NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
14 reportsClear category filter120,000 miles · Feb 17, 2011
Fuel System, GasolineStructure
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT IN 2008 WHILE DRIVING 65 MPH, THE VEHICLE STALLED. A LOCAL MECHANIC REPLACED THE FUEL PUMP BUT THE FAILURE CONTINUED. THE ENGINE WOULD NOT START SO THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE FUEL PUMP AND SUBFRAME HAD HOLES DUE TO CORROSION. THE C…
Read full complaint
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT IN 2008 WHILE DRIVING 65 MPH, THE VEHICLE STALLED. A LOCAL MECHANIC REPLACED THE FUEL PUMP BUT THE FAILURE CONTINUED. THE ENGINE WOULD NOT START SO THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE FUEL PUMP AND SUBFRAME HAD HOLES DUE TO CORROSION. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THE CONTACT TO HAVE THE VEHICLE TOWED TO AN AUTHORIZED DEALER. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 150,000.
NHTSA ODI #10383130
Mileage unknown · Dec 10, 2010
Fuel System, GasolineStructure
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS HAVING THE VEHICLE REPAIRED AT AN AUTHORIZED DEALER FOR UNRELATED FAILURES WHEN THE CONTACT WAS INFORMED THAT THE UNDER FRAME WAS SEVERELY CORRODED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED AT AN AUTHORIZED DEALER FOUR TIMES IN THE PAST FOR A CORRODED INTAKE SYST…
Read full complaint
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS HAVING THE VEHICLE REPAIRED AT AN AUTHORIZED DEALER FOR UNRELATED FAILURES WHEN THE CONTACT WAS INFORMED THAT THE UNDER FRAME WAS SEVERELY CORRODED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED AT AN AUTHORIZED DEALER FOUR TIMES IN THE PAST FOR A CORRODED INTAKE SYSTEM AND FUEL TANK FILLER NECK. DUE TO THE CORROSION OF THE FUEL TANK FILLER NECK THE CONTACT WAS NO LONGER ABLE TO REFUEL THE VEHICLE WITHOUT GASOLINE SPILLAGE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 93,000.
NHTSA ODI #10369895
124,000 miles · Nov 17, 2010
Fuel System, GasolineSuspension
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER REAR SIDE SUSPENSION FRACTURED AND SEPARATED FROM THE FRAME. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHO STATED THAT THE CONTROL SOCKET ON THE DRIVER SIDE AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE C…
Read full complaint
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER REAR SIDE SUSPENSION FRACTURED AND SEPARATED FROM THE FRAME. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHO STATED THAT THE CONTROL SOCKET ON THE DRIVER SIDE AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT WHEN FILLING THE FUEL TANK, THE FUEL BEGAN TO SPILL BACK OUT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THERE WERE HOLES IN THE FUEL LINE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 124,000.
NHTSA ODI #10366608
500 miles · Feb 13, 2008
EquipmentFuel System, GasolineFuel System, OtherCrashInjury
I TOOK THE DEALER ISUZU TO LEMON LAW AND I WAS TOLD IT WORKS AS DESIGNED. THE JURY WAS SO STUPID IT WAS UN BELIEVABLE, THEY ALL CAME UP TO MY WIFE AND I AND SAID MAKE SURE YOU TAKE THE CAR TO THE DEALERS TO GET IT FIXED. AHHHHHHHHHHHHH ISN'T THAT WHY I AM HERE IN COURT? GOOD LUCK PEOPLE ARE STUPID AND WE ARE STUCK DRIVING AN UN…
Read full complaint
I TOOK THE DEALER ISUZU TO LEMON LAW AND I WAS TOLD IT WORKS AS DESIGNED. THE JURY WAS SO STUPID IT WAS UN BELIEVABLE, THEY ALL CAME UP TO MY WIFE AND I AND SAID MAKE SURE YOU TAKE THE CAR TO THE DEALERS TO GET IT FIXED. AHHHHHHHHHHHHH ISN'T THAT WHY I AM HERE IN COURT? GOOD LUCK PEOPLE ARE STUPID AND WE ARE STUCK DRIVING AN UNSAFE CARE BECAUSE CONSUMER REPORTS WILL NOT GET INVOLVED. LEMON CARS FOR SALE ANY ISUZU CHEAP (RELATED VEHICLE INFORMATION: MODEL YEAR=2000, MAKE=ISUZU, MODEL=RODEO). *TR
NHTSA ODI #10217902
37,000 miles · Sep 26, 2006
Fuel System, Gasoline
THE GAS GAUGE IS FAULTY. I HAVE HEARD OF MANY COMPLAINTS AND THAT WHEN THERE ARE HARD SHIFTS (TURNS) OR PRESS HARDER ON THE ACCELERATION CAUSES THE GAS GAUGE TO WORK INCORRECTLY AND THE GAS LIGHT COMES ON. THIS IS HAPPENING TO MY CAR CURRENTLY. FURTHERMORE, AFTER THE LIGHT COMES ON THE CHECK ENGINE LIGHT COMES ON. *NM
NHTSA ODI #10169291
Mileage unknown · May 19, 2005
Fuel System, Gasoline
GAS LIGHT COMES ON DURING TURNS AND AT OTHER RANDOM TIMES AND GAS GAUGE DROPS TO EMPTY WHEN TANK IS FULL.
NHTSA ODI #10121600
49,000 miles · Oct 15, 2004
Fuel System, Gasoline
2000 ISUZU RODEO LSE - FUEL TANK SENDING UNIT IS FAULTY. IT BLINKS WHEN THE TANK WAS RECENTLY FILLED AND THE CHECK ENGINE LIGHT GOES ON FOR NO APPARENT REASON. IF THE FUEL TANK SENDING UNIT DOES NOT GET RECALLED, A CLASS LAWSUIT MAY BE FILED. NUMEROUS COMPLAINTS ABOUT THIS PROBLEM. FOR MORE COMPLAINTS REGARDING THIS MATTER: …
Read full complaint
2000 ISUZU RODEO LSE - FUEL TANK SENDING UNIT IS FAULTY. IT BLINKS WHEN THE TANK WAS RECENTLY FILLED AND THE CHECK ENGINE LIGHT GOES ON FOR NO APPARENT REASON. IF THE FUEL TANK SENDING UNIT DOES NOT GET RECALLED, A CLASS LAWSUIT MAY BE FILED. NUMEROUS COMPLAINTS ABOUT THIS PROBLEM. FOR MORE COMPLAINTS REGARDING THIS MATTER: HTTP://WWW.AUTOMOTIVEFORUMS.COM/T193601.HTML. *AK
NHTSA ODI #10095807
55,000 miles · Jul 21, 2004
Engine And Engine CoolingFuel System, Gasoline
I BOUGHT THIS CAR USED WITH 50128 MILES IN APRIL 3, 2004. ON, JULY 12, 2004 AROUND 55000 MILES. I STOPPED AND LET THE CAR RUNNING FOR 3 MINS. I CAME BACK AND THE FUEL SENSOR LOW LIGHT WAS FLASHING AND THE CAR SAID I WAS EMPTY, BUT I KNEW I WASN'T BECAUSE I JUST FILLED THE TANK UP THAT DAY. I STARTED GOING AND THE FUEL SENSOR …
Read full complaint
I BOUGHT THIS CAR USED WITH 50128 MILES IN APRIL 3, 2004. ON, JULY 12, 2004 AROUND 55000 MILES. I STOPPED AND LET THE CAR RUNNING FOR 3 MINS. I CAME BACK AND THE FUEL SENSOR LOW LIGHT WAS FLASHING AND THE CAR SAID I WAS EMPTY, BUT I KNEW I WASN'T BECAUSE I JUST FILLED THE TANK UP THAT DAY. I STARTED GOING AND THE FUEL SENSOR SAID I HAD ALL MY GAS BACK. AFTER THAT, EVERYDAY, THE SENSOR WILL SAY LOW FUEL AFTER THE SENSOR HAS PASSED 3/4 OF A TANK. ON, JULY 15, WHEN THE FUEL LIGHT COMES ON FOR SOMETIME THE CHECK ENGINE LIGHT WILL COME ON AND STAY ON UNTIL I FILL THE GAS TANK UP AND DRIVE FOR SEVERAL MILES. I AM GOING TO TAKE IT TO MY MECHANIC AND MAYBE THE DEALERSHIP WHERE I BOUGHT THE CAR TO SOLVE THIS PROBLEM. *LA
NHTSA ODI #10082386
41,700 miles · Mar 23, 2004
Fuel System, Gasoline
VEHICLE SPORADICLY STALLS WHEN SLOWING TO STOP OR WHEN ALREADY STOPPED. THE VEHICLE "BUCKS" WHEN ACCELERATING FROM STOPPED POSITION. ALL DASH LIGHTS COME ON WHEN THE VEHICLE STALLS. AFTER A FEW MINUTES OF REST, VEHICLE WILL START AND DASH LIGHTS TURN OFF. NOTHING WILL REGISTER IN THE COMPUTER SYSTEM. THROTTLE BODY HAS BEEN CLEA…
Read full complaint
VEHICLE SPORADICLY STALLS WHEN SLOWING TO STOP OR WHEN ALREADY STOPPED. THE VEHICLE "BUCKS" WHEN ACCELERATING FROM STOPPED POSITION. ALL DASH LIGHTS COME ON WHEN THE VEHICLE STALLS. AFTER A FEW MINUTES OF REST, VEHICLE WILL START AND DASH LIGHTS TURN OFF. NOTHING WILL REGISTER IN THE COMPUTER SYSTEM. THROTTLE BODY HAS BEEN CLEANED, FUEL FILTER HAS BEEN CHANGED. MECHANIC CANNOT DUPLICATE PROBLEM. ALL SIGNS POINT TO BAD INTAKE MANIFOLD GASKET BUT MECHANIC REFUSES TO REPLACE EVEN AT OWNERS REQUEST. THIS PROBLEM HAS HAPPENED 7 TIMES IN THE 3 MONTHS I HAVE OWNED IT.*AK
NHTSA ODI #10063674
Mileage unknown · Jun 28, 2003
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
INTERMITTENTLY THE VEHICLE WOULD NOT START PROPERLY AND THE CONSUMER HAD TO CRANK THE VEHICLE SEVERAL TIME BEFORE STARTING. THE CHECK ENGINE LIGHT AND THE FUEL LIGHT WOULD ILLUMINATE AFTER THE VEHICLE WAS STARTED AND STAY ON MOMENTARY BEFORE IT WENT OUT. DEALER WAS NOT NOTIFIED AT THIS TIME. *NLM
NHTSA ODI #10025137
Official recalls
3Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Aug 9, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Feb 22, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration