← New search

2017 Hyundai Santa Fe

Owner reports · Recalls · Investigations

More warning signs than most Santa Fe years

Owner complaints for the 2017 Hyundai Santa Fe are substantially higher than the model-year median of 212.5.

About this comparison →

When problems were reported

Mileage at the reported incident

268 reports with mileage · 694 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 643 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports23 fire reports11 injury reports

Power Train complaints

161 reports
Clear category filter
1,200 miles · Apr 4, 2017
Electronic Stability Control (esc)EnginePower Train

HIT POT HOLE AFTER STOP AND STABILITY CONTROL STOPS POWER TO TRANSMISSION...5-8 SECONDS OF NO ACCELARATION HAS CAUSED SAFETY ISSUE WHEN MERGING INTO TRAFFIC. APPEARS TO BE A VERY COMMON PROBLEM ON USER BASED FORUMS.

NHTSA ODI #10970592

17,000 miles · Mar 27, 2017
Fuel/propulsion SystemPower Train

CAR HESITATES TO ACCELERATE FROM A COMPLETE STOP, ACCELERATING WHILE COMING OUT OF TURN, OR SLOWING DOWN AND ACCELERATING AGAIN. ALSO SEEMS TO BE USING A LOT OF GAS. HAVEN'T CALCULATED IT YET BUT CAN SEE THE FUEL GAUGE LOWER AS I'M DRIVING. CAR ONLY HAS 17000 MILES.

NHTSA ODI #10968770

Mileage unknown · Mar 6, 2017
Power Train

2017 STA FE 7 SEATER:WHEN GOING TO A SLOW SPEED TO ALMOST COMPLETE STOP THEN TRY TO TURN RIGHT FROM THE INTERSECTION,THE SUV CAN'T FIND THE RIGHT GEAR FOR FEW SECONDS THEN LOUNGES ABRUPTLY THAT JOLT YOUR BODY FORWARD AND BACK FROM YOUR SEAT.IT SHIFT BEAUTIFULLY WHEN TURNING TO THE LEFT OR FROM STRAIGHT LINE.IT FEELS VERY WEIRD…

Read full complaint

2017 STA FE 7 SEATER:WHEN GOING TO A SLOW SPEED TO ALMOST COMPLETE STOP THEN TRY TO TURN RIGHT FROM THE INTERSECTION,THE SUV CAN'T FIND THE RIGHT GEAR FOR FEW SECONDS THEN LOUNGES ABRUPTLY THAT JOLT YOUR BODY FORWARD AND BACK FROM YOUR SEAT.IT SHIFT BEAUTIFULLY WHEN TURNING TO THE LEFT OR FROM STRAIGHT LINE.IT FEELS VERY WEIRD AND DANGEROUS THAT YOU MIGHT HIT THE CAR IN FRONT OF YOU OR YOU MIGHT BE HIT FROM BEHIND.I HOPE THAT YOUR GOOD OFFICE WILL INVESTIGATE THIS PROBLEM BEFORE ANY ACCIDENT HAPPENS.IT MAKES ME NERVOUS EVERY TIME I MAKE A RIGHT TURN.

NHTSA ODI #10958741

Mileage unknown · Feb 16, 2017
Power Train

MY BRAND NEW 2017 SANTA FE LIMITED HESITATES BADLY WHEN COMING OUT OF TURNS AND ATTEMPTING TO ACCELERATE...JUST SHORT OF COMING TO A STOP. IT IS VERY PRONOUNCED WHEN IN ECO MODE, BUT IS AN ISSUE TO A LESSER DEGREE IN THE OTHER TWO DRIVING MODES. DOES ANYONE ELSE HAVE THIS ISSUE? (I HAVE AN APPOINTMENT SOON TO GET IT LOOKED AT, B…

Read full complaint

MY BRAND NEW 2017 SANTA FE LIMITED HESITATES BADLY WHEN COMING OUT OF TURNS AND ATTEMPTING TO ACCELERATE...JUST SHORT OF COMING TO A STOP. IT IS VERY PRONOUNCED WHEN IN ECO MODE, BUT IS AN ISSUE TO A LESSER DEGREE IN THE OTHER TWO DRIVING MODES. DOES ANYONE ELSE HAVE THIS ISSUE? (I HAVE AN APPOINTMENT SOON TO GET IT LOOKED AT, BUT WAS TOLD THAT THERE IS NO ADJUSTMENT THAT THEY CAN DO.) IT IS UNACCEPTABLE AND I'M LOOKING TO HEAR IF THIS IS A COMMON. THE OWNERS MANUAL STATES THAT PERFORMANCE IN ECO MODE IS LESS. BUT THIS IS VERY ANNOYING AND BORDERS BEING DANGEROUS.

NHTSA ODI #10955056

9,000 miles · Feb 15, 2017
Power Train

2017 HYUNDAI SANTA FE SPORT 2.0 T WHEN MAKING A TURN DURING ACCELERATION, SUDDEN POWER LOSS TO ENGINE. USUALLY HAPPENS IN 2ND GEAR, ESPECIALLY AFTER DOWNSHIFT FROM 3RD GEAR. MAKING A SHARP LEFT TURN FROM A FULL STOP CAUSED THE STABILITY CONTROL TO TURN ON AND VEHICLE LOST ALL POWER (RPM SAT AT 1500 RPM) FOR APPROX. 2 SECONDS.…

Read full complaint

2017 HYUNDAI SANTA FE SPORT 2.0 T WHEN MAKING A TURN DURING ACCELERATION, SUDDEN POWER LOSS TO ENGINE. USUALLY HAPPENS IN 2ND GEAR, ESPECIALLY AFTER DOWNSHIFT FROM 3RD GEAR. MAKING A SHARP LEFT TURN FROM A FULL STOP CAUSED THE STABILITY CONTROL TO TURN ON AND VEHICLE LOST ALL POWER (RPM SAT AT 1500 RPM) FOR APPROX. 2 SECONDS. ALMOST GOT REAR-ENDED. ANOTHER TIME, MAKING A RIGHT TURN ON INTERSTATE ONRAMP AND RIGHT FRONT TIRE HIT A POT HOLE, VEHICLE LOST ALL POWER FOR APPROX. 2 SECONDS (AROUND 20 MPH). ALMOST GOT HIT. MAKING A LEFT HAND TURN AT TURN SIGNAL (VEHICLE DOWNSHIFTED FROM 3RD TO 2ND) AND VEHICLE RPM WENT TO 1500 AND DIDN'T MOVE FOR APPROX. 2 SECONDS. ALMOST GOT HIT. ACCELERATING UP HILL, SLOWED DOWN FOR CAR IN FRONT OF ME (VEHICLE DOWNSHIFTED FROM 3RD TO 2ND), APPROX. 20 MPH. WENT TO ACCELERATE AGAIN AND VEHICLE SAT AT 1500 RPM WITH POWER LOSS FOR APPROX. 2 SECONDS. SEVERAL OTHERS REPORT THIS SAME ISSUE ON THE VARIOUS HYUNDAI SANTA FE FORUMS WITH THE SPORT TURBO. I KNOW THERE WAS A TSB FOR THE FULL-SIZED SANTA FE WITH THE V6, BUT THIS IS THE SWB (SHORT WHEEL BASE) SPORT MODEL WITH 4 CYLINDER TURBO.

NHTSA ODI #10954872

1,000 miles · Jan 20, 2017
Power Train

I HAVE THE 2017 SPORT 2.0T MODEL, AND I AM EXPERIENCING THE SAME POWERTRAIN ISSUE. WHEN DRIVING AT SLOW SPEEDS, THERE IS A 3-4 SECOND DELAY IF POWER IS NEEDED SUDDENLY. THE POWERTRAIN JUST GOES TO SLEEP AND NOTHING HAPPENS, FOLLOWED BY A SUDDEN, DANGEROUS LURCH. THE SIGNIFICANT DELAY BETWEEN THE TIME THE POWER IS NEEDED AND T…

Read full complaint

I HAVE THE 2017 SPORT 2.0T MODEL, AND I AM EXPERIENCING THE SAME POWERTRAIN ISSUE. WHEN DRIVING AT SLOW SPEEDS, THERE IS A 3-4 SECOND DELAY IF POWER IS NEEDED SUDDENLY. THE POWERTRAIN JUST GOES TO SLEEP AND NOTHING HAPPENS, FOLLOWED BY A SUDDEN, DANGEROUS LURCH. THE SIGNIFICANT DELAY BETWEEN THE TIME THE POWER IS NEEDED AND THE TIME THE POWER IS DELIVERED, MAKES THIS CAR UNDRIVABLE AND HIGHLY DANGEROUS. I'M NOT SURE IF IT IS A TRANSMISSION PROBLEM ( SLOW TO DOWNSHIFT), A SOFTWARE ISSUE, OR A TURBO DELAY, LIKELY ALL THREE COMBINED. THE RESULT IS THAT THE CAR'S PERFORMANCE IS UNACCEPTABLE, AND HIGHLY DANGEROUS. THIS PROBLEM OCCURS DAILY. THIS IS MY THIRD HYUNDAI AND MY FINAL ONE. NEVER HAVE I EXPERIENCED SO MUCH REGRET AT BUYING A CAR; I WANT MY MONEY BACK. IF HYUNDAI DOES NOTHING TO RECTIFY THIS ISSUE (I'M NOT SURE WHAT THEY CAN DO, AS THIS SEEMS TO BE A RESULT OF SHODDY ENGINEERING) I WILL JUST SELL MY CAR JUST TO GET RID OF THIS DANGEROUS VEHICLE AND EAT THE LOSS. MY LIFE AND THAT OF MY FAMILY ARE FAR MORE IMPORTANT. *TR

NHTSA ODI #10946640

1,800 miles · Jan 20, 2017
EnginePower Train

ENGINE STALLING AT SLOW SPEEDS. FURTHER, AT SLOW SPEEDS, THERE IS A SIGNIFICANT DELAY OF SEVERAL SECONDS FOR POWER DELIVERY. FOR EXAMPLE, IF DRIVING SLOWLY, SAY AT 5 MPH, AND POWER IS NEEDED IMMEDIATELY (SUCH AS IN AN EMERGENCY OR A LANE CHANGE SITUATION), NOTHING HAPPENS FOR OVER 3 SECONDS WHEN THE ACCELERATOR PEDAL IS DEPRES…

Read full complaint

ENGINE STALLING AT SLOW SPEEDS. FURTHER, AT SLOW SPEEDS, THERE IS A SIGNIFICANT DELAY OF SEVERAL SECONDS FOR POWER DELIVERY. FOR EXAMPLE, IF DRIVING SLOWLY, SAY AT 5 MPH, AND POWER IS NEEDED IMMEDIATELY (SUCH AS IN AN EMERGENCY OR A LANE CHANGE SITUATION), NOTHING HAPPENS FOR OVER 3 SECONDS WHEN THE ACCELERATOR PEDAL IS DEPRESSED, FOLLOWED BY A DANGEROUS LURCH WHEN POWER IS DELIVERED SUDDENLY. THIS IS A HIGHLY DANGEROUS AND UNACCEPTABLE CONDITION. I SPOKE TO THE DEALER, WHO DISMISSED MY COMPLAINT AND CLAIMED THAT "ALL CARS ARE THE SAME THESE DAYS". THIS IS A REGULAR PROBLEM THAT OCCURS MULTIPLE TIMES EVERY DAY.

NHTSA ODI #10946634

400 miles · Jan 7, 2017
Power Train

WHEN ACCELERATING THE CAR BOGS DOWN. IT HAPPENS RANDOMLY. DANGEROUS IF YOU ARE MAKING A LEFT HAND TURN WITH ONCOMING TRAFFIC. YOU CAN GET STUCK IN THE INTERSECTION.

NHTSA ODI #10940343

450 miles · Dec 19, 2016
Power Train

WHEN DOING A LOW SPEED TURN,AND DRIVE MODE SWITCH IS IN ECO MODE,WAY TOO MUCH LAG TIME BEFORE VEHICLE ACCELERATES.YOU PUSH ACCELERATOR PEDAL DOWN ,NORMALLY,AND VEHICLE DOES NOT SPEED UP ,INSTANTLY.SOMETIMES,IT IS A FULL SECOND BEFORE VEHICLE STARTS TO GAIN SPEED.THAT IS DANGEROUS WHEN VEHICLES ARE APPROACHING YOU.I HAVE HAD THE…

Read full complaint

WHEN DOING A LOW SPEED TURN,AND DRIVE MODE SWITCH IS IN ECO MODE,WAY TOO MUCH LAG TIME BEFORE VEHICLE ACCELERATES.YOU PUSH ACCELERATOR PEDAL DOWN ,NORMALLY,AND VEHICLE DOES NOT SPEED UP ,INSTANTLY.SOMETIMES,IT IS A FULL SECOND BEFORE VEHICLE STARTS TO GAIN SPEED.THAT IS DANGEROUS WHEN VEHICLES ARE APPROACHING YOU.I HAVE HAD THE VEHICLE ONLY THREE WEEKS,AND THIS CAN BE EXTREMELY DANGEROUS.I TRADED IN A LIKE MODEL VEHICLE,WHICH WAS A 2013 YEAR,AND IT DID NOT HAVE THAT ISSUE IN ECO MODE.THIS ISSUE MUST BE FIXED.

NHTSA ODI #10936377

3,000 miles · Nov 19, 2016
Power Train

INTERMITTENTLY SINCE PURCHASING THE VEHICLE ON 3/28/16, WHEN ACCELERATING FROM A STOP (EG. MERGING INTO TRAFFIC), USUALLY TURNING TO THE RIGHT OR LEFT, THE VEHICLE HESITATES FOR WHAT SEEMS TO BE MORE THAT A COUPLE OF SECONDS. THE HESITATION IS ENOUGH TO CAUSE PANIC THAT ONCOMING TRAFFIC WILL HAVE TO STOP ABRUPTLY TO AVOID A COL…

Read full complaint

INTERMITTENTLY SINCE PURCHASING THE VEHICLE ON 3/28/16, WHEN ACCELERATING FROM A STOP (EG. MERGING INTO TRAFFIC), USUALLY TURNING TO THE RIGHT OR LEFT, THE VEHICLE HESITATES FOR WHAT SEEMS TO BE MORE THAT A COUPLE OF SECONDS. THE HESITATION IS ENOUGH TO CAUSE PANIC THAT ONCOMING TRAFFIC WILL HAVE TO STOP ABRUPTLY TO AVOID A COLLISION. ON ONE OCCASION, THE VEHICLE WAS PULLED OFF THE SIDE OF THE ROAD TO GET OUT OF THE WAY OF TRAFFIC BECAUSE IT WOULD NOT ACCELERATE FAST ENOUGH. THE CONDITION IS VERY WORRISOME BECAUSE YOU NEVER KNOW WHEN IT WILL OCCUR, WE CAN'T SEEM TO MAKE IT HAPPEN ON COMMAND. THE 3.3L V6 IS VEY PEPPY WHEN EVERYTHING IS WORKING RIGHT, BUT YOU LOSE CONFIDENCE IN IT WHEN THESE HESITATION EVENTS OCCUR. ADDITIONALLY, WE HAVE NOTICED THAT THE VEHICLE HAS A HARD TIME SELECTING A GEAR WHEN DOWNSHIFTING WHILE MOVING AT AROUND 30-40 MPH. WHAT HAPPENS IS THE TRANSMISSION SEEMS TO STAY IN A "FLOAT" CONDITION FOR AN EXTENDED PERIOD OF TIME AND FINALLY WILL SELECT THE GEAR AND ACCELERATE. DON'T KNOW IF THE TWO CONDITIONS ARE RELATED, BUT BOTH ARE SCARY WHEN ACCELERATION DOESN'T HAPPEN WHEN YOU PRESS THE ACCELERATOR PEDAL. THE DATE OF WHEN THIS HAPPENED IS FOR THE MOST RECENT.

NHTSA ODI #10927069

Official recalls

6

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V578000 · Engine And Engine Cooling:engine

Sep 20, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.

Consequence & remedy

Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.

Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

17V142000 · Tires:pressure Monitoring And Regulating Systems

Mar 6, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: An underinflated inflated tire can increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.

16V842000 · Electrical System:wiring; Trailer Hitches

Nov 21, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Additional source detail variants (2)

Trailer Hitches

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Electrical System:wiring

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

16V145000 · Seat Belts:front:warning Light/devices

Mar 10, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP24001 · 3.3L Engine Loss Of Motive Power (lomp)

Opened Feb 8, 2024 · Closed May 16, 2024

Status: closed (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data.  It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident.  The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership.  A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil.  This maintenance reminder will help reinforce the need for proper oil maintenance intervals.  Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning.  These actions will help limit negative consumer incidents related to loss of motive power.  Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition.  The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition.  The agency reserves the right to take additional action if warranted by future circumstances.  To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.