IllustrationEVERY JEEP CHEROKEE (AROUND 1999 YEARS) HAVE NO AC. IT IS A CRIME TO SEE ALMOST EVERY JEEP CHEROKEE ON THE HIGHWAY WITH THEIR WINDOWS OPEN IN 95 DEGREE TEMPS. WE ARE TALKING THOUSANDS OF JEEP OWNERS! REPAIR COSTS ARE STAGGERING. *TR
1999 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 1999 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1225–50K
2450–75K
1775–100K
21100–150K
14150K+
95 reports with mileage · 271 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports18 fire reports25 injury reports
What owners actually said
366 reportsTHE WINDOW REGULATORS IN BOTH THE FRONT WINDOWS OF MY 1999 JEEP CHEROKEE HAVE FAILED, AND I HAVE BEEN UNABLE TO FIND REPLACEMENTS. NO AUTO PARTS STORES HAVE THEM- THEY ARE ALL ON BACK ORDER INDEFINITELY, NO USED PARTS DEALERS HAVE ANY- TOO HIGH OF A DEMAND, I HAVE ALSO EXHAUSTIVELY SEARCHED ONLINE FOR THE PARTS WITH NO LUCK . S…
Read full complaint
THE WINDOW REGULATORS IN BOTH THE FRONT WINDOWS OF MY 1999 JEEP CHEROKEE HAVE FAILED, AND I HAVE BEEN UNABLE TO FIND REPLACEMENTS. NO AUTO PARTS STORES HAVE THEM- THEY ARE ALL ON BACK ORDER INDEFINITELY, NO USED PARTS DEALERS HAVE ANY- TOO HIGH OF A DEMAND, I HAVE ALSO EXHAUSTIVELY SEARCHED ONLINE FOR THE PARTS WITH NO LUCK . SO I AM UNABLE TO HAVE MY VEHICLE INSPECTED DUE TO LACK OF PARTS. *TR
AS MY HUSBAND AND I WERE ON OUR WAY TO A RELATIVES LAST WEEKEND, THE PASSENGER SIDE WINDOW LOWERED ON IT'S OWN. I TRIED TO ROLL IT UP WITH THE DRIVERS CONTROL, AND MY HUSBAND TRIED WITH THE PASSENGER CONTROL ( WHICH HAS NEVER WORKED WELL) BUT THE WINDOW JUST CONTINUED TO GO DOWN. I HAD MY SON LOOK AT IT AND HE TOOK EVERYTHING OF…
Read full complaint
AS MY HUSBAND AND I WERE ON OUR WAY TO A RELATIVES LAST WEEKEND, THE PASSENGER SIDE WINDOW LOWERED ON IT'S OWN. I TRIED TO ROLL IT UP WITH THE DRIVERS CONTROL, AND MY HUSBAND TRIED WITH THE PASSENGER CONTROL ( WHICH HAS NEVER WORKED WELL) BUT THE WINDOW JUST CONTINUED TO GO DOWN. I HAD MY SON LOOK AT IT AND HE TOOK EVERYTHING OFF INCLUDING DOOR PANEL, AND SPEAKERS, BUT HE WAS NOT FAMILIAR WITH JEEP WINDOWS AND COULD NOT DETERMINE HOW TO FIX IT. IN THE MEANTIME, I HAVE CHECKED OUT SOME WEBSITES ON THIS PROBLEM AND FOUND OUT THAT THIS IS AN ONGOING PROBLEM WITH JEEPS. NOW IT IS GOING TO COST ME BETWEEN $250.00 AND $600.00 TO REPAIR . PLEASE DO SOMETHING ABOUT THIS SO NO ONE ELSE WILL HAVE SUCH AN UNEXPECTED EXPENSE. *TR
DOOR ON THE BACK OF JEEP (99) CLOSES DURING COOL (COLD) WEATHER AND YOU BUMP YOUR HEAD OR OTHER AREAS. THE PISTONS HOLDING THE DOOR OPEN DO NOT (AND HAVE NEVER) WORKED PROPERLY. *TR
TL*THE CONTACT OWNS A 1999 JEEP CHEROKEE. WHILE DRIVING 45 MPH, THE VEHICLE BEGAN TO STALL. AFTER A FEW MINUTES, THE VEHICLE COMPLETELY SHUT OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE SHOP FOR A DIAGNOSIS AND THE MECHANIC BELIEVED THE CAUSE OF FAILURE TO BE THE FUEL PUMP. THE COIL PACK WAS PREVIOUSLY REPLACED. THE MA…
Read full complaint
TL*THE CONTACT OWNS A 1999 JEEP CHEROKEE. WHILE DRIVING 45 MPH, THE VEHICLE BEGAN TO STALL. AFTER A FEW MINUTES, THE VEHICLE COMPLETELY SHUT OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE SHOP FOR A DIAGNOSIS AND THE MECHANIC BELIEVED THE CAUSE OF FAILURE TO BE THE FUEL PUMP. THE COIL PACK WAS PREVIOUSLY REPLACED. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR A DIAGNOSIS. HE WAS INFORMED OF A RECALL FOR THE INTAKE MANIFOLD. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 79,000.
WHILE DRIVING ON A HIGHWAY THE POSTED SPEED LIMIT, MY VEHICLE STARTED SHAKING UNCONTROLABLY AND I HAD TO GET OFF THE HIGHWAY TO STOP THE CAR SO THE SHAKING WILL STOP. I HAVE HAD A NUMBER PARTS REPLACED SUCH AS THE STEERING STABILIZER, AND THE STEERING ROD. *JB
TL*THE CONTACT OWNS A 1999 JEEP CHEROKEE. IN THE PAST, THE CONTACT NOTICED SMOKE COMING FROM THE HOOD OF THE VEHICLE. HE PANICKED AND CRASHED INTO A POLE AT 25 MPH. THE RADIATOR WAS REPAIRED. THE CONTACT RECEIVED A RECALL NOTICE FOR THE ELECTRICAL RADIATOR FAN. HE TOOK THE VEHICLE TO THE CHRYSLER DEALER, BUT THE VEHICLE IS …
Read full complaint
TL*THE CONTACT OWNS A 1999 JEEP CHEROKEE. IN THE PAST, THE CONTACT NOTICED SMOKE COMING FROM THE HOOD OF THE VEHICLE. HE PANICKED AND CRASHED INTO A POLE AT 25 MPH. THE RADIATOR WAS REPAIRED. THE CONTACT RECEIVED A RECALL NOTICE FOR THE ELECTRICAL RADIATOR FAN. HE TOOK THE VEHICLE TO THE CHRYSLER DEALER, BUT THE VEHICLE IS NOW SMOKING AND UNABLE TO BE DRIVEN. THE DEALER STATED THAT THIS IS A NEW FAILURE AND THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR. THE RECALL # WAS UNKNOWN. THE CURRENT MILEAGE IS 61,041 AND THE FAILURE MILEAGE WAS UNKNOWN.
I DROVE MY JEEP TO A HOME, PARKED IN THE DRIVEWAY, LEFT THE CAR RUNNING ABOUT 5-10 MINUTES. AS I WAS LOCKING THE DOOR LEAVING THE HOME I TURNED AND SAW THE JEEP GOING IN REVERSE TOWARD THE ROAD, I RAN TO THE JEEP TO TRY AND GET IN AND CONTROL THE JEEP, I SLIPPED UNDER THE VEHICLE AND IT RAN OVER BOTH MY LEGS. IT CAME TO A COMPL…
Read full complaint
I DROVE MY JEEP TO A HOME, PARKED IN THE DRIVEWAY, LEFT THE CAR RUNNING ABOUT 5-10 MINUTES. AS I WAS LOCKING THE DOOR LEAVING THE HOME I TURNED AND SAW THE JEEP GOING IN REVERSE TOWARD THE ROAD, I RAN TO THE JEEP TO TRY AND GET IN AND CONTROL THE JEEP, I SLIPPED UNDER THE VEHICLE AND IT RAN OVER BOTH MY LEGS. IT CAME TO A COMPLETE STOP ABOUT 30-50 FEET AFTER IT RAN ME OVER. I WAS TAKEN TO THE HOSPITAL, TREATED AND RELEASED. I HAVE NOT YET HAD THE CAR LOOKED AT BY A MECHANIC. *JB
MY BRAKES "FUSED" TOGETHER, AND I HAD TO DOWN SHIFT QUICKLY IN ORDER TO STOP. THE AUTO REPAIR SHOP SAID IT WAS CAUSED BY FAULTY BRAKE "KNUCKLES", AND THAT JEEP IS AWARE OF THE ISSUE, BUT DOES NOT FEEL IT IS A SAFETY ISSUE. MY CHILDREN WERE IN THE CAR, AND IT'S NOT A SAFETY ISSUE? *NM
DT*: THE CONTACT STATED WHILE DRIVING 50-60 MPH ON THE HIGHWAY DURING DRY ROAD CONDITIONS, THE STEERING WOULD NOT RESPOND TO STEERING INPUT. THERE WAS A NOISE AS IF SOMETHING FELL OFF OF THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE IT WAS DETERMINED THE LOWER CONTROL ARM; LOWER BALL JOINTS SEPARAT…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 50-60 MPH ON THE HIGHWAY DURING DRY ROAD CONDITIONS, THE STEERING WOULD NOT RESPOND TO STEERING INPUT. THERE WAS A NOISE AS IF SOMETHING FELL OFF OF THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE IT WAS DETERMINED THE LOWER CONTROL ARM; LOWER BALL JOINTS SEPARATED.
Official recalls
200V136000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
May 10, 2000
VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, ILLINOIS, INDIANA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, OR WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT DISC BRAKE ROTORS CAN EXPERIENCE SEVERE CORROSION IF OPERATED FOR AN EXTENSIVE PERIOD IN THE "SALT BELT." IF THE ROTORS ARE NOT REPLACED, THE CORROSION CAN EVENTUALLY COMPROMISE THE STRUCTURAL INTEGRITY OF THE STAMPED STEEL CENTER HUB SECTION OF THE ROTOR.
Consequence & remedy
Consequence: THE REDUCED STRENGTH CAN ALLOW THE CAST IRON WEAR SURFACE TO SEPARATE FROM THE HUB, REDUCING THE BRAKE EFFECTIVENESS OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THESE ROTORS WITH ROTORS THAT ARE COATED WITH A CORROSION PROTECTION.
00V105000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Apr 11, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. WATER AND/OR ROAD SALT IN THE PROXIMITY OF THE AIR BAG CONTROL MODULE COULD LEAD TO CORROSION.
Consequence & remedy
Consequence: SUCH CORROSION CAN LEAD TO ILLUMINATION OF THE AIR BAG WARNING LIGHT OR COULD ALLOW INADVERTENT DEPLOYMENT OF THE AIR BAGS.
Remedy: DEALERS WILL REPLACE THE AIR BAG CONTROL MODULE AND LOCATE THE NEW MODULE ON THE TOP OF THE TRANSMISSION TUNNEL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by