IllustrationDON'T BUY A JEEP! PIECE OF JUNK. SINCE I HAVE OWNED MINE THE FOLLOWING HAS BROKE RADIATOR, SEAT TRACK, POWER WINDOW MOTOR, BRAKES, BLOWOUT, TRANSMISSION, HEADLIGHT COVERS DULLED, MULTIPLE REAR LIGHT OUTAGES, INSIDE LIGHTS OUT. *TR
2001 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2001 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
1525–50K
2250–75K
1475–100K
19100–150K
8150K+
104 reports with mileage · 125 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports13 fire reports15 injury reports
Power Train complaints
24 reports2001 JEEP CHEROKEE SPORT, WIFE PARKS VEHICLE AT TOP OF STEEP DRIVEWAY ON FAIRLY LEVEL GROUND. PUTS TRANSMISSION IN "PARK", SETS EMERGENCY BRAKE AND EXITS CAR, LEAVING CAR RUNNING FOR NIECE AND 2YR OLD SON TO HAVE AC. AFTER APPROXIMATELY 15 MIN, NIECE DECIDES TO EXIT VEHICLE, OPENS PASSENGER DOOR, REACHES OVER TO TURN OFF IGNITIO…
Read full complaint
2001 JEEP CHEROKEE SPORT, WIFE PARKS VEHICLE AT TOP OF STEEP DRIVEWAY ON FAIRLY LEVEL GROUND. PUTS TRANSMISSION IN "PARK", SETS EMERGENCY BRAKE AND EXITS CAR, LEAVING CAR RUNNING FOR NIECE AND 2YR OLD SON TO HAVE AC. AFTER APPROXIMATELY 15 MIN, NIECE DECIDES TO EXIT VEHICLE, OPENS PASSENGER DOOR, REACHES OVER TO TURN OFF IGNITION. AS SOON AS IGNITION IS TURNED OFF, CAR LURCHES BACKWARD, RUNS DOWN HILL, CROSSES THE STREET, RUNS THROUGH NEIGHBORS BACK YARD, THROUGH TREES, OVER RETAINING WALL AND HIGH CENTERS ON LARGE LOG. ALL PASSENGERS WERE OKAY BUY DID OVER $3000.00 IN DAMAGE TO VEHICLE. *NM
DT: THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALERSHIP STATED THE COMPUTER SHOWED A PROBLEM WITH THE TRANSMISSION. THE ORIGINAL TRANSMISSION JERKED WHILE IN MOTION AND CHANGING GEARS. HOWEVER, THE REPLACEMENT TRANSMISSION EXPERIENCED THE SAME PROBLEM. THE DEALERSHIP REPLACED THE TRANSMISSION AGAIN, BUT …
Read full complaint
DT: THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALERSHIP STATED THE COMPUTER SHOWED A PROBLEM WITH THE TRANSMISSION. THE ORIGINAL TRANSMISSION JERKED WHILE IN MOTION AND CHANGING GEARS. HOWEVER, THE REPLACEMENT TRANSMISSION EXPERIENCED THE SAME PROBLEM. THE DEALERSHIP REPLACED THE TRANSMISSION AGAIN, BUT THE REPLACEMENT STARTED SMOKING. THE DEALER REPLACED AN OIL SEAL AND THE SMOKING CONTINUED. AFTER THE TRANSMISSIONS WERE REPLACED THE CHECK ENGINE LIGHT CONTINUED TO STAY ILLUMINATED. *AK
I OWN A 2001 JEEP CHEROKEE SPORT. I HAVE HAD SEVERAL ISSUES SUCH AS BRAKES/ROTORS THAT I HAVE TAKEN CARE OF WITHOUT COMPLAINT. HOWEVER MY JEEP WAS JUST DIAGNOSED WITH A FRONT DIFFERENTIAL FAILURE AND NEEDS A COMPLETE OVERHAUL. MY CAR HAS ONLY 60,000 MILES ON IT AND I HAVE HAD THE FRONT AND REAR DIFFERENTIALS SERVICED TWICE EACH …
Read full complaint
I OWN A 2001 JEEP CHEROKEE SPORT. I HAVE HAD SEVERAL ISSUES SUCH AS BRAKES/ROTORS THAT I HAVE TAKEN CARE OF WITHOUT COMPLAINT. HOWEVER MY JEEP WAS JUST DIAGNOSED WITH A FRONT DIFFERENTIAL FAILURE AND NEEDS A COMPLETE OVERHAUL. MY CAR HAS ONLY 60,000 MILES ON IT AND I HAVE HAD THE FRONT AND REAR DIFFERENTIALS SERVICED TWICE EACH ACCORDING TO THE SPECS IN MY OWNER'S MANUAL. I'VE BEEN TOLD BY PRIVATE MECANICS AS WELL AS JEEP TECHNICIANS THAT THIS SHOULD NOT HAVE OCCURED. CHRYSLER TOLD ME AFTER I HAD IT DIAGNOSED BY MY PERSONAL MECHANIC TO HAVE IT CHECKED BY MY DEALERSHIP. IF THE DEALERSHIP CAME TO THE SAME CONCLUSION I WAS ASSURED THAT MY WARRANTY WOULD BE EXTENDED TO COVER THE REPAIR. NOW CHRYSLER IS REFUSING THE REPAIR AND WILL NOT RETURN MY CALLS. I HAVE BEEN GIVEN AT LEAST FALSE INFORMATION AND HAVE MOST LIKELY BEEN LIED TO. I'VE ALREADY PAID ALMOST $200 FOR THE DIAGNOSTICS AND NOW AM BEING QUOTED ANOTHER $925 FOR THE REPAIR BY THE DEALER. I STILL HAVE OVER A YEAR LEFT ON THE NOTE FOR THIS VEHICLE AND AM APPALLED THAT I AM ALREADY PAYING TO HAVE A MAJOR DRIVETRAIN COMPONENT REBUILT. CHRYSLER HAS DONE NOTHING TO REMEDY THIS. *AK
CONSUMER WAS COMPLAINING ABOUT A DIFFERENTIAL PROBLEM. THE BEARINGS WERE GRINDING. CONSUMER TOOK VEHICLE TO THE DEALER ON 4 DIFFERENT OCCASIONS, BUT PROBLEM RECURRED. *AK
CONSUMER COMPLAINED ABOUT ABOUT REAR DIFFERENTIAL. CONSUMER TOOK VEHICLE TO DEALER FOR SERVICING ON 4 OCCASIONS, AND IT WAS MAKING A GRINDING NOISE 8 MONTHS LATER. WARRANTY EXPIRED, AND CONSUMER WAS ASKED TO PAY $500.00 FOR REPAIRS. CONSUMER WAS TOLD THAT THERE WAS METAL IN THE BOTTOM OF DIFFERENTIAL. *AK
VEHICLE WAS PARKED IN THE HOTEL PARKING LOT AND WITHOUT WARNING THE VEHICLE WENT INTO REVERSE, HITTING THE DRIVER BEFORE STOPPING. DEALER HAS BEEN CONTACTED.*AK
WHILE DRIVING THE TRANSMISSION DECELERATED EVEN WHEN THE DRIVERS FOOT WAS ON THE ACCELERATOR, IT ALSO BECAME HARD FOR THE DRIVER TO CONTROL THE VEHICLE. *NLM
THE VEHICLE JERKED AT ANY SPEED.*JB
JEEP PURCHASED 7/19/02. WHEN TRANSMISSION SHIFTS THE SECOND SHIFT, THE SHIFT IS VERY RUFF AND YOU HERE A CLUNK. THIS DOES NOT HAPPEN ON A CONSISTANT BASIS. JEEP WAS TAKEN INTO THE SHOP ON 7/26/02 A CODE "65" FOR TRANSMISSION AND ACCUSED ME OF DRIVING VEHICLE HARSHLY. WHILE DRIVING DURING THE WEEKEND JEEP CONT TO SHIFT THE SAME…
Read full complaint
JEEP PURCHASED 7/19/02. WHEN TRANSMISSION SHIFTS THE SECOND SHIFT, THE SHIFT IS VERY RUFF AND YOU HERE A CLUNK. THIS DOES NOT HAPPEN ON A CONSISTANT BASIS. JEEP WAS TAKEN INTO THE SHOP ON 7/26/02 A CODE "65" FOR TRANSMISSION AND ACCUSED ME OF DRIVING VEHICLE HARSHLY. WHILE DRIVING DURING THE WEEKEND JEEP CONT TO SHIFT THE SAME WAY. TOOK JEEP BACK IN ON 7/29/02 AND GOT JEEP BACK ON7/30/02 STATING THERE WAS NOTHING WRONG WITH IT. THAT EVENING I HAD THE TRANNY SHIFT HARSHLY 2 X. JEEP IS STILL UNDER WARRANTY AND SINCE I AM A WOMAN I THINK THEY DON'T BELIEVE ME. ANY HELP OR INFO WOULD BE GREATLY APPRECIATED. *AK
Official recalls
202V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V366000 · Child Seat
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by