NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
962 reportsMileage unknown · Aug 21, 2023
EnginePower Train
My ‘17 Santa Fe has been well taken care of with regular oil changes and we have kept up with the recommended maintenance. While driving on 8/17/2023 the car started to struggle to accelerate and I heard a knocking sound. Within moments there was total engine and power failure and I had to quickly get the vehicle off the road to…
Read full complaint
My ‘17 Santa Fe has been well taken care of with regular oil changes and we have kept up with the recommended maintenance. While driving on 8/17/2023 the car started to struggle to accelerate and I heard a knocking sound. Within moments there was total engine and power failure and I had to quickly get the vehicle off the road to avoid being rear ended. There were no warning lights on until the moment it was dying. The battery light, check engine light, and oil light came on, but then the vehicle had quickly lost all power immediately after. Once it was towed to Meineke and looked over by the mechanics there it was determined that it needs a new engine and that it had very, very little oil in it.
NHTSA ODI #11539804
Mileage unknown · Aug 18, 2023
Engine
Blown engine in the middle of the highway. The car have been consuming excessive amounts of oil. I though that, if the car has the oil change done more often, the engine would be fine, but that was not the case.
NHTSA ODI #11539400
Mileage unknown · Aug 16, 2023
EngineUnknown Or Other
Had oil changed July 5, 2023, Aug. 14 check engine light came on. Took it to shop and was told Hyundai vehicles are burning oil in the engine and the diagnostic code came back as Catalytic Convert and had to add oil. Have oil spots all over my drive so was told to check oil and make sure it's not low and see if light comes back …
Read full complaint
Had oil changed July 5, 2023, Aug. 14 check engine light came on. Took it to shop and was told Hyundai vehicles are burning oil in the engine and the diagnostic code came back as Catalytic Convert and had to add oil. Have oil spots all over my drive so was told to check oil and make sure it's not low and see if light comes back on. Repair shop checked for recalls and found none for this car, yet. Daughter has 2013 Kia Rio with same problem for past couple of years. Why do recalls take so long?
NHTSA ODI #11539020
Mileage unknown · Aug 16, 2023
Engine
Previous to the day of this incident there was no check engine light showing. I was driving and heard a knocking /grinding sound that progressively got worse. I was trying to get home and the engine suddenly died , all of the warning lights came on and the engine couldn’t start. Took it to the dealership. The third party ext…
Read full complaint
Previous to the day of this incident there was no check engine light showing. I was driving and heard a knocking /grinding sound that progressively got worse. I was trying to get home and the engine suddenly died , all of the warning lights came on and the engine couldn’t start. Took it to the dealership. The third party extended warranty didn’t cover it because all of the oil was missing ( no oil leak was present). Still waiting to see if the dealership will repair.
NHTSA ODI #11538925
Mileage unknown · Aug 15, 2023
EngineFuel/propulsion SystemPower Train
Upon approaching stop sign, the vehicle stalled and after restart, the vehicle ceased acceleration at intervals. This caused the vehicle to impede/slow traffic during journey. Again, at stop light, the vehicle stalled and “all” warning lights appeared. The engine failed to restart and the vehicle was towed from traffic due to en…
Read full complaint
Upon approaching stop sign, the vehicle stalled and after restart, the vehicle ceased acceleration at intervals. This caused the vehicle to impede/slow traffic during journey. Again, at stop light, the vehicle stalled and “all” warning lights appeared. The engine failed to restart and the vehicle was towed from traffic due to engine failure. The vehicle is a 2017 Hyundai Santa Fe Sport 2.4 with 116,000 miles. An Engine Class Settlement has been established for the model years 2010-2012 with this same issue. The vehicle will be towed to a dealership for inspection, confirmation and repair. I felt the need to make an incident report thinking maybe other reports have been filed, also, and the manufacturer reusing to admit to problem issues.
NHTSA ODI #11538673
Mileage unknown · Aug 15, 2023
Engine
While driving on the highway my engine seized up and stopped working altogether. My dashboard went completely red with warning lights and I could get to the side of the road to call for assistance. The day prior while getting an oil change I was told by the mechanic that some Hyundai cars have been consuming oil quickly and th…
Read full complaint
While driving on the highway my engine seized up and stopped working altogether. My dashboard went completely red with warning lights and I could get to the side of the road to call for assistance. The day prior while getting an oil change I was told by the mechanic that some Hyundai cars have been consuming oil quickly and that I had less than a quart left while I just was a little of the 3000-mile mark. The previous oil change I was also told I was at a very low level as well. I called the dealership about the concern and they were willing to run some tests on the car, but that afternoon the engine seized up. The car was towed back to the dealership and I was able to have the engine replaced by the manufacturer. I was very concerned for our safety when the incident happened because I was on a highway traveling at a high-speed rate (posted 60mph) but was glad to safely make it to the shoulder of the roadway.
NHTSA ODI #11538607
Mileage unknown · Aug 12, 2023
Electrical SystemEngineUnknown Or Other
On May 2023, while my husband was taking my daughter to go to school with 2017 Hyundai Santa Fe, he noticed engine knocking noises emanating from the engine compartment. Shortly after, the vehicle's performance significantly deteriorated, and the check engine light illuminated on the dashboard, and the engine shut down. Get the…
Read full complaint
On May 2023, while my husband was taking my daughter to go to school with 2017 Hyundai Santa Fe, he noticed engine knocking noises emanating from the engine compartment. Shortly after, the vehicle's performance significantly deteriorated, and the check engine light illuminated on the dashboard, and the engine shut down. Get the car towed to the nearest auto service, the mechanic told me that there’s an engine failure as result of abnormal oil consumption causing internal damage and need to be fixed by Hyundai. I called Hyundai USA, and was told that in order to have it covered under the warranty, it needed to be repaired by an authorized dealer. However, no authorized dealer had an available appointment for at least 2 months. Finally after 2 months, I had the car towed to the authorized Hyundai service center for diagnosis and repairs. Upon examination by the certified technicians at the Hyundai service center, I was informed that it needs and engine replacement that will cost around $20,000. I called Hyundai Corporation and had escalated my case to the case manager, but the manager never called back to give me an update. Their customer service department is also frustrating to deal with. They just sort of repeat the same phrases over and over again rather than having any sort of actual conversation with you. It's been more than 2 months after the incident and they finally they can’t do anything about it because it’s outside of warranty. It’s very frustrating
NHTSA ODI #11538150
Mileage unknown · Aug 12, 2023
Engine
My 2017 Hyundai Santa Fe is excellently maintained with 130,000 miles on it with a faulty rod requiring engine replacement. There is a safety recall #168 for the exact same failure on the same year make and model and engine but Hyundai will not cover my engine as this recall is vin specific and mine does not qualify. Now left a …
Read full complaint
My 2017 Hyundai Santa Fe is excellently maintained with 130,000 miles on it with a faulty rod requiring engine replacement. There is a safety recall #168 for the exact same failure on the same year make and model and engine but Hyundai will not cover my engine as this recall is vin specific and mine does not qualify. Now left a loan on a car that I cannot drive.
NHTSA ODI #11538085
Mileage unknown · Aug 11, 2023
Engine
About two months ago my son was driving home and noticed the oil light flash on and off quickly while he was driving. He immediately brought the car to our regular mechanic who instructed him to just check the oil "it might be a little low"- When my son arrived home we checked the oil and the oil was down 3+quarts. There is no e…
Read full complaint
About two months ago my son was driving home and noticed the oil light flash on and off quickly while he was driving. He immediately brought the car to our regular mechanic who instructed him to just check the oil "it might be a little low"- When my son arrived home we checked the oil and the oil was down 3+quarts. There is no engine oil leak, and the oil in the car had been changed recently and has also been changed every 3-5K miles per the manufacturers recommendation. We did a bit of research and learned that this is a known problem for thousands of Hyundai owners and that Hyundai recommended we start a case with them. We did. We had an oil consumption test performed during which we were told not to check the oil at all ourselves or it would "ruin the test". We were then told that the car was "only down a quart of oil after 1K miles and so it is fine"- The case manager told us that if the car had been down even an ounce more than a quart, we would be moved into a place where we could get some repairs done on the known defective engine. We are now left with a car that burns oil at a rate that is not normal or safe. In addition, our car makes loud popping noises upon start which we have researched and found is due to oil escaping from the engine and going to places in the car where it should not be. We don't believe the car is safe to drive because there is no consistent way to determine how much oil the car is burning and asking a customer to replace a quart of oil every 1K miles is unreasonable. There are thousands of people across the US who are experiencing this same issue. Why hasn't there been a recall?
NHTSA ODI #11537846
Mileage unknown · Aug 10, 2023
Fuel/propulsion SystemPower Train
The car is 2017 Hyundai Santa Fe with a defective crankshaft. The car is leaking oil. I called Hyundai and they noted that although they have recall 168 the VIN for my car doesn't match a recall that is on their website. I spoke to a Hyundai case manager today who said that even though my car has the defective crankshaft they w…
Read full complaint
The car is 2017 Hyundai Santa Fe with a defective crankshaft. The car is leaking oil. I called Hyundai and they noted that although they have recall 168 the VIN for my car doesn't match a recall that is on their website. I spoke to a Hyundai case manager today who said that even though my car has the defective crankshaft they will not repair the vehicle because it beyond 100,000 and the recall is expired. I am seeking help from the NHTSA as my car should be covered under this recall. I took it to an independent shop that noted that my car should be covered. I have photo and documents to prove that my car should be covered under this recall. My VIN just doesn't match their records and they are denying my claim.
NHTSA ODI #11537803
Official recalls
6Feb 3, 2022
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Sep 20, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
Consequence & remedy
Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Jun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Mar 6, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An underinflated inflated tire can increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Nov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Mar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP24001 · 3.3L Engine Loss Of Motive Power (lomp)
Opened Feb 8, 2024 · Closed May 16, 2024
Status: closed (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration