2025 Hyundai Santa Fe Hybrid

Gas Motor is not engaging to assist electric drivetrain on a hybrid AWD 2025 Santa Fe. This resulted in a dangerous situation crossing a busy road from a stop sign. The Santa Fe rolled into the intersection at the drivers request, but did not accelerate normally (only to a maximum of a few miles per hour) and felt like an eternity to cross the road. Fortunately oncoming drivers from left and right were paying attention and slowed down and in one case honked aggressively to point out we driving badly. Pulling over to the side of the road, turning the vehicle off and then back on again has sometimes made it run normally, but we limited our trips at that point to first getting safely home and then delivering it to the dealer. The 20 mile drive to the dealer required pulling over twice to reset the vehicle so the electric motor would assist. We have had repeated warnings from the onboard system including "Follow up checks required - Engine Management System" and "There may be a problem with the engine management system Contact your Dealer". I will note that we have 11,000 miles and 11 months experience with the vehicle with NO problems. It may not be relevant, but these new faults began 2 days routine service for oil and tire rotation when recall was performed including ECU Software Update for Recall 25-01-028-1. Dealer is uncertain of problem and referring with outside tech assistance from Hyundai but we were told to expect 2 weeks for parts and repair and uncertainty as to whether that would fix it. In the meantime a vehicle with unreliable acceleration and top speed is unsafe and parked. I do note on this NHTSA website 2025 HYUNDAI SANTA FE HYBRID SUV AWD that there are 47 Complaints. 9 relating to this problem all beginning October 2025 and none prior back to the first post of Nov 2024 for this model. Complaints similar to this for engine management and speed and power loss account for 50% of complaints for this vehicle on the NHSTA website since October 2025.

Vehicle experienced a loss of acceleration while driving. When pressing the accelerator, engine RPM increased significantly but the vehicle did not increase speed. The vehicle felt as though it was stuck in one gear and would not upshift or downshift. The issue was most noticeable while driving uphill, where the vehicle was unable to maintain speed despite full throttle input. This created a safety concern as the vehicle could not accelerate normally in traffic conditions. The problem has been progressively worsening over time. Initially there were mild symptoms, but it has become more severe and frequent, culminating in a near-complete inability to accelerate under load. No warning lights or messages were observed prior to or during the failure (if that’s true—adjust if needed). Vehicle has approximately 28,000 miles. The vehicle is currently at a dealership for inspection and diagnosis, but the issue has not yet been confirmed or resolved at the time of this report.

Vehicle went in to limp mode in the middle of driving. Would not accelerate past 30mph. Was able to turn around and pull in to a neighborhood when the vehicle stopped responding altogether and had an additional warning about letting the engine recharge the hybrid system. Restarting the car got it home. This would have been extremely dangerous had it happened on the highway, at highway speeds. Dealership replaced the high pressure fuel pump. Got it back yesterday, we will see if that fixes it.

The 2025 Hyundai Santa Fe Hybrid has had multiple occasions, most recently on February 3, 2026 with 12,330 miles on the car, where the gas-powered engine fails to provide any power to the drivetrain. The car experiences vast power loss and enters "limp mode" where only the small hybrid battery is powering the vehicle. Max speed ranges from 10 - 25mph and there is little, if any, acceleration, even when the gas pedal is pegged to the floor. It is necessary to pull over, engage the flashing safety lights and try to find a safe place to park. After turning the vehicle off and on several times, eventually, the gas engines re-engages. The first incident of this type for this vehicle was on August 7, 2025 with approximately 4,400 miles on the vehicle. It was taken to the dealer, Key Hyundai of Salem, who could not find any DTCs and could not replicate the problem. They said "bring it back if it happens again." They next time was on February 3, 2026 where it happened several times on a trip to and from a local restaurant. This time, at DTC code of P088000 POWERTRAIN / POWERLOSS was recorded and reported. However, by the time the car was seen by Key Hyundai of Salem on February 5, 2026, the code has cleared itself. Hyundai's corporate policy is that historical codes can not be used for Warranty claims. So, the dealer tried one potential fix, cleaning the TCM connectors under the driver's seat, and returned the vehicle stating that Hyundai corporate would not authorize warranty work unless/until the car was presented to the dealership with a current / live DTC or visible broken parts. It seems unsafe to put a vehicle back on the road that could lose power and drivability at any time for no apparent reason. I am aware that there have been several other reports of similar POWER LOSS / LIMP MODE situations by owners of 2024-25 Hyundai Santa Fe Hybrids. At the moment, I am told that there is no current Technical Service Bulletin on this from Hyundai.

While driving, the vehicle will suddenly fail to accelerate beyond approximately 45 mph, even with the accelerator fully depressed. During these events, the engines RPMs increase significantly without a corresponding increase in vehicle speed. When this occurs, the hybrid battery fails to hold or maintain a charge, and the vehicle appears to enter a reduced-power or limp mode condition. This condition makes the vehicle unsafe to operate, particularly in traffic, on highways, or when merging or passing is required. This issue has occurred multiple times and is ongoing. The vehicle has been taken to the dealership 5 separate times (currently in there now for the 5th time) for the same issue. Despite repeated repair attempts, the dealership has been unable to identify or permanently correct the problem, and the condition continues to occur. The safety impacts are as follows: -Vehicle cannot maintain normal traffic speeds -Sudden loss of acceleration -High RPMs without propulsion -Inability to safely merge or respond to traffic. This defect substantially impairs the use and safety of the vehicle. Yes, the problem has been reproduced and confirmed by the dealership on each occasion and the issue continues even after several repair attempts. No warning lights have ever been displayed. The first time in the dealership was 5/10/25 No injuries/accidents (the issue is still safety-critical even without a crash)

While driving at highway speeds (59–75 mph), the vehicle suddenly lost propulsion power and entered a reduced-speed “limp mode,” rapidly decelerating and creating a dangerous traffic situation. The dashboard displayed a “Hybrid Power Control Unit” warning along with audible alarms. During the second incident, the vehicle failed to shut off when the engine stop button was pressed. Multiple adult witnesses were in the vehicle on each dangerous traffic situation.

Sitting at stoplight and attempted to go. Car wouldn’t go above 10mph even with pedal all the way down. Drove for a bit trying to figure out what was wrong. Then flashing red lights and beeping telling me to pull over safely. Pulled over and turned the car off. Restarted and car said charge battery. Apparently this is called “limp mode” and happens when there is something seriously wrong with the car in order to prevent further damage. Very dangerous to not be able to go about 10mph on the highway. Took to dealership. Vehicle isn’t throwing any codes and blue link shows nothing of the incident. Dealership supposedly checked battery and connections. Nothing done

Supplemental Update – Ongoing Safety Concerns and Extended Loss of Use Since submitting my initial complaint, my leased Hyundai vehicle (VIN [XXX] ) has now been presented for service for the third time for the same unresolved safety-related issues. The vehicle has been held by the dealership for eight (8) consecutive days during this service visit with no resolution and no clear timeline for return. Safety concerns remain unresolved, including: Persistent toxic/chemical odor inside the cabin Random rear hatch opening while vehicle is parked and locked Repeated false “windows open” alerts Electrical/body control system irregularities To date, I have not been provided with documentation confirming that cabin air quality testing, exhaust intrusion testing, or comprehensive electrical diagnostics have been performed. These unresolved conditions present ongoing safety risks and loss of use. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Started car, reading paperwork and suddenly my car went into Neutral bycitself and rolled backwards in a parking lot. Thank goodness no one was walking behind my car. This is the 2nd time it has happened. Additionally, twice previously, my car screen blacked off. 1 other time while sitting at a traffic light, the car shut off. I have been patient but now I'm afraid ti drive this car with only 2,650 miles on it.