2017 Hyundai Santa Fe

Vehicle: 2017 Hyundai Santa Fe On June 9, 2024, when my wife started the vehicle, the engine was immediately knocking. Due to concern for safety and the risk of catastrophic engine failure, the vehicle was not driven and was towed to our home to prevent further damage. Hyundai was contacted shortly after discovery of the issue. During a phone call, we were told there were no active recalls applicable to our vehicle and no replacement engines available. Due to the lack of immediate support and the vehicle being undrivable, we were forced to send the vehicle to a third-party mechanic on June 14, 2024, to complete a necessary engine repair. On August 21, 2024, we received warranty documentation from Hyundai related to this issue. Despite providing all requested documentation and Hyundai contacting the third-party mechanic directly, the warranty claim process was repeatedly delayed. We were told multiple times that the case was in its final stage, only to later be assigned a new case manager with no knowledge of the case, requiring the process to restart. The vehicle was not returned to us until April 7, 2025, resulting in an extended loss of our primary vehicle for our family. We paid approximately $10,000 out of pocket for the engine repair while the warranty claim remained unresolved. We have since been informed that Hyundai may require the engine to be repaired or replaced again by a dealer with no reimbursement, potentially rendering the previous repair and financial loss unnecessary. This raises serious concerns regarding Hyundai’s handling of a known engine issue and their warranty process. Hyundai Case Number: XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased my 2017 Hyundai Santa Fe Sport secondhand from CarMax and have maintained it regularly with timely oil changes and tune‑ups. Despite this, the vehicle is burning oil at an extreme rate—approximately 1 quart every 378 miles. My local Hyundai dealership confirmed this through three consecutive 1,000‑mile oil consumption tests, all showing excessive oil loss far beyond normal operating limits. This level of consumption appears to indicate an internal engine defect, not normal wear. Hyundai corporate denied my case solely because I am the second owner, even though the vehicle is well under 100,000 miles and the defect has been verified by their own technicians. The denial did not address the confirmed test results or the safety implications. I am deeply concerned that the engine could seize while driving due to rapid oil loss, creating a serious risk of sudden loss of power, stalling, or inability to accelerate in traffic. This is a significant safety hazard for me, my passengers, and other drivers. The vehicle has been inspected by the Hyundai dealership, and I am fully willing to make it available for further inspection. A low‑oil warning lamp appeared far earlier than expected after a routine oil change, which prompted the initial investigation and ultimately revealed the defect. Based on my research, this appears to be a known issue affecting Hyundai GDI engines from this era. I am filing this report because the excessive oil consumption represents a latent engine defect with clear safety implications, and Hyundai has declined to address it despite documented evidence.

Check engine code called issue for cam shaft position error. Replaced sensor, still failing. After reading online forums found that the smaller engine had oil consumption issues, I decided to check oil level, No low oil light, dip stick showed very low oil even though had been to service at Hyundai all correct service intervals. Filled oil to proper level numerous times over last year, monitor it every two weeks. Some times totally fine no oil loss and many other times it continues to have excessive oil consumption. Now randomly smell gas in cabin while driving. Reading online again and the issue is becoming more well documented by users but Hyundai has not yet acknowledged issue with this 3.3L engine. Now the gas mileage head dropped significantly which gives further indication that the piston rings are allowing oil and gas to pass by. This can lead to cam shaft bearings to wear prematurely, other mechanical parts wearing or seizing, including the engine itself for a compete engine failure, a significant risk.

I have a 2017 Hyundai Santa Fe with ~88,000 miles. I noticed on 12/18/2025 that the oil lamp light came on briefly then turned off. So, I decided to take my car in to get serviced on 12/19/2025. I was told that there is an oil consumption issue with the engine and that Hyundai would need to do a combustion cleaning, and worst case scenario a full engine replacement. Hyundai refuses to cover us under warranty because we transferred the car from my Mother-in-Law's name to my wife's name. I want to file this as a complaint to the NHTSA because a car that isn't even 10-years old AND has less than 90,000 miles should not be needing an engine replacement. Hyundai appears to be aware of the issue as my service advisor at the dealership has mentioned that several of their cars with this engine have the exact same issue. To me, this sounds like a defect and should have a recall.

Check engine light came on Oil Light came on then the vehicle shut off while I was driving. Safety was not good as I was driving the vehicle. I then had it towed to a shop to have it looked at. That is when I was told I would need a new motor due to a Crankshaft failure. The check engine light had come on the night before but when turning the vehicle on the next morning to take it to get looked at it was no longer on. Was driving it too the shop to have it looked at when it shut off on me while driving.

While driving- in total movement- the car completely shut off. Without any prior warning or indication. Immediately after, the car restarted, drove a couple blocks over, continuing to shut off while driving. It was then towed. How was your safety or the safety of others put at risk? The warning lights did not appear until AFTER the car quit. They all came on & flashed & quickly went back out. Uncertain which component misfired or is affected- possibly related to an engine or fuel/ cylinder failure. Car is at mechanic for inspection. Our safety & lives were in critical jeopardy as the vehicle stopped without warning while driving in traffic congested area. It is unknown if this is a known issue or if this situation has been replicated however the current mechanic facility has experienced the same issue with this vehicle. Also strong odor of gas was experienced during shutoff.

“My 2017 Hyundai Santa Fe Sport 2.4 has been experiencing severe oil consumption issues for a long time. I previously completed a combustion chamber cleaning service as recommended, but the problem continued. On November 10, the Hyundai dealership confirmed the engine oil was low and topped it off. On December 10, the oil was completely empty again with no warning lights. The dealer has documented the issue and recommended an engine replacement, but Hyundai is refusing to approve the repair . The vehicle continues to lose oil rapidly, creating a serious safety risk of engine failure or stalling while driving. This appears to be a known safety-related engine defect affecting this model.”

My vehicle has never missed an oil change or maintenance event yet at my last oil change my engine had burned through all its oil and no low oil light or check engine light came on. Hyundai is refusing to cover it under their warranty stating it occurred due to maintenance neglect even though all oil changes and maintenance events receipts were provided to Hyundai and are available in car fax.

# **NHTSA Complaint Answers** ### **1. What component or system failed or malfunctioned, and is it available for inspection upon request?** The **engine** failed due to **sudden and extreme oil consumption** that resulted in the engine being completely dry of oil despite regular maintenance. This caused internal damage including **CVVT (Continuous Variable Valve Timing) system failure**, bearing damage, and a complete engine seizure. Yes, the failed engine is fully available for inspection upon request. The vehicle is currently located at Dick Smith Hyundai in Greenville, South Carolina, where the dealership diagnosed the failure and recommended a full engine long block replacement. ### **2. How was your safety or the safety of others put at risk?** The engine failure occurred **suddenly and without warning**, causing the vehicle to lose power while operating. The loss of engine function created the risk of: * sudden deceleration in traffic, * inability to accelerate or maneuver, * potential rear-end collision, * complete engine stall in unsafe conditions. The vehicle had **no oil warning light** prior to the failure, meaning I had no indication that the engine was at risk until the failure occurred. ### **3. Has the problem been reproduced or confirmed by a dealer or independent service center?** Yes. The engine failure was confirmed by: • **Schwab’s Automotive** in Fayetteville, NC – determined the engine suffered catastrophic internal damage and was not repairable. • **Dick Smith Hyundai** dealership – confirmed **high oil consumption and CVVT damage**, and recommended a full **engine long block replacement** (estimate: $8,160.60). The problem has been fully verified by both an independent mechanic and an authorized Hyundai dealership. ## **4.Yes.The vehicle was formally inspected by Hyundai Motor America through the dealership’s diagnostic report. Hyundai reviewed the case (Case #XXX) after receiving the dealership findings.The engine remains intact avai. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF IN