Engine. Review the 643 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports23 fire reports11 injury reports

Engine complaints

643 reports

Clear category filter

Mileage unknown · Sep 23, 2023

Engine

Engine failure, crankshaft sensory did not go off and it will need a brand new engine. Only 94k miles

NHTSA ODI #11546167

Mileage unknown · Sep 20, 2023

Engine

Read full complaint

In June, I was driving my Santa Fe down the highway with my children when it suddenly died. I had no control over the vehicle. There were no warning lights on, my engine temp was not high. I was able to get it off to the side of the road. I found that the oil was almost completely empty even though I have regular oil changes and have had no leaks. I took my vehicle to Vern Eddy on Sioux City, IA, where I originally bought this vehicle. (I bought this new) They confirmed it was the rod bearings. Which is a known manufacturers defect in many of their engines that are being recalled however, not in this particular model so, they are refusing to fix it. I've looked online and seen hundreds of others with this exact engine having the exact same issue. I just want them to fix it. My children could have been seriously injured.

NHTSA ODI #11545561

Mileage unknown · Sep 1, 2023

Engine

I was driving the car and then all of a sudden I was getting a lot vibrations. It was very hard to control the car. I pulled over and had it tow to the dealer I bought it from, Herb Chambers Honda of Westborough, Massachusetts. They told me it was the fuel injection system. I had replaced, and then the same thing happened again,…

Read full complaint

NHTSA ODI #11542049

Mileage unknown · Aug 31, 2023

Engine

Car stopped suddenly and when I went to check, the oil had been completely depleted. The shop says the engine failed, most likely because the oil had evaporated. Low mileage, well maintained, so the car has a defect that can be life threatening. Thankfully, for me, it stopped in a quiet road and had to be towed. This could have …

Read full complaint

NHTSA ODI #11541822

Mileage unknown · Aug 29, 2023

Engine

Read full complaint

I've owned my 2017 Hyundai Santa Fe 3.3L V6 since late 2021. I haven't noticed it using oil. Stopped at a traffic light, the engine lost power. It was so scary! No warning lights were on my dash. I was thankful to not be rear-ended...although I could have filed an insurance claim if I had been. As it is, my insurance says it is a 'mechanical failure.' The car would not start but luckily some strangers pushed me out of the highway. I tried two different jumper cables and was able to roll up my windows but not much else. The car was towed back to hometown. At a repair shop, the mechanic told me the engine was locked. It has 97,000 miles on it and I'm the second owner so the 100K warranty doesn't apply to me. I called Hyundai and they instructed me to have the car towed to a Hyundai dealership where they 'might' help. The car sat for 2 weeks before anyone looked at it. This week, I heard from the repair shop that the engine is seized and not repairable. This model has no open engine recalls. I don't understand how this engine isn't being recalled like the other Hyundai models. I have to say that I will no longer purchase Hyundai's or recommend them to anyone else! As I still owe quite a bit on this car, I still don't know what I am going to do. The shop said they would look for an used engine with lower miles. I still haven't heard anything additional. Seems like the hens are guarding the henhouse pretty tight!

NHTSA ODI #11541423

Mileage unknown · Aug 22, 2023

Engine

Read full complaint

Driving down the highway and vehicle just shut off at a stop light. No lights of any kind on the dashboard. Started it up stayed running, checked all the gages, everything was normal. Was waiting at the red light and it turned off again. When I started it up again noticed that the oil light was on longer than the other lights, but it went out. Pulled over and checked the oil, no oil on the dip stick. Put 2 quarts of oil in it and tried to limp home. Turned off again and wouldn't restart. No warning lights. Took it to a dealership and was told the engine was seized and they knew about the oil consumption issue, but they told me that 3.3L engines weren't covered. No I still have half my car to pay for and engine replacement costs as much as the car is worth. I currently still have the vehicle and trying to figure things out.

NHTSA ODI #11540006

Mileage unknown · Aug 21, 2023

Engine

Read full complaint

I've owned my 2017 Hyundai Santa Fe 3.3L V6 since 2017, the last year, the engine has been consuming oil at a higher rate than normal. Performed an oil change in early June, it has burned 3 quarts of oil in two months. Last Thursday, 08/17/2023, the engine started knocking bad, and it lost power as the vehicle was being parked. Towed to a repair shop, waiting on inspection but it sounds like a camshaft knock, but it's terrible. It has 103,000 miles on it and I just paid it off last year. I don't understand how this engine isn't being recalled like the other Hyundai models. I have to say that I will no longer purchase Hyundai's or recommend them to anyone else.

NHTSA ODI #11539808

Mileage unknown · Aug 21, 2023

EnginePower Train

Read full complaint

My ‘17 Santa Fe has been well taken care of with regular oil changes and we have kept up with the recommended maintenance. While driving on 8/17/2023 the car started to struggle to accelerate and I heard a knocking sound. Within moments there was total engine and power failure and I had to quickly get the vehicle off the road to avoid being rear ended. There were no warning lights on until the moment it was dying. The battery light, check engine light, and oil light came on, but then the vehicle had quickly lost all power immediately after. Once it was towed to Meineke and looked over by the mechanics there it was determined that it needs a new engine and that it had very, very little oil in it.

NHTSA ODI #11539804

Mileage unknown · Aug 18, 2023

Engine

Blown engine in the middle of the highway. The car have been consuming excessive amounts of oil. I though that, if the car has the oil change done more often, the engine would be fine, but that was not the case.

NHTSA ODI #11539400

Mileage unknown · Aug 16, 2023

EngineUnknown Or Other

Read full complaint

Had oil changed July 5, 2023, Aug. 14 check engine light came on. Took it to shop and was told Hyundai vehicles are burning oil in the engine and the diagnostic code came back as Catalytic Convert and had to add oil. Have oil spots all over my drive so was told to check oil and make sure it's not low and see if light comes back on. Repair shop checked for recalls and found none for this car, yet. Daughter has 2013 Kia Rio with same problem for past couple of years. Why do recalls take so long?

NHTSA ODI #11539020

Official recalls

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V578000 · Engine And Engine Cooling:engine

Sep 20, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.

Consequence & remedy

Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.

Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

17V142000 · Tires:pressure Monitoring And Regulating Systems

Mar 6, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: An underinflated inflated tire can increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.

16V842000 · Electrical System:wiring; Trailer Hitches

Nov 21, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Additional source detail variants (2)

Trailer Hitches

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Electrical System:wiring

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

16V145000 · Seat Belts:front:warning Light/devices

Mar 10, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP24001 · 3.3L Engine Loss Of Motive Power (lomp)

Opened Feb 8, 2024 · Closed May 16, 2024

Status: closed (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.