IllustrationLOW FUEL INDICATOR IS ON CONSTANTLY. HAS GOTTEN WORSE OVER TIME AS THE GAS GAUGE WOULD WORK PROPERLY FOR THE FIRST 1/2 TANK, BUT BELOW 1/2 TANK WOULD SIMPLY SHOW EMPTY. NOW, AFTER FILLING UP WITH GAS, STILL SHOWS AS EMPTY WITH LOW FUEL LIGHT ON. *TR
1999 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 1999 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3725–50K
6750–75K
2875–100K
59100–150K
43150K+
253 reports with mileage · 297 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 85 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
76 crash reports8 fire reports24 injury reports
What owners actually said
550 reportsTL*THE CONTACT OWNS A 1999 ISUZU RODEO. THE CONTACT STATED THAT THE ABS LIGHT FREQUENTLY ILLUMINATES AND THE VEHICLE HAS A DELAY IN STOPPING DISTANCE. THE DEALER WAS NOTIFIED. THE SENSORS HAVE BEEN CHANGED, BUT THE VEHICLE CONTINUES TO EXPERIENCE THE DELAY IN STOPPING DISTANCE. THE VEHICLE IS A PART OF RECALL # 02I00200 (SER…
Read full complaint
TL*THE CONTACT OWNS A 1999 ISUZU RODEO. THE CONTACT STATED THAT THE ABS LIGHT FREQUENTLY ILLUMINATES AND THE VEHICLE HAS A DELAY IN STOPPING DISTANCE. THE DEALER WAS NOTIFIED. THE SENSORS HAVE BEEN CHANGED, BUT THE VEHICLE CONTINUES TO EXPERIENCE THE DELAY IN STOPPING DISTANCE. THE VEHICLE IS A PART OF RECALL # 02I00200 (SERVICE BRAKES, HYDRAULIC:ANTILOCK). ISUZU STATED THAT THE RECALL REPAIR WAS PREVIOUSLY PERFORMED ON THE VEHICLE. HOWEVER, THE CONTACT STATED THAT SHE OWNED THE VEHICLE AT THE TIME AND DID NOT TAKE IT ANYWHERE TO HAVE THE RECALL WORK DONE. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 92,000 AND FAILURE MILEAGE WAS 66,000.
TL*- THE CONTACT OWNS A 1999 ISUZU RODEO, AND STATED THAT WHILE DRIVING ON THE ROAD AT 30 MPH THE VEHICLE IN FRONT OF THE CONTACT'S VEHICLE SLAMMED THE BRAKES SUDDENLY, CAUSING THE CONTACT TO DO THE SAME. THE CONTACT STATED THAT THE VEHICLE HAD SEVERE DAMAGE IN THE FRONT. UPON IMPAQCT, THE AIRBAGS DID NOT DEPLOY. THERE WERE…
Read full complaint
TL*- THE CONTACT OWNS A 1999 ISUZU RODEO, AND STATED THAT WHILE DRIVING ON THE ROAD AT 30 MPH THE VEHICLE IN FRONT OF THE CONTACT'S VEHICLE SLAMMED THE BRAKES SUDDENLY, CAUSING THE CONTACT TO DO THE SAME. THE CONTACT STATED THAT THE VEHICLE HAD SEVERE DAMAGE IN THE FRONT. UPON IMPAQCT, THE AIRBAGS DID NOT DEPLOY. THERE WERE NO WARNING LIGHTS CONCERNING THE AIRBAGS BEFORE AND SUBSEQUENT TO THE ACCIDENT. THE CONTACT COULD PROVIDE PICTURE IF NEEDED. THE FAILURE MILEAGE WAS 96,371 MILES. *AK
DT*: THE CONTACT STATED WHILE TRAVELING 55 MPH ON NORMAL ROAD CONDITIONS, THE FUEL GAUGE SUDDENLY DROPPED DOWN TO THE EMPTY INDICATOR. THIS OCCURRED ON 2 OCCASIONS AND THE NEEDLE USUALLY DROPPED TO EMPTY A FEW DAYS AFTER FILLING THE TANK WITH FUEL. THE SERVICE DEALER WAS CONTACTED, AND AN APPOINTMENT WAS SCHEDULED FOR 12/19/06…
Read full complaint
DT*: THE CONTACT STATED WHILE TRAVELING 55 MPH ON NORMAL ROAD CONDITIONS, THE FUEL GAUGE SUDDENLY DROPPED DOWN TO THE EMPTY INDICATOR. THIS OCCURRED ON 2 OCCASIONS AND THE NEEDLE USUALLY DROPPED TO EMPTY A FEW DAYS AFTER FILLING THE TANK WITH FUEL. THE SERVICE DEALER WAS CONTACTED, AND AN APPOINTMENT WAS SCHEDULED FOR 12/19/06. THE PROBLEM RECURRED ON 12/10/06. THE CONTACT PLANNED TO NOTIFY THE MANUFACTURER AFTER FILING A COMPLAINT WITH THE NHTSA. THE CONTACT ENCOUNTERED SEVERAL COMPLAINTS ABOUT THIS PROBLEM, AND EXPRESSED CONCERN THAT THIS WAS A SAFETY ISSUE THAT SHOULD BE RECALLED. *AK
FUEL LEVEL SENSOR IN GAS TANK FAILED EARLY IN AUTOMOBILE'S LIFE. GAS GAUGE USED TO READ INCORRECTLY, EVENTUALLY NOT REGISTERING ANY GASOLINE AT ALL (ALWAYS ON EMPTY). THIS HAS CAUSED AUTOMOBILE'S "CHECK ENGINE" LIGHT TO ILLUMINATE, THOUGH THERE IS NO TRUE ISSUE WITH THE ENGINE. THIS ISSUE DID NOT LEAD TO ANY INJURIES, THOUGH …
Read full complaint
FUEL LEVEL SENSOR IN GAS TANK FAILED EARLY IN AUTOMOBILE'S LIFE. GAS GAUGE USED TO READ INCORRECTLY, EVENTUALLY NOT REGISTERING ANY GASOLINE AT ALL (ALWAYS ON EMPTY). THIS HAS CAUSED AUTOMOBILE'S "CHECK ENGINE" LIGHT TO ILLUMINATE, THOUGH THERE IS NO TRUE ISSUE WITH THE ENGINE. THIS ISSUE DID NOT LEAD TO ANY INJURIES, THOUGH COULD IF THERE WAS A DRIVER WHO WAS UNAWARE OF THIS PROBLEM (IE, RUNNING OUT OF GAS IN UNPOPULATED AREA, ETC.). I AM AWARE OF A NUMBER OF PEOPLE WHO HAVE COMPLAINED (ONLINE AND VIA PHONE) ABOUT THIS PROBLEM AND DO NOT UNDERSTAND WHY IT HAS NOT BEEN ELEVATED TO RECALL STATUS AS OF YET. *NM
THE ANTILOCK BRAKE SYSTEM INDICATION LIGHT ILLUMINATED AND ANTI-LOCK BRAKES DO NOT FUNCTION. CHECK THE MESSAGE BOARDS ON THE INTERNET AND YOU WILL SEE ALOT OF THESE PROBLEMS WITH THE SAME MAKE AND MODEL VEHICLE. ALSO THE EGR VALVE PROBLEM WHERE THE VEHICLE CLOGS WITH CARBON BUILD UP CAUSING THE CHECK ENGINE LIGHT TO ILLUMINATE I…
Read full complaint
THE ANTILOCK BRAKE SYSTEM INDICATION LIGHT ILLUMINATED AND ANTI-LOCK BRAKES DO NOT FUNCTION. CHECK THE MESSAGE BOARDS ON THE INTERNET AND YOU WILL SEE ALOT OF THESE PROBLEMS WITH THE SAME MAKE AND MODEL VEHICLE. ALSO THE EGR VALVE PROBLEM WHERE THE VEHICLE CLOGS WITH CARBON BUILD UP CAUSING THE CHECK ENGINE LIGHT TO ILLUMINATE INTERMITTENLY AND THE VEHICLE STALLS OUT. THE PROBLEMS HAPPEN TO ENOUGH OF THE SAME MAKE AND MODEL VEHICLES THAT THERE SHOULD BE A RECALL. *NM
GASOLINE GAUGE HAS FAILED. IT INDICATES AN EMPTY TANK EVEN WHEN THE TANK HAS JUST BEEN FILLED. ALSO THE LOW FUEL INDICATOR IS BLINKING. APPARENTLY, THIS HAS OCCURRED WITH NUMEROUS ISUZU RODEOS BUT ISUZU REFUSES TO ACKNOWLEDGE THE PROBLEM. EVEN THOUGH IT OCCURRED MORE THAN A YEAR AGO, I JUST BECAME AWARE OF THIS ON-LINE COMPL…
Read full complaint
GASOLINE GAUGE HAS FAILED. IT INDICATES AN EMPTY TANK EVEN WHEN THE TANK HAS JUST BEEN FILLED. ALSO THE LOW FUEL INDICATOR IS BLINKING. APPARENTLY, THIS HAS OCCURRED WITH NUMEROUS ISUZU RODEOS BUT ISUZU REFUSES TO ACKNOWLEDGE THE PROBLEM. EVEN THOUGH IT OCCURRED MORE THAN A YEAR AGO, I JUST BECAME AWARE OF THIS ON-LINE COMPLAINT PROCEDURE. *JB
1) ABS INDICATOR LIGHT ILLUMINATED 2) NON-WORKING ABS SYSTEM 3) TAKEN TO DEALER WHERE SW UPGRADE PERFORMED. DEALER INDICATED THAT SERVICE WAS FULLY PERFORMED BASED ON SW UPGRADE. DEALER STATED THERE WAS AN ADDITIONAL FAILURE DUE TO CABLE CHAFING AND THAT CABLE ASSEMBLY WOULD NEED TO BE REPLACED TO RESTORE ABS OPERATION. *NM
THE CHECK ENGINE LIGHT REMAINS ON AT ALL TIMES AND THE GAS GAUGE WILL NOT WORK ACCURATELY. *JB
AT ABOUT 55,000 MILES THE GAS GAUGE STOPPED FUNCTIONING PROPERLY AND ACCURATELY. IT IS COMPLETELY UNRELIABLE, AND I HAVE TO RESET THE TRIP METER EACH TIME I FILL THE VEHICLE UP WITH GAS. I THOUGHT IT WAS JUST A FLUKE UNTIL MY WIFE HEARD A WORK COLLEAGUE ON THE TELEPHONE WITH ISUZU COMPLAINING ABOUT THE SAME ISSUE WITH HER RODEO …
Read full complaint
AT ABOUT 55,000 MILES THE GAS GAUGE STOPPED FUNCTIONING PROPERLY AND ACCURATELY. IT IS COMPLETELY UNRELIABLE, AND I HAVE TO RESET THE TRIP METER EACH TIME I FILL THE VEHICLE UP WITH GAS. I THOUGHT IT WAS JUST A FLUKE UNTIL MY WIFE HEARD A WORK COLLEAGUE ON THE TELEPHONE WITH ISUZU COMPLAINING ABOUT THE SAME ISSUE WITH HER RODEO AS WELL (DIFFERENT MODEL YEAR). NOW I SEE IN REVIEWING THIS WEBSITE, THAT THIS IS MORE THAN A COINCIDENCE. IN ADDITION, THE CHECK ENGINE LIGHT IS CONSTANTLY ON AND OFF ON THE VEHICLE. I BELIEVE THAT THIS IS DUE TO THE ISSUE WITH THE GAS GAGE AS WELL. ACCORDING TO MY MECHANIC, IT COSTS ABOUT $500 TO REPAIR THIS PR PROBLEM AS THE LABOR INVOLVED IS QUITE EXTENSIVE. *NM
Official recalls
310V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
00V121001 · Structure:body
Apr 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
00V058000 · Suspension:rear
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available