IllustrationTHIS IS A POORLY DESIGNED SYSTEM WITH NO SAFETY IN MIND BY ISUZU. NLM
1999 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 1999 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3725–50K
6750–75K
2875–100K
59100–150K
43150K+
253 reports with mileage · 297 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 85 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
76 crash reports8 fire reports24 injury reports
Service Brakes, Hydraulic complaints
193 reportsBRAKE SYSTEM HAS FAILED FOUR TIMES IN ONE YEAR. VEHICLE MAKES A SCRAPPING NOISE. *AK
WHILE PULLING INTO CARPORT CONSUMER PRESSED BRAKES AND PEDAL WENT TO THE FLOOR, AND DRIVER HIT A HOUSE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
WHEN DRIVING, AND UPON MAKING A SUDDEN STOP BY DEPRESSING BRAKE PEDAL, BRAKES RESPONDED, AND THEN GO OUT AND WILL NOT RE-ENGAGE UNTILL ALL TIRES ARE ON LEVEL GROUND AND ROTATING TOGETHER THEN THE BRAKES WILL SLOWLY RETURN AND PRESSURE WILL RETURN TO THE BRAKE PEDAL. *JG *AK
DURING ROUTINE INSPECTION, MECHANIC DETERMINED FRONT/REAR ROTORS AND ABS SENSOR HARNESS NEEDED TO BE REPLACED. ROTORS WERE EXTREMELY THIN. NO EXTENDED BRAKING DISTANCE OR VIBRATION REPORTED. *AK DEALER REPLACED FRONT BRAKES AND ANTI-SKID BRAKE SYSTEM HARNESS. *TT
CONSUMER STATES THE BRAKE PEDAL LINKAGE IS SMALL AND TOO CLOSE TO THE GAS PEDAL, THIS CAUSES DRIVERS FOOT TO INADVERTENDLY PRESS THE GAS PEDAL WHEN APPLYING BRAKES, CONSUMER WAS INFORMED THAT THIS COULD NOT BE CHANGED, BECAUSE THAT IS THE DESIGN OF VEHICLE.*AK. CONSUMER STATED THE BRAKE PEDAL IS TOO SMALL FOR AN AUTOMATIC, THE …
Read full complaint
CONSUMER STATES THE BRAKE PEDAL LINKAGE IS SMALL AND TOO CLOSE TO THE GAS PEDAL, THIS CAUSES DRIVERS FOOT TO INADVERTENDLY PRESS THE GAS PEDAL WHEN APPLYING BRAKES, CONSUMER WAS INFORMED THAT THIS COULD NOT BE CHANGED, BECAUSE THAT IS THE DESIGN OF VEHICLE.*AK. CONSUMER STATED THE BRAKE PEDAL IS TOO SMALL FOR AN AUTOMATIC, THE BRAKE PEDAL LINKAGE WAS DESIGNED WRONG AND IS BENT TOWARDS THE GAS PEDAL, THE LINKAGE SHOULD HAVE BEEN DESIGNED STRAIGHT DOWN AND THE PEDAL WELDED ON THE RIGHT SIDE OF THE LINKAGE.*SLC
THIS REQUEST IS BEING SUBMITTED FOLLOWING A FATAL ACCIDENT THAT OCCURRED THIS PAST SUMMER INVOLVING A 1999 RODEO. THE CIRCUMSTANCES SURROUNDING THE ACCIDENT ARE SUSPICIOUS AS THE DRIVER APPEARED TO BE UNABLE TO STOP HIS CAR AND TRAVELED ACROSS AN ENTIRE MEDIAN OF AN INTERSTATE, HIT ANOTHER CAR HEAD-ON AND BURST INTO FLAMES UPON…
Read full complaint
THIS REQUEST IS BEING SUBMITTED FOLLOWING A FATAL ACCIDENT THAT OCCURRED THIS PAST SUMMER INVOLVING A 1999 RODEO. THE CIRCUMSTANCES SURROUNDING THE ACCIDENT ARE SUSPICIOUS AS THE DRIVER APPEARED TO BE UNABLE TO STOP HIS CAR AND TRAVELED ACROSS AN ENTIRE MEDIAN OF AN INTERSTATE, HIT ANOTHER CAR HEAD-ON AND BURST INTO FLAMES UPON IMPACT. THE DRIVER OF THE RODEO WAS MY DAUGHTER'S FATHER AND HIS CAUSE OF DEATH WAS DUE TO THERMAL BURNS. HE WAS TRAPPED IN THE CAR AND BURNED TO DEATH. QUESTIONS: COULD BRAKE FAILURE HAVE CAUSED THIS ACCIDENT? ARE THERE REPORTS OF EXPLOSIONS/FIRES WITH THE ISUZU RODEO? CRASH TESTS? THE DRIVER DID NOT SUSTAIN LIFE THREATENING INJURIES FROM THE IMPACT OF THE CRASH. HE DIED BECAUSE THE VEHICLE EXPLODED INTO FLAMES AND HE WAS TRAPPED IN THE VEHICLE. HAVE THERE BEEN ANOTHER REPORTS FILED WITH YOUR ORGANIZATION WITH THESE CIRCUMSTANCES? PLEASE HELP. *AK
WHEN THERE IS ICE OR SNOW COVERED ON THE ROAD, VEHICLE DOES NOT STOP PROPERLY. BRAKES KEEP RESETTING, AND VEHICLE TAKES A LONG TIME TO COME TO A STOP. CONSUMER HAS CONTACTED DEALER, AND DEALER STATED THAT THIS WAS NORMAL.*AK CONSUMER STATES THIS OCCURS ON BUMPY ROADS TOO AND VEHICLE SKIDS THROUGH INTERSECTIONS UPON NORMAL BRAK…
Read full complaint
WHEN THERE IS ICE OR SNOW COVERED ON THE ROAD, VEHICLE DOES NOT STOP PROPERLY. BRAKES KEEP RESETTING, AND VEHICLE TAKES A LONG TIME TO COME TO A STOP. CONSUMER HAS CONTACTED DEALER, AND DEALER STATED THAT THIS WAS NORMAL.*AK CONSUMER STATES THIS OCCURS ON BUMPY ROADS TOO AND VEHICLE SKIDS THROUGH INTERSECTIONS UPON NORMAL BRAKING, DEALER HAS BLEED THE BRAKES. AT TIMES THE BRAKE LIGHT AND ALTERNATOR LIGHT WILL ILLUMINATE, DEALER FOUND THAT THE ALTERNATOR WAS NOT CHARGING, DEALER REPLACED ALTERNATOR ASSEMBLY. *SLC
MY SON WAS DRIVING MY 1999 ISUZU RODEO HOME FROM SCHOOL. HE WAS AT A RED LIGHT, STOPPED TO TAKE A RIGHT TURN AND CAR ACCELERATED ON ITS OWN WENT OUT OF CONTROL. HE TRIED TO GET IT UNDER CONTROL BUT IT WOULDN'T STOP; IT JUST KEPT GOING, HE WENT ONTO THE OTHER LANE AND COLLIDED WITH ANOTHER DRIVER HEAD ON. FORTUNATELY, NOBODY …
Read full complaint
MY SON WAS DRIVING MY 1999 ISUZU RODEO HOME FROM SCHOOL. HE WAS AT A RED LIGHT, STOPPED TO TAKE A RIGHT TURN AND CAR ACCELERATED ON ITS OWN WENT OUT OF CONTROL. HE TRIED TO GET IT UNDER CONTROL BUT IT WOULDN'T STOP; IT JUST KEPT GOING, HE WENT ONTO THE OTHER LANE AND COLLIDED WITH ANOTHER DRIVER HEAD ON. FORTUNATELY, NOBODY WAS HURT. THIS IS THE 3RD TIME THE CAR HAS REVVED UP AND WENT ON ITS OWN. THE FIRST TIME IT HAPPENED TO ME I THOUGHT IT WAS BECAUSE IT WASN'T WARMED UP BUT IT HAS HAPPENED 3 TIMES. I CALLED ISUZU AND THEY SAID THEY NEVER HEARD OF ANY COMPLAINT LIKE THIS ALTHOUGH I HAVE SPOKEN WITH OTHER PEOPLE WHO HAVE THESE CARS AND THEY SAID THE SAME THINK HAPPENED TO THEM. I HAVE REPORTED IT TO THE INSURANCE COMPANY. I ALSO CALLED ANOTHER ISUZU DEALER AND HE SAID HE HAS HEARD OF THIS HAPPENING, I THINK THIS REALLY NEEDS TO BE ADDRESSED.*AK
THE ACCIDENT OCCURRED ON THE FREEWAY, IN HEAVY TRAFFIC. I SLAMMED MY BRAKES ON, AND I HEARD (AND FELT) THE BRAKES LOCK-UP, AND THEN RELEASE (THIS FELT LIKE I WAS SURGING FORWARD). IT WAS WHEN THE BRAKES RELEASED THAT I HIT THE CAR IN FRONT OF ME.*AK
Official recalls
310V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
00V121001 · Structure:body
Apr 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
00V058000 · Suspension:rear
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available