NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
65 reportsClear category filter95,276 miles · Oct 11, 2009
StructureSuspension
THE EVENTS LEADING UP TO THE FAILURE ARE SIMPLE. LEAVING OUR DRIVEWAY AND WITHIN TWO TENTHS OF A MILE THERE WAS A REAR SUSPENSION LOWER LINK FAILURE ON OUR ISUZU RODEO JUST AS DESCRIBED IN NHTSA ACTION PE09030. HERE ARE THE ACTIONS / MOMENTS LEADING UP TO THE FAILURE. WE SIMPLY GATHERED IN OUR RODEO. PULLED FROM OUR DRIVEWAY…
Read full complaint
THE EVENTS LEADING UP TO THE FAILURE ARE SIMPLE. LEAVING OUR DRIVEWAY AND WITHIN TWO TENTHS OF A MILE THERE WAS A REAR SUSPENSION LOWER LINK FAILURE ON OUR ISUZU RODEO JUST AS DESCRIBED IN NHTSA ACTION PE09030. HERE ARE THE ACTIONS / MOMENTS LEADING UP TO THE FAILURE. WE SIMPLY GATHERED IN OUR RODEO. PULLED FROM OUR DRIVEWAY ON TO A RURAL COUNTRY ROAD. SINGLE LANE AND TRAVELING A SPEED OF APPROXIMATELY 10MPH (LUCKILY). IT IS ON THIS ROAD AND WITH IN TWO TENTHS OF A MILE FROM LEAVING OUR HOME THE FAILURE OCCURRED. THERE WAS NO WARNING WHATSOEVER. WHEN THE FAILURE OCCURRED THERE WAS A LOSS OF CONTROL, THE REAR END OF THE VEHICLE BEGAN SWERVING FROM LEFT TO RIGHT IN A TRACK ABOUT 3 FEET FROM THE ORIGINAL LINE OF TRAVEL. BECAUSE WE WERE NOT YET ON A MAJOR HIGHWAY, STOPPING THE VEHICLE WAS NO PROBLEM AND THERE WAS NO CRASH, HOWEVER, WE CAN'T BARE THE THOUGHTS OF WHAT IT COULD HAVE BEEN IF WE HAD BEEN TRAVELING AT HIGHWAY SPEEDS. AGAIN, LUCKILY WE WERE VERY CLOSE TO HOME. TOWING THE VEHICLE WAS NOT NECESSARY AS WE WERE ABLE TO SLOWLY BACK THE VEHICLE IN REVERSE TO OUR HOME AT NOTHING MORE THAN AN IDLING SPEED. THE NATURE OF THE FAILURE IS THE LEFT REAR SUSPENSION BAR BREAKING FROM THE FRAME OF THE VEHICLE. THERE HAS BEEN NO REPAIR ATTEMPTED AS THE FRAME IS IN NO CONDITION TO REMOUNT THE SUSPENSION BAR. AFTER THIS INCIDENT WE HAVE LOOKED MORE AT THE CONDITION OF FRAME ON THIS VEHICLE. THERE ARE OTHER PLACES ON THE FRAME WERE THERE IS TOTAL RUST THROUGH. BECAUSE OF THE INCIDENT AND BECAUSE OF WHAT WE ARE NOW SEEING WE DEEM THE FRAME UNSAFE. *TR
NHTSA ODI #10287038
500 miles · Feb 13, 2008
EquipmentFuel System, GasolineFuel System, OtherCrashInjury
I TOOK THE DEALER ISUZU TO LEMON LAW AND I WAS TOLD IT WORKS AS DESIGNED. THE JURY WAS SO STUPID IT WAS UN BELIEVABLE, THEY ALL CAME UP TO MY WIFE AND I AND SAID MAKE SURE YOU TAKE THE CAR TO THE DEALERS TO GET IT FIXED. AHHHHHHHHHHHHH ISN'T THAT WHY I AM HERE IN COURT? GOOD LUCK PEOPLE ARE STUPID AND WE ARE STUCK DRIVING AN UN…
Read full complaint
I TOOK THE DEALER ISUZU TO LEMON LAW AND I WAS TOLD IT WORKS AS DESIGNED. THE JURY WAS SO STUPID IT WAS UN BELIEVABLE, THEY ALL CAME UP TO MY WIFE AND I AND SAID MAKE SURE YOU TAKE THE CAR TO THE DEALERS TO GET IT FIXED. AHHHHHHHHHHHHH ISN'T THAT WHY I AM HERE IN COURT? GOOD LUCK PEOPLE ARE STUPID AND WE ARE STUCK DRIVING AN UNSAFE CARE BECAUSE CONSUMER REPORTS WILL NOT GET INVOLVED. LEMON CARS FOR SALE ANY ISUZU CHEAP (RELATED VEHICLE INFORMATION: MODEL YEAR=2000, MAKE=ISUZU, MODEL=RODEO). *TR
NHTSA ODI #10217902
350 miles · Dec 5, 2003
SteeringSuspension
SINCE THE PURCHASE OF MY VEHICLE IN 2000, THERE HAS BEEN A CONTINUOUS VIBRATION IN THE FRONT END AS IF EITHER THE TIRES ARE OUT OF BALANCE OR THE FRONT NEEDS ALIGNING. I HAVE CONTINUOUSLY REPORTED THIS TO SEVERAL DEALERS AND AS OF THIS TIME NONE HAVE BEEN ABLE TO CORRECT THIS PROBLEM..I, AFTER BEING ADVISED TO, AND AT MY OWN EX…
Read full complaint
SINCE THE PURCHASE OF MY VEHICLE IN 2000, THERE HAS BEEN A CONTINUOUS VIBRATION IN THE FRONT END AS IF EITHER THE TIRES ARE OUT OF BALANCE OR THE FRONT NEEDS ALIGNING. I HAVE CONTINUOUSLY REPORTED THIS TO SEVERAL DEALERS AND AS OF THIS TIME NONE HAVE BEEN ABLE TO CORRECT THIS PROBLEM..I, AFTER BEING ADVISED TO, AND AT MY OWN EXPENSE REPLACED ALL FOUR TIRES TO NO AVAIL. *JB
NHTSA ODI #10049248
250 miles · Jul 3, 2003
Suspension
THE TIRES LOSE CONTACT WITH THE ROAD WHEN BRAKING UNDER ROUGH ROAD CONDITIONS, WHICH MAKES STOPPING VIRTUALLY IMPOSSIBLE. THE SUSPENSION COMPONENTS ARE INADEQUATE, THEY FAIL TO KEEP THE TIRES ON THE ROAD WHILE ENCOUNTERING BUMPS DURING BRAKING. THIS HAS BEEN A PROBLEM SINCE NEW, BUT RECENT EXPERIENCE HAS MADE IT CLEAR TO ME JU…
Read full complaint
THE TIRES LOSE CONTACT WITH THE ROAD WHEN BRAKING UNDER ROUGH ROAD CONDITIONS, WHICH MAKES STOPPING VIRTUALLY IMPOSSIBLE. THE SUSPENSION COMPONENTS ARE INADEQUATE, THEY FAIL TO KEEP THE TIRES ON THE ROAD WHILE ENCOUNTERING BUMPS DURING BRAKING. THIS HAS BEEN A PROBLEM SINCE NEW, BUT RECENT EXPERIENCE HAS MADE IT CLEAR TO ME JUST HOW DANGEROUS THE PROBLEM ACTUALLY IS. I WOULD LIKE THE PROBLEM TO BE ADDRESSED BY ISUZU - RECALL THE SUSPENSION COMPONENTS AND REPLACE WITH SOMETHING THAT HANDLES BUMPS BETTER.*AK
NHTSA ODI #10025355
Mileage unknown · May 7, 2003
Service Brakes, HydraulicSuspension
THE FRONT END OF THE VEHICLE WOBBLED WHILE DRIVING AT 65 MPH. THE VEHICLE HAD THREE NEW SETS OF BRAKE ROTORS, HOWEVER IT DID NOT SOLVE THE PROBLEM, REAR END WOBBLING CONTINUED. *AK *JB
NHTSA ODI #10017576
10 miles · Apr 30, 2003
Engine And Engine CoolingSeat BeltsSuspensionCrashFire
VEHICLE IS VERY UNSTABLE DUE TO INSUFFICENT DAMPENING OF THE SUPENSION, DEALER SAYS THIS THERE IS NO PROBLEM. TRUCK WILL BOTTOM OUT ON SLIGHT BUMPS, AND BOUNCE UP AND DOWN AS IF YOU WERE IN A BOAT, THE SUSPENSION PARTS ARE INFERIOR COMPARED TO THE WEIGHT OF THE VEHICLE. CONDITION IS VERY UNSAFE AND COULD CAUSE LOSS OF CONTROL IN…
Read full complaint
VEHICLE IS VERY UNSTABLE DUE TO INSUFFICENT DAMPENING OF THE SUPENSION, DEALER SAYS THIS THERE IS NO PROBLEM. TRUCK WILL BOTTOM OUT ON SLIGHT BUMPS, AND BOUNCE UP AND DOWN AS IF YOU WERE IN A BOAT, THE SUSPENSION PARTS ARE INFERIOR COMPARED TO THE WEIGHT OF THE VEHICLE. CONDITION IS VERY UNSAFE AND COULD CAUSE LOSS OF CONTROL IN CERTAIN DRIVING SITUATIONS. BOUNCE = LOSS OF TREAD CONTACT TO PAVEMENT = LOSS OF CONTROL. ALL TIRES/POINTS OF SUPENSION (SPRINGS/SHOCKS) HAVE THE SAME PROBLEM. WOULD NOT RECCOMEND THIS VEHICLE TO ANYONE OTHER THAN A PIRATE, AS THEY ARE USED TO THE HEAVING AND YAWING OF A SHIP.-----------CATALITIC CONVERTER / ENGINE ~ CATALITIC CONVERTER WAS GLOWING RED ONE DAY (WITH THE USUAL CHECK ENGINE LIGHT) JIFFYLUBE EMPLOYEE IN THE PIT POINTED THIS PROBLEM OUT TO ME, LAUGHING AND SAYING IT WAS RIGHT NEXT TO THE GAS LINE, WHICH COULD CAUSE A FIRE. DEALER REPLACED CAT AND NOW THE TRUCH HESITATES/SPUTTERS IN FIRST GEAR AND EVEN MORE SO IN SECOND GEAR.----------------SEATBELT~ON PASSENDER SIDE BINDS UP WITHOUT PROVOCATION, LIMITING MOVEMENT OF PASSENGER FROM THE SHOLDER, DEALER SAID IT WAS NORMAL BUT IT IS NOT LIKE THE DRIVERS SIDE SEATBELT TENSION THAT BINDS WHEN THERE IS ACTUALY A STRONGER FORCE OPPOSING IT.
NHTSA ODI #10016774
Mileage unknown · Oct 22, 2001
Engine And Engine CoolingSuspension
WE ARE CONSTANTLY ADDING OIL TO THE VEHICLE WITHIN A MONTHS TIME NO OIL WILL MEASURE ON THE DIPSTICK AND THERE ARE NO SIGNS OF LEAKAGE. WHEN THE TRUCK REACHES OVER 50MPH THE VEHICLE VIBRATES AND PULLS TO THE RIGHT EVERYTIME
NHTSA ODI #753512
Mileage unknown · Oct 19, 2001
Suspension
WHEN VEHICLE REACHES 65-70 MPH VEHICLE BOUNCES ALL OVER THE ROAD, AND IS VERY HARD TO CONTROL. DEALER BLAMES TIRES FOR THIS, CONSUMER HAS REPLACED TIRES 3 TIMES PLUS 2 EXTRA TIRES. ISUZU SAYS IT IS A SUV, AND WILL RIDE ROUGH. VEHICLE TAKEN TO DEALER 5 TIMES FOR THIS PROBLEM.*AK *YH
NHTSA ODI #898037
Mileage unknown · Sep 6, 2001
SteeringSuspension
FRONT END SHAKES VIOLENTLY AT ALL TIMES, VEHICLE IS HARD TO OPERATE. VEHICLE HAS BEEN IN OVER 5 TIMES FOR SAME PROBLEM. ISUZU REPRESENTATIVE HAD STEERING COLUMN TIGHTENED WHICH DID NOT REMEDY PROBLEM.*AK THE STEERING FREEZES UP AT TIMES AFTER HITTING A BUMP. NLM CONSUMER STATES AT SPEEDS OF 45 MPH THE BACK WHEELS VIBRATE UP …
Read full complaint
FRONT END SHAKES VIOLENTLY AT ALL TIMES, VEHICLE IS HARD TO OPERATE. VEHICLE HAS BEEN IN OVER 5 TIMES FOR SAME PROBLEM. ISUZU REPRESENTATIVE HAD STEERING COLUMN TIGHTENED WHICH DID NOT REMEDY PROBLEM.*AK THE STEERING FREEZES UP AT TIMES AFTER HITTING A BUMP. NLM CONSUMER STATES AT SPEEDS OF 45 MPH THE BACK WHEELS VIBRATE UP AND DOWN, THEY DO NOT STAY IN CONTACT WITH THE ROAD, THE FRONT WHEELS ALSO TEND TO SQUIRM LEFT TO RIGHT AT THESE SPEEDS, THE PROBLEM TENDS TO GET WORSE THE LONGER THE VEHICLE IS DRIVEN. *SLC
NHTSA ODI #895887
Mileage unknown · Jul 11, 2001
EquipmentService Brakes, HydraulicSuspension
WHEN DRIVING AT ANY SPEED AND WHEN APPLYING BRAKE PEDAL TO MAKE A GRADUAL STOP, AND WHEN APPROACHING AN INTERSECTION OR A TRAFFIC LIGHT, BRAKE PEDAL TRAVELED TO FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE/ BRAKE FADE AWAY. CONSUMER NOTICED SHORTLY THEREAFTER THAT BRAKES KICKED BACK IN. CONSUMER HAS CONTACTED DEALER, DEALER…
Read full complaint
WHEN DRIVING AT ANY SPEED AND WHEN APPLYING BRAKE PEDAL TO MAKE A GRADUAL STOP, AND WHEN APPROACHING AN INTERSECTION OR A TRAFFIC LIGHT, BRAKE PEDAL TRAVELED TO FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE/ BRAKE FADE AWAY. CONSUMER NOTICED SHORTLY THEREAFTER THAT BRAKES KICKED BACK IN. CONSUMER HAS CONTACTED DEALER, DEALER WAS UNABLE TO DETERMINE CAUSE OF PROBLEM. *AK THE VEHICLE PULLS TO THE RIGHT. THE A/C MALFUNCTIONED. THE VEHICLE VIBRATES AT SPEED OF 35 MPH. THE CD PLAYER FAILED. *YH
NHTSA ODI #892456
Official recalls
3Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Aug 9, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Feb 22, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration