NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
515 reportsClear category filter1,500 miles · Dec 2, 2014
Engine
WHILE DRIVING, WHEN I TAKE MY FOOT OFF THE GAS PEDAL IN ORDER TO COAST, THE CAR WILL ACCELERATE. WHILE DRIVING, WHEN I TAKE MY FOOT OFF THE GAS AND BEGIN TO BRAKE, MY CAR WILL ACCELERATE. THIS HAS BEEN HAPPENING SINCE I PURCHASED THE VEHICLE ON OCT 30, 2014. IT WAS A MINIMAL OCCURRENCE AND WOULD COME AND GO, BUT NOW IT OCCURS EV…
Read full complaint
WHILE DRIVING, WHEN I TAKE MY FOOT OFF THE GAS PEDAL IN ORDER TO COAST, THE CAR WILL ACCELERATE. WHILE DRIVING, WHEN I TAKE MY FOOT OFF THE GAS AND BEGIN TO BRAKE, MY CAR WILL ACCELERATE. THIS HAS BEEN HAPPENING SINCE I PURCHASED THE VEHICLE ON OCT 30, 2014. IT WAS A MINIMAL OCCURRENCE AND WOULD COME AND GO, BUT NOW IT OCCURS EVERY SINGLE TIME I DRIVE THE CAR. THIS DAILY ISSUE WHERE MY VEHICLE ACCELERATES WHEN IT SHOULD NOT HAS BEEN GOING ON SINCE APPROXIMATELY MID-LATE NOVEMBER 2014. *JS
NHTSA ODI #10661551
8,500 miles · Nov 25, 2014
Electrical SystemElectronic Stability Control (esc)Engine
SECOND INCIDENT FOR THIS CAR. FIRST INCIDENT WAS 10.18.14. I WAS PARKING CAR AT A RESTAURANT. WHILE EDGING NEAR ENDING POINT OF PARKING SPACE, PARK SENSE SUDDENLY DISABLED AND WOULD NOT ENABLE. IMMEDIATELY THEREFORE, A SERIES OF ICONS APPEARED ON THE DASHBOARD IN THIS ORDER: 1) RED LIGHTENING BOLT FOR THE ETC, 2) FRONT END CO…
Read full complaint
SECOND INCIDENT FOR THIS CAR. FIRST INCIDENT WAS 10.18.14. I WAS PARKING CAR AT A RESTAURANT. WHILE EDGING NEAR ENDING POINT OF PARKING SPACE, PARK SENSE SUDDENLY DISABLED AND WOULD NOT ENABLE. IMMEDIATELY THEREFORE, A SERIES OF ICONS APPEARED ON THE DASHBOARD IN THIS ORDER: 1) RED LIGHTENING BOLT FOR THE ETC, 2) FRONT END COLLISION LIGHT LIKE I HAD A WRECK, 3) ENGINE LIGHT, 4) TRACTION LIGHT. THE POWER STEERING APPEARED VERY STIFF. CAR WAS STILL RUNNING. DROVE CAR OUT OF PARKING SPACE AND IT WOULD NOT ACCELERATE; IT MOVED AT A VERY SLOW PACE LIKE IT WAS STUCK IN MOLASSES OR QUICK SAND. PLACED CAR IN PARK AND TURNED OFF IGNITION. WHILE SHIFTING FROM D TO P, THE SHIFT WAS SO VIOLENT IT SHOOK THE ENTIRE CAR AND I COULD HEAR GRINDING. LET CAR REST FOR 60-90 SECONDS. TURNED CAR BACK ON AND ONLY THE ENGINE LIGHT REMAINED LIT. POWER STEERING WAS NOT STIFF. DROVE CAR TO DEALERSHIP THE NEXT MORNING. *TR
NHTSA ODI #10660985
200 miles · Nov 25, 2014
EngineExterior LightingVehicle Speed Control
SORRY I'M NOT SURE WHY IT DOES THIS... WHEN I'M DRIVING SOMETIMES AND I TAKE MY FOOT OFF THE GAS TO SLOW DOWN.. FOR SOME REASON MY CAR ON IT OWN.. SPEEDS UP.. I WATCH THE RPM AND THERE IS A BIG JUMP IN REV.. I'M NOT SURE WHAT THAT IS.. I ACTUALLY LURCH FORWARD. I'M SCARED THAT ONE DAY IT'S GOING TO HIT A PERSON OR GO THROUGH THE…
Read full complaint
SORRY I'M NOT SURE WHY IT DOES THIS... WHEN I'M DRIVING SOMETIMES AND I TAKE MY FOOT OFF THE GAS TO SLOW DOWN.. FOR SOME REASON MY CAR ON IT OWN.. SPEEDS UP.. I WATCH THE RPM AND THERE IS A BIG JUMP IN REV.. I'M NOT SURE WHAT THAT IS.. I ACTUALLY LURCH FORWARD. I'M SCARED THAT ONE DAY IT'S GOING TO HIT A PERSON OR GO THROUGH THE WALL OF MY GARAGE! THE SECOND THING IS MY LIGHT SWITCH I AM NOT SURE WHY BUT TWICE IT'S PUSHED INTO MY DASH BOARD .. .THE FIRST TIME IT HAPPENED I WAS STUCK AT DUSK .. COULDN'T DRIVE.. MY NORMAL DEALERSHIP IN NORTH SEATTLE CALLED THE DWAYNE LANE IN EVERETT AND THEY TOLD MY DEALERSHIP THAT THEY WON'T DO WARRANTY WORK.. SO MY DEALERSHIP HAD TO SEND OUT A GUY FROM SERVICE AND DRIVE ALL THE WAY TO EVERETT TO DO A TEMPORARY FIX... THE THIRD COMPLAINT .. NOW AT 9500 MILES THERE'S A LEAK IN MY ENGINE COOLANT.. AND IT LEFT ME STRANDED IN EVERETT AND HAD TO BE TOWED.. BY THE WAY TRIED TO GO TO THE EVERETT DEALERSHIP DWAYNE LANE AND AGAIN THEY WOULDN'T HELP ME THIS TIME.. I HAD NO RIDE HOME AND THEY WOULDN'T PROVIDE A RENTAL CAR.. EVEN THOUGH I PAID FOR A VERY EXPENSIVE EXTENDED WARRANTY. I HAD THE CAR TOWED THE NEXT DAY TO MARYSVILLE JEEP DEALERSHIP AND THEY ARE WONDERFUL! DON'T BUY FROM DWAYNE LANE IN EVERETT!!!! THE SERVICE DEPARTMENT IS THE WORST IN THE COUNTRY. I'VE HEARD MANY HORROR STORIES FROM CLIENTS.. TO TOW TRUCK DRIVERS .. TO OTHER DEALERS. *TR
NHTSA ODI #10660972
1,450 miles · Nov 24, 2014
EnginePower Train
AT A HIGHWAY CRUISING SPEED, WHEN THE GAS PEDAL IS RELEASED AND THE CAR IS ALLOWED TO DECELERATE ITSELF WITHOUT PRESSING THE BRAKE, AT CERTAIN DOWNSHIFTS THE CAR WILL EXPERIENCE A JUMP IN ENGINE RPM OF 1000 AND THE CAR WILL LURCH FORWARD AND ACCELERATE ON ITS OWN. THIS IS ESPECIALLY DANGEROUS WHEN GOING AROUND CURVES OR IF THER…
Read full complaint
AT A HIGHWAY CRUISING SPEED, WHEN THE GAS PEDAL IS RELEASED AND THE CAR IS ALLOWED TO DECELERATE ITSELF WITHOUT PRESSING THE BRAKE, AT CERTAIN DOWNSHIFTS THE CAR WILL EXPERIENCE A JUMP IN ENGINE RPM OF 1000 AND THE CAR WILL LURCH FORWARD AND ACCELERATE ON ITS OWN. THIS IS ESPECIALLY DANGEROUS WHEN GOING AROUND CURVES OR IF THERE WERE ICE ON THE ROAD OR THE CAR WERE HYDROPLANING. CHRYSLER JEEP HAS NOT RELEASED A FIX OR A RECALL FOR THIS ISSUE AND IT IS BEING SAID THAT IT IS NORMAL FOR THE TRANSMISSION TO DO THIS. I BELIEVE IT IS A DANGEROUS CONDITION WITH HIGH POTENTIAL FOR ACCIDENTS UNLESS FIXED. *TR
NHTSA ODI #10660549
7,490 miles · Nov 20, 2014
Electrical SystemEngineVehicle Speed Control
I RECEIVED A PHONE CALL FROM MY WIFE WHO WAS ON HER WAY HOME FROM WORK AT APPROXIMATELY 1825HRS. SHE WENT ON TO EXPLAIN TO ME THAT HER VEHICLE WAS "ACTING" UP AGAIN WITH ALL THE SAME SYMPTOMS AS LAST TIME (FIRST INCIDENT HAS ALREADY BEEN SUBMITTED UNDER SAME INFORMATION). SHE LOST A SIGNIFICANT AMOUNT OF POWER WHILE TRAVELING …
Read full complaint
I RECEIVED A PHONE CALL FROM MY WIFE WHO WAS ON HER WAY HOME FROM WORK AT APPROXIMATELY 1825HRS. SHE WENT ON TO EXPLAIN TO ME THAT HER VEHICLE WAS "ACTING" UP AGAIN WITH ALL THE SAME SYMPTOMS AS LAST TIME (FIRST INCIDENT HAS ALREADY BEEN SUBMITTED UNDER SAME INFORMATION). SHE LOST A SIGNIFICANT AMOUNT OF POWER WHILE TRAVELING ON A BUSY HIGHWAY WHERE THE SPEED POSTED IS 65MPH. WHEN THIS HAPPENED SHE PULLED OFF TO SHOULDER AND TOOK PHOTOGRAPHS WITH HER IPHONE TO KEEP FOR OUR RECORDS AND TO WHAT HER DASH WAS DISPLAYING. SHE STOPPED WHILE ON THE SHOULDER AND PUT THE VEHICLE IN PARK AND TURNED OFF THE IGNITION. AFTER SOME TIME SHE TURNED THE IGNITION ON AND PUT THE VEHICLE IN DRIVE WHEN SHE NOTICED THE VEHICLE "JERKED" AND MADE A LOUD CLUNKY NOISE. THIS IS THE SECOND INCIDENT. THE FIRST INCIDENT DEALERSHIP WAS UNABLE TO FIND ANY PROBLEMS UNDER THE DIAGNOSTICS THEY RAN. *TR
NHTSA ODI #10659612
6,400 miles · Nov 20, 2014
Electrical SystemEngineVehicle Speed Control
ON THE ABOVE DATE WHILE TRAVELING TO WORK MY WIFE CALLED ME AND INFORMED THAT HER VEHICLE HAD LOST POWER DURING OPERATION ON A BUSY HIGHWAY. UPON FURTHER EXPLANATION SHE INFORMED ME WHILE ACCELERATING TO THE PROPER SPEED FOR THE POSTED SPEED LIMIT OF 55MPH THE VEHICLE HAD LOST POWER AND THE "SERVICE TRANSMISSION" LIGHT ILLUMINA…
Read full complaint
ON THE ABOVE DATE WHILE TRAVELING TO WORK MY WIFE CALLED ME AND INFORMED THAT HER VEHICLE HAD LOST POWER DURING OPERATION ON A BUSY HIGHWAY. UPON FURTHER EXPLANATION SHE INFORMED ME WHILE ACCELERATING TO THE PROPER SPEED FOR THE POSTED SPEED LIMIT OF 55MPH THE VEHICLE HAD LOST POWER AND THE "SERVICE TRANSMISSION" LIGHT ILLUMINATED. SHE THEN PULLED OFF THE BUSY ROAD TO A SAFE A SPOT AND PROCEEDED TO CONTACT OUR INSURANCE AND THE LOCAL JEEP/CHRYSLER DEALERSHIP, AS WE ARE CURRENTLY UNDER WARRANTY. ONCE I ARRIVED TO MY WIFE'S LOCATION WE WAITED FOR THE TOW TRUCK AND UPON HIS ARRIVAL HE ASKED IF THE VEHICLE COULD BE DRIVEN, AT THIS TIME I TURNED ON THE VEHICLE AND PLACED IT IN DRIVE, THE "SERVICE TRANSMISSION" LIGHT WAS STILL ON. I WAS ABLE TO DRIVE IN APPROXIMATELY 3 MILES TO THE DEALERSHIP ALL AWHILE BEING FOLLOWED BY THE TOW TRUCK AND WITHOUT INCIDENT. *TR
NHTSA ODI #10659611
12,630 miles · Nov 4, 2014
Electronic Stability Control (esc)EnginePower Train
THE CAR IS ONLY 5 MONTHS OLD. HAS A ZF 9 SPEED AUTOMATIC TRANSMISSION AND 3.2L 46 24V -VVT ENGINE. I WAS DRIVING ON A TOLLWAY IN MODERATE TRAFFIC AT A SPEED OF APPROXIMATELY 60-65 MPH. WITHOUT SLOWING DOWN OR CHANGING SPEED, THE DISPLAY ON THE DASH LISTED "SERVICE TRANSMISSION". ALL POWER TO THE ENGINE WAS LOST AND CAR BEGAN TO …
Read full complaint
THE CAR IS ONLY 5 MONTHS OLD. HAS A ZF 9 SPEED AUTOMATIC TRANSMISSION AND 3.2L 46 24V -VVT ENGINE. I WAS DRIVING ON A TOLLWAY IN MODERATE TRAFFIC AT A SPEED OF APPROXIMATELY 60-65 MPH. WITHOUT SLOWING DOWN OR CHANGING SPEED, THE DISPLAY ON THE DASH LISTED "SERVICE TRANSMISSION". ALL POWER TO THE ENGINE WAS LOST AND CAR BEGAN TO SLOW DOWN. WOULD NOT RESPOND TO ACCELERATION. CHECK ENGINE LIGHT, STABILITY CONTROL LIGHT, P! WERE ALL DISPLAYED. HAD TO FIND A WAY TO THE SHOULDER AND STOP CAR. TURNED OFF CAR AND RESTARTED IT. "CHECK TRANSMISSION " WAS DISPLAYED. PUT IT IN DRIVE AND IT FELT LIKE IT WAS STARTING IN 2ND OR 3RD GEAR. WOULD NOT SHIFT GEARS. COULD GET UP TO 35 MPH WITH THE TACH AT 2000 RPM. WOULD NOT SHIFT AT ALL. GOT HOME AND LET CAR SIT FOR A FEW HOURS. STARTED CAR AFTER SITTING FOR A FEW HOURS AND THE "SERVICE TRANSMISSION" WAS GONE. ALL OTHER WARNING LIGHTS WERE GONE EXCEPT FOR SERVICE ENGINE LIGHT. DROVE TO DEALER NEXT DAY AND CAR APPEARED TO SHIFT OK. DEALER LOADED PCM FLASH UPDATE. REPROGRAMMED TCM PER TSB 21-018-14. REPROGRAMMED RF HUB PER 08-077-14. CAR APPEARS TO BE DRIVING OK. DEALER SAID THEY COULDN'T FIND ANY PROBLEMS WITH THE TRANSMISSION. THEY TREATED THIS VERY LIGHTLY . I FEEL THIS IS A SIGNIFICANT SAFETY ISSUE. LOST ALL ACCELERATION AND CONTROL AT HIGH SPEED. NO NOTIFICATION OF UPDATES WERE SENT PREVIOUSLY. *TR
NHTSA ODI #10652549
4,500 miles · Oct 25, 2014
EngineFuel/propulsion SystemPower Train
WHEN DECELERATING FOR A SPEED ZONE, THE TRANSMISSION DOWNSHIFTED FROM 5TH TO 4TH, THE RPMS WENT UP APPROXIMATELY 1000 AND THE CAR ACCELERATED. THE 'UNINTENDED' ACCELERATION CHARACTERISTIC IS ALSO EVIDENT ON DOWNHILL DRIVING IN THE MOUNTAINOUS TERRAIN. THIS OCCURS OR A FREQUENT BASIS AND WAS EVIDENT PRIOR TO, AND AFTER, A TRANS…
Read full complaint
WHEN DECELERATING FOR A SPEED ZONE, THE TRANSMISSION DOWNSHIFTED FROM 5TH TO 4TH, THE RPMS WENT UP APPROXIMATELY 1000 AND THE CAR ACCELERATED. THE 'UNINTENDED' ACCELERATION CHARACTERISTIC IS ALSO EVIDENT ON DOWNHILL DRIVING IN THE MOUNTAINOUS TERRAIN. THIS OCCURS OR A FREQUENT BASIS AND WAS EVIDENT PRIOR TO, AND AFTER, A TRANSMISSION/TCM REPLACEMENT. MY WIFE NO LONGER FEELS SAFE DRIVING THIS VEHICLE AND HAS GONE BACK TO USING HER SUBARU FOR COMMUTING. THERE ARE OBVIOUS ISSUES WITH THE ENGINE/TRANSMISSION CONTROL FIRMWARE/HARDWARE WHICH NEED TO BE ADDRESSED. *TR
NHTSA ODI #10649970
6,900 miles · Oct 22, 2014
Electrical SystemEnginePower Train
AT FREEWAY SPEED OF 65, THE VEHICLE SUDDENLY HAD NO POWER, WENT INTO NEUTRAL, AND "SERVICE TRANSMISSION" WARNING CAME ON. UPON TRYING TO ACCELERATE TO PULL TO THE SHOULDER, THE ENGINE WOULD SIMPLY REV RPMS BUT PROVIDED NO POWER, EVEN AFTER TRYING TO SHIFT BETWEEN NEUTRAL AND DRIVE. AFTER GETTING TO THE SIDE OF THE ROAD, THE VE…
Read full complaint
AT FREEWAY SPEED OF 65, THE VEHICLE SUDDENLY HAD NO POWER, WENT INTO NEUTRAL, AND "SERVICE TRANSMISSION" WARNING CAME ON. UPON TRYING TO ACCELERATE TO PULL TO THE SHOULDER, THE ENGINE WOULD SIMPLY REV RPMS BUT PROVIDED NO POWER, EVEN AFTER TRYING TO SHIFT BETWEEN NEUTRAL AND DRIVE. AFTER GETTING TO THE SIDE OF THE ROAD, THE VEHICLE WAS SHUT OFF AND TURNED BACK ON, AT WHICH TIME THE SERVICE TRANSMISSION LIGHT WAS STILL ON, BUT THE VEHICLE WORKED AGAIN. THE DEALER REPLACED THE ENTIRE TRANSMISSION UNDER WARRANTY BUT PROVIDED NO EXPLANATION OF WHY IT SUDDENLY LOST ALL POWER ON THE FREEWAY AND COULD HAVE EASILY CAUSED A WRECK WHEN TRYING TO GET OVER SEVERAL LANES ON A BUSY FREEWAY. *TR
NHTSA ODI #10649310
7,500 miles · Oct 21, 2014
Electrical SystemEngineSteering
WHILE PARKING THE VEHICLE, THE PARKSENSE FEATURE DISABLED ON ITS OWN. IMMEDIATELY THEREAFTER, THE RED LIGHTNING BOLT INDICATOR LIGHT APPEARED ON THE DASH, WHICH HAS BEEN KNOWN TO BE ASSOCIATED WITH THE ELECTRONIC THROTTLE CONTROL, GLOW PLUGS, SWIRL MOTOR FAILURE (LOW PRESSURE IN RAIL OR FUEL RAIL PRESSURE MALFUNCTION) AND ALSO S…
Read full complaint
WHILE PARKING THE VEHICLE, THE PARKSENSE FEATURE DISABLED ON ITS OWN. IMMEDIATELY THEREAFTER, THE RED LIGHTNING BOLT INDICATOR LIGHT APPEARED ON THE DASH, WHICH HAS BEEN KNOWN TO BE ASSOCIATED WITH THE ELECTRONIC THROTTLE CONTROL, GLOW PLUGS, SWIRL MOTOR FAILURE (LOW PRESSURE IN RAIL OR FUEL RAIL PRESSURE MALFUNCTION) AND ALSO SPEED SENSORS. THE VEHICLE THEN REVVED UP ON ITS OWN WITHOUT ACCELERATION WHILE MY FOOT WAS POSITIONED FIRMLY ON THE BRAKE PEDAL. IMMEDIATELY FOLLOWING THAT, THE WORD "TRANSMISSION" APPEARED ON THE DASH, THEN THE CHECK ENGINE LIGHT, THEN THE COLLISION INDICATOR AS IF A CAR CRASH HAD OCCURRED, WHICH IT HAD NOT. FINALLY, THE POWER STEERING BECAME VERY STIFF. DROVE THE VEHICLE TO THE DEALERSHIP IT WAS PURCHASED FROM AND THEY SAID THE CODES WERE UNKNOWN LIKE HIEROGLYPHICS. LEFT VEHICLE THERE. THE FOLLOWING MONDAY THE DEALERSHIP INFORMED ME THERE WERE 3 SOFTWARE UPGRADES THAT WERE NEEDED ON THE VEHICLE, HOWEVER, THOSE UPGRADES DID NOT CORRECT THE PROBLEM. TECHNICIAN ALSO INFORMED ME THE CAR WAS NOT SAFE TO DRIVE AND THEY DIDN'T FEEL SAFE DRIVING IT THEMSELVES AND GOT OFF OF THE HIGHWAY DURING A TEST RUN. THE TECHNICIAN FURTHER EXPLAINED THE VEHICLE HAD 3 TEST RUNS AND FAILED ALL 3 AND IT WAS BEYOND THEIR EXPERTISE SO CHRYSLER ENGINEERS WOULD BE CONSULTED THIS WEEK. LASTLY, THE TECHNICIAN INFORMED ME I "MAY BE AHEAD OF A RECALL ISSUE." THE CAR IS 5 AND HALF MONTHS OLD. I ORDERED THE CAR, MEANING, I HAD IT MADE/BUILT FROM THE MANUFACTURER. IT WAS NOT A CAR PURCHASED FROM THE LOT. THEREFORE, NO OTHER DRIVERS OF THE CAR AND IT IS BRAND NEW. IT IS A SAFETY CONCERN, ESPECIALLY SINCE THE CHEROKEE HAS BEEN OUT OF PRODUCTION FOR MANY YEARS UNTIL THE 2014 RELEASE. AS A SIDE NOTE, I REMEMBER AN INCIDENT THAT OCCURRED THE WEEK PRIOR WHEN THE VEHICLE HAD DIFFICULTY SHIFTING GEARS (AUTOMATIC TRANSMISSION). INSTEAD IT STALLED AND REVVED ON ITS OWN. *TR
NHTSA ODI #10649110
Official recalls
13May 11, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Jun 11, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence & remedy
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Additional source detail variants (2)
Power Train:driveline:differential Unit
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Jun 13, 2019
Chrysler (FCA US LLC) is recalling certain 2014 Jeep Cherokee vehicles equipped with 3.2L engines. In the event that a clutch becomes stuck in the transmission, the transmission software may shift the transmission to neutral.
Consequence & remedy
Consequence: An unexpected shift to neutral would result in a loss of drive, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will update the transmission software, free of charge. The recall began August 8, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V69.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 10, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence & remedy
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Additional source detail variants (2)
Seats:mid/rear Assembly
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Seats
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Jul 12, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee and 2015 Chrysler 200, Jeep Renegade, RAM ProMaster, and 2016 Fiat 500X vehicles equipped with 9-speed automatic transmissions. The transmission sensor clusters may have insufficient crimps in the transmission wire harness, and as a result, the transmission may unexpectedly shift to neutral. On August 29, 2016 Chrysler added the 2016 Fiat 500X vehicles to this recall.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Chrysler will notify owners, dealers will reprogram the Powertrain Control Module and the Transmission Control Module and if necessary replace the transaxle range sensor wire harness, free of charge. The recall began on November 7, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S55.
Aug 12, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014 Jeep Cherokee vehicles manufactured January 4, 2013, to July 11, 2014. Use of the front windshield wipers on dry glass may cause damage to the body control module (BCM).
Consequence & remedy
Consequence: BCM damage may result in the failure of the windshield wipers, impairing the driver's vision and increasing the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will install a ground strap to protect the BCM from damage, free of charge. Owners were notified of the recall on October 7, 2015. The recall began on December 15, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R39.
Jul 23, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Consequence & remedy
Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.
Jun 22, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 4, 2013, to February 18, 2015 and equipped with a Power Liftgate option. In the affected vehicles, water may enter the Power Liftgate Control Module and cause a high resistance short circuit in the module.
Consequence & remedy
Consequence: A short circuit in the liftgate control module may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the power liftgate control module and connectors for corrosion, substitute a bolt for the threaded grommet installed to seal an attachment point used in non-power liftgate vehicles and cover the power liftgate control module in a foam water shield, free of charge. The recall began on October 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R27. This recall is superseded by NHTSA recall 23V-338.
Jan 28, 2015
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence & remedy
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Additional source detail variants (2)
Air Bags:side/window:curtain
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Air Bags:side/window
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Jul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Jeep Cherokee and Ram 1500 and 2015 Chrysler 200 vehicles. Due to an insufficient weld, the rear shocks may detach from the vehicle at one end and possibly damage other chassis components, the tire or result in reduced braking.
Consequence & remedy
Consequence: Damage to the tire or reduced braking increases the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will inspect the rear shocks and replace any affected ones, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P37.
Jun 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence & remedy
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Additional source detail variants (2)
Forward Collision Avoidance: Adaptive Cruise Control
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Vehicle Speed Control:accelerator Pedal
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE22009 · Electronic Parking Brake Water Ingress
Opened Jul 22, 2022 · Closed Oct 29, 2023
Status: closed (inferred from source dates) · Parking Brake:electrical; Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Parking Brake:electrical
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
RQ15004 · Software Security Vulnerability
Opened Jul 24, 2015 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Electrical System:software
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015 letter, FCA submitted a second Part 573 safety recall report expanding the scope of the Uconnect RA4 model radio to include additional 7,810 MY 2015 Jeep Renegade vehicles manufactured from September 18, 2014 through June 25, 2015 (Recall 15V-508).Scope analysis indicated that Uconnect radios installed in FCA vehicles not included in recalls 15V-461 or 15V-508 (subject recalls) are not equipped with built-in cellular access or short range wireless communication features and, thus, do not contain the security vulnerabilities addressed by the subject recalls. SUBJECT VEHICLES: MY2014 through 2015 Dodge Durango, Jeep Grand Cherokee and Jeep Cherokee sport utility vehicles; MY2013 through 2015 Ram 1500, 2500, 3500 and 4500/5500 pickup trucks; MY2013 through 2015 Dodge Viper vehicles; and MY2015 Chrysler 200, 300, Jeep Renegade, Dodge Charger and Challenger vehicles.According to FCA, long and short range wireless vulnerabilities identified in the recalled vehicles could allow unauthorized third-party access to, and manipulation of, networked vehicle control systems.Successful exploitation of the vulnerabilities, coupled with reverse engineering of networked microprocessor control modules, could result in unauthorized manipulation of vehicle control systems. This unauthorized manipulation of vehicle controls and systems could expose the driver, vehicle occupants or other highway users to an increased risk of injury.FCA and its network provider, Sprint, conducted a nationwide campaign to block access to a radio communications port that was unintentionally left open.On July 27, 2015, short range wireless vulnerabilities were also blocked.Finally, third party security evaluation and regression testing identified vulnerabilities that were either remedied by Sprint or through updates to the FCA Uconnect software.ODI identified a total of 30 complaints or field reports on unique vehicles submitted by FCA (29) or received by NHTSA (1) alleging incidents of theft from a vehicle or anomalous performance that the owner alleged were caused by, or may have been caused by, remote hacking.Twenty-six (87%) of these reports were submitted after a magazine article was published on July 21, 2015, describing the remote hacking of an FCA vehicle by researchers who were able to affect the operation of various vehicle control systems, including the service brakes, steering, throttle and ignition.Most of the complaints involved vehicle systems that were not safety critical (e.g., complaints related to radio, navigation system, or air-conditioning control) and did not affect vehicle control.Three complaints reported engine stalls.One owner reported sudden unintended acceleration allegedly related to hacking.None of the complaints or field reports reviewed involved the steering and braking vehicle control effects demonstrated by the research hackers prior to the recall.There were no confirmed incidents of hacking in any of the records reviewed by ODI.The remedies completed by Sprint and FCA appear to have eliminated vulnerabilities that mi
Illustration