Engine. Review the 643 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports23 fire reports11 injury reports

Engine complaints

643 reports

Clear category filter

Mileage unknown · Jun 12, 2024

Engine

Engine knocks when I try to accelerate, there is also a long hesitation and vibration when I accelerate, reduced power, engine is burning oil excessively and engine smokes.

NHTSA ODI #11593836

Mileage unknown · Jun 8, 2024

Engine

Engine started to have knocking when starting engine after long sitting while off. Later, something with engine broke and it's at dealer to look at. We regularly changed the oil but started to have mass oil consumption. Had to get a tow.

NHTSA ODI #11593249

Mileage unknown · Jun 7, 2024

Engine

Read full complaint

Driving on busy interstate no warning. No lights to indicate issue. Car stops. Looses all power. AAA towed. The engine had locked up. No oil none. Car maintained oil changes as recommended. Oil was just checked 3 days prior for long rode trip there were no oil. Leaks no Lights on dash indicating check engine There are thousands and thousands of consumers online stating the Same happened to them. The majority state Hyundai will not replace or fix repairs because of numerious reasons. The biggest is that a recall was issued to reset a code. Since purchased new in 2017 original owner , I have not received any recal notices. So if a owner does not receive notice. How is it our fault further damages aren’t covered? I am still traumitized from the car locking up on a 6 lane Highway surrounded by 70 mph plus cars trucks. Please do not allow deaths to occur before the Goverment steps in and forces Hyundai to take full responsibility for our safety. Thank you for your time

NHTSA ODI #11593006

Mileage unknown · Jun 5, 2024

Engine

Total engine failure at 120,000 miles. Car shut down without warning while driving.

NHTSA ODI #11592671

Mileage unknown · Jun 4, 2024

Engine

Read full complaint

Oil consumption issue. the car was eating 2-2.5 qts per 1,000 miles of oil. Over numerous 1,000 mile tests, it was confirmed my care was eating oil. The dealership did a combustion chamber cleaning, but the car still eats almost 1qt of oil per 1,000. I was actually told by a service advisor not to refill the oil and let the engine blow while I was driving it which is a safety issue. In my research there is a known oil consumption issue and I want Hyundai to replace my engine. I've been trying to get this rectified for almost 8k miles and am at 85K. I feel like Hyundai is trying to get me limp to 100K so my warranty is over.

NHTSA ODI #11592411

Mileage unknown · May 30, 2024

Engine

Read full complaint

My car's VIN has not been listed on the recall list for the engine, but the recall description is exactly what happened to me and my family while driving our vehicle. We have been going back-and-forth with Hyundai USA and BBBAuto for two years trying to get approval without any progress or success. We purchased our vehicle used with approximately 68k miles September of 2021, and the engine seized around 75k miles in February of 2022. Attached is the initial diagnosis reflecting the exact recall problem that happened with our engine. Hyundai confirmed the diagnosis when our car was towed there once they opened for business, but we did not receive approval for the engine replacement under the warranty. The car has been undriveable since as we await our VIN on the recall list as no one will give us approval that we've talked with about it. There is a Class Action in progress, but it has not been approved - meanwhile, our family has been without our car for years now. Any / all assistance you can offer is greatly appreciated, thank you!

NHTSA ODI #11591598

Mileage unknown · May 29, 2024

Engine

Read full complaint

While highway driving a few hours from home, the car started shaking so I pulled over, turned the car off & called AAA. Prior to that, there were no warning lights or messages, until it died & the Check Engine light turned on. The car was towed to a Hyundai dealer in Wilmington, NC for diagnostics. They determined that the cause was a burned valve in cylinder 4 so it had no compression & the engine would not run. Their only repair option was to REPLACE THE ENTIRE ENGINE. Given that the car was inoperable, we had no choice but to do that. After further investigation, we discovered that this company has a widespread issue with their engines & also has a class-action lawsuit for similar problems. Hyundai mechanics have told us that they know their engines are problematic & they replace multiple ones every day of the week. A Facebook Group with discussions about Hyundai engine failures was formed & currently has over 26,000 members! Many of their experiences are similar to ours & it puts drivers at great risk as their car randomly dies on the road during normal driving. Our engine failure did not specifically meet the criteria of their lawsuit terms (naming rod bearings as the cause of engines failure) so Hyundai will not assist with any replacement costs. As a 2017 model with only 103,000 miles, the car is relatively young, compared to other better manufactured brands, especially for entire engine failure. Hyundai Mechanics and Service Personnel have told us that is typical lifespan for the Hyundai engine so if that is the case, the company should be required to reveal that information to consumers or cease making a product that has at least half the shelf-life of most auto manufacturers. The car was purchased for $21,000 & now requiring a $6,000 engine to be operable again (plus temporary car rentals) puts us underwater with the cost of this vehicle. It's reprehensible & should be illegal for car manufacturers like Hyundai to be able to treat customers this way.

NHTSA ODI #11591350

Mileage unknown · May 29, 2024

Engine

Something in the engine failed while driving 55mph on a state highway my vehicle started knocking. I have also noticed metal shavings when I checked the oil. I have had a local mechanic look at my vehicle and told me that I need an engine replacement. There were no warnings or clues prior to this happening. I ha…

Read full complaint

NHTSA ODI #11591268

Mileage unknown · May 28, 2024

EngineEngine And Engine Cooling

Read full complaint

The contact owns a 2017 Hyundai Santa Fe. The contact stated that upon start the vehicle, there was an abnormal grinding noise coming from the engine. There was no warning light illuminated. The contact stated that the vehicle stalled soon after while depressing the accelerator pedal. Due to the failure, the vehicle was towed to Bell Road Mitsubishi (1901 E Bell Rd, Phoenix, AZ 85022) where the vehicle was diagnosed with engine failure. The dealer and the manufacturer were both notified of the failure and instructed the contact to tow the vehicle to the dealer. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 17V578000 (Engine and Engine Cooling). The vehicle remained in the possession of the dealer where it was towed. The failure mileage was unknown.

NHTSA ODI #11591123

Mileage unknown · May 27, 2024

Engine

Read full complaint

Our car started making noises and hesitating while revving engine to increase speed. Two days later we took the car to our mechanic. No warning lights. They test drove the car but apparently couldn't replicate the issue. Tried again and couldn't start engine. They thought it may be the starter. A new starter did not solve issue. They called us back and said the engine has locked up. It wasn't a safety issue as the car was parked but I assume it could have been an issue if we were driving it when engine locked up. We regularly change the oil. We have approx. 109k miles on the car. An engine should last longer than that.

NHTSA ODI #11590886

Official recalls

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V578000 · Engine And Engine Cooling:engine

Sep 20, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.

Consequence & remedy

Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.

Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

17V142000 · Tires:pressure Monitoring And Regulating Systems

Mar 6, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: An underinflated inflated tire can increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.

16V842000 · Electrical System:wiring; Trailer Hitches

Nov 21, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Additional source detail variants (2)

Trailer Hitches

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Electrical System:wiring

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

16V145000 · Seat Belts:front:warning Light/devices

Mar 10, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP24001 · 3.3L Engine Loss Of Motive Power (lomp)

Opened Feb 8, 2024 · Closed May 16, 2024

Status: closed (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.