NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
73 reportsClear category filter13,000 miles · Mar 12, 2013
EnginePower Train
ON OR ABOUT THE ABOVE DATE THE RPMS ON MY VEHICLE RACED UP AND THE CAR SUDDENLY LUNGED FORWARD, IT HAPPENED AGAIN A FEW TIMES AFTERWARD WITHOUT ANY CHECK ENGINE CODES. I HAD IT CHECKED BACK THEN AND NOTHING WAS FOUND BECAUSE NO CODES WERE PRESENT.THIS HAPPENED A COUPLE OF TIMES A YEAR SINCE I OWNED IT, BUT NOTICED IT HAPPENS W…
Read full complaint
ON OR ABOUT THE ABOVE DATE THE RPMS ON MY VEHICLE RACED UP AND THE CAR SUDDENLY LUNGED FORWARD, IT HAPPENED AGAIN A FEW TIMES AFTERWARD WITHOUT ANY CHECK ENGINE CODES. I HAD IT CHECKED BACK THEN AND NOTHING WAS FOUND BECAUSE NO CODES WERE PRESENT.THIS HAPPENED A COUPLE OF TIMES A YEAR SINCE I OWNED IT, BUT NOTICED IT HAPPENS WHEN IT'S RAINING. TODAY 3/12/2013 (HEAVY RAIN) MY WIFE WAS STOPPED AT A LIGHT AND IT RACED & LUNGED FORWARD JUST MISSING A PEDESTRIAN. I IMMEDIATELY BROUGHT IT TO A NEIHBORHOOD JEEP DEALER & EXPLAINED THE SEVERITY OF THE SITUATION. HE WAS VERY ACCOMODATING AND TOOK IT IN IMMEDIATELY. AFTER A FEW HOURS IN THE SHOP & A TEST DRIVE ,AGAIN, NOTHING FOUND. THERE WERE NO ENGINE CODES PRESENT, ALL OTHER COMPONENTS WERE WITH-IN SPECS. I ASKED IF THIS IS A SIMILAR PROBLEM TO THE 2006 RECALL, HE SAID POSSIBLY, BUT THIS VIN. IS NOT UNDER RECALL. (I BELIVE THE 2006 RECALL WAS THE POWER TRAIN CONTROL MODULE.) I AM NOT SURE WERE TO GO WITH THIS BUT THIS NEEDS TO BE RESOLVED BY JEEP BEFORE AN ACCIDENT HAPPENS. *TR
NHTSA ODI #10502561
15 miles · Feb 11, 2013
Engine
THE CAR WILL SLOW DOWN AND THE SERVICE PARK LIGHT WILL POP ON THEN THE ENGINE LIGHT WILL COME ON. THIS HAS BEEN HAPPENING SINCE THE DAY I PURCHASED THE CAR. I HAVE TAKEN INTO THE SHOP PLENTY OF TIMES AND THEY KEEP TELLING ME NOTHING IS WRONG WITH IT. OVER THE PAST FEW YEARS IT HAS ONLY GOTTEN WORSE. IT HAS DONE THIS ON THE HIGHW…
Read full complaint
THE CAR WILL SLOW DOWN AND THE SERVICE PARK LIGHT WILL POP ON THEN THE ENGINE LIGHT WILL COME ON. THIS HAS BEEN HAPPENING SINCE THE DAY I PURCHASED THE CAR. I HAVE TAKEN INTO THE SHOP PLENTY OF TIMES AND THEY KEEP TELLING ME NOTHING IS WRONG WITH IT. OVER THE PAST FEW YEARS IT HAS ONLY GOTTEN WORSE. IT HAS DONE THIS ON THE HIGHWAY WHILE GOING 75 MILES AN HOUR. I HAVE HAD TO PULL OFF THE SIDE OF THE ROAD WAIT LIKE 5 MINUTES BEFORE I CAN TAKE OFF AGAIN. THIS IS REALLY BECOMING A PROBLEM AND I AM AFRAID TO EVEN PUT MY GRANDBABY IN THE CAR WITH ME BECAUSE I'M AFRAID THIS WILL CAUSE AN ACCIDENT. I HAVE JUST RECENTLY WENT TO DEALERSHIP AND THEY WANT TO CHARGE ME FOR THEM TO CHECK MY CAR AND I HAVE BEEN TELLING THEM THIS ISSUE FROM THE DAY I HAD MY CAR AND MY WARRANTY WAS STILL IN PLACE, BUT THEY CONTINUED TO TELL ME NOTHING IS WRONG WITH IT. *TR
NHTSA ODI #10497773
89,000 miles · Feb 3, 2013
EnginePower Train
WHEN SHIFTING FROM PARK TO DRIVE, OR REVERSE TO DRIVE, THE ENGINE STALLS AND IT TAKES ALMOST A MINUTE FOR THE SHIFT TO ACTUALLY OCCUR SO I CAN DRIVE. *TR
NHTSA ODI #10496218
89,000 miles · Feb 3, 2013
EngineFuel/propulsion SystemVehicle Speed Control
THIS HAS HAPPENED TO ME SEVERAL TIMES IN THE TWO YEARS I'VE OWNED THIS VEHICLE. EVERY TIME I TAKE IT TO THE SHOP THE MECHANICS SAY THEY CANNOT REPLICATE THE ISSUE SO CANNOT FIX IT. FIRST THE CHECK ENGINE LIGHT WILL COME ON AND NO CODES WILL APPEAR WHEN RUN. A COUPLE DAYS LATER (MOSTLY WHEN DRIVING ON THE HIGHWAY, OR ANY SPEED AB…
Read full complaint
THIS HAS HAPPENED TO ME SEVERAL TIMES IN THE TWO YEARS I'VE OWNED THIS VEHICLE. EVERY TIME I TAKE IT TO THE SHOP THE MECHANICS SAY THEY CANNOT REPLICATE THE ISSUE SO CANNOT FIX IT. FIRST THE CHECK ENGINE LIGHT WILL COME ON AND NO CODES WILL APPEAR WHEN RUN. A COUPLE DAYS LATER (MOSTLY WHEN DRIVING ON THE HIGHWAY, OR ANY SPEED ABOVE 30MPH) I WILL BE DRIVING AS USUAL AND BEGIN TO INCREASE SPEED ON THE ON RAMP FOR THE INTERSTATE AND THE ENGINE WILL TAP OUT AT 45MPH. I WILL PRESS THE GAS PEDAL TO THE FLOOR AND THE ENGINE WILL NOT REV AND THE RPM'S WILL NOT INCREASE. I TRIED TO PUT THE CAR IN NEUTRAL AND BACK INTO DRIVE AND NOTHING CHANGED WITH THE ENGINE. ALL THE WHILE I HAD MY ONE YEAR OLD CHILD IN THE CAR WITH ME. EVERY TIME I TRY TO RESEARCH WHAT IS WRONG WITH MY JEEP I JUST SEE THE SAME COMPLAINT FROM THOUSANDS OF PEOPLE. THIS IS OBVIOUSLY AN ISSUE AND NEEDS TO BE FIXED IMMEDIATELY! I DON'T CARE IF THEY HAVE TO GIVE ME A NEW JEEP I NEED SOMETHING SAFE FOR MY FAMILY! *TR
NHTSA ODI #10496217
70,256 miles · Jan 14, 2013
Electrical SystemEnginePower Train
VEHICLE WAS TRAVELING AT A SPEED OF SIXTY FIVE MPH ON THE HIGHWAY, WHEN THE ENGINE JUST SHUT OFF, LOSING POWER AND MAKING IT VERY HARD TO GET THE VEHICLE OFF THE ROAD AND STOPPED SAFELY. THIS HAS HAPPENED NUMEROUS TIMES IN THE YEAR WE HAVE OWNED THE VEHICLE. WHEN THE ENGINE SHUTS OFF IT MAKES IT VERY HARD TO TURN BECAUSE POWER S…
Read full complaint
VEHICLE WAS TRAVELING AT A SPEED OF SIXTY FIVE MPH ON THE HIGHWAY, WHEN THE ENGINE JUST SHUT OFF, LOSING POWER AND MAKING IT VERY HARD TO GET THE VEHICLE OFF THE ROAD AND STOPPED SAFELY. THIS HAS HAPPENED NUMEROUS TIMES IN THE YEAR WE HAVE OWNED THE VEHICLE. WHEN THE ENGINE SHUTS OFF IT MAKES IT VERY HARD TO TURN BECAUSE POWER STEERING IS DISABLED BECAUSE THE ENGINE IS NOT RUNNING. WHEN THE VEHICLE SHUTS OFF IT MAKES IT VERY HARD TO GET TO THE SHOULDER OF THE ROADWAY WITHOUT ANY ENGINE POWER AND THE SUDDEN SLOWING DOWN IS A VERY HIGH RISK FOR A REAREND COLLISION. WE HAVE HAD NUMEROUS CLOSE CALLS IN THIS VEHICLE BECAUSE OF THIS PROBLEM. I HAVE REPLACED NUMEROUS PARTS TO TRY AND RESOLVE THIS ISSUE BUT WITH NO SUCCESS IT CONTINUES TO HAPPEN. THE VEHICLE HAS BEEN TO THE DEALERSHIP NUMEROUS TIMES TO HAVE THIS PROBLEM FIXED AND THEY SAY (WE CAN NOT GET THE VEHICLE TO ACT UP WITH THE TECHNICIAN DRIVING THE VEHICLE TO EXACTLY PIN POINT THE PROBLEM.) THIS IS VERY FRUSTRATING BECAUSE THIS VEHICLE IS VERY UNSAFE TO DRIVE WITH THIS ISSUE. I HAVE LOOKED UP NUMEROUS COMPLAINTS AND ISSUES OF PEOPLE WITH THE SAME VEHICLE HAVING IDENTICAL PROBLEMS AND HAVE YET TO BE RESOLVED. WE HAVE REPLACED SPARK PLUGS, COILS, MAP SENSOR, MDS WIRING HARNESS, IGNITION SWITCH WITH OEM PARTS AND THE ISSUE STILL CONTINUES. I RECOMMEND FAULTY ENGINE WIRING, ECM, TO THE SERVICE ADVISORS JUST TO BE IGNORED. THEY TELL ME UNTIL THE ISSUE IS RECORDED ON THE VEHICLE SCANNER THAT NOTHING CAN BE DONE TO PIN POINT THE PROBLEM. *TR
NHTSA ODI #10492958
85,000 miles · Jan 14, 2013
Engine
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER 4X4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE RPMS INCREASED AND THERE WAS A LOSS OF ACCELERATION POWER. THE FAILURE OCCURRED TWICE BUT THE ENGINE FAILED TO START THE SECOND TIME. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A MEC…
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP COMMANDER 4X4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE RPMS INCREASED AND THERE WAS A LOSS OF ACCELERATION POWER. THE FAILURE OCCURRED TWICE BUT THE ENGINE FAILED TO START THE SECOND TIME. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A MECHANIC AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.
NHTSA ODI #10492941
83,500 miles · Jan 14, 2013
Electrical SystemEngineFuel/propulsion System
VEHICLE SHUTS OFF WHILE DRIVING. VARIOUS CONDITIONS. IDLING, CRUISING AT HIGHWAY SPEEDS, ACCELERATING, DECELERATING, ETC. MUST SHUT KEY OFF TO RESET ENGINE BEFORE THE VEHICLE WILL START AGAIN. THIS HAS HAPPENED AT LEAST 20 TIMES WITH NO CHECK ENGINE LIGHT ILLUMINATING. IT HAS BECOME A HUGE SAFETY ISSUE SINCE ALL POWER IS…
Read full complaint
VEHICLE SHUTS OFF WHILE DRIVING. VARIOUS CONDITIONS. IDLING, CRUISING AT HIGHWAY SPEEDS, ACCELERATING, DECELERATING, ETC. MUST SHUT KEY OFF TO RESET ENGINE BEFORE THE VEHICLE WILL START AGAIN. THIS HAS HAPPENED AT LEAST 20 TIMES WITH NO CHECK ENGINE LIGHT ILLUMINATING. IT HAS BECOME A HUGE SAFETY ISSUE SINCE ALL POWER IS LOST AT ANY SPEED. *TR
NHTSA ODI #10492921
67,522 miles · Dec 18, 2012
Electrical SystemEngineVehicle Speed ControlCrash
I WAS DRIVING HOME FROM PICKING UP MY DAUGHTER FROM A SCHOOL EVENT WHEN SUDDENLY MY CAR SLOWED DOWN ON ITS OWN DOWN TO 10 MPH. THEN THE CAR COMPLETELY STOPPED. ON THE CONTROL CONSOLE IT ONLY READ "SERVICE PARK ASSIST" AND THE DRIVE POSITION CONTROLS WHERE ALL HIGHLIGHTED AND BOXED OUT (DRNP). I LOST ALL CONTROL OF THE VEHICL…
Read full complaint
I WAS DRIVING HOME FROM PICKING UP MY DAUGHTER FROM A SCHOOL EVENT WHEN SUDDENLY MY CAR SLOWED DOWN ON ITS OWN DOWN TO 10 MPH. THEN THE CAR COMPLETELY STOPPED. ON THE CONTROL CONSOLE IT ONLY READ "SERVICE PARK ASSIST" AND THE DRIVE POSITION CONTROLS WHERE ALL HIGHLIGHTED AND BOXED OUT (DRNP). I LOST ALL CONTROL OF THE VEHICLE OTHER THAN TURNING THE WHEEL. I TRIED TO ACCELERATE BY PRESSING THE GAS AND IT JUST REVVED THE ENGINE AND DID NOTHING ELSE. I SWERVED OFF THE ROAD AND HIT A MEDIAN THAT TOOK OUT THE TIRE AND LEFT DAMAGE TO THE LEFT OF THE CAR UNDER CARRIAGE. I HAD TO SHIFT THE GEAR INTO PARK AND BACK TO DRIVE IN ORDER FOR THE CAR TO START UP AGAIN. I TOOK THE CAR TO A LOCAL JEEP CHRYSLER DODGE SERVICE DEPOT AND HAD IT RAN FOR A DIAGNOSTIC FOR AT WHICH TIME THEY TOLD ME THAT IT WAS A COMMON ISSUE FOUND IN THIS MODEL AND EARLIER MODELS AND THAT IT WASN'T COVERED BY THE POWER TRAIN THAT THE VEHICLE WOULD NEED $1100.00 IN REPAIRS TO FIX AN ELECTRONIC TRANSFORMER SHIFT MODULATOR. I HAD JUST PURCHASED THE CAR ON OCTOBER 31 FROM A JEEP CHRYSLER DODGE DEALERSHIP AND LESS THAN THREE WEEKS LATER THE CAR IS FOR CRAP. AND THE DEALERSHIP REFUSED TO FIX THE PROBLEM AND JEEP HAS NOT ISSUED A RECALL FOR THIS ISSUE BUT THEY HAVE FOR THE 2006 MODEL. THIS PROBLEM IS LIFE THREATENING. IT CAN OCCUR AT ANYTIME AT ANY SPEED. IF I WERE ON A EXPRESSWAY MY CHILDREN AND I WOULD PROBABLY BE DEAD. JEEP NEEDS TO BE PURSED FOR THIS ISSUE AND FORCED TO FIX THE DAMAGE ON ANY VEHICLES REPORTING THIS ISSUE. *TR
NHTSA ODI #10489140
112,344 miles · Dec 10, 2012
EnginePower Train
2007 JEEP COMMANDER LIMITED 5.7L HEMI STALLED AGAIN WHILE DRIVING. THIS TIME, MY DAUGHTER WAS PULLING INTO THE DRIVEWAY WHEN IT STALLED AND SHE HAD NO CONTROL OVER THE BRAKES OR STEERING BECAUSE THEY DON'T WORK WHEN THE VEHICLE STALLS. SHE JUST ABOUT DROVE THROUGH THE GARAGE DOOR. THIS IS A MAJOR SAFETY ISSUE AND MUST BE ADDRESS…
Read full complaint
2007 JEEP COMMANDER LIMITED 5.7L HEMI STALLED AGAIN WHILE DRIVING. THIS TIME, MY DAUGHTER WAS PULLING INTO THE DRIVEWAY WHEN IT STALLED AND SHE HAD NO CONTROL OVER THE BRAKES OR STEERING BECAUSE THEY DON'T WORK WHEN THE VEHICLE STALLS. SHE JUST ABOUT DROVE THROUGH THE GARAGE DOOR. THIS IS A MAJOR SAFETY ISSUE AND MUST BE ADDRESSED BEFORE SOMEONE GETS HURT OR EVEN WORSE, KILLED. I TOOK IT TO THE JEEP DEALERSHIP AND THEY UPDATED THE PCM, BUT AS SOON AS I LEFT IT STALLED AGAIN, SO I TOOK IT BACK AND THEY REPLACED AN IGNITION COIL. AS SOON AS I PULLED OFF THE HIGHWAY ON MY WAY HOME, IT STALLED AGAIN. THEY WANT TO REPLACE ALL OF THE IGNITION COILS WHICH WILL COST ABOUT $550, AND THEY CLAIM THIS MAY FIX THE ISSUE. I DON'T UNDERSTAND HOW JEEP DOESN'T KNOW HOW TO FIX THIS ISSUE. THERE ARE THOUSANDS OF JEEP OWNERS THAT ARE EXPERIENCING THE SAME ISSUE WITH NO FIX. THAT'S ALL WE WANT IS A SOLUTION TO THE PROBLEM BEFORE SOMEONE DIES. *TR
NHTSA ODI #10487909
48,114 miles · Sep 30, 2012
Electrical SystemEnginePower Train
MY 2007 HEMI COMMANDER PURCHASED AUG 30TH 2012 HAD A TRANSMISSION PROBLEM YESTERDAY.. I CAN NOT DRIVE IT ALL AT, IT IS PARKED IN MY DRIVEWAY. WHAT SHOULD I DO? *TR
NHTSA ODI #10477990
NHTSA investigations
3PE14017 · Air Bag Non-deployment
Opened Jun 16, 2014 · Closed Dec 23, 2014
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Additional source detail variants (3)
Electrical System:ignition
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:module
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
EA07007 · Engine Stalling
Opened Apr 27, 2007 · Closed May 7, 2008
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Additional source detail variants (3)
Electrical System
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Engine And Engine Cooling
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
PE07009 · Engine Stall
Opened Feb 12, 2007 · Closed Apr 27, 2007
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Electrical System
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Illustration