NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
50 reportsClear category filter105,000 miles · Jun 1, 2009
Electronic Stability Control (esc)Engine And Engine CoolingFuel System, Gasoline
AFTER ONLY HAVING MY RODEO FOR A FEW MONTHS MY ABS WENT BAD BUT IT WAS REPLACED BY THE DEALER UNDER WARRANTY. THEN SHORTLY AFTER THAT THE WARRANTY ENDED AND GAS GAUGE WOULD READ EMPTY BUT IT WAS FULL, NEXT I HAVE TO ADD OIL TO MY CAR EVERY TWO TO THREE DAYS BECAUSE IT BURNS OIL REALLY BAD NO LEAKAGE OR NOTHING LIKE THAT. NOW I H…
Read full complaint
AFTER ONLY HAVING MY RODEO FOR A FEW MONTHS MY ABS WENT BAD BUT IT WAS REPLACED BY THE DEALER UNDER WARRANTY. THEN SHORTLY AFTER THAT THE WARRANTY ENDED AND GAS GAUGE WOULD READ EMPTY BUT IT WAS FULL, NEXT I HAVE TO ADD OIL TO MY CAR EVERY TWO TO THREE DAYS BECAUSE IT BURNS OIL REALLY BAD NO LEAKAGE OR NOTHING LIKE THAT. NOW I HAVE STARTED ADDING ANTI-FREEZE THE SAME AMOUNT OF TIME. THERE ARE MAJOR TRANMISSION PROBLEMS WITH THIS CAR AND FROM READING THE INTERNET IT'S NOT JUST MY CAR IT'S ISUZU. *TR
NHTSA ODI #10272550
64,000 miles · Jul 11, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1999 ISUZU RODEO. WHILE DRIVING 30 MPH, THE CONTACT HEARD A NOISE COMING FROM THE ENGINE. THE VEHICLE THEN SHUT OFF WITHOUT WARNING. THE MECHANIC STATED THAT THE TIMING BELT WAS DEFECTIVE. THE DEALER STATED THAT THE VEHICLE WAS EXCLUDED FROM RECALL # 01I002000 (ENGINE AND ENGINE COOLING:ENGINE). THE CO…
Read full complaint
TL*THE CONTACT OWNS A 1999 ISUZU RODEO. WHILE DRIVING 30 MPH, THE CONTACT HEARD A NOISE COMING FROM THE ENGINE. THE VEHICLE THEN SHUT OFF WITHOUT WARNING. THE MECHANIC STATED THAT THE TIMING BELT WAS DEFECTIVE. THE DEALER STATED THAT THE VEHICLE WAS EXCLUDED FROM RECALL # 01I002000 (ENGINE AND ENGINE COOLING:ENGINE). THE CONTACT FELT THAT HIS VEHICLE SHOULD BE INCLUDED. THE CURRENT AND FAILURE MILEAGES WERE 64,000.
NHTSA ODI #10196124
110,000 miles · Oct 24, 2006
Engine And Engine CoolingService Brakes, Hydraulic
THE ANTILOCK BRAKE SYSTEM INDICATION LIGHT ILLUMINATED AND ANTI-LOCK BRAKES DO NOT FUNCTION. CHECK THE MESSAGE BOARDS ON THE INTERNET AND YOU WILL SEE ALOT OF THESE PROBLEMS WITH THE SAME MAKE AND MODEL VEHICLE. ALSO THE EGR VALVE PROBLEM WHERE THE VEHICLE CLOGS WITH CARBON BUILD UP CAUSING THE CHECK ENGINE LIGHT TO ILLUMINATE I…
Read full complaint
THE ANTILOCK BRAKE SYSTEM INDICATION LIGHT ILLUMINATED AND ANTI-LOCK BRAKES DO NOT FUNCTION. CHECK THE MESSAGE BOARDS ON THE INTERNET AND YOU WILL SEE ALOT OF THESE PROBLEMS WITH THE SAME MAKE AND MODEL VEHICLE. ALSO THE EGR VALVE PROBLEM WHERE THE VEHICLE CLOGS WITH CARBON BUILD UP CAUSING THE CHECK ENGINE LIGHT TO ILLUMINATE INTERMITTENLY AND THE VEHICLE STALLS OUT. THE PROBLEMS HAPPEN TO ENOUGH OF THE SAME MAKE AND MODEL VEHICLES THAT THERE SHOULD BE A RECALL. *NM
NHTSA ODI #10171716
Mileage unknown · Jan 11, 2006
Engine And Engine Cooling
ON MY 1999 RODEO THE OIL DISAPPEARS IT WILL GO FOR LITTLE WHILE THEN NO OIL REGISTER ON STICK IT IS NOT BURNING OIL AND CAN'T FIND ANY LEAKS. I KNOW THIS IS PROBLEM IN MANY OF THESE . IT ALSO SEEMS AT TIMES THAT SOMETHING IS DRAGGING IN THE ENGINE AREA LIKE FAN OR SOMETHING. *JB
NHTSA ODI #10147406
Mileage unknown · Dec 12, 2005
Engine And Engine Cooling
JAN 2004, I STARTED MY VEHICLE AND DROVE ABOUT 500 FT WHEN THE VEHICLE STARTED TO OPERATE ROUGH. I TURNED AROUND TO GO BACK THE PARKING LOT AND WHITE SMOKE (STEAM I BELIEVE) WAS COMING FROM THE EXHAUST PIPE. THE ISUZU DEALER SHIP TOLD THE WARRANTY COMPANY THAT I HAD BEEN OPERATING THE VEHICLE OVERHEATED AND THAT THE ONLY THING T…
Read full complaint
JAN 2004, I STARTED MY VEHICLE AND DROVE ABOUT 500 FT WHEN THE VEHICLE STARTED TO OPERATE ROUGH. I TURNED AROUND TO GO BACK THE PARKING LOT AND WHITE SMOKE (STEAM I BELIEVE) WAS COMING FROM THE EXHAUST PIPE. THE ISUZU DEALER SHIP TOLD THE WARRANTY COMPANY THAT I HAD BEEN OPERATING THE VEHICLE OVERHEATED AND THAT THE ONLY THING TO DO WAS TO REPLACE THE ENTIRE ENGINE. THE TEMP GAUGE HAS NEVER READ ABOVE MEDIAN RANGE. I HAD THE HEAD GASKET AND THERMOSTAT REPLACED BY MY LOCAL MECHANIC AND HE SAID THERE WAS NO REASON TO REPLACE THE ENGINE JUST THE GASKETS. NOW, I WAS SETTING IN TRAFFIC 11/2005 AND THE SAME THING STARTED HAPPENING. WHAT IS THE ISSUE WITH THE HEAD GASKET? ARE THEY DEFECTIVE? *JB
NHTSA ODI #10144958
Mileage unknown · Aug 22, 2005
Engine And Engine Cooling
EXTREMELY EXCESSIVE OIL CONSUMPTION ON ISUZU RODEO 1999 MODEL. HAD THE SAME PROBLEM WITH ISUZU RODEO 2000 MODEL. FORTUNATELY I DONT HAVE TO DEAL WITH THE 2000 MODEL ANY MORE AS IT HAS BEEN TOTALED BYT MY INSURANCE COMPANY DUE TO IMPROPER REPAIR AFTER A COLLISION IN MARCH OF 2005. I DID NOT KNOW THAT THE 1999 ISUZU RODEO HAD THE …
Read full complaint
EXTREMELY EXCESSIVE OIL CONSUMPTION ON ISUZU RODEO 1999 MODEL. HAD THE SAME PROBLEM WITH ISUZU RODEO 2000 MODEL. FORTUNATELY I DONT HAVE TO DEAL WITH THE 2000 MODEL ANY MORE AS IT HAS BEEN TOTALED BYT MY INSURANCE COMPANY DUE TO IMPROPER REPAIR AFTER A COLLISION IN MARCH OF 2005. I DID NOT KNOW THAT THE 1999 ISUZU RODEO HAD THE SAME PROBLEM UNTIL MY SON WHO DROVE THE SUV BROUGHT IT BACK TO ME TWO WEEKS AGO, AS HE IS IN THE MILITARY AND IS DEPLOYING TO IRAQ. IT SEEMS THAT THE VEHICLE SPENT MORE TIME AT THE DEALERSHIP GETTING REPAIRED THAN BEING ON THE ROAD. MY SON ASKED ME TO GET RID OF IT AS HE IS TIRED DEALING WITH ALL THE PROBLEMS THIS CAR HAD. UPON HIS ARRIVAL I NOTICED THE CAR LOW ON OIL AND I ADDED TWO QUARTS. MY SON INFORMED ME THAT HE HAD JUST CHANGED OIL PRIOR LEAVING GRAND FORKS AFB IN ND AND DRIVING TO NORMAN, OK. AFTER DRIVING FOR 5 DAYS I CHECKED OIL LEVEL AND IT WAS AGAIN TWO QUARTS LOW, AFTER ONLY DRIVING 300 MILES. I THEN DECIDED TO INQUIRE ON THE WEB FOR SIMILAR INCIDENTS, AND I COULD NOT BELIEVE THE QUANTITY OF PEOPLE WITH THE SAME PROBLEM WITH THEIR ISUZUS. IN ADDITION, ONE OF MY CO-WORKERS ISUZU TROOPER ENGINE WAS DAMAGED DUE TO THE SAME PROBLEM IN 2004. I FOUND THIS SITE TROUGH SEARCHING THE INTERNET FOR SIMILAR ISSUES. IN ADDITION I CALLED THE DEALERSHIP WHERE I PURCHASED MY 2000 ISUZU AND HAVE BEEN INFORMED THAT ISUZU IS AWARE OF THE ISSUE BUT NO BULETIN OR RECALL HAS BEEN ISSUED, AND THAT IT IS NOT CONSIDERED A PROBLEM AT THIS TIME. I KEEP MY CARS WELL MAINTAINED, AND CHECK MY PCV AND EGR VALVES ON A REGULAR BASIS. I PERFORM MOST OF MY CAR MAINTENANCE MYSELF AND USE THE BEST PORDUCTS ON THE MARKET. WITH SO MANY OF US AFFECTED WITH THE SAME CONDITION ON OUR ISUZU'S IS ISUZU/GM GOING TO BE HELD ACCOUNTABLE FOR A BAD PRODUCT THEY KNOW THEY HAVE, OR ARE WE AS CONSUMERS HAVING TO PAY THE BILL FOR THEIR INFERIOR ENGINES INSTALLED IN THESE SUV'S. AVERY DISSATISFIED AND FRUSTRATED AND NEVER TO BE AGAIN ISUZU OWNER. JR
NHTSA ODI #10133693
66,000 miles · Oct 30, 2004
Engine And Engine Cooling
COMING BACK FROM OHIO, THE OIL LIGHT BRIEFLY WENT ON. THERE WAS NO INDICATION WHATSOEVER ASIDE FROM THE OIL LIGHT COMING ON FOR A FEW SECONDS THAT A BIG PROBLEM COMING UP. A FEW MINUTES LATER THE ENGINE WAS MAKING A KNOCKING SOUND. WE TRY TO DRIVE IT TO A NEAREST GAS STATION TO GET IT CHECK OUT. UNFORTUNATELY IT WAS SUNDAY AN…
Read full complaint
COMING BACK FROM OHIO, THE OIL LIGHT BRIEFLY WENT ON. THERE WAS NO INDICATION WHATSOEVER ASIDE FROM THE OIL LIGHT COMING ON FOR A FEW SECONDS THAT A BIG PROBLEM COMING UP. A FEW MINUTES LATER THE ENGINE WAS MAKING A KNOCKING SOUND. WE TRY TO DRIVE IT TO A NEAREST GAS STATION TO GET IT CHECK OUT. UNFORTUNATELY IT WAS SUNDAY AND NO MECHANIC WAS AVAILABLE. WE OIL CHANGE OUR VEHICLE EVERY 3-4K MILES SO WE HAVE NO REASON TO BELIEVE THAT IT WOULD BE AN OIL PROBLEM. WE TRIED TO DRIVE IT BUT THE ENGINE JUST DIED ON US. THE CAR ONLY HAVE 66K MILES ON IT AND NOW THE CAR IS WORTHLESS.*JB
NHTSA ODI #10098018
Mileage unknown · Oct 20, 2004
Engine And Engine Cooling
WHILE DRIVING, THE VEHICLE STARTED RIDING ROUGHLY AND HESITATED WHILE ACCELERATING. THE DRIVER WAS ABLE TO DRIVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE HEAD GASKET WAS CRACKED. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10097248
82,000 miles · Oct 19, 2004
Engine And Engine Cooling
INTAKE MANIFOLD GASKET, KNOW OF SEVERAL IZUZU RODEOS AND HONDA PASSPORTS THAT NEEDED THESE REPLACED!*AK
NHTSA ODI #10096004
65,000 miles · Mar 26, 2004
Engine And Engine CoolingFuel System, OtherVisibility
THE GAS GAUGE DOES NOT WORK ANY MORE AND THE REAR WIPER ALSO STOPPED WORKING. BOTH SEEM TO BE COMMON PROBLEMS WITH THE 1999 ISUZU RODEO LS. *AK
NHTSA ODI #10063931
Official recalls
3Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Apr 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
Illustration