Illustration1999 JEEP GRAND CHEROKEE. CONSUMER WRITES IN REGARDS TO TRANSFER CASE ACTUATOR RECALL NOTICE. *SMD THE CONSUMER STATED THE RECALL NOTICED STATED, THE PARTS WERE NOT AVAILABLE.
1999 Jeep Grand Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Grand Cherokee years
Owner complaints for the 1999 Jeep Grand Cherokee are substantially higher than the model-year median of 726.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
550–25K
7125–50K
10750–75K
7775–100K
138100–150K
80150K+
528 reports with mileage · 1,110 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 595 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 386 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 162 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
123 crash reports15 fire reports52 injury reports
Electrical System complaints
84 reportsI AM COMING HOME DRIVING MY JEEP GRAND CHEROKEE 1999 FROM MY MECHANIC IN QUEENS VILLAGE AFTER HE CHANGE THE MAP SENSOR AND RELAY TO FIX THE STALLING PROBLEM ON THE JEEP. DRIVING ON GRAND CENTRAL PARKWAY AT THE SPEED OF 55MPH, I WAS LUCKY TO HAVE DRIVEN MY CAR AND BE ABLE TO COME TO INNER ROADS WHEN MY CAR DIED(STALLS) AGAIN IN T…
Read full complaint
I AM COMING HOME DRIVING MY JEEP GRAND CHEROKEE 1999 FROM MY MECHANIC IN QUEENS VILLAGE AFTER HE CHANGE THE MAP SENSOR AND RELAY TO FIX THE STALLING PROBLEM ON THE JEEP. DRIVING ON GRAND CENTRAL PARKWAY AT THE SPEED OF 55MPH, I WAS LUCKY TO HAVE DRIVEN MY CAR AND BE ABLE TO COME TO INNER ROADS WHEN MY CAR DIED(STALLS) AGAIN IN THE MIDDLE OF THE TRAFFIC. AFTER 30MIN, THE CAR STARTS AGAIN AFTER A NUMEROUS TRIES THEN STOPS AFTER 500FT AND IT DIDN'T START UNTIL AFTER 15MIN OF STANDING BY IN THE MIDDLE OF TRAFFIC AGAIN. IT'S JUST SO FRUSTRATING WHEN THIS HAPPENS BECAUSE MY CAR IS IN VERY GOOD SHAPE AND IT'S STALLING MY ENGINE, UNBEARABLE PROBLEM BECAUSE I AM AFRAID TO DRIVE MY CAR ON A HIGHWAY OR EXPRESSWAY. *TR
REAR LIGHTS (BRAKE AND PARK) STOPPED WORKING. *TR
INTERMITTENT STALLING PROBLEM WHEN MOVING, VERY DANGEROUS, ABOUT REAR ENDED NUMEROUS TIMES. DEALER CAN NOT FIX, JUST THROW MONEY AT IT IN PARTS HOPING TO FIX THE PROBLEM. THIS NEEDS TO BE ADDRESSED BY JEEP BEFORE SOMEONE IS KILLED!!!!!!!! *TR
WENT OUT SHOPPING. DROVE 15 MINUTES FROM HOME. CAR RUNNING AT NORMAL OPERATING TEMPS. WENT INTO STORE FOR 10 MINUTES, ON RETURN CAR WOULD NOT START. WOULD CRANK AND TURN OVER, BUT NOT FULLY START. AFTER LETTING SIT FOR 1 HOUR, THE CAR STARTED WITH NO OTHER ACTION. WHILE TRYING TO START, ALL OTHER FUNCTIONS WORKED OK. RADIO. A/C…
Read full complaint
WENT OUT SHOPPING. DROVE 15 MINUTES FROM HOME. CAR RUNNING AT NORMAL OPERATING TEMPS. WENT INTO STORE FOR 10 MINUTES, ON RETURN CAR WOULD NOT START. WOULD CRANK AND TURN OVER, BUT NOT FULLY START. AFTER LETTING SIT FOR 1 HOUR, THE CAR STARTED WITH NO OTHER ACTION. WHILE TRYING TO START, ALL OTHER FUNCTIONS WORKED OK. RADIO. A/C. HEADLAMPS. ETC. CAR ALSO STARTING STALLING AFTER THE "NO-START" ISSUE BEGAN. STALLED AT ANY TEMP, ANY SPEED, HIGHWAY, AROUND TOWN. CAR STALLS, BUT STILL HAVE LIGHTS, FLASHERS ETC. *TR
AUTO HAD 40000+ MILES WHEN I BOUGHT IT FROM MY BROTHER. I HAD IT ONLY A FEW MONTHS WHEN IT STALLED ON THE INTERSTATE. IT WOULD NOT START UNTIL I SAT FOR A LITTLE WHILE. I AM CAPABLE OF OVERCOMING AUTO TROUBLE SO I DIDN'T THINK MUCH ABOUT THIS INCIDENT DUE TO THE FACT THAT I HAVE BEEN A MECHANIC FOR MANY YEARS NOW. THEN IT BEGAN …
Read full complaint
AUTO HAD 40000+ MILES WHEN I BOUGHT IT FROM MY BROTHER. I HAD IT ONLY A FEW MONTHS WHEN IT STALLED ON THE INTERSTATE. IT WOULD NOT START UNTIL I SAT FOR A LITTLE WHILE. I AM CAPABLE OF OVERCOMING AUTO TROUBLE SO I DIDN'T THINK MUCH ABOUT THIS INCIDENT DUE TO THE FACT THAT I HAVE BEEN A MECHANIC FOR MANY YEARS NOW. THEN IT BEGAN TO STALL IN HEAVY TRAFFIC AND SOMETIMES WOULD START AGAIN AND OTHER TIMES AFTER WAITING SEVERAL MINUTES. I REPLACED THE CRANK SENSOR, IN-TANK FUEL PUMP AND FILTER. IT RAN OKAY FOR A WHILE BUT BEGAN TO HARD START AND STALL AGAIN ABOUT 2 MOS. AGO. THEN 2 DAYS AGO IT STALLED SOMETHING LIKE 25 TIMES COMING HOME FROM THE HOSPITAL. SINCE THEN I HAVE BEEN ON THE INTERNET READING THE BLOGS ABOUT THIS PROBLEM AND IF EVERYONE THAT HAS THIS ISSUE WOULD EMAIL YOU, YOUR COMPUTERS WOULD SHUT DOWN. IT IS UNBELIEVABLE THAT THE MANUFACTURER IS JUST REPLACING THE EXPENSIVE PARTS AT RANDOM, TAKING THE MONEY AND NOT FIXING THE PROBLEM. THESE PEOPLE, MYSELF INCLUDED, ARE BEGGING FOR A SOLUTION TO A PROBLEM WITH A VERY NICE AUTOMOBILE MADE IN AMERICA BY SKILLED TOP DOLLAR UNION LABOR. IT IS GETTING CLOSE TO SCAM EPIDEMIC. MY CAR IS SITTING IN MY GARAGE NOT FIXED BECAUSE THERE ARE ABOUT TEN DIFFERENT THINGS IN THE ELECTRICAL AND FUEL SYSTEM THAT CAN CAUSE THESE SYMPTOMS. I AM A DISABLED VETERAN AND CANNOT AFFORD TO GO DOWN THAT ELIMINATING PROCESS. MY DOCTOR DOESN'T DO ME THAT WAY AND I WON'T ALLOW THE MANUFACTURER TO DO IT EITHER. *TR
MY TRUCK BACK LIGHTS DOESN'T WORK WHEN I TURN MY LIGHTS ON. I CALLED THE DEALERSHIP AND THEY STATED THAT IT WILL COST $1000 TO FIX BECAUSE IT IS AN ELECTRICAL PROBLEM. I REALLY LIKE MY TRUCK AND WOULD LOVE FOR TO KEEP IT BUT I CAN NOT DRIVE IT AT NIGHT. I HAVE SEEN TO MANY CARS TO EXPLAIN IN THE ATLANTA AREA THAT ARE EXPERIENCIN…
Read full complaint
MY TRUCK BACK LIGHTS DOESN'T WORK WHEN I TURN MY LIGHTS ON. I CALLED THE DEALERSHIP AND THEY STATED THAT IT WILL COST $1000 TO FIX BECAUSE IT IS AN ELECTRICAL PROBLEM. I REALLY LIKE MY TRUCK AND WOULD LOVE FOR TO KEEP IT BUT I CAN NOT DRIVE IT AT NIGHT. I HAVE SEEN TO MANY CARS TO EXPLAIN IN THE ATLANTA AREA THAT ARE EXPERIENCING THE SAME PROBLEMS, AND I DO NOT THINK THAT IT IS FAIR THAT WE PAY OUR MONEY FOR THESE CARS AND THE DEALER DOESN'T INFORM TO US THAT THERE NEEDS TO BE A RECALL ON OUR VEHICLES AND FIX THEM, MY HUSBAND HAS A FORD TRUCK AND WHEN THEY RECALLED SOMETHING ON HIS TRUCK AND THEY CALLED HIM AND SENT HIM A LETTER AND HE TOOK HIS TRUCK AND THEY FIXED IT WITH NO PROBLEMS I DON'T UNDERSTAND WHY IT CAN'T BE THE SAME WAY WITH JEEP. PLEASE IF YOU CAN HELP PLEASE DO.
MY 99 JEEP GRAND CHEROKEE LIMITED JUST STARTED HAVING A PROBLEM WITH THE AIR BAG LIGHT AND CHIME WHEN STEERING WHEEL IS TURNED. AND IT SOUNDS LIKE A VERY COMMON PROBLEM WITH MANY PEOPLE. THIS PROBLEM MAY OR MAY NOT HAVE CAUSED AN INJURY BUT WHAT IS IT GOING TO TAKE TO KEEP YOUR LOYAL JEEP CUSTOMERS FROM THINKING THAT THIS COMPAN…
Read full complaint
MY 99 JEEP GRAND CHEROKEE LIMITED JUST STARTED HAVING A PROBLEM WITH THE AIR BAG LIGHT AND CHIME WHEN STEERING WHEEL IS TURNED. AND IT SOUNDS LIKE A VERY COMMON PROBLEM WITH MANY PEOPLE. THIS PROBLEM MAY OR MAY NOT HAVE CAUSED AN INJURY BUT WHAT IS IT GOING TO TAKE TO KEEP YOUR LOYAL JEEP CUSTOMERS FROM THINKING THAT THIS COMPANY DOES NOT CARE ABOUT IT CUSTOMERS SAFETY! THIS SAFETY PROBLEM SHOULD BE RECALLED AND DONE VERY SOON BEFORE THERE ARE INJURIES OR LOYAL CUSTOMERS DEATHS FROM A SIMPLE FIX. *TR
WHEN I TURNED ON THE HEAT ONE FALL DAY I GOT HOT AIR ON THE DRIVER SIDE AND COLD AIR ON THE PASSENGER SIDE. IT DOESN'T MATTER WHETHER I SELECT DEFROST, FLOOR, OR MID-LEVEL VENTS.ALSO I HAD THE TEMPERATURE SETTINGS ON HIGH. I HAVE NOT REPAIRED THIS YET, IT IS A SAFETY ISSUE DUE TO DIFFICULTY DEFROSTING THE WINDSHIELD. THE DEALERS…
Read full complaint
WHEN I TURNED ON THE HEAT ONE FALL DAY I GOT HOT AIR ON THE DRIVER SIDE AND COLD AIR ON THE PASSENGER SIDE. IT DOESN'T MATTER WHETHER I SELECT DEFROST, FLOOR, OR MID-LEVEL VENTS.ALSO I HAD THE TEMPERATURE SETTINGS ON HIGH. I HAVE NOT REPAIRED THIS YET, IT IS A SAFETY ISSUE DUE TO DIFFICULTY DEFROSTING THE WINDSHIELD. THE DEALERSHIP SAID IT WILL BE VERY COSTLY. IT IS NOT INTERMITTENT BECAUSE IT IS ALWAYS FAILED. *TR
I HAVE A 1999 GRAND CHEROKEE, THE HEADLIGHTS FLASH ON AND OFF WHEN THE CAR IS PARKED AND SHUT OFF. *TR
Official recalls
402V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V119000 · Seat Belts:front:retractor
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V034000 · Seat Belts
Feb 4, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.
Consequence & remedy
Consequence: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.
98V276000 · Seat Belts:rear/other
Nov 4, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR OUTBOARD SEAT BELT RETRACTOR SPRING CAN DISENGAGE FROM THE REWIND MECHANISM, DISABLING THE RETRACTOR FUNCTION, AND PREVENTING THE BELT FROM FITTING SNUGLY AROUND THE OCCUPANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THESE RETRACTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
PE10031 · Crash Related Fuel Tank Fires
Opened Aug 23, 2010 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
DP09005 · Fuel Storage System Crash Related Fires
Opened Nov 6, 2009 · Closed Aug 23, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
EA01017 · ROLL-AWAY In Reverse When Parked
Opened Nov 1, 2001 · Closed Dec 18, 2002
Status: closed (inferred from source dates) · Power Train
DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONALITY AND ERGONOMICS, HELPS TO PROVIDE FEEDBACK TO THE DRIVER TO INDICATE WHETHER ?PARK? HAS OR HAS NOT BEEN ACHIEVED.ALTHOUGH THE INVESTIGATOR WAS ABLE TO INDUCE A ?FALSE PARK? IN THE WJ PLATFORM FOR 6 CYL. VEHICLES, THE LEVEL OF DIFFICULTY WAS GREATER THAN THAT REQUIRED FOR ALL ZJ MODELS, AND THE COMPLAINT RATE WAS SIGNIFICANTLY LOWER THAN THE RECALLED ZJ POPULATION.FURTHER, THE ODI INVESTIGATOR WAS ALSO ABLE TO CREATE A ?FALSE PARK? IN PEER VEHICLES WITH THE SAME LEVEL OF DIFFICULTY AND FREQUENCY AS THE SUBJECT VEHICLE WJ PLATFORM.THE WJ COMPLAINT RATE WAS INFLATED DUE TO NATIONAL EXPOSURE THROUGH THE PRESS. THE COMPLAINT RATE PRIER TO THE JULY 5, 2001 MEDIA COVERAGE FOR THE WJ VEHICLES IS SIMILAR TO THE PEER VEHICLE INCIDENT RATE.BASED ON THE ABOVE, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME IN THE WJ POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED WITH A SAFETY RECAL FOR THE ZJ PLATFORM ONLY.
PE01021 · Inadvertent Rollaway In Reverse Park
Opened Jun 28, 2001 · Closed Nov 1, 2001
Status: closed (inferred from source dates) · Power Train
No summary supplied.