NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
371 reportsClear category filter140,000 miles · Apr 6, 2017
Electrical SystemUnknown Or Other
ALL LIGHT FLASH OFF AND ON RANDOMLY SOMETIMES LEAVING THE GAUGES AND AC NOT WORKING THEN RETURN AND LEAVE THE EAS AND TRACTION CONTROL LIGHT AND CHECK ENGINE LIGHT ON. PULLING THE CODE REVEAL A U1403 AND U1411 CODE. WHEN BUMPS ARE HIT OR THE AC IS ON THE LIGHTS FLASH AND SOMETIME WIGGLING THE IGNITION SWITCH STOPS THE FLASHING O…
Read full complaint
ALL LIGHT FLASH OFF AND ON RANDOMLY SOMETIMES LEAVING THE GAUGES AND AC NOT WORKING THEN RETURN AND LEAVE THE EAS AND TRACTION CONTROL LIGHT AND CHECK ENGINE LIGHT ON. PULLING THE CODE REVEAL A U1403 AND U1411 CODE. WHEN BUMPS ARE HIT OR THE AC IS ON THE LIGHTS FLASH AND SOMETIME WIGGLING THE IGNITION SWITCH STOPS THE FLASHING OTHER TIMES IT IS RANDOM AND SOMETIME MORE SPORADIC, WHEN THE VEHICLE IS EXPERIENCING THE PROBLEM THE CAR IGNITION CAN BE SHUT OFF AND THE RESTARTED SOMETIMES IT STOPS THE TROUBLE..
NHTSA ODI #10971021
98,000 miles · Mar 11, 2017
Electrical System
WHILE HIGHWAY DRIVING, THE VEHICLE SHUT OFF AT 70MPH IN MIDDLE LANE. THERE WERE NO WARNING LIGHTS OR CHIMES THAT PRECEDED THE EVENT. AFTER PULLING OVER AND PUTTING THE VEHICLE IN PARK, THE JEEP STARTED NORMALLY. THE KEY RING ONLY HAD THE JEEP KEY AND THE VALET KEY, AND I FAR AWAY FROM THE DASHBOARD.
NHTSA ODI #10960116
85,000 miles · Feb 1, 2017
Electrical System
DRIVING DOWN THE ROAD ON RT3 HEADING WEST TOWARDS WEST CHESTER PA PASSING BY PROVIDENCE ROAD I WAS GOING ABOUT 55MPH WHEN MY JEEP SHUT OFF AND I LOST POWER TO THE ENGINE (THIS WAS VERY SCARY). I WAS ABLE TO PULL OFF THE ROAD AND EVENTUALLY GOT MY JEEP STARTED AGAIN. ABOUT 6 MONTHS LATER I WAS STOPPED AT A TRAFFIC LIGHT AND AG…
Read full complaint
DRIVING DOWN THE ROAD ON RT3 HEADING WEST TOWARDS WEST CHESTER PA PASSING BY PROVIDENCE ROAD I WAS GOING ABOUT 55MPH WHEN MY JEEP SHUT OFF AND I LOST POWER TO THE ENGINE (THIS WAS VERY SCARY). I WAS ABLE TO PULL OFF THE ROAD AND EVENTUALLY GOT MY JEEP STARTED AGAIN. ABOUT 6 MONTHS LATER I WAS STOPPED AT A TRAFFIC LIGHT AND AGAIN MY JEEP SHUT OFF. I WAS ABLE TO RESTART IT AGAIN A FEW SECONDS LATER. I BELIEVE THIS IS AN IGNITION SWITCH PROBLEM. *TR
NHTSA ODI #10948856
120,000 miles · Dec 1, 2016
Electrical System
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. AFTER THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM), THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A CUT WIRE ON THE DRIVER SIDE DOOR THAT CAUSED THE FAILURE. THE VEHICLE WAS REPAIRED; HOWEVER,…
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. AFTER THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM), THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A CUT WIRE ON THE DRIVER SIDE DOOR THAT CAUSED THE FAILURE. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
NHTSA ODI #10929480
Mileage unknown · Oct 26, 2016
Electrical System
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE VEHICLE HAD A SUDDEN LOSS OF POWER WITHOUT WARNING AND RANDOMLY STALLED MORE THAN TWICE. IN ADDITION, THE CONTACT EXPERIENCED AN UNINTENDED CHANGE IN THE IGNITION SWITCH POSITION WHILE DRIVING. THE FAILURE PROGRESSED FOR MONTHS. THE VEHICLE WAS NOT DIAGNOSED…
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE VEHICLE HAD A SUDDEN LOSS OF POWER WITHOUT WARNING AND RANDOMLY STALLED MORE THAN TWICE. IN ADDITION, THE CONTACT EXPERIENCED AN UNINTENDED CHANGE IN THE IGNITION SWITCH POSITION WHILE DRIVING. THE FAILURE PROGRESSED FOR MONTHS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM) AND WAS TO CHECK WITH THE MANUFACTURER TO DETERMINE IF A DEALER MAY DIAGNOSE THE FAILURE AND SCHEDULE THE RECALL REPAIR. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10919180
Mileage unknown · Oct 17, 2016
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE IGNITION KEY FAILED TO START THE VEHICLE INTERMITTENTLY. IN ADDITION, THE VEHICLE WAS ABLE TO SHIFT GEARS WITHOUT THE KEY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V175000 (ELECTR…
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE IGNITION KEY FAILED TO START THE VEHICLE INTERMITTENTLY. IN ADDITION, THE VEHICLE WAS ABLE TO SHIFT GEARS WITHOUT THE KEY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V175000 (ELECTRICAL SYSTEM, POWER TRAIN). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10916421
Mileage unknown · Oct 13, 2016
Electrical System
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10915979
20,000 miles · Sep 19, 2016
Electrical SystemEnginePower Train
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST POWER. THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. ALL THE GEAR SELECTIONS ILLUMINATED ON THE INSTRUMENT CLUSTER. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIA…
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST POWER. THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. ALL THE GEAR SELECTIONS ILLUMINATED ON THE INSTRUMENT CLUSTER. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE, RADIATOR, SPARK PLUGS, AND MULTIPLE PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VIN WAS LATER INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10907978
109,022 miles · Sep 15, 2016
Electrical System
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED TROUBLE STARTING. AFTER APPROXIMATELY 4-5 MINUTES, THE VEHICLE WAS ABLE TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. PRIOR TO THE FAILURE, THE CONTACT WAS INFORMED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V438000…
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED TROUBLE STARTING. AFTER APPROXIMATELY 4-5 MINUTES, THE VEHICLE WAS ABLE TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. PRIOR TO THE FAILURE, THE CONTACT WAS INFORMED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,022.
NHTSA ODI #10906888
159,000 miles · Aug 24, 2016
Electrical SystemEnginePower Train
MY 2007 JEEP COMMANDER IS STALLING AND SHUTTING OFF WHILE IN PARK AND WHILE DRIVING REGARDLESS OF SPEED. IT HAS BEEN DIAGNOSED AT A JEEP DEALERSHIP AND THEY SAY THE FUEL PUMP IS BAD THOUGH ARE UNSURE IF THAT WILL FIX THE PROBLEM.
NHTSA ODI #10898159
Official recalls
5Jul 21, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2007 Jeep Grand Cherokee vehicles manufactured February 11, 2004, to July 5, 2007, and 2006-2007 Jeep Commander vehicles manufactured January 31, 2005, to July 5, 2007. In the affected vehicles, the driver may accidentally hit the ignition key with their knee, unintentionally knocking the key out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. Chrysler sent interim notifications to owners in September 2014. The recall began on October 9, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P41.
May 7, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
Consequence & remedy
Consequence: If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Remedy: Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
Additional source detail variants (2)
Electrical System
Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
Consequence: If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Remedy: Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
Power Train:transfer Case (4-WHEEL Drive)
Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
Consequence: If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Remedy: Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
Sep 14, 2007
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.
Consequence & remedy
Consequence: THIS COULD CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Sep 12, 2007
ON CERTAIN SPORT UTILITY VEHICLES, FRONT BRAKE CALIPERS IN A CERTAIN LOT MAY HAVE BEEN MANUFACTURED FROM GRAY IRON INSTEAD OF DUCTILE IRON AS DESIGNED AND COULD FRACTURE WITHOUT WARNING.
Consequence & remedy
Consequence: THIS WOULD INCREASE THE VEHICLE'S STOPPING DISTANCE AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT BRAKE CALIPERS TO SEE IF THEY FALL INTO THIS LOT AND, IF SO, WILL REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 29, 2006
ON CERTAIN VEHICLES, THE ANTILOCK BRAKE SYSTEM (ABS) CONTROL MODULE SOFTWARE MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL UNIT. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE14017 · Air Bag Non-deployment
Opened Jun 16, 2014 · Closed Dec 23, 2014
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Additional source detail variants (3)
Electrical System:ignition
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:module
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA07007 · Engine Stalling
Opened Apr 27, 2007 · Closed May 7, 2008
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Additional source detail variants (3)
Electrical System
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Engine And Engine Cooling
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
PE07009 · Engine Stall
Opened Feb 12, 2007 · Closed Apr 27, 2007
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Electrical System
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Illustration