NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
962 reportsMileage unknown · May 27, 2026
EngineForward Collision Avoidance
reporting a serious safety concern involving my 2017 Hyundai Santa Fe Sport with the Theta II engine. While driving on the highway, my vehicle suddenly lost power without warning. The vehicle became unsafe to drive and I had to pull over and have it towed. There was no warning light before the failure. The vehicle has been reg…
Read full complaint
reporting a serious safety concern involving my 2017 Hyundai Santa Fe Sport with the Theta II engine. While driving on the highway, my vehicle suddenly lost power without warning. The vehicle became unsafe to drive and I had to pull over and have it towed. There was no warning light before the failure. The vehicle has been regularly maintained. Hyundai later stated there was internal engine damage. My vehicle also shows an open engine-related recall/campaign since November 2025. I have found many similar complaints from other Hyundai owners describing sudden loss of power, excessive oil consumption, and engine problems involving the Theta II engine. I contacted Hyundai Motor America and provided documentation and videos, but I have not received a meaningful response. I am concerned this issue may represent a serious safety defect because the sudden loss of power occurred while driving on a highway.
NHTSA ODI #11740312
Mileage unknown · May 24, 2026
Engine
The engine in my 2017 Hyundai Santa Fe Sport equipped with the 2.4L Theta II GDI engine is experiencing severe excessive oil consumption. The vehicle consumes approximately 2–2.5 quarts of oil every 1,000 miles despite multiple repair attempts and dealership-performed combustion cleaning procedures. Hyundai Motor America and the…
Read full complaint
The engine in my 2017 Hyundai Santa Fe Sport equipped with the 2.4L Theta II GDI engine is experiencing severe excessive oil consumption. The vehicle consumes approximately 2–2.5 quarts of oil every 1,000 miles despite multiple repair attempts and dealership-performed combustion cleaning procedures. Hyundai Motor America and the dealership documented the condition under PA #[XXX] and recommended engine replacement. Hyundai Motor America advised me in writing that the vehicle should not be operated in its current condition because of the excessive oil consumption and pending engine replacement. Excessive oil consumption creates a risk of sudden engine failure, engine seizure, stalling while driving, and potential engine fire if oil levels drop unexpectedly. Because the engine rapidly loses oil between normal service intervals, the vehicle may become unsafe to operate without warning, placing myself, passengers, and other motorists at risk. The defect was confirmed multiple times by Capital Hyundai in San Jose, CA through two official Hyundai oil consumption tests. The dealership documented oil consumption of approximately 2–2.5 quarts per 1,000 miles and submitted the results to Hyundai Motor America under PA #[XXX].The dealership also performed multiple repair attempts, including spark plug replacement, fuel induction cleaning, combustion chamber cleaning, and repeated oil changes, but the excessive oil consumption continued. Prior symptoms included: Check engine light illumination, Cylinder #4 misfire condition, Engine noise, Excessive oil loss between oil changes, and Oil level dropping significantly within short mileage intervals. The check engine light and misfire condition first became severe enough to require dealership diagnosis on or around [XXX], when the vehicle was towed to the dealership. The excessive oil consumption issue was formally documented beginning [XXX] during Hyundai’s oil consumption testing process. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6
NHTSA ODI #11739834
Mileage unknown · May 19, 2026
EngineFuel/propulsion System
I am submitting a complaint regarding a turbocharger failure on my 2017 Hyundai Santa Fe VIN [XXX] . The vehicle experienced turbocharger-related failure symptoms including loss of power and drivability concerns. This created a potentially dangerous situation because the vehicle was unable to accelerate normally and could have …
Read full complaint
I am submitting a complaint regarding a turbocharger failure on my 2017 Hyundai Santa Fe VIN [XXX] . The vehicle experienced turbocharger-related failure symptoms including loss of power and drivability concerns. This created a potentially dangerous situation because the vehicle was unable to accelerate normally and could have caused difficulty merging into traffic or maintaining safe roadway speeds. I contacted Hyundai Motor America requesting assistance with repair coverage. Hyundai denied assistance solely because the vehicle was outside the warranty period by time and mileage, despite the seriousness of the failure. I am concerned this issue may be related to broader engine or oil-related defects reported in Hyundai vehicles, including possible oil starvation, excessive oil consumption, or internal engine contamination that could contribute to turbocharger damage or failure. I believe this condition may represent a safety-related defect because sudden power loss during operation increases the risk of a crash. I request that NHTSA review this issue and investigate whether similar turbocharger or related engine failures are occurring in 2017 Hyundai Santa Fe vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11738896
Mileage unknown · May 19, 2026
EnginePower TrainVehicle Speed Control
After the installation of the Service Campaign 9C2 engine update, the car now seems to surge or rev up briefly at lower speeds like it can't find the right gear or is trying to briefly accelerate. It doesn't seem to be as noticeable at highway speeds, but in residential or low speeds, it's very noticeable and a little unsettlin…
Read full complaint
After the installation of the Service Campaign 9C2 engine update, the car now seems to surge or rev up briefly at lower speeds like it can't find the right gear or is trying to briefly accelerate. It doesn't seem to be as noticeable at highway speeds, but in residential or low speeds, it's very noticeable and a little unsettling as the car feels like it wants to briefly lunge forward. No lights are on the dash and there is no indication of any malfunction, but it did not behave this way prior to the 9C2 engine program update. I waited for a couple weeks before contacting Hyundai Corporate about this issue because I was hoping maybe the transmission or engine was relearning after a battery disconnection, but it has not gone away.
NHTSA ODI #11738814
Mileage unknown · May 11, 2026
Fuel/propulsion System
After conducting Hyundai Service Campaign 9C2 for an emission update, vehicle now lunges and lags when accelerator is depressed. Symptoms tend to be more present soon after vehicle is started and reappear less often after the vehicle engine is at optimal temperature. This problem was not at all present prior to the service campa…
Read full complaint
After conducting Hyundai Service Campaign 9C2 for an emission update, vehicle now lunges and lags when accelerator is depressed. Symptoms tend to be more present soon after vehicle is started and reappear less often after the vehicle engine is at optimal temperature. This problem was not at all present prior to the service campaign update. The vehicle had no warning lights prior to the service update. This problem causes a safety issue when acceleration is not consistently present in a time of lane merging and turning onto higher speed roads. There are no warning lamps on the vehicle currently. Hyundai customer service was contacted about problem and I requested to remove the campaign update as this safety problem was not present prior to the update. Hyundai would not attempt to do this and required me to pay a diagnostic fee of several hundred dollar to troubleshoot the source of the problem. I declined.
NHTSA ODI #11737161
94,700 miles · May 11, 2026
Engine And Engine Cooling
The contact owns a 2017 Hyundai Santa Fe. The contact stated that the vehicle was using an excessive amount of oil. There were no warning lights illuminated. There was no indication of a leak. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The dealer informed the contact the failure was related to…
Read full complaint
The contact owns a 2017 Hyundai Santa Fe. The contact stated that the vehicle was using an excessive amount of oil. There were no warning lights illuminated. There was no indication of a leak. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The dealer informed the contact the failure was related to combustion chamber cleaning. The manufacturer was contacted, who informed the diagnostic fees were at her expense and there was no coverage. The failure mileage was approximately 94,700.
NHTSA ODI #11736987
77,000 miles · May 6, 2026
Air Bags
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated and remained on, despite no accident occurring. The vehicle was taken to an independent mechanic who could not determine the failure and advised the contact to visit the dealer. At the de…
Read full complaint
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated and remained on, despite no accident occurring. The vehicle was taken to an independent mechanic who could not determine the failure and advised the contact to visit the dealer. At the dealer, the vehicle was diagnosed with a failed passenger air bag inflator that needed replacement. The dealer also found that the SRSCM (Supplemental Restraint System Control Module) required replacement due to the part shorting the inflator. The airbag was replaced, but the dealer refused to replace the SRSCM as it was no longer under warranty. The manufacturer was not notified of the failure. The failure occurred at approximately 77,000 miles.
NHTSA ODI #11736061
Mileage unknown · May 4, 2026
Engine
Engine seized up on the interstate. Vehicle has ~97,000 miles. Towed to dealership. Dealership wanted $8,000+ to replace engine. Hyundai refused to honor their warranty of 15 years/150,000 miles. Remains at the dealership, unrepaired.
NHTSA ODI #11735603
Mileage unknown · May 2, 2026
EngineFuel/propulsion System
My vehicle had oil consumption problems that were fixed with a new replacement engine now my catalytic converter is going bad due to engine oil consumption problems and the dealer I deal with is refusing to help with this issue. There is only around 50k miles on the new engine. I would greatly appreciate your help with this Than…
Read full complaint
My vehicle had oil consumption problems that were fixed with a new replacement engine now my catalytic converter is going bad due to engine oil consumption problems and the dealer I deal with is refusing to help with this issue. There is only around 50k miles on the new engine. I would greatly appreciate your help with this Thank you!
NHTSA ODI #11735297
Mileage unknown · May 1, 2026
EngineUnknown Or Other
On 4/17/26 McDonalds Hyundai of [XXX] , dealership performed an ECU update for THETA II Emissions logic improvement (Hyundai campaign number 9C2). Ever since that time the vehicle has been lurching during acceleration. This happens particularly when the vehicle has been sitting for several hours. I reported this to the dealershi…
Read full complaint
On 4/17/26 McDonalds Hyundai of [XXX] , dealership performed an ECU update for THETA II Emissions logic improvement (Hyundai campaign number 9C2). Ever since that time the vehicle has been lurching during acceleration. This happens particularly when the vehicle has been sitting for several hours. I reported this to the dealership on 4/28/26 (Scott, service manager) and to Hyundai on 4/29/26 (Hyundai Case Management #: 42610495). I noted to Hyundai that this same/similar problem has been reported by other owners ( see [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11735182
Official recalls
6Feb 3, 2022
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Sep 20, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
Consequence & remedy
Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Jun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Mar 6, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An underinflated inflated tire can increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Nov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Mar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP24001 · 3.3L Engine Loss Of Motive Power (lomp)
Opened Feb 8, 2024 · Closed May 16, 2024
Status: closed (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration