IllustrationI HAVE A 1999 JEEP CHEROKEE, THE AIR BAG LIGHT COMES ON AND OFF. I HAVE RECENTLY DISCOVERED THAT THIS IS OCCURING TO OTHER JEEP PRODUCTS. *AK
1999 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 1999 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1225–50K
2450–75K
1775–100K
21100–150K
14150K+
95 reports with mileage · 271 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports18 fire reports25 injury reports
What owners actually said
366 reportsCRASH - I REAR ENDED ANOTHER VEHICLE IN MY 1999 JEEP CHEROKEE SPORT. I WAS BRAKING WHEN THE CAR SUDDENLY ACCELERATED, DRIVING ME INTO THE VEHICLE IN FRONT OF ME. THIS HAS HAPPENED BEFORE, BUT ONLY THIS TIME DID IT RESULT IN AN ACCIDENT. I TOOK IT TO A CERTIFIED JEEP DEALERSHIP AND HAD THE SERVICE DEPARTMENT CHECK IT OUT. THE…
Read full complaint
CRASH - I REAR ENDED ANOTHER VEHICLE IN MY 1999 JEEP CHEROKEE SPORT. I WAS BRAKING WHEN THE CAR SUDDENLY ACCELERATED, DRIVING ME INTO THE VEHICLE IN FRONT OF ME. THIS HAS HAPPENED BEFORE, BUT ONLY THIS TIME DID IT RESULT IN AN ACCIDENT. I TOOK IT TO A CERTIFIED JEEP DEALERSHIP AND HAD THE SERVICE DEPARTMENT CHECK IT OUT. THEY SAID NOTHING IS WRONG WITH IT. I AM PRETTY NERVOUS ABOUT THIS. I KNOW HOW HARD I WAS BRAKING, AND IT JUST DIDN'T MATTER. THE CAR WAS WORKING AGAINST ME. I HAD TO THROW IT INTO PARK JUST TO STOP THE CAR. *AK
WHILE DOWN SHIFTING TO SECOND GEAR AT 40 MPH, THE ENGINE ACCELERATED AT A HIGHER RATE. THE CONSUMER PULLED OVER AND HAD THE VEHICLE TOWED. THE CONSUMER HAD TAKEN THE VEHICLE TO A PRIVATE MECHANIC AND DID NOT PLAN ON CONTACTING THE JEEP DEALERSHIP ABOUT THE PROBLEM. THE CAUSE WAS NOT DETERMINED. *AK THE VEHICLE WAS SLOW…
Read full complaint
WHILE DOWN SHIFTING TO SECOND GEAR AT 40 MPH, THE ENGINE ACCELERATED AT A HIGHER RATE. THE CONSUMER PULLED OVER AND HAD THE VEHICLE TOWED. THE CONSUMER HAD TAKEN THE VEHICLE TO A PRIVATE MECHANIC AND DID NOT PLAN ON CONTACTING THE JEEP DEALERSHIP ABOUT THE PROBLEM. THE CAUSE WAS NOT DETERMINED. *AK THE VEHICLE WAS SLOWED DOWN WHEN THE ENGINE STARTED REVVING, IT WAS THEN SWITCHED TO A LOWER GEAR AND PROCEEDED, THEN WAS PLACED BACK INTO DRIVE IN WHICH IT WAS SLOWED DOWN AND THE ENGINE STARTED REVVING AGAIN IN A LOWER GEAR BUT DID NOT WORK. THE VEHICLE WOULD JERK AND KNOCK WHEN PLACED IN THE ENGINE WHEN PLACED IN PARK. (THE U-JOINT FAILED) *SC THE CONSUMER WAS INFORMED THE VEHICLE NEEDED AN OXYGEN SENSOE. *JB
WHILE DRIVING 60 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CEMENT WALL. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. THE VEHICLE WAS TOWED TO A REPAIR SHOP. *AK *SC *JB
I OWN A 1991 JEEP CHEROKEE SP/CL 4 WD. WHEN I TAKE IT OUT OF 4WD IT WON'T DISINGAGE UNLESS I PUT IT INTO REVERSE. THE MANUAL DOES NOT MENTION THIS. I DROVE FOR 20 MILES IN 4 WD WITHOUT KNOWING IT UNTIL I STARTED TO SMELL SOMETHING. I CALLED AN AUTO REPAIR SHOP AND THEY TOLD ME TO PUT IT IN REVERSE. I DID AND IT WORKED.*AK
CASTING SAND (FROM THE FACTORY) IN THE COOLING SYSTEM CAUSED THE ENGINE TO OVERHEAT. ENGINE REPLACEMENT WAS NECESSARY AT 52,000 MILES SINCE THE CASTING SAND WAS THROUGHOUT THE ENTIRE ENGINE. A TSB HAD BEEN ISSUED ON THE SUBJECT. *JB
WHILE DRIVING REAR LEFT SIDE WINDOW SUDDENLY DROPPED DOWN INTO THE DOOR. THIS PAST SATURDAY THE RIGHT SIDE WINDOW DROPPED DOWN. *AK BOTH FRONT POWER WINDOWS' REGULATOR ASSEMBLY AND STEEL CABLE BROKE. DEALER REPLACED FRONT WINDOW REGULATOR, BUT THE REPLACEMENT PARTS ARE IDENTICAL TO THE OLD ONE WHICH CONCERNED THE CONSUMER T…
Read full complaint
WHILE DRIVING REAR LEFT SIDE WINDOW SUDDENLY DROPPED DOWN INTO THE DOOR. THIS PAST SATURDAY THE RIGHT SIDE WINDOW DROPPED DOWN. *AK BOTH FRONT POWER WINDOWS' REGULATOR ASSEMBLY AND STEEL CABLE BROKE. DEALER REPLACED FRONT WINDOW REGULATOR, BUT THE REPLACEMENT PARTS ARE IDENTICAL TO THE OLD ONE WHICH CONCERNED THE CONSUMER THAT ALL WINDOWS MIGHT DROP AT THE SAME TIME WITHOUT WARNING. *LA
WHILE DRIVING THE CHECK ENGINE LIGHT AND AIR BAG LIGHT ILLUMINATED AND ALL OF THE GAUGES CEASED TO WORK PROPERLY. THE SPEEDOMETER WOULD GO BLANK AND ALL LIGHTS ON THE DASH BOARD WOULD DIM. THE MANUFACTURER AND THE DEALER ARE AWARE OF THE PROBLEM. *NM THIS WOULD OCCUR WHEN THE VEHICLE IS GOING IN DIFFERENT SPEEDS. THE PR…
Read full complaint
WHILE DRIVING THE CHECK ENGINE LIGHT AND AIR BAG LIGHT ILLUMINATED AND ALL OF THE GAUGES CEASED TO WORK PROPERLY. THE SPEEDOMETER WOULD GO BLANK AND ALL LIGHTS ON THE DASH BOARD WOULD DIM. THE MANUFACTURER AND THE DEALER ARE AWARE OF THE PROBLEM. *NM THIS WOULD OCCUR WHEN THE VEHICLE IS GOING IN DIFFERENT SPEEDS. THE PROBLEM BEGUN WITH THE AIRBAG, FOLLOWED BY THE ODOMETER, TACHOMETER, AND THE SPEEDOMETER DROPPING TO ZERO. THEN THE CHECK ENGINE LIGHT WOULD COME ON AND "NO BUS" ERROR MESSAGE WOULD APPEAR ON THE ODOMETER. SOMETIMES THE GAS, BATTERY, TEMPERATURE, AND OIL PRESSURE GAUGE WOULD FAIL AS WELL. THE PROBLEM WOULD LAST FROM ANYWHERE UP TO FORTY MINUTES OR MORE. CORROSION WAS FOUND WHERE THE HARNESS PLUGS INTO THE CLUSTER. THE VEHICLE HAD BEEN TO THE DEALER FOUR TIMES AND STILL HAS NOT BEEN REPAIRED. *SC
WHEN THE BRAKES ARE APPLIED THERE IS A DELAY BEFORE VEHICLE WILL STOP. DEALERSHIP INDICATED TO THE CONSUMER THAT VEHICLE WAS OPERATING AS DESIGNED. *AK
CONSUMER COMPLAINED ABOUT A FUEL PUMP PROBLEM. IT CAUSED THE VEHICLE TO STALL AT DIFFERENT SPEEDS. DRIVER HAD TO WAIT 5 OR 6 MINUTES BEFORE VEHICLE WOULD START UP AGAIN. THE FUEL PUMP WAS CHANGED 3 TIMES. *AK
Official recalls
200V136000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
May 10, 2000
VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, ILLINOIS, INDIANA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, OR WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT DISC BRAKE ROTORS CAN EXPERIENCE SEVERE CORROSION IF OPERATED FOR AN EXTENSIVE PERIOD IN THE "SALT BELT." IF THE ROTORS ARE NOT REPLACED, THE CORROSION CAN EVENTUALLY COMPROMISE THE STRUCTURAL INTEGRITY OF THE STAMPED STEEL CENTER HUB SECTION OF THE ROTOR.
Consequence & remedy
Consequence: THE REDUCED STRENGTH CAN ALLOW THE CAST IRON WEAR SURFACE TO SEPARATE FROM THE HUB, REDUCING THE BRAKE EFFECTIVENESS OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THESE ROTORS WITH ROTORS THAT ARE COATED WITH A CORROSION PROTECTION.
00V105000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Apr 11, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. WATER AND/OR ROAD SALT IN THE PROXIMITY OF THE AIR BAG CONTROL MODULE COULD LEAD TO CORROSION.
Consequence & remedy
Consequence: SUCH CORROSION CAN LEAD TO ILLUMINATION OF THE AIR BAG WARNING LIGHT OR COULD ALLOW INADVERTENT DEPLOYMENT OF THE AIR BAGS.
Remedy: DEALERS WILL REPLACE THE AIR BAG CONTROL MODULE AND LOCATE THE NEW MODULE ON THE TOP OF THE TRANSMISSION TUNNEL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by