Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
1325–50K
3450–75K
5075–100K
144100–150K
34150K+
288 reports with mileage · 101 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 214 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports3 fire reports10 injury reports
What owners actually said
389 reports
Mileage unknown · Jan 22, 2003
Electrical System
I'M HAVING THE FOLLOWING ELECTRICAL ISSUES WITH MY RODEO. INTERMITENTLY, THE CRUISE LIGHT BUTTON TURNS ON, THEN THE CRUISE LIGHT INDICATOR TURNS ON, THEN THE CHECK TRANSMISSION LIGHT TURNS ON. AT THAT SAME TIME ALL THE INDICATORS ARE ON THE TRUCK HESITATES AS IF THE TRANSMISSION IS SLIPPING. THIS MOST FREQUENTLY OCCURS AFTER C…
Read full complaint
I'M HAVING THE FOLLOWING ELECTRICAL ISSUES WITH MY RODEO. INTERMITENTLY, THE CRUISE LIGHT BUTTON TURNS ON, THEN THE CRUISE LIGHT INDICATOR TURNS ON, THEN THE CHECK TRANSMISSION LIGHT TURNS ON. AT THAT SAME TIME ALL THE INDICATORS ARE ON THE TRUCK HESITATES AS IF THE TRANSMISSION IS SLIPPING. THIS MOST FREQUENTLY OCCURS AFTER COMING TO A COMPLETE STOP, HOWEVER HAS OCCURED WHILE CRUSING. THUS FAR THE TECHNICIANS HAVE REPLACED
NHTSA ODI #10003184
Mileage unknown · Nov 27, 2002
Electrical System
WHILE IN MOTION AND WITH OUT ANY WARNING, THE VEHICLE SUDDENLY SLOWED DOWN AND STOPPED IN THE HIGHWAY. CONSUMER HAD TO PUSH THE VEHICLE OFF ONTO THE SHOULDER TO AVOID AN ACCIDENT. THE VEHICLE WAS TOWED TO A SERVICE SHOP WHERE IT WAS DIAGNOSED AS A POOR CONNECTION AT H-7, AND THE CONNECTOR WAS REPLACED. THE MECHANIC INFORMED C…
Read full complaint
WHILE IN MOTION AND WITH OUT ANY WARNING, THE VEHICLE SUDDENLY SLOWED DOWN AND STOPPED IN THE HIGHWAY. CONSUMER HAD TO PUSH THE VEHICLE OFF ONTO THE SHOULDER TO AVOID AN ACCIDENT. THE VEHICLE WAS TOWED TO A SERVICE SHOP WHERE IT WAS DIAGNOSED AS A POOR CONNECTION AT H-7, AND THE CONNECTOR WAS REPLACED. THE MECHANIC INFORMED CONSUMER THAT THIS WAS A FACTORY DEFECT. *JG
NHTSA ODI #568443
Mileage unknown · Sep 27, 2002
Seat Belts
FRONT PASSENGER SEAT BELT GETS TIGHTER EVERY TIME THE PASSENGER MOVES. DEALER STATED BELT IS DESIGNED TO HOLD CHILD SAFETY SEAT. THERE WAS NOTHING HE COULD DO. *MR
NHTSA ODI #8019702
Mileage unknown · Sep 25, 2002
Vehicle Speed Control
WHILE DRIVING THE VEHICLE AT ANY SPEED THE THE CRUISE CONTROL WILL COME ON/OFF BY ITSELF. THE DEALER HAS BEEN NOTIFIED AND THE PROBLEM STILL OCCURS. THE CONSUMER IS REQUESTING A NEW VEHICLE IF THE CRUISE CONTROL CANNOT BE FIXED. *SCC
NHTSA ODI #8019471
Mileage unknown · Aug 30, 2002
Engine And Engine Cooling
ENGINE CONTINUES TO OVERHEAT WHILE DRIVING SINCE 4,700 MILES TO THE PRESENT. VEHICLE BEEN TO THE DEALER ON FIVE OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8017727
Mileage unknown · Jun 4, 2002
Power Train
WHEN COMING TO A STOP THERE'S A POP, AND WHEN TAKING OFF, THERE'S A POP. CONSUMER FEELS LIKE SOMETHING IS SHIFTING BACK AND FORTH. CAN FEEL A BUMP WHEN STOPPING AND TAKING OFF. DEALER INSISTS IT IS NORMAL. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #8010992
Mileage unknown · May 23, 2002
Power Train
THERE IS A LOUD GROANING SOUND WHEN MAKING LEFT TURNS AND BACKING UP. THE VEHICLE WAS TAKEN TO THE DEALER 5 TIMES AND THE DEALER COULD NOT FIND A PROBLEM. ON 21 MAY 2002 ,THE CHECK TRANSMISSION LIGHT CAME ON. THE VEHICLE IS AT THE DEALERSHIP.*JB
NHTSA ODI #8010382
Mileage unknown · May 14, 2002
Engine And Engine Cooling
ENGINE PINGNS WHILE ACCELERATING. THIS SAME PROBLEM WAS REPORTED ON 1-26-01. RESPONSE WAS THAT ENGINE NEEDED TO ADJUST. NOW THE RESPONSE HAS BEEN THAT I NEED TO USE CHEVRON FUEL OF WHICH THAT IS WHAT I USE FOR MY TRUCK. I CAN PROVIDE RECEIPTS OF THIS IF NEEDED, BUT I NEED TO REPORT THE PROBLEM SINCE THE SERVICE DEPARTMENT AT …
Read full complaint
ENGINE PINGNS WHILE ACCELERATING. THIS SAME PROBLEM WAS REPORTED ON 1-26-01. RESPONSE WAS THAT ENGINE NEEDED TO ADJUST. NOW THE RESPONSE HAS BEEN THAT I NEED TO USE CHEVRON FUEL OF WHICH THAT IS WHAT I USE FOR MY TRUCK. I CAN PROVIDE RECEIPTS OF THIS IF NEEDED, BUT I NEED TO REPORT THE PROBLEM SINCE THE SERVICE DEPARTMENT AT MIDWAY SEEM TO THINK THAT IS NOT A SERIOUS PROBLEM ON THE TRUCK.M DO GASOLINE SERO. *AK
NHTSA ODI #761906
Mileage unknown · May 7, 2002
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
I AM WRITING TO NOTIFY YOU OF THE CONTINUING PROBLEMS I AM EXPERIENCING WITH MY 2001, ISUZU, RODEO (VIN [XXX], (SEE ENCLOSURES 1. & 2.), AND TO REQUEST RESOLUTION OF THESE PROBLEMS WITHIN THIRTY DAYS OF YOUR RECEIPT OF THIS LETTER. I PURCHASED MY VEHICLE 13 JANUARY 2001 FROM WEST LOOP DODGE, INC. IN FORT WORTH, TX WITH ASSISTAN…
Read full complaint
I AM WRITING TO NOTIFY YOU OF THE CONTINUING PROBLEMS I AM EXPERIENCING WITH MY 2001, ISUZU, RODEO (VIN [XXX], (SEE ENCLOSURES 1. & 2.), AND TO REQUEST RESOLUTION OF THESE PROBLEMS WITHIN THIRTY DAYS OF YOUR RECEIPT OF THIS LETTER. I PURCHASED MY VEHICLE 13 JANUARY 2001 FROM WEST LOOP DODGE, INC. IN FORT WORTH, TX WITH ASSISTANCE OF MY GRANDFATHER, REV. [XXX]. THE MODEL TEST-DRIVEN WAS IMPRESSIVE BECAUSE OF ITS MECHANICAL/FUNCTIONAL, WARRANTY AND SAFETY FEATURES. (SEE ENCLOSURES 3.) I WAS SOLD ON BUYING A RODEO AND I DID. HOWEVER, APPROXIMATELY TWO WEEKS AFTER I PURCHASED THE RODEO, AND HAD DRIVEN IT TO COLLEGE STATION, HOUSTON AND BACK FOR TWO ROUND TRIPS; [XXX]., SALESMAN, INFORMED ME THAT THE INCORRECT VEHICLE IDENTIFICATION NUMBER WAS ON MY FINANCE PAPERS. (SEE ENCLOSURES 10.) SO, INSTEAD OF CHANGING VEHICLE IDENTIFICATION NUMBERS ON THE PAPERWORK, [XXX]. INSTRUCTED ME TO EXCHANGE THE VEHICLE IN MY POSSESSION FOR THE CORRECT IDENTICAL VEHICLE. HE ALSO TOLD ME THAT THE COLOR AND THE LACK OF TINT ON THE BLACK RODEO WAS THE ONLY DIFFERENCE BETWEEN THE TWO VEHICLES. [XXX]. COMPENSATION FOR THE INCONVENIENCE OF DRIVING FROM COLLEGE STATION TO FORT WORTH WAS INSTALLING TINT (ROLANDS WINDOW TINTING 7800 HWY 80, SUITE 103 FORT WORTH, TX 76116) AND PROVIDING TWENTY DOLLARS FOR GAS. (SEE ENCLOSURE 4.) NEVERTHELESS, THREE MONTHS AFTER THE EXCHANGE, THE BLACK RODEO, CURRENTLY IN MY POSSESSION (ALTHOUGH REPRESENTED TO BE IDENTICAL TO THE SILVER VEHICLE THAT WAS TEST DRIVEN, PURCHASED, AND USED FOR 12 DAYS), NOW APPEARS TO BE A LEMON.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #761653
Mileage unknown · Apr 30, 2002
Vehicle Speed Control
ALMOST GOT HIT 4 TIMES BECAUSE OF LOSS OF POWER/ ALMOST HIT A CHILD WHEN IT ACCELERATED AND I COULD NOT STOP
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DURING THE MANUFACTURE OF CERTAIN FUEL RETURN HOSES, INCORRECT RUBBER MATERIAL FOR THE OUTER LAYER WAS USED.
Consequence & remedy
Consequence: THE FUEL RETURN HOSE DOES NOT MEET OZONE-RESISTANT SPECIFICATIONS, AND COULD ULTIMATELY CRACK, CAUSING FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE VEHICLE TO DETERMINE IF THE VEHICLE WAS EQUIPPED WITH AN INCORRECT HOSE. IF IT IS INCORRECT, DEALERS WILL REPLACE IT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
On April 10, 2018, NHTSA received a petition from Mr. Kevin Byrne (the Petitioner) requesting that the Agency ?undertake a defects investigation? of ?rust-related detachment of Isuzu Rodeo fuel tanks? (NHTSA ID 11091788). The Petitioner experienced a partial fuel tank detachment in his model year (MY) 2004 Isuzu Rodeo in July 2017. On May 23, 2018, ODI opened DP18-001 to evaluate the Petitioner?s request for a defect investigation. ODI sent information request letters to Isuzu and Honda requesting production, design history and field data related to fuel tank retention failures in MY 2001-2004 Isuzu Rodeo, MY 2002-2004 Isuzu Axiom and MY 2001-2002 Honda Passport vehicles equipped with the same fuel tank shield part number as the Petitioner?s vehicle (the ?subject vehicles?). ODI notes that Isuzu manufactured the subject Passport vehicles for Honda. Isuzu implemented a change to the tank shield corrosion protection system as a running change in early MY 2002 production. Isuzu and Honda sold approximately 172,000 subject vehicles in the United States. Fifty-eight (58) percent of the subject vehicles were produced prior to the shield change (99,000) and 42 percent after the change (73,000).ODI?s analysis of field data identified 19 incidents of partial fuel tank detachments in the subject vehicles. The incidents all occurred in states with high road salt usage in winter months (Salt States) and involved older vehicles beyond 10-years in service. On average, the failures occurred in the vehicle?s 13th year-in-service. Evidence of severe general corrosion in multiple undercarriage components was also noted in 13 of the 19 vehicles that experienced partial fuel tank detachments. None of the incidents resulted in fuel leakage or fire. Aside from the petitioner?s vehicle, ODI has not identified any other incidents of complete or partial fuel tank detachment in the MY 2002-2004 subject vehicles equipped with the modified retention shield.In addition, ODI reviewed 24 NHTSA complaints alleging corrosion concerns with the fuel tank retention system in the subject vehicles that did not result in fuel tank detachment. Twenty-three (23) of these complaints involve subject vehicles built prior to the shield change. Like the vehicles reporting fuel tank detachments, these vehicles are also all from Salt States and, in most cases (20 of the 24 complaints), the vehicles also experienced severe corrosion concerns in other undercarriage components. Half (12 of the 24 complaints) of the vehicles show prior accident damage in their service histories.Based on these analyses, ODI has not identified evidence of a defect trend for premature corrosion-related fuel tank detachments in the MY 2004 Isuzu Rodeo or similarly equipped vehicles. The damage that may result in tank retention concerns appears to occur progressively over many years with ample opportunity for detection and repair. Furthermore, ODI has not identified any crashes, fires, injuries, or fuel leaks associated with fuel tank retention failures in a population of vehicles that currently range from 16 to 19 years old.Accordingly, the Agency is denying the petition.A summary of ODI?s analysis of this petition will be published in the Federal Register and is also available in the investigative file for this action.The NHTSA consumer complaints counted in the closing resume for DP18-001 can be reviewed at www.nhtsa.gov under the following ODI identification numbers (VOQs in parentheses denote duplicate records): Allegations of fuel tank retention failure: 11084098 (11091788), 10532845, 10486109. Allegations of fuel tank retention component corrosion: 11138931, 10992150, 10845523,
EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
2001 Isuzu Rodeo Problems, Complaints & Recalls | Skip That Year
Illustration