IllustrationTHE CLOCKSPRING IN MY 2000 JEEP CHEROKEE FAILED. AS A RESULT OF THIS I LOST ALL FUNCTIONS IN THE STEERING WHEEL. INCLUDING A OPERABLE AIRBAG AND HORN.
2000 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2000 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2825–50K
2450–75K
1975–100K
28100–150K
16150K+
132 reports with mileage · 237 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports40 fire reports13 injury reports
What owners actually said
369 reportsTL *- THE CONTACT OWNSA 2000 JEEP CHEROKEE. THE CONTACT STATED THAT HE MADE REPAIRS TO THE VEHICLE AND THEN HE RECEIVED A SAFETY RECALL. THE CONTACT SENT THE MANUFACTURER THE REQUIRED INFORMATION AND WAS DENIED THE REIMBURSEMENT. *AK
SAFETY RECALL F-25 ELECTRIC RADIATOR FAN**CC OCTOBER 05 THE ELECTRIC FAN IN THE CONSUMER 'S 2000 JEEP CHEROKEE BROKE AND PUNCTURED AN HOLE IN THE VEHICLE'S RADIATOR. NOVEMBER 06 THE CONSUMER RECEIVED RECALL NOTICE FOR THE ELECTRIC FAN. THE CONSUMER CONTACTED THE MANUFACTURER AND INFORMED THEM THAT THE FAN HAD ALREADY BEEN REP…
Read full complaint
SAFETY RECALL F-25 ELECTRIC RADIATOR FAN**CC OCTOBER 05 THE ELECTRIC FAN IN THE CONSUMER 'S 2000 JEEP CHEROKEE BROKE AND PUNCTURED AN HOLE IN THE VEHICLE'S RADIATOR. NOVEMBER 06 THE CONSUMER RECEIVED RECALL NOTICE FOR THE ELECTRIC FAN. THE CONSUMER CONTACTED THE MANUFACTURER AND INFORMED THEM THAT THE FAN HAD ALREADY BEEN REPLACED. THE MANUFACTURER AGREED TO REIMBURSE THE CONSUMER FOR THE REPAIR COST, BUT REFUSED TO REIMBURSE HIM FOR TOWING COST, RENTAL CAR, AND MISSED WORK. *NM
TL* - THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE LOST POWER. THE CONTACT WAS ABLE TO GET THE VEHICLE RESTARTED ABOUT 30 SECONDS AFTER THE INCIDENT. THE VEHICLE FAILED THREE ADDITIONAL TIMES BEFORE THE CONTACT COULD GET THE VEHICLE TO THE DEALER. THERE WERE NO WARNING SIGNS. THE DIAGNOSIS FROM THE DEALER WAS A SHORT IN…
Read full complaint
TL* - THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE LOST POWER. THE CONTACT WAS ABLE TO GET THE VEHICLE RESTARTED ABOUT 30 SECONDS AFTER THE INCIDENT. THE VEHICLE FAILED THREE ADDITIONAL TIMES BEFORE THE CONTACT COULD GET THE VEHICLE TO THE DEALER. THERE WERE NO WARNING SIGNS. THE DIAGNOSIS FROM THE DEALER WAS A SHORT IN THE VEHICLE'S COMPUTER. *AK
BLEND DOOR FAILURE, HEATER CORE FAILURE. *NM
THE FRONT DRIVERS SIDE SEAT BROKE AT THE BACK APPROXIMATELY JULY 2003. I HAD IT REPAIRED AND I WAS TOLD THAT THE METAL IS TOO THIN AND THAT'S WHY IT BROKE. IT BROKE AGAIN SO I TRIED TO BUY A USED SEAT FROM SEVERAL SALVAGE YARDS. THEY ALL SAID THAT THEY SELL AS FAST AS THEY COME IN DO TO THE BACKS BREAKING. *NM
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON THE HIGHWAY, THE HOOD FLEW UP WITHOUT WARNING OBSTRUCTING BOTH THE DRIVER AND PASSENGER VIEW. THE CONTACT MANAGED TO PULL OVER WITHOUT INCIDENT. AFTER THE CONTACT CLOSED THE HOOD, A PIECE OF STRING WAS TIED TO THE HOOD, AND FRONT GRILL TO SECURE THE HOOD DOWN WHILE DRIVING. THE …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON THE HIGHWAY, THE HOOD FLEW UP WITHOUT WARNING OBSTRUCTING BOTH THE DRIVER AND PASSENGER VIEW. THE CONTACT MANAGED TO PULL OVER WITHOUT INCIDENT. AFTER THE CONTACT CLOSED THE HOOD, A PIECE OF STRING WAS TIED TO THE HOOD, AND FRONT GRILL TO SECURE THE HOOD DOWN WHILE DRIVING. THE DEALER AND MANUFACTURER WERE NOT ALERTED.
DT*: THE CONTACT STATED WHILE DRIVING 5 MPH, THE FRONT OF THE VEHICLE SHOOK. THE VEHICLE WAS IMMEDIATELY DRIVEN HOME AND VISUALLY INSPECTED. UPON VISUAL INSPECTION, IT WAS DISCOVERED THE FAN HAD BROKEN CAUSING THE FAN COVER TO FRACTURE. PIECES OF THE FAN LODGED IN THE ENGINE AND SHROUD. THERE IS A RECALL, NHTSA CAMPAIGN #06…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 5 MPH, THE FRONT OF THE VEHICLE SHOOK. THE VEHICLE WAS IMMEDIATELY DRIVEN HOME AND VISUALLY INSPECTED. UPON VISUAL INSPECTION, IT WAS DISCOVERED THE FAN HAD BROKEN CAUSING THE FAN COVER TO FRACTURE. PIECES OF THE FAN LODGED IN THE ENGINE AND SHROUD. THERE IS A RECALL, NHTSA CAMPAIGN #06V199000, CONCERNING THE FAN. THE VEHICLE IS NOT INCLUDED DUE THE VIN. THE MANUFACTURER HAS BEEN ALERTED OF THE PROBLEM. UPDATED 7/14/2006 - *NM
NOTICE THAT COOLANT WAS DISAPPEARING FROM THE RESERVOIR TANK...HAD TO REFILL EVERY WEEK. TOOK INTO SHOP...NO VISIBLE COOLANT LEAKS. DISCOVERED THAT COOLANT WAS LEAKING INTO THE HEAD IN BETWEEN CYLINDER 3 AND 4. COOLANT VISIBLE UNDER OIL CAP AND OIL CAP AREA. POSSIBLE DEFECTIVE HEAD CASTING (0331). *NM
ON MY WIFE'S 2000 RIGHT HAND DRIVE JEEP CHEROKEE AFTER 120,000 MILES THE CHECK ENGINE LIGHT CAME ON, THE OBD II CODE READ A TRANSMISSION PROBLEM AFTER TRYING TO FIX THE PROBLEM I TOOK IT INTO THE DEALER WHERE THE CAR WAS PURCHASED. THEY INFORMED ME THAT IT WOULD NEED A NEW TRANSMISSION, THEY DO NOT WORK ON THE AW4 TRANSMISSIONS,…
Read full complaint
ON MY WIFE'S 2000 RIGHT HAND DRIVE JEEP CHEROKEE AFTER 120,000 MILES THE CHECK ENGINE LIGHT CAME ON, THE OBD II CODE READ A TRANSMISSION PROBLEM AFTER TRYING TO FIX THE PROBLEM I TOOK IT INTO THE DEALER WHERE THE CAR WAS PURCHASED. THEY INFORMED ME THAT IT WOULD NEED A NEW TRANSMISSION, THEY DO NOT WORK ON THE AW4 TRANSMISSIONS, THEIR FIX IS TO REPLACE IT. I HAD A FRIEND INSTALL THE NEW TRANNY ONLY TO HAVE THE SAME PROBLEM 3,000 MILES LATER, SO BACK TO THE DEALER WE WENT. I WAS CHARGED $550 TO INSTALL THE NEXT ONE BECAUSE THEY DID NOT INSTALL THE FIRST. AFTER 300 MILES THE LIGHT CAME BACK ON AND THE TRANSMISSION WOULD NOT DOWN SHIFT WHICH PUT HER IN DANGER NOT BEING ABLE TO ACCELERATE AFTER DELIVERING MAIL. SO A NEW TRANSMISSION WAS PUT IN AGAIN THIS TIME FOR NO COST EXCEPT GAS TO GET IT TO THE DEALER AND MY WIFE HAVING TO USE HER LEAVE TO HAVE THIS DONE. NOW AFTER 100 MILES THE LIGHT CAME ON THE DEALER SAID THAT THE CHANCES ARE SLIM THAT THE TRANNY WAS BAD AND IT MUST BE IN THE TCM OR THE WIRING HARNESS. WHY DOES CHRYSLER INSTALL A TRANSMISSION IN A VEHICLE AND NOT TRAIN THEIR MECHANICS TO WORK ON THEM. *JB
Official recalls
102V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by