IllustrationTHERE WAS A PROBLEM WITH THE BRAKES, A NOISE IN THE MOTOR, AND THE DIFFERENTIAL WAS LEAKING.*DT *JB
2000 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2000 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2825–50K
2450–75K
1975–100K
28100–150K
16150K+
132 reports with mileage · 237 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports40 fire reports13 injury reports
Power Train complaints
29 reportsTHE VEHICLE WAS PARK BUT RUNNNING, WITHOUT PRIOR WARNING THE VEHICLE JUMPED OUT OF GEAR AND WENT INTO THE RIVER. THE DEALERSHIP IS AWARE OF THE PROBLEM. NLM
I ANGLE PARKED MY JEEP IN A BANK PARKING LOT. AFTER PARKING, THE TRANSMISSION REMAINED IN DRIVE WITH THE MOTOR RUNNING. I SAT IN MY JEEP FOR A MINUTE OR TWO, ASSEMBLING THE PAPERWORK I'D NEED IN THE BANK. I THEN TURNED THE IGNITION SWITCH TO THE LOCK POSITION, WHICH TURNED OFF THE MOTOR (BUT, UNFORTUNATELY, THE TRANSMISSION R…
Read full complaint
I ANGLE PARKED MY JEEP IN A BANK PARKING LOT. AFTER PARKING, THE TRANSMISSION REMAINED IN DRIVE WITH THE MOTOR RUNNING. I SAT IN MY JEEP FOR A MINUTE OR TWO, ASSEMBLING THE PAPERWORK I'D NEED IN THE BANK. I THEN TURNED THE IGNITION SWITCH TO THE LOCK POSITION, WHICH TURNED OFF THE MOTOR (BUT, UNFORTUNATELY, THE TRANSMISSION REMAINED IN DRIVE). I THEN PULLED MY JEEP KEY OUT OF THE IGNITION, GOT OUT OF THE JEEP AND WALKED ABOUT 75 - 100 FEET TO THE ENTRY STAIRS LEADING TO THE BANK. AT THAT MOMENT, A LADY YELLED TO ME. MY JEEP WAS SLOWLY ROLLING BACKWARDS AND IT STOPPED AFTER IT HIT A BUILDING ABOUT 70 FEET AWAY, STRIKING THE BUILDING AT AN APPROXIMATE 60 DEGREE ANGLE. DUE TO THE MANUFACTURING DEFECT, MY JEEP SUSTAINED BODY DAMAGE IN THE AMOUNT OF $260.42 FOR WHICH I HAVE AN ESTIMATE. HAD THE DEFECT NOT EXISTED, THERE WOULD HAVE BEEN NO ACCIDENT BECAUSE I WOULD NOT HAVE BEEN ABLE TO TURN THE IGNITION SWITCH TO LOCK WITHOUT FIRST PLACING THE TRANSMISSION IN PARK. DAIMLERCHRYSLER MOTORS CORPORATION REPAIRED THE MANUFACTURING DEFECT BUT REFUSES TO TAKE ANY RESPONSIBILITY FOR BODY DAMAGE TO MY JEEP. CAN YOU HELP? WILL YOU HELP? YOUR HELP TO RESOLVE THIS RIDICULOUS ISSUE WOULD BE GREATLY APPRECIATED. DAIMLERCHRYSLER'S REFERENCE NUMBER FOR MY CLAIM IS 9908985. I HAVE TELEPHONED THEM TWO OR THREE TIMES AND WRITTEN TWO LETTERS TO THEIR AUBURN HILLS, MI OFFICES AND THEY HAVE WRITTEN THREE LETTERS TO ME BUT REFUSE TO PAY THE $260.42. *AK
VEHICLE ROLLED IN REVERSE WHILE IT WAS PUT IN PARK, AND IGNITION WAS TURNED ON. VEHICLE HIT ANOTHER VEHICLE BEFORE COMING TO A STOP. DEALER HAS NOT SEEN VEHICLE. *AK
WHILE INSURED WAS TRAVELING NORTH ON CENTRAL STARTED TO SEE SMOKE AND PULLED OVER, VEHICLE CAUGHT ON FIRE, INSURED STATED THAT FIRE ORIGINATED WITHIN THE ENGINE COMPARTMENT FROM THE IGNITION OF TRANSMISSION FLUID WHICH EXPELLED FROM THE TRANSMISSION COOLER HOSE ONTO HOT SURFACES OF THE EXHAUST SYSTEM. CLAIM NUMBER 13-7494-462. …
Read full complaint
WHILE INSURED WAS TRAVELING NORTH ON CENTRAL STARTED TO SEE SMOKE AND PULLED OVER, VEHICLE CAUGHT ON FIRE, INSURED STATED THAT FIRE ORIGINATED WITHIN THE ENGINE COMPARTMENT FROM THE IGNITION OF TRANSMISSION FLUID WHICH EXPELLED FROM THE TRANSMISSION COOLER HOSE ONTO HOT SURFACES OF THE EXHAUST SYSTEM. CLAIM NUMBER 13-7494-462. *YH
CONSUMER USED VEHICLE FOR DELIVERING MAIL. SHE PULLED UP AND THERE WAS A MAILBOX NEXT TO HER. SHE GOT OUT OF VEHICLE WITH VEHICLE BEING TURNED OFF IN PARK POSITION. SHE WENT TO RETRIEVE A POST CARD AND WHEN SHE LOOKED UP DOOR WAS OPEN, AND VEHICLE WAS GOING BACKWARDS AND IT HIT MAIL BOX. CONSUMER JUMPED INTO VEHICLE A…
Read full complaint
CONSUMER USED VEHICLE FOR DELIVERING MAIL. SHE PULLED UP AND THERE WAS A MAILBOX NEXT TO HER. SHE GOT OUT OF VEHICLE WITH VEHICLE BEING TURNED OFF IN PARK POSITION. SHE WENT TO RETRIEVE A POST CARD AND WHEN SHE LOOKED UP DOOR WAS OPEN, AND VEHICLE WAS GOING BACKWARDS AND IT HIT MAIL BOX. CONSUMER JUMPED INTO VEHICLE AND TURNED IT ON TO STOP IT. $2300.00 WORTH OF DAMAGE. DEALERSHIP WILL HEAR ABOUT IT.*AK CONSUMER STATED SHE JUMPED INTO THE VEHICLE, SLAMMED ON BRAKES AND TURNED THE KEYS TO UNLOCK STEERING WHEEL AND PUT VEHICLE BACK INTO PARL.*SLC
ENGINE BLEWOUT WHILE DRIVING AT HIGHWAY SPEED OF 65-70 MPH. DEALER NOTIFIED. *AKVEHICLE JERKS WHILE IN MOTION AT HYWY SPEEDS. THE COMPRESSOR CLUTCH WAS DEFECTIVE AND WAS REPLACED. THE BRAKES PULSATE WHEN APPLIED. THE FRONT ROTORS WAS TURNED. BRAKES SHUDDER WHEN BRAKING FROM HIGHWAY SPEEDS. THE ROTORS WERE FOUND TO BE WARPE…
Read full complaint
ENGINE BLEWOUT WHILE DRIVING AT HIGHWAY SPEED OF 65-70 MPH. DEALER NOTIFIED. *AKVEHICLE JERKS WHILE IN MOTION AT HYWY SPEEDS. THE COMPRESSOR CLUTCH WAS DEFECTIVE AND WAS REPLACED. THE BRAKES PULSATE WHEN APPLIED. THE FRONT ROTORS WAS TURNED. BRAKES SHUDDER WHEN BRAKING FROM HIGHWAY SPEEDS. THE ROTORS WERE FOUND TO BE WARPED. THE ENGINE OVERHEATS. THE COOLING SYSTEM WAS FOUND TO BE UNDER HIGH PRESSURE. THE CYLINDER HEADS WERE REMOVED BECAUSE THEY WERE WARPED. THE ENGINE WAS REPLACED DUE TO WARPAGE. A BUMP IS FELT WHEN COMING TO A STOP. THE REAR DRIVESHAFT WAS REPLACED WITH REVISED PARTS PER TECHNICAL SERVICE BULLETIN. THE REAR END NOISE IS STILL APPARENT. A NEW SHAFT AND YOKE WERE INSTALLED. THE TRANSMISSION SHOFTS HARD ON ACCELERATION IN LOW GEARS. THE TRANSMISSION CONTROL MODULE WAS REPROGRAMMED. ACCELERATION IS STILL JERKY WHILE IN MOTION AND THE TURN SIGNALS AND HEADLIGHTS GO ON AND OFF AT RANDOM. CONSUMER ASKS FOR REIMBURSMENT OF MONIES PAID AND TO HAVE VEHICLE TRADED FOR ONE THAT CAN BE TRUSTED. *JG
WHILE DRIVING, CONSUMER COULD SEE SMOKE, AFTER PULLING OVER CONSUMER COULD SEE THERE WAS A FIRE IN THE ENGINE COMPARTMENT, FIRE ORIGINATED WITHIN THE ENGINE COMPARTMENT FROM THE IGNITION OF TRANSMISSION FLUID EXPELLED FROM THE TRANSMISSION COOLER HOSE ONTO HOT SURFACES OF THE EXHAUST SYSTEM, CLAIM 13-7494-462. *SLC
WHEN VEHICLE IS IN REVERSE IT WILL INTERMITTENTLY SHIFT FORWARD, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
TRANSMISSION GRINDS WHEN SHIFTING, GROWLS WHEN CLUTCH NOT DEPRESSED, POPS OUT OF GEAR, AT HIGHWAY SPEEDS WHEN RAINING PASS. SIDE LEAKS ONTO FEET AND SOAKING CARPET, ALL COMPLAINTS MADE TO DEALER AND CAN EITHER FIND NO PROBLEM OR SAYS THAT THE NOISES ARE NORMAL, AND REFUSES TO DO ANYMORE WITH VEHICLE. *AK
Official recalls
102V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by