NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
73 reportsClear category filter89,193 miles · Dec 12, 2013
EngineVehicle Speed Control
I PURCHASED THE 2007 JEEP COMMANDER WITH THE 5.7 HEMI IN SPRING 2013 AND A FEW MONTHS LATER COMING TO A STOP IT JUST SHUT OFF. AT FIRST I THOUGHT MAYBE SOME WATER HAD GOTTEN INTO THE ENGINE COMPARTMENT SINCE IT WAS RAINING AND SHORTED SOMETHING. STARTED BACK UP AND THOUGHT ALL WAS FINE. WELL RECENTLY IT HAS BEEN HAPPENING MORE…
Read full complaint
I PURCHASED THE 2007 JEEP COMMANDER WITH THE 5.7 HEMI IN SPRING 2013 AND A FEW MONTHS LATER COMING TO A STOP IT JUST SHUT OFF. AT FIRST I THOUGHT MAYBE SOME WATER HAD GOTTEN INTO THE ENGINE COMPARTMENT SINCE IT WAS RAINING AND SHORTED SOMETHING. STARTED BACK UP AND THOUGHT ALL WAS FINE. WELL RECENTLY IT HAS BEEN HAPPENING MORE OFTEN, WHETHER IT IS WET OR DRY OUT AND AT ANY SPEED OR WHETHER THE CRUISE CONTROL IS ON OR OFF. IT ALSO SEEMS TO TRY TO SHUT DOWN WHILE FEATHERING THE GAS PEDAL AT HIGHWAY SPEEDS FROM ACCELERATING TO COAST. ON ONE OCCASION THIS SUMMER AT HIGHWAY SPEED PULLING OUR CAMPER IT SHUT DOWN AND I HAD TO COAST TO A STOP ALONG THE SIDE OF THE HIGHWAY TO RESTART. SOMETHING HAS TO BE DONE. I HAVE CHILDREN, AS I AM SURE MANY HERE WITH THE SAME COMPLAINT DO. *TR
NHTSA ODI #10555794
82,674 miles · Nov 10, 2013
Engine
I WOULD BE DRIVING, AND MY TEMPERATURE GAUGE WOULD SLOWLY CREEP OVER TO HOT, TEMP OVER HEATING..I NOTICED AS I SLOWED DOWN MY CAR WANTED TO STALL, IT WOULD PUTT PUTT PUTT UNTIL I GAVE IT A GO AS IF IT WAS MISFIRING, AND SLOWLY THE TEMPERATURE GAUGE WOULD GO BACK TO NORMAL. HONESTLY NOT THINKING ANYTHING OF IT, I WENT HOME, DROP…
Read full complaint
I WOULD BE DRIVING, AND MY TEMPERATURE GAUGE WOULD SLOWLY CREEP OVER TO HOT, TEMP OVER HEATING..I NOTICED AS I SLOWED DOWN MY CAR WANTED TO STALL, IT WOULD PUTT PUTT PUTT UNTIL I GAVE IT A GO AS IF IT WAS MISFIRING, AND SLOWLY THE TEMPERATURE GAUGE WOULD GO BACK TO NORMAL. HONESTLY NOT THINKING ANYTHING OF IT, I WENT HOME, DROPPED THE GROCERIES OFF AND PROCEEDED BACK TO MY CAR TO PICK MY SON UP FROM SCHOOL. I STARTED MY CAR, IT STALLED, I STARTED IT AGAIN, IT STALLED, EXTREMELY WORRIED I WAS PRAYING THIRD TIME A CHARM..AS I STARTED IT THE THIRD TIME IT STARTED WITH MUCH HESITATION AND DID THE SAME STUTTERING AS IF IT WAS MISFIRING AGAIN. I PROCEEDED TO MY SONS SCHOOL, WATCHING THE TEMPERATURE GAUGE CREEP RIGHT BACK UP TO HOT. WHEN I GOT THERE I CHECKED THE HOOD, NO STEAM, NOTHING SEEMED HOT, AND THE COOLANT LEVEL WAS STILL FULL. WHEN WE WENT TO LEAVE IT REFUSED TO START. LONG STORY SHORT, I HAVE BEEN WITHOUT MY CAR FOR A MONTH NOW, AND AFTER SPENDING 1000'S OF DOLLARS TO FIX THE SITUATION, THE MECHANIC CANT FOR CERTAIN PUT HIS HAND ON IT. EVERYTHING HE DOES, LEADS TO HIM THINKING SOMETHING ELSE, AND LEADS TO THE PROBLEM BECOMING AN ENGINE OVERHAUL. HAS ANYONE ELSE HAD THIS OVER HEATING ISSUE, AND THE MISFIRING OF THE CAR, AS IF IT STALLS WHILE DRIVING? PLEASE, I HAVE CONTACTED CHRYSLER, I AM AT MY WITS END. *TR
NHTSA ODI #10551718
94,000 miles · Oct 16, 2013
Electrical SystemEngineSteering
ON TWO SEPARATE OCCURRENCES SO FAR, THE JEEP HAS RANDOMLY STALLED OUT AT HIGHWAY SPEEDS IN TRAFFIC. ACCELERATOR AND STEERING LOOSE FUNCTION. OTHER TIMES IT HAS NEARLY STALLED BUT REGAINED OPERATION. CHECK ENGINE LIGHT COMES ON WITH CODE FOR LARGE VACUUM LEAK? DEALER WAS UNABLE TO FIND ANYTHING WRONG AND IS CURRENTLY EVALUATI…
Read full complaint
ON TWO SEPARATE OCCURRENCES SO FAR, THE JEEP HAS RANDOMLY STALLED OUT AT HIGHWAY SPEEDS IN TRAFFIC. ACCELERATOR AND STEERING LOOSE FUNCTION. OTHER TIMES IT HAS NEARLY STALLED BUT REGAINED OPERATION. CHECK ENGINE LIGHT COMES ON WITH CODE FOR LARGE VACUUM LEAK? DEALER WAS UNABLE TO FIND ANYTHING WRONG AND IS CURRENTLY EVALUATING AGAIN. VEHICLE STARTS BACK UP FINE AFTER PULLING TO SIDE OF ROAD AND REMOVING AND REINSERTING KEY. SAFETY ISSUE TO STALL AT HIGHWAY SPEEDS AND LOSE POWER STEERING! THIS DOES NOT APPEAR TO BE THE FIRST OCCURRENCE AS THERE ARE MANY OTHER COMPLAINTS AND A RECALL/INVESTIGATION WHICH NOTED IT IN 2007 VEHICLES BUT ONLY ISSUED A PCM RECALL FOR 2006 VEHICLES. *TR
NHTSA ODI #10548115
46,900 miles · Sep 4, 2013
Electrical SystemEnginePower Train
AFTER TAKING THE JEEP COMMANDER IN TO A DEALER SHIP TO GET RECALL NHTSA CAMPAIGN NUMBER 13V175000 FIXED THE VEHICLE HAS BEEN WANTING TO TURN OFF AT RANDOM. IT HAS HAPPENED WHILE IN PARK OR EVEN DRIVING THE VEHICLE. THE 1ST TIME IT HAPPEN, I WAS ACCELERATING WHILE GETTING ON THE HIGH WAY AND I WAS GOING ABOUT 40 MPH AND THE ENG…
Read full complaint
AFTER TAKING THE JEEP COMMANDER IN TO A DEALER SHIP TO GET RECALL NHTSA CAMPAIGN NUMBER 13V175000 FIXED THE VEHICLE HAS BEEN WANTING TO TURN OFF AT RANDOM. IT HAS HAPPENED WHILE IN PARK OR EVEN DRIVING THE VEHICLE. THE 1ST TIME IT HAPPEN, I WAS ACCELERATING WHILE GETTING ON THE HIGH WAY AND I WAS GOING ABOUT 40 MPH AND THE ENGINE LOST ALL POWER AND IT WAS HARD TO STEER. IT LASTED ABOUT 4 SEC AND THEN STOPPED. THE NEXT TIME IT HAPPEN WAS GOING DOWN THE HIGH WAY ABOUT 65 MPH WITH THE CRUISE ON AND IT DID THE SAME THING AND THE LAST TIME IT DID IT THE VEHICLE WAS PARKED. EACH TIME IT HAPPENS IT ONLY LAST ABOUT 4-5 SECS. IT JUST STARTED DOING IT RIGHT AFTER THE DEALER SHIP REPROGRAMMED THE ECM TO FIX THE RECALL. *JB
NHTSA ODI #10541830
75,000 miles · Aug 9, 2013
EngineSteeringVehicle Speed Control
I WAS BEGINNING TO ACCELERATE OUT OF A RIGHT TURN AND NOTICED THAT I WAS NOT PICKING UP SPEED AND THE CAR STARTED TO SHAKE. I TRIED TO SPEED UP TO THE FLOW OF TRAFFIC AND THE ACCELERATOR WAS NOT WORKING AND THE STEERING WHEEL KEPT SHAKING AND HAD TO PULL OVER TO THE SIDE OF THE ROAD. I NOTICED THAT ALL THE GEARS ON THE DASH WERE…
Read full complaint
I WAS BEGINNING TO ACCELERATE OUT OF A RIGHT TURN AND NOTICED THAT I WAS NOT PICKING UP SPEED AND THE CAR STARTED TO SHAKE. I TRIED TO SPEED UP TO THE FLOW OF TRAFFIC AND THE ACCELERATOR WAS NOT WORKING AND THE STEERING WHEEL KEPT SHAKING AND HAD TO PULL OVER TO THE SIDE OF THE ROAD. I NOTICED THAT ALL THE GEARS ON THE DASH WERE LIT UP, FROM PARK TO DRIVE AND EVERYTHING IN BETWEEN. I DECIDED TO SHUT OFF THE ENGINE AND START IT AGAIN. THE CAR WAS FINE BUT DID IT AGAIN ON 2 SEPARATE OCCASIONS. THANK GOODNESS I WAS NOT ON THE FREEWAY AND THERE WAS NOT A LOT OF TRAFFIC. *TR
NHTSA ODI #10534481
100,555 miles · Jul 25, 2013
Engine
VEHICLE STALLED WHEN ATTEMPTING TO TAKE OFF FROM A RED LIGHT. IT WOULD NOT INITIALLY RESTART, BUT A FULL POWER CYCLE OF THE CAR RESOLVED THE ISSUE. REPORTING INCIDENT AS MANY OTHERS HAVE REPORTED SIMILAR PROBLEMS AND WANT TO ADD TO THE DATA. *TR
NHTSA ODI #10531726
79,400 miles · Jun 20, 2013
Engine
WHILE DRIVING UP HILL (JUST AUTOSTICKED TO 3RD) JEEP COMMANDER STALLED. HAD TO SLOWLY BACK DOWN CURVE ON HILL TO SAFE POINT. ENGINE LIGHT CAME ON AND VEHICLE WOULD NOT RESTART. CALLED FOR TOW AND WAITED. TRUCK STARTED AFTER 10 MINUTES AND DROVE TO DEALERSHIP IN STAFFORD CONNECTICUT. VEHICLE STAYED THERE FOR 3 WEEKS ULTIMATELY EN…
Read full complaint
WHILE DRIVING UP HILL (JUST AUTOSTICKED TO 3RD) JEEP COMMANDER STALLED. HAD TO SLOWLY BACK DOWN CURVE ON HILL TO SAFE POINT. ENGINE LIGHT CAME ON AND VEHICLE WOULD NOT RESTART. CALLED FOR TOW AND WAITED. TRUCK STARTED AFTER 10 MINUTES AND DROVE TO DEALERSHIP IN STAFFORD CONNECTICUT. VEHICLE STAYED THERE FOR 3 WEEKS ULTIMATELY ENDING WITH NO FINDINGS. WITH 79000 MILES I AM AFRAID THIS WILL HAPPEN AGAIN WITHOUT NOTICE. DEALER SAW ENGINE CODES INITIALLY BUT COULD NOT DUPLICATE ISSUE AFTER CODES DISAPPEARED. DEALER REFUSED TO CHANGE ANYTHING WITHOUT CODE VERIFICATION. THIS IS A KNOWN PROBLEM WITH COMMANDERS PRE/POST YEARS-WONDERING WHAT IS GOING ON IN TERMS OF RECALL? *TR
NHTSA ODI #10520973
60,100 miles · Jun 3, 2013
Engine
THE ENGINE HAS STALLED ON ME MANY TIMES WHILE DRIVING AT A SLOW SPEED, TAKE OFF FROM A STOP LIGHT OR WHILE STANDING STILL. ENGINE LIGHT HAS COME ONE NUMEROUS TIMES AND CODES HAVE LEAD TO DIFFERENT SENSORS. WHICH WERE REPLACED BUT DID NOT FIX THE PROBLEM OF THE JEEP STALLING AND SHUTTING OFF. THIS IS MY MAIN VEHICLE AND I CAN NOT…
Read full complaint
THE ENGINE HAS STALLED ON ME MANY TIMES WHILE DRIVING AT A SLOW SPEED, TAKE OFF FROM A STOP LIGHT OR WHILE STANDING STILL. ENGINE LIGHT HAS COME ONE NUMEROUS TIMES AND CODES HAVE LEAD TO DIFFERENT SENSORS. WHICH WERE REPLACED BUT DID NOT FIX THE PROBLEM OF THE JEEP STALLING AND SHUTTING OFF. THIS IS MY MAIN VEHICLE AND I CAN NOT CHANCE THE SAFETY OF MY KIDS AND FAMILY WHEN NO ONE WANTS TO TAKE ACTION FOR A PROBLEM THAT HAS NOT BEEN FIXED OR RECALLED. IF ANYTHING HAPPENS TO MY FAMILY DIE TO THIS PROBLEM THERE WILL BE A LAW SUIT. I BOUGHT THIS VEHICLE USED WITH A LITTLE OVER 60,000 MILES ON IT AND HAVE ONLY HAD IT FOR A MONTH. I CAN NOT EVEN GO A FULL WEEK WITH OUT IT SHUTTING OFF OR STALLING ON ME. THERE IS A SERIOUS ISSUE THAT JEEP CHRYSLER NEEDS TO LOOK INTO! *TR
NHTSA ODI #10514885
40,000 miles · May 14, 2013
Electrical SystemEnginePower Train
PURCHASED THE JEEP IN JANUARY OF 2011. WITHIN A MONTH OF OWNING IT, IT WOULD RANDOMLY STALL WHILE DRIVING DOWN THE ROAD. WHEN THE JEEP STALLS, ALL OF THE LIGHTS IN THE DASHBOARD ILLUMINATE. YOU CAN PUSH DOWN ON THE GAS PEDAL AND THE RPM'S GO UP, BUT THE SPEED STILL DECREASES UNTIL THE VEHICLE STOPS. IT WILL CUT RIGHT BACK ON…
Read full complaint
PURCHASED THE JEEP IN JANUARY OF 2011. WITHIN A MONTH OF OWNING IT, IT WOULD RANDOMLY STALL WHILE DRIVING DOWN THE ROAD. WHEN THE JEEP STALLS, ALL OF THE LIGHTS IN THE DASHBOARD ILLUMINATE. YOU CAN PUSH DOWN ON THE GAS PEDAL AND THE RPM'S GO UP, BUT THE SPEED STILL DECREASES UNTIL THE VEHICLE STOPS. IT WILL CUT RIGHT BACK ON AFTER STOPPING AND CUTTING THE ENGINE OFF. THE VEHICLE WILL RANDOMLY DO THIS NO MATTER THE WEATHER CONDITIONS, SPEED, OR ANYTHING ELSE. TOOK IT TO A MECHANIC AND THEY COULDN'T FIND ANYTHING WRONG WITH IT AND I WAS TOLD THEY WOULD HAVE TO RECREATE THE PROBLEM THEMSELVES TO FIX IT. SINCE IT RANDOMLY MESSES UP UNDER NO SPECIAL CIRCUMSTANCES, I COULDN'T LEAVE THE VEHICLE WITH THEM WHILE THEY DROVE IT EVERY DAY TRYING TO RECREATE THE PROBLEM. JEEP HAS DONE THIS PROBABLY 10 TIMES SINCE I HAVE OWNED IT. I CALLED A DEALERSHIP AND GAVE MY VIN AND WAS TOLD NO RECALLS ON THIS VEHICLE. YET I AM CONTINUOUSLY READING ABOUT THE SAME EXACT ISSUE WITH OTHER PEOPLE'S 2007 JEEP COMMANDERS. *TR
NHTSA ODI #10511843
65,000 miles · May 11, 2013
Electrical SystemEngineFuel/propulsion System
VEHICLE WILL IDLE ROUGH AND STALL AFTER 15-45 SECONDS AFTER STARTING. WILL NOT STAY RUNNING IN P,N, OR D. *TR
NHTSA ODI #10511494
NHTSA investigations
3PE14017 · Air Bag Non-deployment
Opened Jun 16, 2014 · Closed Dec 23, 2014
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Additional source detail variants (3)
Electrical System:ignition
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:module
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
EA07007 · Engine Stalling
Opened Apr 27, 2007 · Closed May 7, 2008
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Additional source detail variants (3)
Electrical System
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Engine And Engine Cooling
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
PE07009 · Engine Stall
Opened Feb 12, 2007 · Closed Apr 27, 2007
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Electrical System
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Illustration