NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
211 reportsClear category filter105,000 miles · Jan 19, 2010
Service Brakes, Hydraulic
I BOUGHT A 1998 2WD ISUZU RODEO FROM A PRIVATE PARTY SIX MONTHS AGO. SINCE I BOUGHT IT, I HAVE BEEN EXPERIENCING A LOSS OF BRAKING CAPABILITY IN SOME CIRCUMSTANCE (EVERY DAY, MAINLY WHEN THE ENGINE IS COLD) THAT RESULTED IN EXTENDED STOPPING DISTANCES AND CONTINUOUS ILLUMINATION OF THE ABS WARNING LAMP. MY GARAGE MECHANIC TOLD …
Read full complaint
I BOUGHT A 1998 2WD ISUZU RODEO FROM A PRIVATE PARTY SIX MONTHS AGO. SINCE I BOUGHT IT, I HAVE BEEN EXPERIENCING A LOSS OF BRAKING CAPABILITY IN SOME CIRCUMSTANCE (EVERY DAY, MAINLY WHEN THE ENGINE IS COLD) THAT RESULTED IN EXTENDED STOPPING DISTANCES AND CONTINUOUS ILLUMINATION OF THE ABS WARNING LAMP. MY GARAGE MECHANIC TOLD ME THIS ISSUE IS DUE TO THE ABS COIL INTEGRATED MODULE THAT NEEDS TO BE REPLACED AND THAT THERE IS A RECALL ON IT FOR 1998-1999 ISUZU RODEO VEHICLES (CAMPAIGN NO. 02I-002, CAMPAIGN BULLETIN SB03-09-S001D, NHTSA CAMPAIGN ID NUMBER: 02I002000). I CALLED TWO ISUZU DEALERS BUT THEY TOLD ME THERE ARE NO OPEN RECALLS FOR MY VEHICLE VIN#. I DON'T UNDERSTAND WHY MY 1998 ISUZU RODEO IS NOT INCLUDED IN THIS RECALL. *TR
NHTSA ODI #10300246
107,000 miles · Feb 3, 2009
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1998 ISUZU RODEO. WHILE DRIVING 15 MPH, THE ABS INDICATOR ILLUMINATED PERIODICALLY. THE BRAKES FAILED TO STOP THE VEHICLE WHEN DRIVING OVER SAND OR GRAVEL ROADS. THE FAILURE HAS OCCURRED ON FOUR OCCASIONS. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE, BUT WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILUR…
Read full complaint
TL*THE CONTACT OWNS A 1998 ISUZU RODEO. WHILE DRIVING 15 MPH, THE ABS INDICATOR ILLUMINATED PERIODICALLY. THE BRAKES FAILED TO STOP THE VEHICLE WHEN DRIVING OVER SAND OR GRAVEL ROADS. THE FAILURE HAS OCCURRED ON FOUR OCCASIONS. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE, BUT WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT WAS ADVISED THAT HER VIN WAS INCLUDED IN A RECALL; HOWEVER, THE MANUFACTURER STATED THAT THE CLOSEST DEALER WAS IN CONNECTICUT. THE CONTACT LIVES IN NEW YORK. A LOCAL ISUZU DEALER STATED THAT THEY ONLY REPAIRED TRUCKS AND COULD NOT ASSIST WITH THE RECALL REPAIR. THE VIN WAS CONFIRMED AS A PART NHTSA CAMPAIGN ID NUMBER: 02I002000. THE FAILURE MILEAGE WAS 107,000.
NHTSA ODI #10257319
45,000 miles · Jul 18, 2008
Fuel System, GasolineService Brakes, Hydraulic
I HAVE SOME VERY IMPORTANT ISSUES PERTAINING TO MY 1998 ISUZU RODEO. I READ SEVERAL BLOGS ON A FORUM FROM OTHER RODEO OWNERS THAT HAVE HAD SOME OF THE SAME PROBLEMS THAT I HAVE WITH MINE. THE BIGGEST ONE IS THE ABS SYSTEM AND THE OTHER IS THE FUEL SENDING UNIT AND GAS GAUGE. THESE ARE TWO OF THE MOST REPORTED PROBLEMS BUT NOT…
Read full complaint
I HAVE SOME VERY IMPORTANT ISSUES PERTAINING TO MY 1998 ISUZU RODEO. I READ SEVERAL BLOGS ON A FORUM FROM OTHER RODEO OWNERS THAT HAVE HAD SOME OF THE SAME PROBLEMS THAT I HAVE WITH MINE. THE BIGGEST ONE IS THE ABS SYSTEM AND THE OTHER IS THE FUEL SENDING UNIT AND GAS GAUGE. THESE ARE TWO OF THE MOST REPORTED PROBLEMS BUT NOT THE ONLY ONES. IT SEEMS THAT ISUZU SHOULD BE DOING SOMETHING TO CORRECT THESE AND OTHER PROBLEMS ASSOCIATED WITH THIS VEHICLE. THE ABS HAS BEEN ADDRESSED IN SOME BUT NOT IN OTHERS. ALTHOUGH THE GAS GAUGE DOES NOT POSE ANY REAL SAFETY ISSUES IT IS ONE THAT POSES MINOR SAFETY ISSUE BECAUSE OF THE POSSIBILITY OF RUNNING OUT OF GAS BECAUSE OF NOT KNOWING THE CORRECT AMOUNT OF FUEL IN THE CAR. *TR
NHTSA ODI #10234880
Mileage unknown · Sep 29, 2007
Service Brakes, Hydraulic
1998 ISZUZU RODEO.
NHTSA ODI #10204434
70,000 miles · May 21, 2007
Service Brakes, HydraulicCrashInjury
TL*THE CONTACT OWNS A 1998 ISUZU RODEO. APPROXIMATELY THREE YEARS AGO, THE CONTACT RECEIVED A RECALL NOTICE FOR HER ANTILOCK BRAKE SYSTEM. THE MECHANIC WOULD NOT PERFORM THE REPAIR AND STATED THAT SHE NEEDED TO HAVE HER CARBURETOR REPLACED. THE REPAIR WOULD COST $2,000. THE CONTACT STATED THAT SHE WAS INVOLVED IN A CRASH APP…
Read full complaint
TL*THE CONTACT OWNS A 1998 ISUZU RODEO. APPROXIMATELY THREE YEARS AGO, THE CONTACT RECEIVED A RECALL NOTICE FOR HER ANTILOCK BRAKE SYSTEM. THE MECHANIC WOULD NOT PERFORM THE REPAIR AND STATED THAT SHE NEEDED TO HAVE HER CARBURETOR REPLACED. THE REPAIR WOULD COST $2,000. THE CONTACT STATED THAT SHE WAS INVOLVED IN A CRASH APPROXIMATELY ONE YEAR AGO BECAUSE HER BRAKES LOCKED. AS A RESULT, SHE CRASHED INTO THE PRECEDING VEHICLE WHILE TRAVELING 35 MPH. THE WOMAN SHE STRUCK STATED THAT HER NECK WAS INJURED, BUT SHE DID NOT FILE A CLAIM. THE CONTACT'S INSURANCE AGENCY PAID FOR THE DAMAGES. THE CONTACT HAD TO GET HER VEHICLE TOTALLY REBUILT. A POLICE REPORT WAS FILED. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 95,000 AND FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10191342
Mileage unknown · Mar 22, 2007
Air BagsService Brakes, HydraulicStructure
VERY DISSATISFIED WITH VEHICLE. IT''S HAS MANY PROBLEMS FROM START. WHILE DRIVING THE VEHICLE AND GOING INTO GEARS THE VEHICLE SURGES FORWARD. CAR SHIMMY'S WITH NO AVAILABLE FIX. VEHICLE HAS STRONG SUSPENSION VIBRATION AND BECOME MORE PRONOUNCED AS SPEED INCREASES. THE ABS LIGHT ILLUMINATED AND STAYED ON. THE BRAKE PEDAL N…
Read full complaint
VERY DISSATISFIED WITH VEHICLE. IT''S HAS MANY PROBLEMS FROM START. WHILE DRIVING THE VEHICLE AND GOING INTO GEARS THE VEHICLE SURGES FORWARD. CAR SHIMMY'S WITH NO AVAILABLE FIX. VEHICLE HAS STRONG SUSPENSION VIBRATION AND BECOME MORE PRONOUNCED AS SPEED INCREASES. THE ABS LIGHT ILLUMINATED AND STAYED ON. THE BRAKE PEDAL NEVER SEEMS TO GO TO THE FLOOR, IT JUST GETS SPONGING AND YOU FEEL THE ABS PULSATING THRU THE PEDAL AND THE VEHICLE DOESNT SLOW DOWN, CAUSING EXTENDED STOPPING DISTANCE. FUEL SENDING UNIT IS OPERATING ERRATICALLY. GAS GAUGE READS EMPTY NEARLY ALL THE TIME REGARDLESS OF LEVEL OF FUEL. AFTER FILLING TANK GAUGE WILL RISE TO 1/2 THEN AS YOU DRIVE A FEW MILES IT WILL DROP AND READ EMPTY. PASSENGER SIDE AIR BAG ASSEMBLY MOUNTS HAVE COME LOOSE WHICH CAUSES AIR BAG ASSEMBLY TO MOVE AROUND BEHIND DASH. THIS RATTLE IS VERY BOTHERSOME. PAID A LOT OF MONEY FOR THE DEALERSHIP TO FIX PROBLEM, BUT THE RATTLE WAS BACK SOON AFTER. THE BOLTS CAME LOOSE ON PASSENGER'S SIDE FRONT DOOR. WHEEL STUDS ON 1998 ISUZU RODEO STRIP OFF. GLOVE BOX IN 1998 ISUZU RODEO STICKS AND HARD TO OPEN.
NHTSA ODI #10185955
Mileage unknown · Apr 18, 2006
Service Brakes, HydraulicCrashInjury
RECEIVED RECALL NOTICE FOR 98 ISUZU RODEO CONTACTED BELL ISUZU WAS TOLD THE PART WAS NOT AVAILABLE AT THE TIME CALLED BACK SEVERAL TIMES,WAS PULLING IN DRIVEWAY BRAKES WENT ALL THE WAY TO THE FLOOR SMASHED INTO BEDROOM OF ROOMMATE. CALLED ISUZU THEY REPLACED PART THEN SAID IT HAD NOTHING TO DO WITH MY BRAKES. SAID THEY TESTED …
Read full complaint
RECEIVED RECALL NOTICE FOR 98 ISUZU RODEO CONTACTED BELL ISUZU WAS TOLD THE PART WAS NOT AVAILABLE AT THE TIME CALLED BACK SEVERAL TIMES,WAS PULLING IN DRIVEWAY BRAKES WENT ALL THE WAY TO THE FLOOR SMASHED INTO BEDROOM OF ROOMMATE. CALLED ISUZU THEY REPLACED PART THEN SAID IT HAD NOTHING TO DO WITH MY BRAKES. SAID THEY TESTED MY BRAKE FLUID IT WAS CONTAMINATED, AND THAT I NEEDED A NEW MASTER CYLINDER. THE PART REPLACED DIRECTLY AFFECTED THE ABS BRAKE SYSTEM FROM WORKING PROPERLY THEY BELIEVE ITS NOT FAILURE FROM THIS ABS MODULE, ALIGORTHAM THANK YOU FOR YOUR TIME. *JB
NHTSA ODI #10155607
Mileage unknown · Nov 15, 2005
Service Brakes, Hydraulic
YOU MAY ENCOUNTER EXTENDED STOPPING DISTANCE ABS, COIL INTEGRATED MODULE REPLACEMENT ITS BEEN A MONTH AND THEY STILL HAVE NOT CORRECTED THE PROBLEM. *JB
NHTSA ODI #10142696
101,905 miles · Nov 7, 2005
Service Brakes, HydraulicCrashInjury
DT: THECONTACT WAS DRIVING ON THE FREEWAY AND HAD BLOW OUT. SHE APPLIED THE BRAKES WHICH WERE UNDER MANUFACTURER'S RECAL 02I-002. THERE WHERE NO BRAKES. THIS RESULTED IN A CRASH. THE CONTACT SUSTAINED INJURIES. *AK
NHTSA ODI #10142003
108,000 miles · Oct 28, 2005
Service Brakes, Hydraulic
DT: THE CONTACT RECEIVED RECALL 02I002000 LAST WEEK. HE CALLED THE DEALERSHIP TO SET UP AN APPOINTMENT TO HAVE THE RECALL REPAIRS DONE. AFTER WAITING A LONG TIME THE DEALERSHIP INFORMED HIM THAT THE PARTS WERE NOT AVAILABLE. THE DEALERSHIP TOLD HIM TO STAY THERE UNTIL THE TRUCK ARRIVED WITH THE PARTS ON IT. FINALLY, THE …
Read full complaint
DT: THE CONTACT RECEIVED RECALL 02I002000 LAST WEEK. HE CALLED THE DEALERSHIP TO SET UP AN APPOINTMENT TO HAVE THE RECALL REPAIRS DONE. AFTER WAITING A LONG TIME THE DEALERSHIP INFORMED HIM THAT THE PARTS WERE NOT AVAILABLE. THE DEALERSHIP TOLD HIM TO STAY THERE UNTIL THE TRUCK ARRIVED WITH THE PARTS ON IT. FINALLY, THE DEALERSHIP TOLD HIM THERE WAS NO TRUCK COMING WITH THE PARTS ON IT. THE CONTACT'S VEHICLE EXPERIENCING EXTENDED STOPPING DISTANCES IN CERTAIN BRAKING CONDITIONS AS DESCRIBED IN THE RECALL, AND WAS CONCERNED ABOUT DRIVING THE CAR. THE DEALERSHIP DID NOT OFFER HIM A RENTAL CAR. THE CONTACT LIVED AT LEAST 50 MILES AWAY FROM THE DEALERSHIP.*AK
NHTSA ODI #10141159
Official recalls
4Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration