Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
550–25K
2825–50K
5350–75K
7775–100K
54100–150K
11150K+
278 reports with mileage · 80 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports5 fire reports15 injury reports
What owners actually said
358 reports
Mileage unknown · May 9, 2016
Service Brakes
THERE IS A CURRENT RECALL FOR THIS MAKE AND MODEL CAR TO REPLACE THE BRAKE LAMP SWITCH FOR SAFETY REASONS BUT IT DIDN'T INCLUDE MY VIN FOR SOME REASON, EVEN THOUGH THE EXACT SAME THING HAPPENED ON MY VEHICLE. THE BRAKE LAMP SWITCH WAS FAILING AND NEEDED TO BE REPLACED. I DON'T UNDERSTAND WHY THE RECALL WOULDN'T BE FOR MY CAR AS…
Read full complaint
THERE IS A CURRENT RECALL FOR THIS MAKE AND MODEL CAR TO REPLACE THE BRAKE LAMP SWITCH FOR SAFETY REASONS BUT IT DIDN'T INCLUDE MY VIN FOR SOME REASON, EVEN THOUGH THE EXACT SAME THING HAPPENED ON MY VEHICLE. THE BRAKE LAMP SWITCH WAS FAILING AND NEEDED TO BE REPLACED. I DON'T UNDERSTAND WHY THE RECALL WOULDN'T BE FOR MY CAR AS WELL AS IT'S THE SAME SAFETY CONCERN.
NHTSA ODI #10864007
Mileage unknown · May 9, 2016
Fuel/propulsion System
AFTER FUELING MY CAR, THE GAS GAUGE IMMEDIATELY DROPPED TO EMPTY AND THE LIGHT WOULD COME ON. WHILE DRIVING IT WOULD THEN SLOWLY CREEP UP TO ABOUT 3/4 OF A TANK. AT THE HALF WAY MARK, IT WOULD GO UP AND DOWN GRADUALLY SO THAT I COULD NEVER TRUST HOW MUCH GAS WAS TRULY IN MY TANK, LEADING ME TO ALWAYS WANT TO REFUEL AT THE HALFWA…
Read full complaint
AFTER FUELING MY CAR, THE GAS GAUGE IMMEDIATELY DROPPED TO EMPTY AND THE LIGHT WOULD COME ON. WHILE DRIVING IT WOULD THEN SLOWLY CREEP UP TO ABOUT 3/4 OF A TANK. AT THE HALF WAY MARK, IT WOULD GO UP AND DOWN GRADUALLY SO THAT I COULD NEVER TRUST HOW MUCH GAS WAS TRULY IN MY TANK, LEADING ME TO ALWAYS WANT TO REFUEL AT THE HALFWAY MARK. THIS HAPPENED CONTINUALLY IN BETWEEN FUELING AND NEVER CORRECTED ITSELF.
NHTSA ODI #10863847
64,500 miles · Apr 22, 2016
Unknown Or Other
THERE HAS BEEN NUMEROUS INSTANCES WHEN MY VEHICLE HAS A FULL TANK AND DURING DRIVING THE GAUGE SUDDENLY INDICATE AN EMPTY TANK. THE CHECK ENGINE LIGHT COMES ON ON FURTHER INVESTIGATION I HAVE DISCOVERED THAT THIS IS A COMMON ISSUE WITH THIS MAKE VEHICLE. I AM AFRAID OF TRAVELLING I BELIEVE THAT THIS ISSUE NEEDS TO BE INVESTI…
Read full complaint
THERE HAS BEEN NUMEROUS INSTANCES WHEN MY VEHICLE HAS A FULL TANK AND DURING DRIVING THE GAUGE SUDDENLY INDICATE AN EMPTY TANK. THE CHECK ENGINE LIGHT COMES ON ON FURTHER INVESTIGATION I HAVE DISCOVERED THAT THIS IS A COMMON ISSUE WITH THIS MAKE VEHICLE. I AM AFRAID OF TRAVELLING I BELIEVE THAT THIS ISSUE NEEDS TO BE INVESTIGATED AS IT COULD CAUSE A SAFETY ISSUE FOR DRIVERS WHO MAKE THE ASSUMPTION THAT THIS IS ONLY A SENSOR PROBLEM AND CONTINUE DRIVING AND SUDDENLY STALL IN THE MIDDLE OF THE ROAD.
NHTSA ODI #10860915
65,000 miles · Mar 28, 2016
Fuel/propulsion System
AT APPROX 65000 MILES OF NORMAL DRIVING FUEL GAUGE BECAME ERRATIC AND UNRELIABLE. GUAGE READS ANYWHERE FROM FULL TO ONE EIGHTH AND FLUCTUATES ALMOST CONSTANTLY REGARDLESS OF ACTUAL FUEL LEVEL. CHECK ENGINE LIGHT ON PRODUCED ERROR CODE P0464. THIS IS A DANGEROUS SITUATION.
NHTSA ODI #10852072
Mileage unknown · Mar 10, 2016
Air Bags
TL* THE CONTACT OWNS A 2009 HYUNDAI SANTE FE. THE CONTACT STATED THAT THE AIR BAG LIGHT WAS CONSTANTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
NHTSA ODI #10846030
77,000 miles · Mar 5, 2016
Fuel/propulsion System
CK ENGIN LIGHT COMES ON CODE P0464 NOT A LL UNCOMMON.
NHTSA ODI #10840025
Mileage unknown · Jan 28, 2016
Fuel/propulsion System
CHECK ENGINE LIGHT CAME ON. FUEL GAUGE READ EMPTY. I HAD JUST FILLED UP A DAY OR SO PRIOR. I TOOK TO MY MECHANIC HE SAID THAT IT IS THE FUEL SENSOR. SO I FILL UP THE CAR AND RESET MY TRIP TO 0 EVERY TIME I FILL UP NOW. OTHERWISE I HAVE NO IDEA HOW MUCH GAS IS IN THE CAR...THE FUEL GAUGE JUMPS AROUND...SOMETIMES IT SAYS HALF EMPT…
Read full complaint
CHECK ENGINE LIGHT CAME ON. FUEL GAUGE READ EMPTY. I HAD JUST FILLED UP A DAY OR SO PRIOR. I TOOK TO MY MECHANIC HE SAID THAT IT IS THE FUEL SENSOR. SO I FILL UP THE CAR AND RESET MY TRIP TO 0 EVERY TIME I FILL UP NOW. OTHERWISE I HAVE NO IDEA HOW MUCH GAS IS IN THE CAR...THE FUEL GAUGE JUMPS AROUND...SOMETIMES IT SAYS HALF EMPTY...SOMETIMES IT SAYS LOW FUEL LIGHT. THIS IS A DANGEROUS AND EXPENSIVE SITUATION...THE FUEL SENSORS SHOULD NOT FAILING! I SEE THAT MAY OTHER PEOPLE ARE EXPERIENCING THE SAME PROBLEM...ALTHOUGH THIS FIRST HAPPENED OVER THE SUMMER THE PROBLEM IS ONGOING AND APPARENTLY WIDE SPREAD.
NHTSA ODI #10822841
129,500 miles · Dec 29, 2015
EnginePower TrainService Brakes
VEHICLE INSPECTION PERFORMED BY MANUFACTURE CERTIFIED TECHNICIAN. TWO ISSUES WERE RECOMMENDED BY THE TECHNICIAN: A) NEW TIRES. ALL 4 TIRES CURRENTLY ON THE VEHICLE ARE AROUND 5 YEARS OLD (BASED ON THE DOT DATE OF MANUFACTURE), AND HAVE BEEN DRIVEN FOR OVER 100,000 MILES (BASED ON ODOMETER READINGS FROM 2010 AND CURRENT). B) NEW …
Read full complaint
VEHICLE INSPECTION PERFORMED BY MANUFACTURE CERTIFIED TECHNICIAN. TWO ISSUES WERE RECOMMENDED BY THE TECHNICIAN: A) NEW TIRES. ALL 4 TIRES CURRENTLY ON THE VEHICLE ARE AROUND 5 YEARS OLD (BASED ON THE DOT DATE OF MANUFACTURE), AND HAVE BEEN DRIVEN FOR OVER 100,000 MILES (BASED ON ODOMETER READINGS FROM 2010 AND CURRENT). B) NEW REAR BRAKE PADS AND ROTORS. THE INSPECTION REVEALED REAR PADS AROUND 3 MM, AND ROTORS SHOWING RUST. THESE ARE SAFETY ISSUES, WHICH SHOULD BE ADDRESSED BEFORE SELLING THE VEHICLE. REGULAR MAINTENANCE HAS BEEN PERFORMED ON THIS VEHICLE, BUT EXISTING RECORDS DO NOT SPECIFY THAT RECOMMENDED FLUID/TIMING BELT REPLACEMENTS WERE PERFORMED.
NHTSA ODI #10816777
106,000 miles · Dec 23, 2015
Unknown Or OtherFire
VEHICLE CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY. VEHICLE HAD NOT BEEN DRIVEN FOR APPROXIMATELY 4 HOURS.
NHTSA ODI #10811957
106,000 miles · Dec 20, 2015
Electrical SystemEngineUnknown Or Other
I NOTICED THAT WHEN I WAS IN PARK, THE CAR WOULD JUST SHUT OFF. THIS HAPPENED THREE TIMES WITHIN A FEW WEEK'S TIME. I WAS CONCERNED AND WONDERED IF THE CAR WOULD EVER JUST SHUT OFF WHILE I WAS DRIVING ON THE FREEWAY OR A BUSY STREET. TO MY HORROR, IT HAPPENED! A FEW DAYS AGO I WAS TURNING INTO A PARKING LOT AND THE CAR JUST …
Read full complaint
I NOTICED THAT WHEN I WAS IN PARK, THE CAR WOULD JUST SHUT OFF. THIS HAPPENED THREE TIMES WITHIN A FEW WEEK'S TIME. I WAS CONCERNED AND WONDERED IF THE CAR WOULD EVER JUST SHUT OFF WHILE I WAS DRIVING ON THE FREEWAY OR A BUSY STREET. TO MY HORROR, IT HAPPENED! A FEW DAYS AGO I WAS TURNING INTO A PARKING LOT AND THE CAR JUST SHUT OFF!...THERE WAS A CAR BEHIND ME THAT CAME TO A SCREECHING HALT! AGAIN MY GREATEST FEAR IS THAT THE CAR WILL STALL ON ME WHILE THE VEHICLE IS IN MOTION AND IF THAT HAPPENS ON A ROAD WHERE CARS ARE TRAVELLING AT HIGH SPEEDS, THEN I WOULD PROBABLY NOT LIVE TO TELL THE STORY.
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Hyundai is recalling certain model year 2007 through 2009 Santa Fe vehicles manufactured from April 19, 2006, through July 7, 2008. The occupant classification system (OCS) may need recalibration to accurately detect small statured adults.
Consequence & remedy
Consequence: Improper classification or detection may cause the front passenger airbag not to deploy in the event of a crash, increasing the risk of injury to the front passenger.
Remedy: Hyundai will notify owners, and dealers will update the classification software free of charge. The safety recall began on September 7, 2012. Owners may contact Hyundai at 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
2009 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration