NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
550 reports90,000 miles · Dec 12, 2005
Service Brakes, HydraulicCrashInjury
DT: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN 021002000 CONCERNING THE ANTI LOCK BRAKES. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. SHE SPOKEN TO THE MANUFACTURER WHO CONFIRMED THE PARTS WERE NOT AVAILABLE. THE CONTACT'S SON WAS IN AN ACCIDENT DUE TO BRAKE FAILURE. THE OTHER D…
Read full complaint
DT: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN 021002000 CONCERNING THE ANTI LOCK BRAKES. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. SHE SPOKEN TO THE MANUFACTURER WHO CONFIRMED THE PARTS WERE NOT AVAILABLE. THE CONTACT'S SON WAS IN AN ACCIDENT DUE TO BRAKE FAILURE. THE OTHER DRIVER WAS INJURED. A POLICE REPORT WAS TAKEN AT THE SCENE.*AK
NHTSA ODI #10144947
Mileage unknown · Dec 5, 2005
Service Brakes, Hydraulic
DT: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN 021V002000 CONCERNING THE ANTI LOCK BRAKES. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THEIR LOCAL DEALERSHIP. HE SPOKE TO THE MANUFACTURER, WHO CONFIRMED THAT THE PARTS WERE NOT AVAILABLE. *AK
NHTSA ODI #10144522
110,000 miles · Nov 28, 2005
Fuel System, Other
DT: THE CONTACT STATED THE FUEL GAUGE WORKED IMPROPERLY. THE NEEDLE MOVED WITHOUT CAUSE. THE FUEL GAUGE WARNING LIGHT CAME ON WHEN THERE WAS STILL FUEL IN THE TANK. THE VEHICLE HAS NOT BEEN INSPECTED OR REPAIRED . *AK
NHTSA ODI #10143824
48,980 miles · Nov 26, 2005
Fuel System, Gasoline
1999 ISUZU RODEO, LS, V6, 49,570 MILES. FUEL TANK SENSOR SENDING FAULTY SIGNAL TO DASH BOARD, GAS GUAGE. CAN HAVE 1/2 TANK, BUT RECEIVE FLASHING INDICATOR OF AN EMPTY TANK. A COLD START OR A SHARP TURN CAUSES INDICATOR TO DROP TO E (EMPTY) MARK. RELYING ON TRIPOMETER AT THIS TIME. RESEARCH INDICATES FUEL TANK MUST BE DROPPE…
Read full complaint
1999 ISUZU RODEO, LS, V6, 49,570 MILES. FUEL TANK SENSOR SENDING FAULTY SIGNAL TO DASH BOARD, GAS GUAGE. CAN HAVE 1/2 TANK, BUT RECEIVE FLASHING INDICATOR OF AN EMPTY TANK. A COLD START OR A SHARP TURN CAUSES INDICATOR TO DROP TO E (EMPTY) MARK. RELYING ON TRIPOMETER AT THIS TIME. RESEARCH INDICATES FUEL TANK MUST BE DROPPED FOR REPAIR. *NM
NHTSA ODI #10143705
Mileage unknown · Nov 19, 2005
Service Brakes, HydraulicCrash
I WAS INVOLVED IN A REAR END COLLISION WHERE I WAS AT FAULT DUE TO THE BRAKES MALFUNCTIONING IN MY 1999 ISUZU RODEO. THE ROADS WERE WET AND I ENCOUNTERED PROBLEMS WITH THE BRAKING SYSTEM, CAUSING ME TO HIT THE VAN IN FRONT OF ME. I HAVE SINCE RECEIVED A RECALL NOTICE FOR THIS EXACT PROBLEM. I WAS FORCED TO PAY A $500 DEDUCTIB…
Read full complaint
I WAS INVOLVED IN A REAR END COLLISION WHERE I WAS AT FAULT DUE TO THE BRAKES MALFUNCTIONING IN MY 1999 ISUZU RODEO. THE ROADS WERE WET AND I ENCOUNTERED PROBLEMS WITH THE BRAKING SYSTEM, CAUSING ME TO HIT THE VAN IN FRONT OF ME. I HAVE SINCE RECEIVED A RECALL NOTICE FOR THIS EXACT PROBLEM. I WAS FORCED TO PAY A $500 DEDUCTIBLE WHEN THIS WAS A KNOWN DEFECT TO THE ISUZU RODEO'S. WHAT CAN I DO TO RECOUP THE OUT OF POCKET EXPENSE FOR THIS ACCIDENT? *NM
NHTSA ODI #10143267
Mileage unknown · Nov 9, 2005
Fuel System, Other
FUEL GAUGE NOT WORKING, WHICH I UNDERSTAND IS A VERY COMMON PROBLEM. *JB
NHTSA ODI #10142229
Mileage unknown · Oct 19, 2005
Air BagsPower TrainService Brakes, HydraulicCrashInjury
DT: THE CONTACT S OWNS A 1999 ISUZU RODEO. HE RECEIVED A RECALL ON 10-14-05 REGARDING THE BRAKES ON THE VEHICLE. THE CONTACT HAS NOT TAKEN THE CAR ITO DEALER TO HAVE THE RECALL REPAIR WORK DONE. THE CONTACT'S VEHICLE WAS INVOLVED IN AN ACCIDENT ONE YEAR AGO. A CHILD RAN O IN FRONT OF VEHICLE, HE SWERVED TO MISS THE CHILD, HI…
Read full complaint
DT: THE CONTACT S OWNS A 1999 ISUZU RODEO. HE RECEIVED A RECALL ON 10-14-05 REGARDING THE BRAKES ON THE VEHICLE. THE CONTACT HAS NOT TAKEN THE CAR ITO DEALER TO HAVE THE RECALL REPAIR WORK DONE. THE CONTACT'S VEHICLE WAS INVOLVED IN AN ACCIDENT ONE YEAR AGO. A CHILD RAN O IN FRONT OF VEHICLE, HE SWERVED TO MISS THE CHILD, HIT THE BRAK THEY DID NOT WORK, AND THE VEHICLE HIT A TELEPHONE POLE. A POLICE REPORT WAS TAKEN. HE FELT THAT THE ACCIDENT CAUSED OTHER DAMAGE TO THE CAR, SUCH AS TRANSMISSION SLIPPING. HE NOTICED THE TRANSMISSION SLIPPING ABOUT FIVE MONTHS AGO. HAD TO DO A LOT OF REPAIR WORK TO THE FRONT END OF THE VEHICLE ABOUT FIVE MONTHS AGO AIR BAGS DEPLOYED ,AND HE HAS NOT HAD THEM INSTALLED AGAIN.*AK
NHTSA ODI #10140255
71,000 miles · Aug 30, 2005
Power Train
DT: THERE IS A PROBLEM WITH THE INHIBITER SWITCH THAT IS ATTACHED TO THE OUTSIDE OF THE TRANSMISSION. THIS PROBLEM FIRST STARTED ON 8-16-05. WHEN THE GEARS ARE MOVED THERE IS A CLANKING SOUND AND THE TRANSITION FROM ONE GEAR TO THE OTHER IS HARD. WHEN SHE CONTACTED THE DEALER, THEY TOLD HER THAT THE TRANSMISSION COULD GO OU…
Read full complaint
DT: THERE IS A PROBLEM WITH THE INHIBITER SWITCH THAT IS ATTACHED TO THE OUTSIDE OF THE TRANSMISSION. THIS PROBLEM FIRST STARTED ON 8-16-05. WHEN THE GEARS ARE MOVED THERE IS A CLANKING SOUND AND THE TRANSITION FROM ONE GEAR TO THE OTHER IS HARD. WHEN SHE CONTACTED THE DEALER, THEY TOLD HER THAT THE TRANSMISSION COULD GO OUT BECAUSE OF THIS PROBLEM AND ADVISED HER TO PARK THE VEHICLE. ALSO,ANOTHER MECHANIC TOLD HER TO PARK THE VEHICLE. THE CONSUMER IS CONCERNED THAT THE REPLACEMENT PART IS ON BACK ORDER BECAUSE THERE IS A PROBLEM WITH THIS IN MULTIPLE VEHICLES. *AK
NHTSA ODI #10134820
Mileage unknown · Aug 28, 2005
Electrical SystemFuel System, GasolinePower Train
THERE WAS A FEW INCIDENTS. ONE DAY MY TWO SISTERS WHERE RIDING DOWN THE HIGHWAY AND OUT OF NO WHERE MY TRUNK WINDOW COMPLETELY BUSTED OUT. MY SISTERS WERE TERRIFIED AND LUCKILY A COP PULLED UP. HE TOLD THEM THAT IT LOOK LIKE SOMEONE HAD PUT TINT OVER THE HEATING WIRES THAT THEY USE TO DEFROST. BEING THAT I HAD BOUGHT IT FROM A D…
Read full complaint
THERE WAS A FEW INCIDENTS. ONE DAY MY TWO SISTERS WHERE RIDING DOWN THE HIGHWAY AND OUT OF NO WHERE MY TRUNK WINDOW COMPLETELY BUSTED OUT. MY SISTERS WERE TERRIFIED AND LUCKILY A COP PULLED UP. HE TOLD THEM THAT IT LOOK LIKE SOMEONE HAD PUT TINT OVER THE HEATING WIRES THAT THEY USE TO DEFROST. BEING THAT I HAD BOUGHT IT FROM A DEALERSHIP THEY LED ME TO BELIEVE THAT MY TINT WAS MANUFACTURED. I FEEL THAT I WAS RIPPED OFF FROM THE COMPANY BECAUSE THEY OVER CHARGED ME AS WELL. WHEN I BOUGHT MY 99' ISUZU RODEO IT WAS FOR 21,995 WHEN THEY FINISH MY PAPER WORK I THOUGHT NOTHING ABOUT WHAT THEY ADDED ON TO MY BILL. YEARS HAD WENT BY AND I DECIDED TO TRADE MY VEHICLE IN FOR A NEW MODEL. SOME FRIENDLY SALESMEN FROM A ISUZU DEALERSHIP FOUND OUT THAT I HAD BEEN RIPPED OFF BY THE PREVIOUS PLACE THAT I PURCHASED MY VEHICLE FROM. I FOUND OUT THAT THEY HAD CHARGED ME IN ALL $34,00. ON MY RECEIPT IT SAID THAT I SUPPOSE TO HAD, INSURANCE AND A WHOLE LOT OF OTHER THINGS THAT I DIDN'T EVEN KNOW ABOUT. I JUST FELT SO BAD BECAUSE I FELT LIKE THEY HAD TOOK ADVANTAGE OF ME BECAUSE I WAS A WOMAN. OTHER THINGS THAT I HAD TO GO THROUGH WITH MY VEHICLE WAS PAYING CONSTANTLY FOR IT TO GET FIXED. MY AXLES AND A WHOLE LOT OF STUFF. I RECEIVED A RECALL IN THE MAIL SAYING RECALLING ALL 99' ISUZU RODEO'S AND I ALSO HEARD IT ON THE NEWS. BUT AS MUCH AS I TRIED TO GET IN TOUCH WITH SOMEONE I NEVER WAS ABLE TOO. I REALLY LIKE HOW RODEOS RIDE, HOW THEY LOOK, I JUST LIKE IT ALL TOGETHER. BUT WHAT I HAD TO GO THROUGH THESE PAST 5 YEARS HAVE BEEN TERRIFYING. *JB
NHTSA ODI #10134437
Mileage unknown · Aug 22, 2005
Engine And Engine Cooling
EXTREMELY EXCESSIVE OIL CONSUMPTION ON ISUZU RODEO 1999 MODEL. HAD THE SAME PROBLEM WITH ISUZU RODEO 2000 MODEL. FORTUNATELY I DONT HAVE TO DEAL WITH THE 2000 MODEL ANY MORE AS IT HAS BEEN TOTALED BYT MY INSURANCE COMPANY DUE TO IMPROPER REPAIR AFTER A COLLISION IN MARCH OF 2005. I DID NOT KNOW THAT THE 1999 ISUZU RODEO HAD THE …
Read full complaint
EXTREMELY EXCESSIVE OIL CONSUMPTION ON ISUZU RODEO 1999 MODEL. HAD THE SAME PROBLEM WITH ISUZU RODEO 2000 MODEL. FORTUNATELY I DONT HAVE TO DEAL WITH THE 2000 MODEL ANY MORE AS IT HAS BEEN TOTALED BYT MY INSURANCE COMPANY DUE TO IMPROPER REPAIR AFTER A COLLISION IN MARCH OF 2005. I DID NOT KNOW THAT THE 1999 ISUZU RODEO HAD THE SAME PROBLEM UNTIL MY SON WHO DROVE THE SUV BROUGHT IT BACK TO ME TWO WEEKS AGO, AS HE IS IN THE MILITARY AND IS DEPLOYING TO IRAQ. IT SEEMS THAT THE VEHICLE SPENT MORE TIME AT THE DEALERSHIP GETTING REPAIRED THAN BEING ON THE ROAD. MY SON ASKED ME TO GET RID OF IT AS HE IS TIRED DEALING WITH ALL THE PROBLEMS THIS CAR HAD. UPON HIS ARRIVAL I NOTICED THE CAR LOW ON OIL AND I ADDED TWO QUARTS. MY SON INFORMED ME THAT HE HAD JUST CHANGED OIL PRIOR LEAVING GRAND FORKS AFB IN ND AND DRIVING TO NORMAN, OK. AFTER DRIVING FOR 5 DAYS I CHECKED OIL LEVEL AND IT WAS AGAIN TWO QUARTS LOW, AFTER ONLY DRIVING 300 MILES. I THEN DECIDED TO INQUIRE ON THE WEB FOR SIMILAR INCIDENTS, AND I COULD NOT BELIEVE THE QUANTITY OF PEOPLE WITH THE SAME PROBLEM WITH THEIR ISUZUS. IN ADDITION, ONE OF MY CO-WORKERS ISUZU TROOPER ENGINE WAS DAMAGED DUE TO THE SAME PROBLEM IN 2004. I FOUND THIS SITE TROUGH SEARCHING THE INTERNET FOR SIMILAR ISSUES. IN ADDITION I CALLED THE DEALERSHIP WHERE I PURCHASED MY 2000 ISUZU AND HAVE BEEN INFORMED THAT ISUZU IS AWARE OF THE ISSUE BUT NO BULETIN OR RECALL HAS BEEN ISSUED, AND THAT IT IS NOT CONSIDERED A PROBLEM AT THIS TIME. I KEEP MY CARS WELL MAINTAINED, AND CHECK MY PCV AND EGR VALVES ON A REGULAR BASIS. I PERFORM MOST OF MY CAR MAINTENANCE MYSELF AND USE THE BEST PORDUCTS ON THE MARKET. WITH SO MANY OF US AFFECTED WITH THE SAME CONDITION ON OUR ISUZU'S IS ISUZU/GM GOING TO BE HELD ACCOUNTABLE FOR A BAD PRODUCT THEY KNOW THEY HAVE, OR ARE WE AS CONSUMERS HAVING TO PAY THE BILL FOR THEIR INFERIOR ENGINES INSTALLED IN THESE SUV'S. AVERY DISSATISFIED AND FRUSTRATED AND NEVER TO BE AGAIN ISUZU OWNER. JR
NHTSA ODI #10133693
Official recalls
3Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Apr 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
Illustration