2008 Hyundai Santa Fe

I STARTED MY VEHICLE AND THE FUEL GAUGE BEGAN TO MOVE UP AND DOWN, SHOWING EMPTY, THEN OVER HALF FULL, THEN JUST UNDER HALF. I SWITCHED TO THE MODE INDICATING HOW MANY MILES LEFT UNTIL I WOULD BE OUT OF GAS, WHICH ALSO FLUCTUATED BY OVER 75 MILES. THIS FLUCTUATION IS CONSISTENT AND NOW IS BECOMING A BIG CONCERN IN REGARDS TO LONGER TRIPS MY YOUNG FAMILY TAKES. THIS OBVIOUSLY IS A KNOWN PROBLEM, BASED ON THE NUMEROUS COMPLAINTS REGISTERED ABOUT THIS SAME MALFUNCTION. SHOULD MY FAMILY BE STRANDED ON A ROADSIDE, OR WORSE YET, GET INTO AN ACCIDENT DUE TO THIS PROBLEM, HYUNDAI WILL BE HELD RESPONSIBLE FOR NEGLIGENCE ON THEIR PART TO ACT ON A KNOWN VEHICLE DEFECT. *TR

AT APPROXIMATELY 60000 MILES,I NOTICED THAT MY FUEL GAUGE WAS NOT REGISTERING CORRECTLY. WOULD FILL IT UP AND THE GAUGE WOULD REGISTER A 1/4 TANK, PROBLEM GOT WORSE IN THE PROCEEDING WEEKS. CHECK ENGINE CAME ON TOOK IT TO AUTO PARTS PLACE AND THEY SAID THE FUEL SENSORS WERE BAD. TOTAL COST TO REPAIR $440. NO HELP FROM DEALER. EXTENDED WARRANTY NOT HELPFUL EITHER. *TR

OUR USED SANTA FE'S WARRANTY EXPIRED ON APRIL 28TH, 2013. A MONTH LATER, THE FUEL GAUGE AND MILEAGE REPORTING STARTED TO FLUCTUATE WILDLY, AND FOR THE PAST MONTH WE'VE UNDERSTOOD THAT THE FUEL SENSOR ASSEMBLY IS FAULTY. THE ACCURATE REPORTING OF THE FUEL LEVEL IS NOW IMPOSSIBLE AND IT IS CLEAR TO US THAT THIS WILL BE AT LEAST A $600 REPAIR JOB. HYUNDAI DEFLECTED OUR E-MAILS TO THEM, SO I ENCOURAGE FOLKS TO ALSO WRITE A LETTER TO THEM BY POSTAL MAIL. THE ADDRESS THEY GAVE US IS HYUNDAI MOTOR AMERICA P. O. BOX 20850 FOUNTAIN VALLEY, CA 92728-0850. IT IS RIDICULOUS TIMING THAT THIS OCCURS AFTER AN EXPENSIVE MAINTENANCE APPOINTMENT AND RIGHT AFTER THE SECOND-OWNER WARRANTY EXPIRED. A SYSTEM LIKE THIS SHOULD NOT FAIL WITH ONLY 44K MILES ON A VEHICLE, AND HYUNDAI CAN'T CONVINCE ME OTHERWISE. THIS NEEDS TO BE A RECALL, AND OWNERS WHO HAVE GONE AHEAD AND DONE THIS REPAIR FOR EXORBITANT FEES NEED TO BE REIMBURSED. IN RECENT NEWS, ASIANA AIRLINES REPRESENTED THE HONOR AND INTEGRITY OF KOREAN CORPORATE CULTURE, I'D EXPECT THE SAME FROM HYUNDAI WHO HAS THUS FAR FAILED IN THEIR DUTY TO THE CUSTOMER. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH THE VEHICLE UNEXPECTEDLY FAILED TO ACCELERATE WITH THE ILLUMINATION OF THE ESC AND ENGINE WARNING INDICATOR. THE ENGINE WAS TURNED OFF. THE VEHICLE RESUMED UPON RESTARTING; HOWEVER, THE ENGINE WARNING INDICATOR REMAINED ILLUMINATED. THE FAILURE RECURRED EIGHT TIMES. IN ADDITION, ON NUMEROUS OCCASIONS WHEN DEPRESSING THE ACCELERATOR PEDAL HESITATION WOULD FOLLOW. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V113000 (EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC). THE RECALL REMEDY WAS PERFORMED ON TWO OCCASIONS AND THE FAILURE PERSISTED AFTER EACH REPAIR. THE VEHICLE WAS CURRENTLY BEING REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 92,099.

ERRATIC FUEL GAUGE FOR SEVERAL MONTHS. VEHICLE IS OUT OF WARRANTY FOR THIS WHEN I CALLED DEALERSHIP. FUEL GAUGE WILL GO BELOW 'E' TO 1/2 TANK IN SECONDS. SOMETIMES WHEN TURNING THE CAR ON, THE GAUGE IS BELOW 'E' AND WILL STAY THERE FOR A WHILE THEN GO BACK UP TO GAS LEVEL. CHECK ENGINE LIGHT HAS COME ON SAYING THERE IS A PROBLEM WITH THE FUEL SYSTEM. CLEARED CODE. IT STAYED OFF FOR WEEK OR SO, AND HAS COME BACK ON. I HOPE THIS BECOMES A RECALL...TOO MANY PEOPLE WITH THE SAME PROBLEM! *TR

AS NOTED IN OTHER COMPLAINTS, MY CHECK ENGINE LIGHT CAME ON AND MY FUEL GAUGE WILL NOT REGISTER THE AMOUNT OF FUEL, IT FLUCTUATES FROM EMPTY TO A 1/4 TANK TO 3/4 TANK. THE FUEL SENSORS ARE BAD. THERE SHOULD BE A RECALL FOR THIS. THIS IS A KNOWN PROBLEM BASED ON NHTSA COMPLAINTS BUT YET IT APPEARS THAT HYUNDAI WILL NOT TAKE ACTION. THIS PROBLEM BEGAN RIGHT AFTER I HIT THE 60,000 MILE MARK. *TR

WHILE DRIVING FROM MARSHALL, NC TO ASHEVILLE, NC, MY WIFE AND I WERE DRIVING AT APPROXIMATELY 55-60 MILES PER HOUR WHEN THEN ENGINE WARNING LIGHT CAME ON. THE FUEL TANK WAS FULL AND THE FUEL GAUGE STARTED TO ACT CRAZY TELLING ME THAT THE TANK WAS EMPTY. UPON NOTICING THIS PROBLEM, I IMMEDIATELY CALLED HYUNDAI AND THEY SAID TO BRING IT IN. WHEN I TOOK IT IN, THEY RAN A DIAGNOSTIC FOR $45.00 AND CAME BACK AND TOLD ME THAT BOTH FUEL SENSORS HAD GONE OUT. THEY PROCEEDED TO TELL ME THAT THE JOB WOULD COST AROUND $600.00 OR SO. I TOLD THEM THAT WAS ABSOLUTELY RIDICULOUS AND THAT IT SHOULD NOT HAVE HAPPENED ESPECIALLY ON A VEHICLE THAT IS NOT THAT OLD. I WENT HOME AND LOOKED THE PROBLEM UP ON LINE, ONLY TO FIND THAT THERE ARE MANY PEOPLE OUT THERE THAT HAVE HAD THE EXACT SAME PROBLEM, SOME EVEN WITH NEWER HYUNDAI VEHICLES. MY WIFE AND I FEEL THAT THIS SHOULD BE A RECALL AND SAFETY ISSUE ITEM. IF THIS MANY PEOPLE ARE HAVING THIS PROBLEM, THEN OBVIOUSLY THIS IS A MANUFACTURING PROBLEM. THIS SITUATION IS NOT SAFE BECAUSE IF THIS HAPPENS TO SOMEONE WHEN THEIR FUEL MAY BE LOW, THEY MAY BE DRIVING ALONG AND STALL IN THE MIDDLE OF THE HIGHWAY OR THEY MAY BE IN A REMOTE AREA. *TR

MY FUEL GAUGE IS VERY ERRATIC ;WE NEVER KNOW HOW MUCH FUEL WE HAVE.IT FLUCTUATES FROM FULL TO EMPTY AT WILL CAUSING US TO TRY TO JUDGE BY THE MILES DRIVEN OR FILL UP EVERY FEW DAYS. I WOULD HATE TO RUN OUT OF GAS ON AN INTERSTATE IN MIDDLE OF THE NIGHT BECAUSE OF A MISCALCULATION ON THE MILEAGE. I FEEL THIS IS A SAFETY HAZARD AND THE COMPANY SEEMS AWARE OF IT. *TR

ON 5/15/13 I HAD MY STOP LAMP SWITCH REPLACED PER RECALL CAMPAIGN 110. THE FOLLOWING DAY, I NOTICED COLD ENGINE FLUCTUATION AND SURGING. THIS HAS HAPPENED REGULARLY, WITH THE ENGINE SOMETIMES FLUCTUATING UP TO NEARLY 2000RPM WHILE THE CAR IS IN PARK. GRADUALLY, THE ISSUE PROGRESSED TO DIFFICULTY ACCELERATING AND A SHAKING/HESITATION FEELING WHILE DOWNSHIFTING THAT FEELS LIKE THE ENGINE IS GOING TO STALL OUT, BUT IT DOES NOT. THIS BEGAN 6/20/13. ALSO ON 6/20/13 MY CHECK ENGINE DASH LIGHT CAME ON, AND THE "ESC OFF" LIGHT WAS ILLUMINATED, EVEN THOUGH I HAD NOT SHUT THE ESC OFF. ADDITIONALLY, THE AWD SYSTEM LIGHT WAS FLASHING. UPON RESTART, ONLY THE CHECK ENGINE LIGHT REMAINED ON. I BROUGHT MY VEHICLE TO GRISMER FOR DIAGNOSTICS. THEY FOUND ERROR CODES: C1513, C1611, P1295, P2106, AND P2135. I REVISITED MY LOCAL HYUNDAI DEALER (VOSS HYUNDAI) AND THEY STATE THAT THEY BELIEVE THE STOP LAMP SWITCH IS WORKING PROPERLY AND THAT THE THROTTLE POSITIONING SENSOR NEEDS TO BE REPLACED. THEY REFUSED TO COVER THIS COST DUE TO BEING OUTSIDE OF THE WARRANTY. I WAS TOLD BY GRISMER THAT THE TPS ISSUE IS DIRECTLY RELATED TO THE STOP LAMP SWITCH ISSUE. I BELIEVE THAT WHAT I AM EXPERIENCING ALSO RELATES DIRECTLY TO SERVICE BULLETIN #TSB-09-FL-003-1. *TR

SEE ATTACHED EMAIL UPDATED 06/04/2013*LJ THE OCCUPANT CLASSIFICATION SYSTEM (OSC) DOES NOT CONSISTENTLY RECOGNIZE SMALL-STATURED ADULTS, CAUSING THE PASSENGER SIDE AIR BAG TO DEACTIVATE WHEN SUCH PERSON OCCUPY THE FRONT SEAT. ALSO, THERE WERE PROBLEMS WITH THE TRANSMISSION, A KNOCKING NOISE COMING FROM THE FRONT OF THE VEHICLE, THE VEHICLE SHUTTING DOWN, AN ISSUE WITH THE THROTTLE CABLE, AND A WHINING SOUND UPON ACCELERATION. *TR