NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
478 reportsMileage unknown · Mar 15, 2004
Service Brakes, Hydraulic
CONSUMER STATED THAT SHE RECEIVED A RECALL NOTE ON ABS BRAKE FAILURE IN OCTOBER 2003, AND EACH TIME SHE CALLED THE ISUZU DEALER THEY TELL HER THEY STILL DID NOT HAVE THE PARTS. DEALER PROMISED THAT THEY WILL CALL HER BACK ONCE PARTS ARRIVED, BUT THEY NEVER DID SO. CONSUMER DID NOT REMEMBER NAME, ADDRESS OR TELEPHONE N…
Read full complaint
CONSUMER STATED THAT SHE RECEIVED A RECALL NOTE ON ABS BRAKE FAILURE IN OCTOBER 2003, AND EACH TIME SHE CALLED THE ISUZU DEALER THEY TELL HER THEY STILL DID NOT HAVE THE PARTS. DEALER PROMISED THAT THEY WILL CALL HER BACK ONCE PARTS ARRIVED, BUT THEY NEVER DID SO. CONSUMER DID NOT REMEMBER NAME, ADDRESS OR TELEPHONE NUMBER OF THIS PARTICULAR DEALER. CONSUMER INDICATED THAT SHE DID NOT HAVE ANY BRAKE PROBLEM, BUT DID WANT THE RECALL TAKEN CARE OFF. *AK
NHTSA ODI #10063230
Mileage unknown · Mar 11, 2004
Wheels
THE ORIGINAL AND THE REPLACEMENT TIRES DEVELOPED CRACKS IN THE SIDEWALL AT LOW MILEAGE. ALSO, VEHICLE EXPERIENCED STRIPPING OF THE LUG, NUTS AND STUDS UPON TIRE REPLACEMENT.*AK
NHTSA ODI #10063024
90,000 miles · Mar 7, 2004
EquipmentFuel System, Gasoline
FUEL SENDING UNIT IS OPERATING ERRATICALLY. HAD IT REPLACED AFTER RECEIVING WHAT I THOUGHT WAS A RECALL FROM THE MANUFACTURER, ONLY TO BE TOLD BY ISUZU REP THAT IT WAS ONLY A RECOMMENDATION THE TIME OF THE REPLACEMENT THE FUEL GAUGE WAS READING CORRECTLY. I HAVE PERSONALLY TALKED TO SEVERAL REPAIR PLACES AND SOME FRIENDS WHO HAV…
Read full complaint
FUEL SENDING UNIT IS OPERATING ERRATICALLY. HAD IT REPLACED AFTER RECEIVING WHAT I THOUGHT WAS A RECALL FROM THE MANUFACTURER, ONLY TO BE TOLD BY ISUZU REP THAT IT WAS ONLY A RECOMMENDATION THE TIME OF THE REPLACEMENT THE FUEL GAUGE WAS READING CORRECTLY. I HAVE PERSONALLY TALKED TO SEVERAL REPAIR PLACES AND SOME FRIENDS WHO HAVE HAD THE SAME PROBLEM WITH THE ISUZU RODEO/HONDA PASSPORT. THIS SEEMS TO TELL ME THAT THIS IS A COMMON PROBLEM WITH THESE VEHICLES. I WOULD GREATLY APPRECIATE ANY HELP OR FEEDBACK YOU CAN GIVE ME ON THIS PROBLEM SINCE THE REPAIR COST IS NEAR $600.00, AND THE SENDING UNIT IS ONLY AVAILABLE THROUGH ISUZU DEALER SERVICE CENTERS. *JB
NHTSA ODI #10060638
Mileage unknown · Mar 3, 2004
Engine And Engine CoolingEquipment
OWN A 1998 RODEO WITH APPROX 98,000 MILES. I KNOW IT'S HIGH MILEAGE AND OLDER MODEL, BUT HAVE ESSENTIALLY REBUILT ENGINE OVER PAST YEAR. NEW ALTINATER, STARTER, REPLACE PART OF EXHAUST, ALL BELTS, IDLER PULLEY JUST TO NAME A FEW. ISUZU DEALER WANTED $900 TO FIX ABS SYSTEM, BUT TWO RECALLS SEEM TO HAVE ALLEVIATED PROBLEM. A/C IS…
Read full complaint
OWN A 1998 RODEO WITH APPROX 98,000 MILES. I KNOW IT'S HIGH MILEAGE AND OLDER MODEL, BUT HAVE ESSENTIALLY REBUILT ENGINE OVER PAST YEAR. NEW ALTINATER, STARTER, REPLACE PART OF EXHAUST, ALL BELTS, IDLER PULLEY JUST TO NAME A FEW. ISUZU DEALER WANTED $900 TO FIX ABS SYSTEM, BUT TWO RECALLS SEEM TO HAVE ALLEVIATED PROBLEM. A/C IS BROKEN AND THEY WANT $1000 TO FIX. SEEMS A CAR W/NO ACCIDENT HISTORY SHOULD HAVE ENITIRE A/C DEFECTIVE/BROKEN NOT JUST A COMPRESSOR OR FAN OR SOMETHING.. MOVED ON TO DIFFERENT DEALER IN AREA AND THEY SEEM TO BE BETTER TO DEAL W/, BUT THIS CAR HAS BEEN METICULOUSLY MAINTAINED IN THE 2 YRS I'VE OWNED IT YET I AM CONSTANTLY FIXING THE CAR. WHY IS THIS CAR FALLING APART...MAYBE THEY SHOULD MAKE THEM CHEAPER IF THEY ARE GOING TO BE SO DISPOSABLE. *AK
NHTSA ODI #10060239
Mileage unknown · Feb 24, 2004
Service Brakes, Hydraulic
CONSUMER RECEIVED A RECALL LETTER CONCERNING ABS BRAKE SYSTEM FAILURE ON OCTOBER 2003. DEALER AND MANUFACTURER WERE COOPERATIVE AND INDICATED THERE WERE NO PARTS AVAILABLE. *AK THERE WAS NO EXPECTED DATE OF AVAILABILITY FOR THE PARTS. *SC
NHTSA ODI #10053378
65,000 miles · Feb 3, 2004
Service Brakes, Hydraulic
RECALL 021002000 CONCERNING ABS/COIL MODULE REPLACEMENT: WHILE DRIVING AT 25 MPH, CONSUMER CAME UPON A STOP LIGHT AND APPLIED THE BRAKES. VEHICLE DID NOT STOP UNTIL IT WAS ACROSS THE INTERSECTION. THE CONSUMER WAS STILL HAVING THE PROBLEMS STEMMING FROM THE ABS BRAKES THAT WERE SUPPOSED TO BE REPAIRED THROUGH THE RECALL. *…
Read full complaint
RECALL 021002000 CONCERNING ABS/COIL MODULE REPLACEMENT: WHILE DRIVING AT 25 MPH, CONSUMER CAME UPON A STOP LIGHT AND APPLIED THE BRAKES. VEHICLE DID NOT STOP UNTIL IT WAS ACROSS THE INTERSECTION. THE CONSUMER WAS STILL HAVING THE PROBLEMS STEMMING FROM THE ABS BRAKES THAT WERE SUPPOSED TO BE REPAIRED THROUGH THE RECALL. *AK
NHTSA ODI #10057463
60,517 miles · Jan 21, 2004
Service Brakes, Hydraulic
AFTER HAVING ABS RECALL 02I002000 REPAIRS DONE VEHICLE EXPERIENCED BRAKE FAILURE, RESULTING IN EXTENDED STOPPING DISTANCE. THIS ONLY OCCURRED WHILE DRIVING ON SNOW OR WET SURFACES.*AK
NHTSA ODI #10055492
Mileage unknown · Jan 13, 2004
Service Brakes, Hydraulic
RECALL 02I002000 CONCERNING ABS BRAKE FAILURE. CONSUMER CONTACTED THE DEALER IN OCTOBER 2003 FOR RECALL REPAIRS. DEALER INDICATED TO CONSUMER THAT THE PARTS WERE NOT AVAILABLE. CONSUMER RECENTLY CONTACTED THE DEALER AGAIN, AND DEALER STATED THE PARTS WERE ON NATIONAL BACK ORDER.*AK
NHTSA ODI #10053973
5 miles · Jan 13, 2004
Service Brakes, HydraulicCrash
WHILE GOING LESS THAN 5 MILES PER HOUR I HAD TO APPLY MY BRAKES SUDDENLY. THE BRAKES LOCKED UP AND THE CAR WOULD NOT STOP CAUSING A CRASH INTO ANOTHER VEHICLE.
NHTSA ODI #10053085
65,000 miles · Jan 12, 2004
Service Brakes, HydraulicCrashInjury
WHILE DRIVING 30 MPH, THE DRIVER APPLIED THE BRAKES, BECAUSE THE MOTORIST IN FRONT OF HER SLAMMED ON THE BRAKES AND WHEN THE CONSUMER ATTEMPTED TO APPLY THE BRAKES, THE BRAKE PEDAL WENT DOWN TO THE FLOOR WHICH CAUSED A COLLISION. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER AND THE MECHANIC NOTICED THAT THE ROTORS AND OTHER…
Read full complaint
WHILE DRIVING 30 MPH, THE DRIVER APPLIED THE BRAKES, BECAUSE THE MOTORIST IN FRONT OF HER SLAMMED ON THE BRAKES AND WHEN THE CONSUMER ATTEMPTED TO APPLY THE BRAKES, THE BRAKE PEDAL WENT DOWN TO THE FLOOR WHICH CAUSED A COLLISION. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER AND THE MECHANIC NOTICED THAT THE ROTORS AND OTHER BRAKE PARTS NEEDED REPLACEMENT.*AK *CB *JB
NHTSA ODI #10046737
Official recalls
4Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration