2008 Hyundai Santa Fe

AFTER ENGINE START AND WHILE DRIVING ANY SPEED THE BATTERY LIGHT AND SEATBELT LIGHT ON THE DASHBOARD FLASHES INTERMITTENTLY. I SEARCHED THIS ONLINE AND IT LOOKS TO BE AN ELECTRICAL CHARGING ISSUE, NAMELY THE ALTERNATOR IS BAD. I SEARCHED MORE AND FOUND THE REASON FOR THIS IS THE FRONT VALVE COVER IS LEAKING OIL AND DRIPPING ONTO THE ALTERNATOR CAUSING IT TO MALFUNCTION. A RECALL HAS BEEN MADE ( #121) ON THE 07-12 VERACRUZ FOR THE SAME ISSUE. *JS

THE FUEL SENSOR ON MY 2008 SANTA FE IS MALFUNCTIONING AND NOT REPORTING THE ACTUAL LEVEL OF FUEL IN THE TANK. IT IS ALSO CAUSING THE EMPTY FUEL INDICATOR AND THE CHECK ENGINE LIGHT TO STAY LIT ALL THE TIME, SO NOT ONLY DO I HAVE TO MANUALLY MEASURE MY FUEL USAGE BY MILES DRIVEN, I ALSO HAVE NO IDEA OF ANY POTENTIAL ENGINE PROBLEMS SINCE THAT LIGHT/WARNING SYSTEM HAS EFFECTIVELY BEEN RENDERED USELESS. HYUNDAI DEALERSHIPS ARE CURRENTLY OFFERING TO FIX THE PROBLEM FOR ABOUT $800.00 AND HAVE THE PARTS READILY ON HAND SINCE THE PROBLEM IS OCCURRING SO FREQUENTLY NOW. THIS APPEARS TO BE A DEFECT WITH THE EARLIER SANTA FE MODELS AND CONSIDERING THE POTENTIAL CONSEQUENCES OF ACCIDENTALLY RUNNING OUT OF FUEL OR HAVING AN ENGINE PROBLEM AND NOT KNOWING IT UNTIL IT'S TOO LATE, A RECALL SHOULD BE ISSUED. *TR

9/19/12 VALVE COVER GASKET LEAKED OIL ON THE ALTERNATOR RESULTING IN ALTERNATOR NEEDING TO BE REPLACED. 10/2/12 NEW BATTERY NEEDED DUE TO BEING WORN DOWN FROM BAD ALTERNATOR. 10/3/14 76,589 MILES VALVE COVER GASKET LEAKED OIL ON THE ALTERNATOR RESULTING IN ALTERNATOR NEEDING TO BE REPLACED AGAIN!! NEW BATTERY NEEDED SINCE COULD NO LONGER HOLD A CHARGE. ALSO MULTIPLE TIMES THE LUMBAR SWITCH ON DRIVER'S SEAT REPLACED: 2/3/10, 3/15/11, 9/19/12, 1/19/13, 10/3/14. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING 25 MPH, THE VEHICLE STARTED TO DRIVE ABNORMALLY ROUGH. THE CONTACT MERGED THE VEHICLE TO THE EMERGENCY LANE AND SHUT THE ENGINE OFF. AFTER MULTIPLE ATTEMPTS, THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER FOR A DIAGNOSIS. THE TECHNICIAN OBSERVED THAT THERE WAS AN OIL LEAK FROM THE FRONT CYLINDER BANK VALVE COVER GASKET AND THERE WAS SUFFICIENT AMOUNT OF OIL IN THE ALTERNATOR. THE LEAK HAD CAUSED THE ALTERNATOR TO DAMAGE THE CHARGING SYSTEM AND TO BECOME INOPERABLE. THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,271.

WHILE DRIVING ON I-95, THE CHARGING SYSTEM WARNING LIGHT CAME ON FOLLOWED BY A LOSS OF ENGINE POWER AND THEN ENGINE STOPPED COMPLETELY. WAS ABLE TO SAFELY MAKE IT TO THE ROAD SIDE. DEALER DIAGNOSED A DEFECTIVE VALVE COVER GASKET ALLOWED OIL TO LEAK WHICH DRIPPED ON AND INTO THE ALTERNATOR CAUSING IT TO FAIL. SECOND IDENTICAL FAILURE ON VEHICLE IN TWO YEARS. V-6, AUTOMATIC, 2WD. FOUND MANUFACTURER JUST ISSUED A RECALL ON VERACRUZ MODEL WHICH SHARES THE SAME PLATFORM FOR IDENTICAL SYMPTOMS AND FAILURES. *TR

THE DASH LIGHTS STARTED FLASHING, THE WIPERS STOPPED WORKING IN THE MIDDLE OF A DOWN POUR, THE LIGHTS WENT DIM. THE TRACTION SYSTEM STARTED DETUNING THE ENGINE. ALL DASH LIGHTS ON. WE FIND THAT IT IS A LEAKY VALUE COVER GASKET. DRIPS ON THE ALTERNATOR AND CAUSES IT TO GO BAD. THE SERVICE MANAGER SAID "THEY ARE ALL STARTING TO HAVE THIS PROBLEM AND IT'S $700.00. IF I WAS THE ORGINAL OWNER HYUNDAI WOULD REPLACE THE GASKET, BUT I WOULD NEED TO PAY FOR THE ALTENATOR. $600.00 UHGG!!! NOW FOR THE FUEL GUAGE. TWO SENSORS UNDER THE BACK SEAT AND GOOD AS NEW. $200.00. *TR

I WAS DRIVING APPROX 30 MPH ON A STRAIGHT ROADWAY WHEN ALL ELECTRICAL SEIZED. POWER STEERING, BRAKES, ECT....I HAD TO PULL OVER AND HAD MY 17 MONTH OLD SON IN THE VEHICLE WITH ME. I HAD TO PUT MY EMERGENCY LIGHTS ON AND FIND A SAFE PLACE TO PULL OVER. IF THIS WOULD HAVE HAPPENED ON A HIGHWAY, WE MOST LIKELY WOULD HAVE HAD AN ACCIDENT. THIS IS AN URGENT SAFETY ISSUE!! WE BROUGHT OUR VEHICLE TO OUR LOCAL HYUNDAI DEALERSHIP, IN WHICH THEY DID NOT FIND ANYTHING WRONG......TO BE CONTINUED!! I SMELL A RECALL DOWN THE ROAD. HOPING IT'S BEFORE SOMEONE GETS SERIOUSLY INJURED, OR WORSE KILLED. *TR

THE SANTA FE GAS GAUGE BEHAVES ERRATICALLY! AS YOU DRIVE, THE FUEL INDICATOR NEEDLE MOVES UP AND DOWN SO THAT YOU DO NOT KNOW ACCURATELY HOW MUCH FUEL REMAINS IN THE GAS TANK. THE NEEDLE MAY ALSO INDICATE A VERY LOW FUEL LEVEL BY ILLUMINATING THE "LOW FUEL" WARNING LIGHT ON THE DASHBOARD AS WELL. THE PROBLEM APPEARS TO BE GETTING WORSE AS DRIVE TIME GOES ON AS THE NEEDLE MOVEMENTS INCREASE THE LONGER TIME THE SUV IS DRIVEN AND THE VOLUME OF FUEL DECREASES IN THE FUEL TANK. AFTER A PERIOD OF TIME THE CHECK ENGINE LIGHT WILL ALSO ILLUMINATE TO WARN OF A VEHICLE ENGINE / DRIVE-TRAIN PROBLEM. IN MY CASE I HAVE RESET THE CHECK ENGINE MANUALLY AND AFTER A NUMBER OF TRIPS THE CHECK ENGINE LIGHT WILL REAPPEAR. THIS LOW FUEL WARNING CYCLE HAS BEEN REPEATED NUMEROUS TIMES AND MAY CAUSE A DRIVER TO BE DISTRACTED TO SEE THE LOW FUEL WARNING LIGHT, WHEN IN FACT THERE MAY BE SUFFICIENT FUEL IN THE GAS TANK. I FIND THAT THIS PROBLEM IS VERY DISCONCERTING AS YOU DON'T KNOW WHETHER YOU MAY BE RUNNING OUT OF GASOLINE. *JS

I TOOK MY VEHICLE TO THE DEALERSHIP TO PERFORM TWO RECALLS: (1) STOP LAMP SWITCH AND (2) PODS RECALIBRATION. I WAS INFORMED THE AIR BAG LIGHT IN THE DASHBOARD HAD COME ON AND STAYED ON AFTER THE RECALIBRATION OF THE PODS. I NEVER HAD AN ISSUE WITH THE PODS SYSTEM OR AN AIR WARNING LIGHT IN THE DASH PRIOR TO THE RECALL. I WAS TOLD HYUNDAI WOULD PAY TO EITHER REPLACE THE PASSENGER FRONT SEAT BELT TENSIONER OR THE ENTIRE SEAT. THEY DID NOT ALLOW ME TO DRIVE MY VEHICLE BECAUSE THEY SAID IT WAS A SAFETY ISSUE AND RENTED ME A CAR FOR 4 DAYS. REPLACING THE SEAT BELT TENSIONER FIXED THE PROBLEM, BUT LESS THAN A YEAR LATER (4-15-14) THE AIR LIGHT HAS COME ON AND NOW THEY TELL ME THAT IT'S THE SCALE IN THE SEAT AND THE ENTIRE SEAT NEEDS TO BE REPLACED AT A COST TO ME OF $2400+. THE SERVICE ADVISOR TOLD ME THAT THE DRIVER'S SIDE AIR BAGS WERE NOT AFFECTED -- ONLY THE PASSENGER'S AND I WOULD BE SAFE TO DRIVE THE CAR. THE SERVICE TECH QUICKLY RETURNED THE CAR AND WE DIDN'T RECEIVE ANY PAPERWORK RESULTING FROM THE INSPECTION. MY HUSBAND AND I DID NOT ELECT TO REPLACE THE SEAT AT THIS TIME WHILE WE RESEARCH THE ISSUE. HOWEVER, MY HUSBAND AND I DID NOTICE THAT THE PODS "OFF" LIGHT TURNS OFF WHEN A PASSENGER IS IN THE SEAT WHICH IS CONFUSING SINCE THE ADVISOR SAID THE SCALE ISN'T WORKING. NOW WE ARE LEFT WITH A 6-YEAR-OLD CAR THAT HAS AN EXPENSIVE SAFETY ISSUE. WE CAN'T SELL IT TO A PRIVATE PARTY BECAUSE OF THE SAFETY ISSUE AND THE TRADE-IN VALUE HAS DRAMATICALLY DECLINED. *TR