAINT RATE WAS SIGNIFICANTLY LOWER THAN THE RECALLED ZJ POPULATION.FURTHER, THE ODI INVESTIGATOR WAS ALSO ABLE TO CREATE A ?FALSE PARK? IN PEER VEHICLES WITH THE SAME LEVEL OF DIFFICULTY AND FREQUENCY AS THE SUBJECT VEHICLE WJ PLATFORM.THE WJ COMPLAINT RATE WAS INFLATED DUE TO NATIONAL EXPOSURE THROUGH THE PRESS. THE COMPLAINT RATE PRIER TO THE JULY 5, 2001 MEDIA COVERAGE FOR THE WJ VEHICLES IS SIMILAR TO THE PEER VEHICLE INCIDENT RATE.BASED ON THE ABOVE, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME IN THE WJ POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED WITH A SAFETY RECAL FOR THE ZJ PLATFORM ONLY.

PE01021 · Inadvertent Rollaway In Reverse Park

Opened Jun 28, 2001 · Closed Nov 1, 2001

Status: closed (inferred from source dates) · Power Train

No summary supplied.

Go deeper into Jeep Grand Cherokee problems