Engine. Review the 643 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports23 fire reports11 injury reports

What owners actually said

962 reports

Mileage unknown · Aug 7, 2025

Engine

Read full complaint

My vehicle is a 2017 Hyundai Santa Fe Sport AWD with a GDI Theta II 2.4L 4 cylinder engine. We purchased it in Feb. 2024 with 120,310 miles. Since then we have only put approximately 8,000 miles on it in 17 months. On Aug. 1st 2025 while driving up a hill out in the country the engine suddenly quit. Of course the steering and the brakes failed to operate. However I was able to coast to the next road and barely able to turn the wheel but made the corner and coasted to a stop. Without a nearby corner I would have been stuck on a state highway with many semi-trucks traveling on it. Could have been much more dangerous for my wife and I especially since we had to have the car put on a flatbed to be hauled home. The person who came to haul it checked the battery which was fine. You could hear the starter engage and try to turn the engine but it would not turn one bit. Once home we had a mechanic with many years experience have a look and listen to it. He could not get the engine to move even when trying to turn it by grabbing the engine belts and pullies. By all appearances the engine is seized. No warning lights were one and the oil was checked that very morning before leaving home. The vehicle was using about 1 qt of oil every 200 miles or so. Always used a high quality oil of proper weight/viscosity. Had no visible oil leaks on ground where it was parked every night. Hesitate to spend hauling fees to take it to the dealer 40 miles away if they are not going to do anything but offer to replace it for many thousands of dollars. For a couple living on social security this can absolutely turn things upside down as we only own one car (which we still owe on).

NHTSA ODI #11679198

Mileage unknown · Aug 7, 2025

Engine

Motor replacement. I had taken my car several times into Hyundai for oil consumption issue. I replaced the recommended parts through Hyundai and ended up having to come right back after being stuck on the side of the interstate due to lack of compression two cylinder two I was told I needed to replace the motor. This has been a …

Read full complaint

NHTSA ODI #11679074

Mileage unknown · Aug 6, 2025

Engine

Hyundai knows about the excessive oil consumption of these 2.0 Turbo GDI engines. My engine went out while driving my daughter down the road. Had to tow it to the dealer. Dealer is saying no compression on cylinder 3. Also a known issue. There was a massive lawsuit over engines already. Hyundai is no help. Excessive oil consumpt…

Read full complaint

NHTSA ODI #11678861

Mileage unknown · Aug 5, 2025

Engine

Driving on main road , car came to complete stop while waiting on traffic light and vehicle loss power , and wouldn’t accelerate. No , dash lights nor sounds were on prior to it loosing power nor stalling .

NHTSA ODI #11678631

Mileage unknown · Aug 5, 2025

Engine

Read full complaint

I am reporting a sudden engine failure involving my 2017 Hyundai Santa Fe Sport 2.0T. At just 68,000 miles, the vehicle experienced catastrophic loss of power due to zero compression in Cylinder 1. The vehicle is equipped with the Theta II turbocharged engine, which has been the subject of previous investigations and safety recalls due to premature failure risks, including stalling and fire hazards. This failure occurred on [XXX], while I was driving on the highway. There was no warning. It put all drivers near me at risk as I had no power, was traveling in the left lane and had to navigate through 3 lanes of traffic to reach the breakdown lane. I request that this case be investigated further as a potential safety risk and recurrence of known issues with this engine type. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11678623

Mileage unknown · Aug 4, 2025

EnginePower Train

Read full complaint

This vehicle has experienced numerous serious failures, including two engine replacements, a transmission replacement, and persistent safety system malfunctions. The Downhill Brake Control (DBC) system remains stuck in the "on" position, and the traction control warning light stays illuminated. These issues directly compromise vehicle safety and stability, particularly on hilly or wet roads. Despite extensive service at Arapahoe Hyundai in Centennial, CO, these problems continue to return. The vehicle has been in the shop multiple times and was most recently in service for nearly 30 days. My wife was stranded at the dealership today due to the same unresolved safety system failure. Dealer communication has been poor, and repairs are often incomplete, requiring immediate return visits. The repeated failure of safety-critical systems, combined with the inability to resolve the issues long-term, presents a significant safety concern for both my family and others on the road. I am requesting NHTSA to investigate whether this is part of a broader defect pattern affecting 2017 Hyundai Santa Fe models and if a recall is warranted.

NHTSA ODI #11678332

Mileage unknown · Aug 1, 2025

Chest Clip, Buckle, HarnessInsert, Padding

Read full complaint

The contact owns a Safety 1st safety seat, Model type: Grow and Go All-In-One-Convertible, Model number: CC31-GYY, Manufacturer Date: August 01, 2023. The contact stated that the cloth part that covers the headpiece does not fit. In addition, the insulation part inside the cloth will detach. Most recently, the contact stated that the harness that goes across would become difficult to buckle. It would take several attempts to make it secure. The manufacturer was not notified of the failure.

NHTSA ODI #11677896

Mileage unknown · Jul 31, 2025

EngineFuel/propulsion System

Read full complaint

The car has been consuming all the engine only after 700 miles. This has been a constant issue since December 2024 and the issue has been brought up with Hyundai dealership in Denville, NJ and Hyundai Corporate as well. Hyundai dealership in Denville, NJ performed 2 oil consumption tests, which the vehicle failed both test only after 700 miles as it consumed all the engine oil. They refused to do further investigation or recall the engine as it should be covered under Hyundai TXXI warranty given the Hyundai Engine II Class Action Settlement a few years ago. The vehicle has broken down on me on the highway a few times and has put my family at risk and danger due to the negligence of the Hyundai dealership in Denville, NJ and Hyundai Corporate refuel to resolve the issue. Now the car does not start at all some days thus it has impacted my work and my ability to provide for my family

NHTSA ODI #11677532

Mileage unknown · Jul 27, 2025

Engine

My car had a thrown connecting rod-the problem described under TSB22-EM-006H-2 (TXXM/6G) which extends engine warranty to 150k miles/15 years for this exact issue my vin is listed my mileage is 113k and KSDS was completed (or I am exempt) please submit prior approval under the extended warranty for engine replacement. Hyundai is…

Read full complaint

NHTSA ODI #11676451

Mileage unknown · Jul 26, 2025

Engine

This modle has a serious oil consumption caused by a manufacturerer design issure with the engine. As time goes by the oil cosumption get wores potentially seizing the engine while driving. I have to constantly fill with oil. This is a major safety concern with many hyundai vehicles.

NHTSA ODI #11676375

Official recalls

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V578000 · Engine And Engine Cooling:engine

Sep 20, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.

Consequence & remedy

Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.

Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

17V142000 · Tires:pressure Monitoring And Regulating Systems

Mar 6, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: An underinflated inflated tire can increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.

16V842000 · Electrical System:wiring; Trailer Hitches

Nov 21, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Additional source detail variants (2)

Trailer Hitches

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Electrical System:wiring

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

16V145000 · Seat Belts:front:warning Light/devices

Mar 10, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP24001 · 3.3L Engine Loss Of Motive Power (lomp)

Opened Feb 8, 2024 · Closed May 16, 2024

Status: closed (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.