Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 43 of 381 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 131 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports4 fire reports10 injury reports
What owners actually said
381 reports
Mileage unknown · Nov 11, 2024
Fuel/propulsion System
2 months ago our engine control system warning light came on with a great decrease in speed while driving on the freeway. Brought to Hyundai dealership and was determined that fuel injector 1 misfired and needed replacement. Just last week exact same issue in fuel injector 4 occurred. They admitted issues with 2022 Tuscon injec…
Read full complaint
2 months ago our engine control system warning light came on with a great decrease in speed while driving on the freeway. Brought to Hyundai dealership and was determined that fuel injector 1 misfired and needed replacement. Just last week exact same issue in fuel injector 4 occurred. They admitted issues with 2022 Tuscon injectors but won’t replace until they fail as no recall. This is a massive safety issue as can be driving at a high rate of speed and speed slows immediately.
NHTSA ODI #11624610
Mileage unknown · Nov 7, 2024
Fuel/propulsion SystemUnknown Or Other
Running lean on bank 1-Dealership states it is a bad fuel injector on cylinder 1says it is not covered under 100,000 mile warranty. Vehicle currently at 80,000 mile. Radio in vehicle is restarting itself and not shutting off when car is turned off. Radio does not respond to commands such as volume adjustment. Dealership perf…
Read full complaint
Running lean on bank 1-Dealership states it is a bad fuel injector on cylinder 1says it is not covered under 100,000 mile warranty. Vehicle currently at 80,000 mile. Radio in vehicle is restarting itself and not shutting off when car is turned off. Radio does not respond to commands such as volume adjustment. Dealership performed software update, but it did not work.
NHTSA ODI #11623996
Mileage unknown · Nov 1, 2024
Power Train
Driving 78 mph on the highway, when the car stopped it accelerating, dropped to 67, pulled to shoulder. Car would not restart. Towed to dealer and was told the fuel injector failed and was flooded engine. Check engine came on with code DTC P030400 DTC System POWERTRAIN DTC Sub System EMS
NHTSA ODI #11623177
Mileage unknown · Oct 31, 2024
Seat BeltsCrashInjury
Stopped at a red light, rear-ended and when hit, seat belt malfunction, did not restrain
NHTSA ODI #11622925
Mileage unknown · Oct 28, 2024
Back Over PreventionLane Departure
Warning lights and messages for the Blind Spot Safety System and Rear Cross Traffic Safety System appear in driver information display. Those systems failed to function. Took to dealer for diagnosis/repair. After dealership working on vehicle both systems fail to function.
NHTSA ODI #11622227
Mileage unknown · Oct 26, 2024
Fuel/propulsion System
Here we go again. Last time the #3 fuel injector failed while driving on the freeway. Car started shaking and lost acceleration with "check engine" warning light on. Two months later, #2 fuel injector failed while driving on the street with same symptoms as last time. Fortunately, both incidents did not cause any accident but …
Read full complaint
Here we go again. Last time the #3 fuel injector failed while driving on the freeway. Car started shaking and lost acceleration with "check engine" warning light on. Two months later, #2 fuel injector failed while driving on the street with same symptoms as last time. Fortunately, both incidents did not cause any accident but was terrifying. I requested the Hyundai service dealer replace the remaining fuel injectors and again, was informed that Hyundai will only authorize them to replace a defective injector when it's failed. I do not understand Hyundai's logical thinking. Hyundai is fully aware of this issue and have already sent out TSBs. Are they waiting for someone to be in an accident and have major bodily injury caused by defective fuel injectors before taking this matter seriously? I will also address this matter to Hyundai Corporation for a response.
NHTSA ODI #11622113
Mileage unknown · Oct 25, 2024
Suspension
Trailing arm bushings on both sides appear to generate considerable noise indicating wear (has been since delivery but getting much worse over this year). Dealer's solution was to simply lubricate them. The owner manual says nothing of this, and I think this is a simple "go away" band-aid solution. Attempted to reach Hyundai co…
Read full complaint
Trailing arm bushings on both sides appear to generate considerable noise indicating wear (has been since delivery but getting much worse over this year). Dealer's solution was to simply lubricate them. The owner manual says nothing of this, and I think this is a simple "go away" band-aid solution. Attempted to reach Hyundai corporate, who asked me to confirm with the dealer if that is proper. That seems like a question for engineering, not the dealer who applied the band-aid fix. It is apparent that the bushings they affixed to the vehicle are defective and could possibly cause larger issues down the line -- far enough down the road when Hyundai can claim they are a wear item and need to be replaced.
NHTSA ODI #11621977
Mileage unknown · Oct 24, 2024
Electrical SystemEngineFuel/propulsion System
Check engine light and error message popped up on screen "A possible condition with your Engine Control System has been detected. A full system check is recommended to be done when convenient. Please contact your local dealership to schedule an appointment." Roughly 46500 miles. Contacted BlueLink and they could not help because…
Read full complaint
Check engine light and error message popped up on screen "A possible condition with your Engine Control System has been detected. A full system check is recommended to be done when convenient. Please contact your local dealership to schedule an appointment." Roughly 46500 miles. Contacted BlueLink and they could not help because dealerships were already closed.
NHTSA ODI #11621661
Mileage unknown · Oct 22, 2024
Forward Collision AvoidanceLane Departure
Vehicle was parked for an hour facing south. When vehicle was started, forward safety and blind spot monitoring warnings came on and many other systems tied to forward camera were disengaged. Mileage: 123k. Power steering was unresponsive and brakes felt spongy. Disconnected battery and let sit for a day. Reconnected and issue w…
Read full complaint
Vehicle was parked for an hour facing south. When vehicle was started, forward safety and blind spot monitoring warnings came on and many other systems tied to forward camera were disengaged. Mileage: 123k. Power steering was unresponsive and brakes felt spongy. Disconnected battery and let sit for a day. Reconnected and issue went away. A week later, was parked at hospital facing south for 4 hours. Issue came back, this time disconnecting battery did not fix issue. Dealer currently has the vehicle and they are claiming it shows rear end damage even though the car hasn’t been in an accident since I was rear ended and car was repaired. Dealer reported over 80 body codes including blind spot monitoring radar.
NHTSA ODI #11621382
Mileage unknown · Oct 20, 2024
Power TrainCrash
Vehicle has experienced, unexpected, slight and brief, acceleration 3 times at highway speeds up to 60 mph. The 4th incident was an uncontrolled acceleration when parking behind another parked vehicle. Car accelerated into the backend of parked vehicle. Operator was at a complete stop and needed to pull forward a few feet. T…
Read full complaint
Vehicle has experienced, unexpected, slight and brief, acceleration 3 times at highway speeds up to 60 mph. The 4th incident was an uncontrolled acceleration when parking behind another parked vehicle. Car accelerated into the backend of parked vehicle. Operator was at a complete stop and needed to pull forward a few feet. They took foot off of brake and lightly pressed the gas peddle. The car unexpectedly surged forward hitting parked car. 1 day later we received an email from Hyundai Blue Link stating that "a possible condition with your Engine Control System has been detected" and recommends bringing in for service for a full system check. Both cars were damaged and Tuscon had to be towed to a repair shop.
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.
Consequence & remedy
Consequence: Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence & remedy
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Additional source detail variants (2)
Structure:critical Fasteners
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Structure:body:roof And Pillars
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence & remedy
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Additional source detail variants (2)
Electrical System:software
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Exterior Lighting
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration