IllustrationI cut my leg, badly, getting out of the car. There is a very sharp edge on the bottom corner of the door. My leg brushed against the door and I got a 2-inch long, deep gash. A review of Hyundai Palisade owner websites show other people have experienced the same issue.
2021 Hyundai Palisade
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2021 Hyundai Palisade do not stand out strongly from the model-year median of 385.
About this comparison →How this year compares
Owner complaints by model year
Compare all Palisade years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 58 of 434 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports10 injury reports
What owners actually said
434 reportsDriving down a 2 lane road, a small pebble struck the top of the windshield. About 5 minutes later a crack extended from the top of the windshield to the middle, directly in the drivers view. There are many, many complaints of these windshields shattering from very minor impacts and some for no reason at all. The fact that th…
Read full complaint
Driving down a 2 lane road, a small pebble struck the top of the windshield. About 5 minutes later a crack extended from the top of the windshield to the middle, directly in the drivers view. There are many, many complaints of these windshields shattering from very minor impacts and some for no reason at all. The fact that the windshield can break like this (not even chip) makes me concerned that an impact from a larger item (stone, retread from semi, etc) will go right thru the windshield, endangering the lives of passengers and by-standers (due to potential loss of control).
Windshield glass cracked in two different locations. One caused by a small pebble and the second looks to have cracked on its own. Vehicle only 6 months owned.
Windshield gets rock chips very easily. It's an ongoing problem
Small rock hit left side of windshield by car frame on a Sunday. Left a small, superficial knick (didn't look to be through windshield). Drove car Monday & Tuesday with no noticeable windshield damage. Went to drive car Wednesday and there was a six inch crack across windshield originating from Sunday's knick. Over the course …
Read full complaint
Small rock hit left side of windshield by car frame on a Sunday. Left a small, superficial knick (didn't look to be through windshield). Drove car Monday & Tuesday with no noticeable windshield damage. Went to drive car Wednesday and there was a six inch crack across windshield originating from Sunday's knick. Over the course of an hour, crack grew to longer than two feet.
windnoise/whistle noise in driver door on 2021 Palisade SEL
Windshield cracks with the slightest impact. After 2 replacement windshields and camera calibration performed four times, the vehicle still strays into oncoming traffic lane and over the fog line with lane keep assist and lane following assist activated. camera has been calibrated three times at Safelite and one time at Hyundai …
Read full complaint
Windshield cracks with the slightest impact. After 2 replacement windshields and camera calibration performed four times, the vehicle still strays into oncoming traffic lane and over the fog line with lane keep assist and lane following assist activated. camera has been calibrated three times at Safelite and one time at Hyundai dealer. The LKA & LFA systems were PRECISE IN THEIR OPERATION WHEN I PURCHASED THE VEHICLE. Now the vehicle self steers into oncoming traffic with no warning until the vehicle is over the center line. Scary as hell. Apparently Hyundai has defective and weak windshields across the board according to many internet sources. Also, apparently the recalibration procedure is not working, causing a major safety issue in these vehicles.
I purchased a new Hyundai Palisade (Limited Version) on April 1, 2021. On or about May 12, 2021, while driving down the road, a small pebble struck the bottom of my windshield directly in front of the driver position, leaving a very small chip in my windshield about the size of a bb. The small chip was so small and insignificant…
Read full complaint
I purchased a new Hyundai Palisade (Limited Version) on April 1, 2021. On or about May 12, 2021, while driving down the road, a small pebble struck the bottom of my windshield directly in front of the driver position, leaving a very small chip in my windshield about the size of a bb. The small chip was so small and insignificant looking no further action was taken at the time. On the morning of May 30, 2021, I got in my Palisade, that was parked in my enclosed garage, and noticed a cracked windshield of approximately 24 inches, that appeared to originate at the location of the "BB size" chip. A cold front had came in on the night of May 29, 2021/early morning of May 30th, reducing the outside temperature much below normal. On June 1, 2021, I took my Palisade to the Hallmark Hyundai, 1198 West Main Street, Hendersonville, Tennessee, to obtain an estimate for repair and determine if this damage was covered under warranty (remember this is a new Palisade, only six weeks old and less than 2,000 miles at the time of the "pebble strike"). I explained to the service manager that I believed the cracked windshield was a possible factory defect and if asked if anyone else had recently had a cracked Palisade windshield. He said they had one other Palisade with a cracked windshield a couple of weeks earlier. The service manager told me the cracked windshield was not covered under my new car warranty and that "at this time" there were no warranty enhancements/recalls on the windshield for my Palisade. The service manager then provided me a service estimate to have my cracked windshield replaced: Part# 86111-S8110 - Glass Windshield: $1,561.89 Part# 86130=S8000 - Garnish Assy.- $188.00 Part# 86140-S8000 - Garnish Assy.- $187.31 Glass Moldings and Labor and Recalibration - $375.00 Fee Windshield Removal/Replacement - $275.00 Tax-$239.33 Grand Total - $2,846.76 In conclusion, I believe there is a lot of smoke that indicates Hyundai has a big fire with its defective windshield
When i was driving suddenly the Sunroof glass bursted and shattered in to pieces. There was nothing fell on to it as i was driving in the middle lane of freeway. I just heard a huge noise like shotgun fired and found out that the glass is shattered. I called dealer to review and find out what can be done. I have been asked to…
Read full complaint
When i was driving suddenly the Sunroof glass bursted and shattered in to pieces. There was nothing fell on to it as i was driving in the middle lane of freeway. I just heard a huge noise like shotgun fired and found out that the glass is shattered. I called dealer to review and find out what can be done. I have been asked to show up to dealerships next week. I have read lot of blogs and forums and found this is a common issue with Hyundai and they are not yet able to fix it. Many owners of Palisades reported this issue as well.
My 2021 Palisade Windshield has cracked after nothing struck the windshield like so many others who own the 2020 and 2021 Palisade and Kia Telluride (Hyundai's company). This is a know quality issue with weak and easily cracked windshields which many owners have filed complaints to this NHTSA site and in online forums. The win…
Read full complaint
My 2021 Palisade Windshield has cracked after nothing struck the windshield like so many others who own the 2020 and 2021 Palisade and Kia Telluride (Hyundai's company). This is a know quality issue with weak and easily cracked windshields which many owners have filed complaints to this NHTSA site and in online forums. The windshield is among the most important safety functions on a car. The auto glass must all be restored and it’s essential to retain the window and in good condition at all times. Driving with a chipped or cracked windshield may put me and my passengers at risk for injury in the event of a rollover or collision. Hyundai needs to issue a recall for the safety of their customers. I respectfully ask that you investigate the windshields on the 2020 and 2021 Huyundi Pallisaide's.
Official recalls
626V034000 · Air Bags:side/window:curtain
Jan 22, 2026
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The side curtain air bags for third-row occupants may deploy improperly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: Improper side curtain air bag deployment increases the risk of injury during a crash.
Remedy: Dealers will install a protective film over the rear window and remove padding, as necessary free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning March 13, 2026. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 292. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 24, 2026.
25V607000 · Seat Belts: Rear/other:buckle Assembly; Seat Belts:front:buckle Assembly
Sep 11, 2025
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence & remedy
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Additional source detail variants (2)
Seat Belts: Rear/other:buckle Assembly
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Seat Belts:front:buckle Assembly
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
23V180000 · Visibility/wiper
Mar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2021-2023 Palisade vehicles. The windshield wiper motor may operate intermittently or fail to operate due to snow or ice buildup on the windshield, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the driver-side windshield wiper arm, free of charge. Owner notification letters were mailed May 15, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 243. This recall is an expansion of recall number 22V-627.
22V633000 · Trailer Hitches
Aug 18, 2022
Hyundai Motor America (Hyundai) is recalling 2020-2022 Palisade vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and wire extension kit, as necessary, free of charge. Owner notification letters were mailed May 18, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 235.
22V627000 · Visibility:windshield Wiper/washer:motor
Aug 15, 2022
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Palisade vehicles. The windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the driver-side windshield wiper arm, free of charge. Owner notification letters were mailed December 13, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 233.
21V840000 · Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 27, 2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Palisade vehicles. The brake fluid may be contaminated, which can cause the brake master cylinder inner-cup seals to swell, and reduce braking performance.
Consequence & remedy
Consequence: Reduced braking performance can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder, and flush the brake fluid, free of charge. Owner notification letters were mailed on December 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 212.
Additional source detail variants (2)
Service Brakes, Hydraulic:fluid
Hyundai Motor America (Hyundai) is recalling certain 2021 Palisade vehicles. The brake fluid may be contaminated, which can cause the brake master cylinder inner-cup seals to swell, and reduce braking performance.
Consequence: Reduced braking performance can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder, and flush the brake fluid, free of charge. Owner notification letters were mailed on December 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 212.
Service Brakes, Hydraulic:foundation Components:master Cylinder
Hyundai Motor America (Hyundai) is recalling certain 2021 Palisade vehicles. The brake fluid may be contaminated, which can cause the brake master cylinder inner-cup seals to swell, and reduce braking performance.
Consequence: Reduced braking performance can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder, and flush the brake fluid, free of charge. Owner notification letters were mailed on December 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 212.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24021 · Inadvertent Seat Belt Unlatch
Opened Aug 7, 2024 · Closed Dec 12, 2025
Status: closed (inferred from source dates) · Seat Belts
On August 7, 2024, the Office of Defects Investigation (ODI) opened PE24021 to investigate complaints alleging inadvertent unlatching of seat belts in model year (MY) 2020-2023 Hyundai Palisade vehicles manufactured by Hyundai Motor America. The complaints alleged that, without warning, the seat belts sometimes inadvertently unlatch, increasing the risk of injury due to full loss of seat belt protection in the event of a crash. As a result of information exchanged as part of the investigation, on April 3, 2025, Hyundai initiated a warranty extension policy for seat belt buckles on model year 2020-2025 Palisade vehicles in the U.S. and Canada. Hyundai subsequently initiated a request for warranty parts returns to support further analysis by the buckle supplier, ZF Lifetec. The warranty extension (reference “Z06”) noted that certain 2020 – 2025 model year Palisade vehicles may experience abnormal seat belt buckle(s) operation. Hyundai extended the warranty coverage for the seat belt buckle under this condition to 15 years/150,000 miles (whichever occurs first) from the date of original retail delivery or date of first use. This action is valid for original and subsequent owners. On September 11, 2025, Hyundai filed recall 25V-607 for certain 2020-2025 Hyundai Palisade vehicles. Hyundai explained in its recall filing that the subject vehicles are equipped with seat belt buckle assemblies in the front row and second row outer seating positions that may contain out-of-specification components manufactured by the supplier. These components can cause interference within the latch channel, potentially increasing friction, particularly under cold ambient temperatures. Improperly produced seat belt buckles, combined with slow insertion of the seat belt tongue plate, may prevent the seat belt buckle from fully latching. The recall remedy is currently under development. In view of Hyundai’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ22005 · Windshield Wiper Failure
Opened Dec 2, 2022 · Closed May 26, 2023
Status: closed (inferred from source dates) · Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Additional source detail variants (4)
Visibility:windshield Wiper/washer
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Visibility:windshield Wiper/washer:linkages
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Visibility:windshield Wiper/washer:motor
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Visibility/wiper
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.