Illustration1998 ISUZU RODEO, 76,000 MILES. WILL NOT PASS INSPECTION, FRAME TOTALLY RUSTED OUT, WAS TOLD IT CANNOT BE REPAIRED. *TR
1998 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 1998 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1025–50K
2650–75K
2975–100K
51100–150K
24150K+
148 reports with mileage · 330 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 211 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
81 crash reports2 fire reports24 injury reports
Structure complaints
69 reportsRUST ON FRAME OF 1998 ISUZU RODEO. *TR
WHILE DRIVING HOME,1998 ISUZU RODEO DRIVERS SIDE REAR WHEEL STABILIZER BROKE AWAY FROM FRAME DUE TO RUST. UNABLE TO CONTINUE DRIVING. VEHICLE TOWED HOME. *TR
I HAVE A 1998 ISUZU RODEO JEEP. A WHILE BACK I HAD A PIECE OF THE FRAME REPAIRED/WELDED, AS IT BROKE AND THE VEHICLE WAS UNSTABLE. I SPENT OVER $500 IN REPAIR COSTS TO BRING THE VEHICLE TO DRIVING STATUS AGAIN. TO THIS DAY I STILL WONDER IF IT IS GOOD ENOUGH TO DRIVE, AS THERE IS RUST ALL ON THE UNDER FRAME OF THE CAR. I HAVE PU…
Read full complaint
I HAVE A 1998 ISUZU RODEO JEEP. A WHILE BACK I HAD A PIECE OF THE FRAME REPAIRED/WELDED, AS IT BROKE AND THE VEHICLE WAS UNSTABLE. I SPENT OVER $500 IN REPAIR COSTS TO BRING THE VEHICLE TO DRIVING STATUS AGAIN. TO THIS DAY I STILL WONDER IF IT IS GOOD ENOUGH TO DRIVE, AS THERE IS RUST ALL ON THE UNDER FRAME OF THE CAR. I HAVE PUT SO MUCH TIME, AND MONEY INTO THIS VEHICLE, AND I CANT AFFORD TO JUST GET RID OF THE CAR AND GET A NEW ONE. I HAVE ONCE THOUGHT THAT MAYBE THE CAR HAD JUST SAT IN WATER BEFORE I PURCHASED IT, BUT DUE TO THE OTHER STORIES I HAVE READ ON THIS VEHICLE, I KNOW NOW THAT IT IS NOT THE CASE. MANY PEOPLE HAVE EXPERIENCED THE SAME ISSUES WITH THE FRAME RUST AS I HAVE. I HAVE TWO YOUNG CHILDREN THAT RIDE IN THIS VEHICLE AS WELL, AND I AM CONCERNED FOR THERE SAFETY AS I HEAR THAT THE CONDITION OF THE VEHICLE CAN DETERIORATE OVER TIME. I THINK SOMETHING SHOULD BE DONE ABOUT THIS NOW BEFORE IT GETS ANY WORSE. I AM NOT SURE WHAT THE DEALER IS WAITING FOR, MAYBE A CATASTROPHE, BEFORE THEY DO SOMETHING ABOUT THIS. PLEASE LOOK INTO THIS MATTER AS SOON AS POSSIBLE BEFORE THINGS GET OUT OF HAND. *TR
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. WHILE DRIVING AT SPEEDS OF 55 MPH, THE LATERAL SUPPORT BRACKET CORRODED AND FRACTURED FROM THE VEHICLE. THE REAR OF THE VEHICLE BEGAN TO SWAY BACK AND FORTH AND THE CONTACT WAS ABLE TO MAINTAIN LIMITED CONTROL OF THE VEHICLE. THE VEHICLE WAS TOWED TO A WELDING SPECIALIST WHERE A NEW BRACK…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. WHILE DRIVING AT SPEEDS OF 55 MPH, THE LATERAL SUPPORT BRACKET CORRODED AND FRACTURED FROM THE VEHICLE. THE REAR OF THE VEHICLE BEGAN TO SWAY BACK AND FORTH AND THE CONTACT WAS ABLE TO MAINTAIN LIMITED CONTROL OF THE VEHICLE. THE VEHICLE WAS TOWED TO A WELDING SPECIALIST WHERE A NEW BRACKET WAS WELDED TO THE FRAME. NEITHER THE MANUFACTURER NOR THE DEALER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 120,000. UPDATED 11/03/10. *LJ UPDATED 11/19/10. *LJ THE CONSUMER STATED THE FUEL TANKS WERE CORRODED. UPDATED 12/02/10
FRAME RUSTED OUT REAR TRAILING ARM BROKE FREE HAD TO BE WELDED BACK TO TRUCK. *TR
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT WAS ADVISED BY THE DEALER THAT THE VEHICLE WAS UNSAFE TO DRIVE DUE TO EXCESSIVE FRAME RUST AND UNDERBODY CORROSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 62,000. UPDATED 07/19/10. *LJ UPDATED 09/21/10*JB
WHILE DRIVING DOWN RTE 9 IN FRAMINGHAM MA ON 12/05/2008, MY 1998 ISUZU RODEO STARTED SWAYING. IT FELT LIKE THE REAR END OF THE VEHICLE WAS SLIDING ON ICE. I PULLED OFF OF THE HIGHWAY AND HAD THE VEHICLE TOWED. MY MECHANIC DETERMINED THAT THE REAR SWAY BAR HAD ROTTED OFF THE VEHICLE. A NEW SWAY BAR WAS INSTALLED, HOWEVER ADDI…
Read full complaint
WHILE DRIVING DOWN RTE 9 IN FRAMINGHAM MA ON 12/05/2008, MY 1998 ISUZU RODEO STARTED SWAYING. IT FELT LIKE THE REAR END OF THE VEHICLE WAS SLIDING ON ICE. I PULLED OFF OF THE HIGHWAY AND HAD THE VEHICLE TOWED. MY MECHANIC DETERMINED THAT THE REAR SWAY BAR HAD ROTTED OFF THE VEHICLE. A NEW SWAY BAR WAS INSTALLED, HOWEVER ADDITIONAL RUST WAS NOTED AND I WAS TOLD TO KEEP AN EYE ON IT FOR FUTURE ROT. IN MARCH 2010, WHILE COMPLETING NORMAL MAINTENANCE, MY MECHANIC NOTED THAT THE FRAME ON THE DRIVERS SIDE BETWEEN THE FRONT AND REAR DOORS WAS ROTTED BEYOND REPAIR. THE VEHICLE NOW SITS IN MY DRIVEWAY. *TR
I HAVE A 1998 RODEO, DRIVERS SIDE FRAME RUSTED AT TRAILING ARM BRACKET, SEPARATED AND WHEEL WENT FORWARD AGAINST WHEEL WELL. LUCKILY IN DRIVE WAY15 MPH. SIX MONTH LATER DRIVER SIDE FRAME RUSTED AT UPPER SHOCK AND COIL SPRING MOUNTS. THE LEFT REAR TRAILING ARM AND BRACKET BROKE FROM THE FRAME(DUE TO RUST), CAUSING THE VEHICLE TO…
Read full complaint
I HAVE A 1998 RODEO, DRIVERS SIDE FRAME RUSTED AT TRAILING ARM BRACKET, SEPARATED AND WHEEL WENT FORWARD AGAINST WHEEL WELL. LUCKILY IN DRIVE WAY15 MPH. SIX MONTH LATER DRIVER SIDE FRAME RUSTED AT UPPER SHOCK AND COIL SPRING MOUNTS. THE LEFT REAR TRAILING ARM AND BRACKET BROKE FROM THE FRAME(DUE TO RUST), CAUSING THE VEHICLE TO SHAKE VIOLENTLY. I BELIEVE ISUZU COMPANY THAT HAS AN OBLIGATION TO NOTIFY OWNERS OF THIS POTENTIALLY DISASTROUS CONDITION. *TR
JANUARY 2010 -1998 ISUZU RODEO-BACKING OUT OF DRIVEWAY VEHICLE ABRUPTLY STOPPED. UPON INVESTIGATION WE DISCOVERED REAR WHEEL OF DRIVER SIDE LODGED AGAINST INSIDE OF WHEEL WELL. FURTHER DISCOVERED REAR STABILIZER BRACKET COMPLETELY OFF OF REAR FRAME. VEHICLE REPAIRED BY A WELDER WHO DISCOVERED 5 FEET OF FRAME ROT IN THE REAR OF…
Read full complaint
JANUARY 2010 -1998 ISUZU RODEO-BACKING OUT OF DRIVEWAY VEHICLE ABRUPTLY STOPPED. UPON INVESTIGATION WE DISCOVERED REAR WHEEL OF DRIVER SIDE LODGED AGAINST INSIDE OF WHEEL WELL. FURTHER DISCOVERED REAR STABILIZER BRACKET COMPLETELY OFF OF REAR FRAME. VEHICLE REPAIRED BY A WELDER WHO DISCOVERED 5 FEET OF FRAME ROT IN THE REAR OF VEHICLE. HE REPLACED ROTTED FRAME AND FABRICATED NEW BRACKET. VISUALLY INSPECTED PASSENGER SIDE WHICH APPEARED TO BE STABLE. APRIL 4,2010-WHILE TRAVELING ON INTERSTATE HIGHWAY THE VEHICLE MADE AN UNEXPECTED VERY ABRUPT SHIFT TO THE RIGHT. VISUAL INSPECTION REVEALED THE REAR PASSENGER SIDE FRAME WAS FAILING.THERE WAS NO PRIOR WARNING IN EITHER INCIDENT. WE HAVE FILED A COMPLAINT WITH ISUZU MOTORS. WE CONSIDER OURSELVES VERY FORTUNATE NOT TO HAVE BEEN INJURED AS THIS PROBLEM IS CLEARLY A MAJOR SAFETY ISSUE. *TR
Official recalls
410V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
00V058000 · Suspension:rear
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
98V170000 · Electrical System:wiring:front Underhood
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
97V206001 · Unknown Or Other
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.