Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1025–50K
2650–75K
2975–100K
51100–150K
24150K+
148 reports with mileage · 330 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 211 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
81 crash reports2 fire reports24 injury reports
What owners actually said
478 reports
160,000 miles · Dec 27, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT WAS DRIVING 40 MPH WHEN THE REAR OF THE VEHICLE SUDDENLY BEGAN TO ABRUPTLY SWAY TO THE RIGHT. THE CONTACT MERGED THE VEHICLE TO THE SHOULDER AND CALLED A TOW TRUCK. THE VEHICLE WAS TOWED TO THE DEALER WHO INSPECTED THE FAILURE AND ADVISED THE CONTACT THAT THE BRACKETS FROM THE…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT WAS DRIVING 40 MPH WHEN THE REAR OF THE VEHICLE SUDDENLY BEGAN TO ABRUPTLY SWAY TO THE RIGHT. THE CONTACT MERGED THE VEHICLE TO THE SHOULDER AND CALLED A TOW TRUCK. THE VEHICLE WAS TOWED TO THE DEALER WHO INSPECTED THE FAILURE AND ADVISED THE CONTACT THAT THE BRACKETS FROM THE FRAME WERE FRACTURED AND ALSO CAUSED A HOLE IN THE FUEL TANK. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION: REAR) AND WAS ADVISED BY THE DEALER THAT THE REAR SUSPENSION COULD BE REPAIRED UNDER THE RECALL BUT NOT THE HOLE IN THE FUEL TANK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO CONFIRMED TO THE CONTACT THAT THE RECALL REPAIR WOULD NOT COVER THE DAMAGE OF THE FUEL TANK. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10441328
126,000 miles · Dec 7, 2011
StructureSuspension
WAS DRIVING THE VEHICLE AT 30 MPH WHEN A POP IN THE BACK WAS HEARD AND ALL STEERING CONTROL WAS LOST. WHEN I LOOKED UNDER THE VEHICLE, THE BRACKET THAT HOLDS THE REAR AXLE (LEFT SIDE) HAD BROKEN OFF. FRAME IS GROSSLY RUSTED. WHEN ISUZU WAS CALLED REGARDING THE CURRENT RECALL, WAS TOLD THAT THE NEAREST SERVICE CENTER WAS OVER …
Read full complaint
WAS DRIVING THE VEHICLE AT 30 MPH WHEN A POP IN THE BACK WAS HEARD AND ALL STEERING CONTROL WAS LOST. WHEN I LOOKED UNDER THE VEHICLE, THE BRACKET THAT HOLDS THE REAR AXLE (LEFT SIDE) HAD BROKEN OFF. FRAME IS GROSSLY RUSTED. WHEN ISUZU WAS CALLED REGARDING THE CURRENT RECALL, WAS TOLD THAT THE NEAREST SERVICE CENTER WAS OVER 3 HOURS AWAY. I AM CURRENTLY IN THE PROCESS OF GETTING THE VEHICLE TO THE SERVICE CENTER, BUT DUE TO DISTANCE THIS IS AN ISSUE. *TR
NHTSA ODI #10438838
100,000 miles · Nov 19, 2011
Structure
FRAME BASICALLY FELL APART DUE TO SEVERE RUST, WAS GOING 40 MPH AT THE TIME AND THE VEHICLE SWIRVED OUT OF CONTROL INTO THE ONCOMING LANE, LUCKILY FOR ME THERE WASN'T ANYONE USING THE OTHER LANE. *TR
NHTSA ODI #10436469
61,000 miles · Sep 6, 2011
Structure
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT WHILE HAVING REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR), SHE WAS NOTIFIED THAT THE VEHICLE FRAME WAS COMPLETELY CORRODED. THE DEALER STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE SINCE THE CORROSION DAMAGE WAS EXTENSIVE. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT WHILE HAVING REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR), SHE WAS NOTIFIED THAT THE VEHICLE FRAME WAS COMPLETELY CORRODED. THE DEALER STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE SINCE THE CORROSION DAMAGE WAS EXTENSIVE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 61,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10423987
149,000 miles · Aug 29, 2011
StructureSuspension
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT TOOK HIS VEHICLE TO A PRIVATE MECHANIC FOR ROUTINE MAINTENANCE AND WAS INFORMED THE ENTIRE REAR FRAME WAS COVERED WITH RUST. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 155,00…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT TOOK HIS VEHICLE TO A PRIVATE MECHANIC FOR ROUTINE MAINTENANCE AND WAS INFORMED THE ENTIRE REAR FRAME WAS COVERED WITH RUST. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 155,000. THE APPROXIMATE FAILURE MILEAGE WAS 149,000. .. UPDATED 09/21/11 *BF UPDATED 09/30/11.*JB
NHTSA ODI #10422396
Mileage unknown · Aug 11, 2011
Suspension
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE REAR BUMPER WAS HANGING DOWN ON THE PASSENGER SIDE DUE TO RUST AND CORROSION. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V436000 (SUSPENSION: REAR). T…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE REAR BUMPER WAS HANGING DOWN ON THE PASSENGER SIDE DUE TO RUST AND CORROSION. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V436000 (SUSPENSION: REAR). THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 153,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10418510
125,000 miles · Jul 19, 2011
Structure
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 00V058000 (SUSPENSION: REAR). THE DEALER STATED THAT THE BOLTS AND NUTS FOR THE REAR AXLE COULD NOT BE REPLACED BECAUSE THE SUBFRAME WAS SEVERELY CORRODED AND THE VEHICLE WO…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 00V058000 (SUSPENSION: REAR). THE DEALER STATED THAT THE BOLTS AND NUTS FOR THE REAR AXLE COULD NOT BE REPLACED BECAUSE THE SUBFRAME WAS SEVERELY CORRODED AND THE VEHICLE WOULD BE UNSAFE TO DRIVE. THE FAILURE AND CURRENT MILEAGES WERE 125,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10413589
168,000 miles · Jun 22, 2011
Electrical SystemFuel System, Gasoline
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT NOTICED FUEL WAS LEAKING FROM THE VEHICLE AND WHILE DRIVING THE FUMES ENTERED THE VEHICLE. THE FUEL GAUGE WAS INOPERABLE AND SHE WAS UNABLE TO DETERMINE HOW MUCH GASOLINE WAS IN THE VEHICLE. THE DEALER NOR MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS TAKEN TO A PRIVATE ME…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT NOTICED FUEL WAS LEAKING FROM THE VEHICLE AND WHILE DRIVING THE FUMES ENTERED THE VEHICLE. THE FUEL GAUGE WAS INOPERABLE AND SHE WAS UNABLE TO DETERMINE HOW MUCH GASOLINE WAS IN THE VEHICLE. THE DEALER NOR MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INSPECTED THE VEHICLE AND CONFIRMED THAT THERE WAS A HOLE IN THE TOP OF THE FUEL TANK AND THE FUEL GAUGE WAS FAULTY. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 168,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10408480
142,000 miles · May 17, 2011
Structure
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT HE HEARD A BANGING SOUND AND NOTICED THAT THE REAR BUMPER WAS LOOSE. HE FURTHER INSPECTED AND SAW THAT THE ENTIRE FRAME WAS RUSTED. THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER:10V436000 (SUSPENSION:REAR) BY A PREVIOUS OWNER. THE C…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT HE HEARD A BANGING SOUND AND NOTICED THAT THE REAR BUMPER WAS LOOSE. HE FURTHER INSPECTED AND SAW THAT THE ENTIRE FRAME WAS RUSTED. THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER:10V436000 (SUSPENSION:REAR) BY A PREVIOUS OWNER. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE RECALL HAD BEEN PERFORMED AND DID NOT COVER THAT PART OF THE FRAME. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 142,000.
NHTSA ODI #10401281
13,770 miles · May 9, 2011
Structure
1998 ISUZU RODEO FRAME IS RUSTED/ROTTED BEYOND REPAIR. MECHANIC HAS ADVISED VEHICLE IS NOT SAFE TO DRIVE & FRAME COULD COLLAPSE AT ANY TIME. I HAD THE RECALL 10V-436 DONE BUT FRAME FAILURE IS NOT COVERED. FRAME HAS MULTIPLE HOLES IN IT INCLUDING ONE THAT A FIST CAN FIT THROUGH. *TR
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
1998 Isuzu Rodeo Problems, Complaints & Recalls | Skip That Year
Illustration