DT*: THE CONTACT STATED THE VEHICLE HESITATED WHEN SHIFTING FROM PARK TO DRIVE. THE VEHICLE JERKS FORWARD EVERY TIME THE GEAR IS SHIFTED INTO DRIVE. UPON INSPECTION THE INDEPENDENT REPAIR SHOP DETERMINED THERE IS A HOLE IN THE PISTON COVER CAUSING THE TRANSMISSION FLUID TO LEAK FROM THE VEHICLE. THE PISTON COVER NEEDS REPLAC…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE HESITATED WHEN SHIFTING FROM PARK TO DRIVE. THE VEHICLE JERKS FORWARD EVERY TIME THE GEAR IS SHIFTED INTO DRIVE. UPON INSPECTION THE INDEPENDENT REPAIR SHOP DETERMINED THERE IS A HOLE IN THE PISTON COVER CAUSING THE TRANSMISSION FLUID TO LEAK FROM THE VEHICLE. THE PISTON COVER NEEDS REPLACED.
NHTSA ODI #10157200
Mileage unknown · May 2, 2005
Power Train
I HAVE LESS THAN 55,000 MILES ON MY 2002 RODEO. A MONTH AGO WHEN TRYING TO ACCELERATE, THE GEAR SHIFT FROM 1 TO 2ND WAS ALMOST IMPOSSIBLE. THE TRUCK WOULD SHAKE AND SHUDDER AND START TO STALL BEFORE KICKING INTO GEAR - MAKING MY INABILITY TO OPERATE VERY SUSCEPTIBLE TO ACCIDENTS (LUCKILY I HAD NONE). I TOOK TO A LOCAL MECHANI…
Read full complaint
I HAVE LESS THAN 55,000 MILES ON MY 2002 RODEO. A MONTH AGO WHEN TRYING TO ACCELERATE, THE GEAR SHIFT FROM 1 TO 2ND WAS ALMOST IMPOSSIBLE. THE TRUCK WOULD SHAKE AND SHUDDER AND START TO STALL BEFORE KICKING INTO GEAR - MAKING MY INABILITY TO OPERATE VERY SUSCEPTIBLE TO ACCIDENTS (LUCKILY I HAD NONE). I TOOK TO A LOCAL MECHANIC WHO INFORMED ME THAT MY TRANSMISSION MY BE SHOT COMPLETELY - I HAD LEAKED 4 QRTS OF FLUID WITH NO INDICATION THAT I WAS LOW. WHEN HE ORDERED THE PART FROM THE LOCAL DEALER - HE ADMITTED TO ME THAT WITH OTHER VEHICLES IT IS RARE THAT THESE PARTS ARE AVAILABLE AND NEED TO BE BACK ORDERED AND THAT B/C THEY HAD ON HAND THIS MUST BE A COMMON PROBLEM. HE SEALED THE LEAKS (THERE WERE SEVERAL). HOWEVER, THIS HAS NOT SOLVED THE PROBLEM THE TRANSMISSION IS STILL LEAKING AND I'M NOT SURE IS THERE WOULD BE ANY RESOLVE WITH REPLACING THE ENTIRE TRANSMISSION. IF THIS IS A COMMON PROBLEM WITH RODEO TRANSMISSION AND IS A DEFECTIVE PART THEN A RECALL IS IN ORDER.
NHTSA ODI #10119364
Mileage unknown · Jan 4, 2005
Power Train
WHILE THE VEHICLE WAS PARKED CONSUMER NOTICED FLUID LEAKING FROM UNDERNEATH THE VEHICLE. WHILE DRIVING 25 MPH CONSUMER WAS UNABLE TO SHIFT GEARS. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINEDTHAT THE TRANSMISSION NEEDED TO BE REPLACED. *AK
NHTSA ODI #10106784
55,500 miles · Oct 6, 2004
Power Train
I HAVE A 2002 ISUZU RODEO LS WITH A SIX CYLINDER ENGINE AND A 2 WHEEL DRIVE AUTOMATIC TRANSMISSION. THE TRANSMISSION IS SEALED AND THE OWNER'S MANUAL REQUIRES SERVICE AT 120,000 MILES. I HAVE NEVER DRIVEN THE VEHICLE UNDER EXTREME CONDITIONS, AND I HAVE NEVER TOWED ANYTHING BEHIND THE VEHICLE. NONETHELESS, MY TRANSMISSION REC…
Read full complaint
I HAVE A 2002 ISUZU RODEO LS WITH A SIX CYLINDER ENGINE AND A 2 WHEEL DRIVE AUTOMATIC TRANSMISSION. THE TRANSMISSION IS SEALED AND THE OWNER'S MANUAL REQUIRES SERVICE AT 120,000 MILES. I HAVE NEVER DRIVEN THE VEHICLE UNDER EXTREME CONDITIONS, AND I HAVE NEVER TOWED ANYTHING BEHIND THE VEHICLE. NONETHELESS, MY TRANSMISSION RECENTLY STARTED TO SHUDDER AND LURCH WHEN THE VEHICLE INITIALLY ACCELERATED FROM LOW TO SECOND GEAR. WHEN THIS PROBLEM BEGAN, THE VEHICLE HAD ABOUT 55,500. THE PROBLEM GREW PROGRESSIVELY WORSE, AND I TOOK IT FOR SERVICE AT ABOUT 56,000. THE DEALERSHIP TO WHICH I TOOK THE CAR ADVISED ME THAT A PART IN THE TRANSMISSION HAD GONE BAD AND THAT THEY HAD SEEN SIMILAR PROBLEMS WITH SIMILAR VEHICLES AND THAT ISUZU HAD A REPLACEMENT PART TO CORRECT THIS PROBLEM. IF IT IS INDEED A DEFECTIVE PART, I THINK A RECALL MAY BE WARRANTED FOR SAFETY REASONS. MOST NOTABLY, THE PROBLEM CAUSED MY CAR TO MOMENTARILY STOP ACCELERATING IN LOW GEAR, AND ON ONE OCCASION, THE DELAYED ACCELERATION CAUSED A CLOSE CALL BECAUSE MY CAR MOMENTARILY STALLED IN THE MIDDLE OF A LEFT-HAND TURN. THE OTHER CONCERN IS THAT AFTER SHUDDERING AND NOT ACCELERATING, THE VEHICLE WOULD SUDDENLY CATCH THE GEAR AND LURCH FORWARD, AGAIN, A SAFEY CONCERN DUE TO THE UNEXPECTED MOVEMENT OF THE CAR.*AK
NHTSA ODI #10093689
6,000 miles · Apr 28, 2004
Power Train
CAR PURCHASED BRAND NEW ON JUNE 28, 2003. MID SEPTEMBER 2003 TRANSMISSION NEEDED TO BE REPLACED.
NHTSA ODI #10067993
Mileage unknown · Sep 26, 2003
Power TrainCrash
WHEN COMING TO A COMPLETE STOP CONSUMER'S VEHICLE LURCHED FORWARD AND HIT ANOTHER VEHICLE. *AK
NHTSA ODI #10040755
17,000 miles · Jan 23, 2003
Power Train
COMPONENT UNDER VEHICLE ALONG DRIVE SHAFT BECAME DETACHED, AND PROCEEDED TO MAKE A GROOVE IN THE DRIVE SHAFT, AND BEND THE FRONT PLATE RENDERING THE VEHICLE UN DRIVE ABLE.
NHTSA ODI #10003267
Mileage unknown · Jul 29, 2002
Power Train
AT 70MPH CLUTCH WILL SWITCH GEARS, AND THEN LOCK UP, CAUSING VEHICLE TO SLOW DOWN .DEALER NOTIFIED. *AK THE CLUTCH FAILED AND HAS BEEN REPLACED SEVERAL TIMES. *YH
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF TYLER, TEXAS. THIS RECALL WILL BE LAUNCHED FOR VEHICLES REGISTERED IN TEXAS AND THE FOUR SURROUNDING STATES: OKLAHOMA, ARKANSAS, NEW MEXICO AND LOUISIANA.
Consequence & remedy
Consequence: A FUEL LEAK COULD LEAD TO A VEHICLE FIRE.
Remedy: FOR VEHICLES REGISTERED IN THE STATES IDENTIFIED ABOVE, DEALERS WILL PROVIDE A NEW COVER OVER THE EXISTING FEED PORT ON THE FUEL PUMP OR, IF THE EXISTING FEED PORT HAS ALREADY BEEN DAMAGED, DEALERS WILL INSTALL A NEW FUEL PUMP THAT IS EQUIPPED WITH THE NEW COVER. THE NEW COVER WILL BE MADE OF A DIFFERENT MATERIAL. THE RECALL BEGAN ON NOVEMBER 25, 2005. OWNERS MAY CONTACT ISUZU AT 1-800-255-6727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
On April 10, 2018, NHTSA received a petition from Mr. Kevin Byrne (the Petitioner) requesting that the Agency ?undertake a defects investigation? of ?rust-related detachment of Isuzu Rodeo fuel tanks? (NHTSA ID 11091788). The Petitioner experienced a partial fuel tank detachment in his model year (MY) 2004 Isuzu Rodeo in July 2017. On May 23, 2018, ODI opened DP18-001 to evaluate the Petitioner?s request for a defect investigation. ODI sent information request letters to Isuzu and Honda requesting production, design history and field data related to fuel tank retention failures in MY 2001-2004 Isuzu Rodeo, MY 2002-2004 Isuzu Axiom and MY 2001-2002 Honda Passport vehicles equipped with the same fuel tank shield part number as the Petitioner?s vehicle (the ?subject vehicles?). ODI notes that Isuzu manufactured the subject Passport vehicles for Honda. Isuzu implemented a change to the tank shield corrosion protection system as a running change in early MY 2002 production. Isuzu and Honda sold approximately 172,000 subject vehicles in the United States. Fifty-eight (58) percent of the subject vehicles were produced prior to the shield change (99,000) and 42 percent after the change (73,000).ODI?s analysis of field data identified 19 incidents of partial fuel tank detachments in the subject vehicles. The incidents all occurred in states with high road salt usage in winter months (Salt States) and involved older vehicles beyond 10-years in service. On average, the failures occurred in the vehicle?s 13th year-in-service. Evidence of severe general corrosion in multiple undercarriage components was also noted in 13 of the 19 vehicles that experienced partial fuel tank detachments. None of the incidents resulted in fuel leakage or fire. Aside from the petitioner?s vehicle, ODI has not identified any other incidents of complete or partial fuel tank detachment in the MY 2002-2004 subject vehicles equipped with the modified retention shield.In addition, ODI reviewed 24 NHTSA complaints alleging corrosion concerns with the fuel tank retention system in the subject vehicles that did not result in fuel tank detachment. Twenty-three (23) of these complaints involve subject vehicles built prior to the shield change. Like the vehicles reporting fuel tank detachments, these vehicles are also all from Salt States and, in most cases (20 of the 24 complaints), the vehicles also experienced severe corrosion concerns in other undercarriage components. Half (12 of the 24 complaints) of the vehicles show prior accident damage in their service histories.Based on these analyses, ODI has not identified evidence of a defect trend for premature corrosion-related fuel tank detachments in the MY 2004 Isuzu Rodeo or similarly equipped vehicles. The damage that may result in tank retention concerns appears to occur progressively over many years with ample opportunity for detection and repair. Furthermore, ODI has not identified any crashes, fires, injuries, or fuel leaks associated with fuel tank retention failures in a population of vehicles that currently range from 16 to 19 years old.Accordingly, the Agency is denying the petition.A summary of ODI?s analysis of this petition will be published in the Federal Register and is also available in the investigative file for this action.The NHTSA consumer complaints counted in the closing resume for DP18-001 can be reviewed at www.nhtsa.gov under the following ODI identification numbers (VOQs in parentheses denote duplicate records): Allegations of fuel tank retention failure: 11084098 (11091788), 10532845, 10486109. Allegations of fuel tank retention component corrosion: 11138931, 10992150, 10845523,
EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
2002 Isuzu Rodeo Problems, Complaints & Recalls | Skip That Year
Illustration