2017 Hyundai Santa Fe. While driving, the vehicle stopped accelerating. The vehicle operated appropriately until half way through the drive. At stops, it would take several seconds (30ish) for the car to go about 20 mph (rough estimate). The car would not go above 50mph, and this took a few minutes to reach with the gas pedal a…
Read full complaint
2017 Hyundai Santa Fe. While driving, the vehicle stopped accelerating. The vehicle operated appropriately until half way through the drive. At stops, it would take several seconds (30ish) for the car to go about 20 mph (rough estimate). The car would not go above 50mph, and this took a few minutes to reach with the gas pedal all the way down. I parked the car and had it towed. After approximately a month at the dealership, the dealership text that there was a hole in the valve cover and that the engine would also need to be replaced. They did not say what was wrong with the engine and later stated, also via text, that to do a diagnostic it would be $350. I purchased the car used with approximately 45000 miles 10 months prior. At the time of the incident, there were 62000 miles on the vehicle. They stated that it would not be covered under warranty because I was not the original owner. I purchased the extended warranty at the time of purchase. They then filed a claim with that policy and we are awaiting an inspector to look at the vehicle. There were no warning lights prior to the issue. My family, husband and 3 children were in the car and it was dangerous because we were on a busy road and the car would not go to the speed of traffic. We are awaiting an inspector to look at the vehicle. The vehicle is currently still at the dealership. If requested, I am willing to have the car inspected. The incident occurred 5/12/2022.
NHTSA ODI #11471449
Mileage unknown · Jun 21, 2022
Engine
My wife was driving down Hwy 105 west in Montgomery, Texas on a 6 lane highway when all of a sudden our 2017 Hyundai Santa Fe lost power at 65mph. She could not accelerate or maintain speed and noticed several light quickly flash and then shut off. She steered into the center median and stopped in order to try and restart the c…
Read full complaint
My wife was driving down Hwy 105 west in Montgomery, Texas on a 6 lane highway when all of a sudden our 2017 Hyundai Santa Fe lost power at 65mph. She could not accelerate or maintain speed and noticed several light quickly flash and then shut off. She steered into the center median and stopped in order to try and restart the car. There was no warning to this issue and the Santa Fe could not be restated and had to be towed to Weisner Hyundai in Conroe Texas to be diagnosed. It was revealed the knock sensor that was supposed to put the vehicle in safe mode so engine damage would not occur, failed with no warning which caused excessive bearing and rod wear causing the engine failure which could have caused an wreck on the road. The Weisner Hyundai in Conroe inspected the Santa Fe and mentioned the state of the engine showed it was well maintained and no signs of sludge in the engine. There were no warning lamps on the dash or symptoms with the engine leading up to this issue. This is a major safty risk is due to the immediate loss of engine power which other cars had to quickly swerve to miss my wife as she steered to the middle median. Weisner Hyundai elected to process a PA claim with Hyundai with photos and a full report. As of today, I have do not have the full report as the service center was still in the process to filing their report.
NHTSA ODI #11470173
Mileage unknown · Jun 20, 2022
Engine
My family was driving down the interstate at approximately 78mph when the engine light came on and the vehicle began to rumble intensely. After letting off the gas to approximately 50mph and touching the gas once more we realized the vehicle was not operable. We pulled to the side of an active interstate and awaited towing. We w…
Read full complaint
My family was driving down the interstate at approximately 78mph when the engine light came on and the vehicle began to rumble intensely. After letting off the gas to approximately 50mph and touching the gas once more we realized the vehicle was not operable. We pulled to the side of an active interstate and awaited towing. We were in this spot for almost an hour hoping my wife and children were not struck by a vehicle. Additionally, as the vehicle broke we were concerned about being hit on the active interstate. Oil had been recently changed, maintenance was always kept up-to-date, no dash lights were on, and we had experienced no prior problems with the vehicle or engine. Vehicle has been inspected by a mechanic shop and a warranty representative, both of which stated the engine was dead. It now sits with a Hyundai dealership for further diagnostics testing.
NHTSA ODI #11470096
Mileage unknown · Jun 14, 2022
Engine
The check engine light came on one day and then before I could take it in to be checked, about two days, the light had turned back off again so I thought it was fine. Then, I was driving 2 hours from my home and on the way back the engine started to make a terrible knocking and screeching noise. It seemed like it was going to br…
Read full complaint
The check engine light came on one day and then before I could take it in to be checked, about two days, the light had turned back off again so I thought it was fine. Then, I was driving 2 hours from my home and on the way back the engine started to make a terrible knocking and screeching noise. It seemed like it was going to break down. I was on a country road so I quickly turned around and made my way back to a truck stop about a mile away. I had to pay to get the car towed to my local dealership an hour away. While at the dealership, after inspection, I was told it was a Rod Bearing Failure in my engine. This absolutely put me at risk as I was driving a far distance and an hour from my home. The dealership then got my service records and gave them to my extended warranty carrier- Assurant. They agreed to cover the over $10,000 cost with just my $50 copay. The car now has a different, used motor in it. My concern now is that I have had the same problem that other Santa Fe's have had in prior years but this one doesn't have a recall. Now, I'm driving with another one of these motors with worries that I'll have the same problem as before and be responsible for the fix. I asked the dealership and Hyundai USA case manager if they would warranty this new to me, used motor AND reimburse me for the 40 days that I had to pay for a rental vehicle and was told NO.
NHTSA ODI #11469150
Mileage unknown · Jun 10, 2022
Engine
While on a road trip, the engine light came on. A further check at a Hyundai authorized mechanic showed the engine had suffered from high oil consumption and ran low on oil. There was no obvious oil leak. As a result, I must replace the engine and I am unsure if Hyundai will cover the cost.
NHTSA ODI #11468677
Mileage unknown · Jun 8, 2022
Engine
My 2017 Hyundai Santa Fe with approximatelh 118,000 suffered a catastrophic engine failure. According to the dealer where the car was towed, CVVT on the camshaft caused further damage to the engine. Recommended solution is engine replacement. Dealer is quoting approximately $13,000 + taxes and fees for this replacement. I hav…
Read full complaint
My 2017 Hyundai Santa Fe with approximatelh 118,000 suffered a catastrophic engine failure. According to the dealer where the car was towed, CVVT on the camshaft caused further damage to the engine. Recommended solution is engine replacement. Dealer is quoting approximately $13,000 + taxes and fees for this replacement. I have opened a case with Hyundai and contacted my insurance company regarding possible recourse. The dealer has indicated the 10 year/100,000 mile Powertrain warranty will not cover the engine replacement as the care has 118,000 miles. There were no preliminary warning signs of engine failure. Just minutes before the car starting leaking a ton of oil, the Check Engine and Oil indicator lights went on. Car has been meticulauly maintained and serviced over the years. The car is currently at the dealer, and I have no replacement transportation provided for this vehicle. While there were no injuried, I can imagine that had I not been in a position to have the car towed, the engine failure may have resulted in dangerous driving conditions.
NHTSA ODI #11468196
Mileage unknown · Jun 6, 2022
Engine
Losing about 1QT of oil every 1k miles. The local Hyundai dealer acknowledged the issue but has no remedy. Their suggestion is to add a QT of oil at every 3k and check the level every 1k mile. I do not feel safe driving this vehicle as the engine also makes loud noises
NHTSA ODI #11467736
Mileage unknown · Jun 4, 2022
Engine
I was driving the vehicle at highway speeds, when I attempted to pass a vehicle, the engine started making a knocking sound. I had the vehicle towed to the Hyundai dealership. When they did their initial inspection, there was no oil in the engine. The engine oil had been changed by a reputable dealer within 3,000 miles. The …
Read full complaint
I was driving the vehicle at highway speeds, when I attempted to pass a vehicle, the engine started making a knocking sound. I had the vehicle towed to the Hyundai dealership. When they did their initial inspection, there was no oil in the engine. The engine oil had been changed by a reputable dealer within 3,000 miles. The vehicle is well maintained and regularly maintained. No warning lights came on to indicate low oil or any other warning light to indicate any problems with the engine at all. Manufacturer has 10yr 100,000 mile warranty for first vehicle owner, but the warranty for second owner is 5 yr 60,000 mile. There are known issues with this engine and other Hyundai GDI engines. Dealership gave me a repair bill for a used engine replacement with labor of $12,650. Manufacturer says they are not responsible for the engine since it is out of warranty (although within original manufacturer warranty). The GDI engine is faulty and dangerous. A 5 year old vehicle burning 4 quarts of oil within 3,000 miles is not user error, thats manufacturer fault and they should be held accountable for it.
NHTSA ODI #11467478
Mileage unknown · May 31, 2022
Engine
Engine failure due to "rod failing". Car lost power and RPMs. Mileage was 119325. Car always serviced at dealership. Dealership recognized the issue and referred me to customer service. Case File #1959318 was files with Hyundai Customer Service. They rejected any assistance in replacing engine citing that it was more than …
Read full complaint
Engine failure due to "rod failing". Car lost power and RPMs. Mileage was 119325. Car always serviced at dealership. Dealership recognized the issue and referred me to customer service. Case File #1959318 was files with Hyundai Customer Service. They rejected any assistance in replacing engine citing that it was more than 10% over 100,000 miles. Replaced used engine cost $10,146.04. Thomas Cumberland Invoice 6035219 (Mar 28, 2022)
NHTSA ODI #11466702
Mileage unknown · May 10, 2022
Engine
While driving to work on the highway. My car begin to stall and hesitated. There were no warning lights no indication that anything was wrong with my car. I’ve been pretty good about keeping up with the maintenance on my car. I creep into work and ask one of my mechanics to look over my car because of what happened on the highwa…
Read full complaint
While driving to work on the highway. My car begin to stall and hesitated. There were no warning lights no indication that anything was wrong with my car. I’ve been pretty good about keeping up with the maintenance on my car. I creep into work and ask one of my mechanics to look over my car because of what happened on the highway. The mechanic checked it out and found there was no oil in the car. It was not time for my scheduled oil change. He asked if any lights came on, if there was any way the oil could have leaked out. No lights came on and I park in my garage everyday, no oil leaks. I told him this isn’t the first time it happened. He put some oil in my car and I told him I was scheduled for an oil change later that week. He said ok. On my way home the engine to knock and again stall. I didn’t take the highway home. My car shut off on me just before I made it home. I decidedly to call the dealership the next day. I parked it in the garage. The next morning I was letting my dog out and there was a strong gas/engine smell in my breezeway. I opened the garage to check to see if something was visibly wrong with my car still no leakage. I brought my car to the dealership, explain what happened. While waiting I was checking on recalls and discovered this is a serious on going problems with the 2017 Santa Fe’s. The dealership quoted me at $12000 to replace the engine. I’m a single parent where am I gonna get $12000.
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
Consequence & remedy
Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An underinflated inflated tire can increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP24001 · 3.3L Engine Loss Of Motive Power (lomp)
Opened Feb 8, 2024 · Closed May 16, 2024
Status: closed (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2017 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration