IllustrationWhile we were in a store shopping the windshield spontaneously cracked. No reason, not caused by a rock chip or any other impact.
2020 Hyundai Palisade
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2020 Hyundai Palisade do not stand out strongly from the model-year median of 385.
About this comparison →How this year compares
Owner complaints by model year
Compare all Palisade years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1380–25K
925–50K
650–75K
775–100K
2100–150K
1150K+
163 reports with mileage · 369 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports7 fire reports9 injury reports
What owners actually said
532 reportsI walked out to my vehicle in the driveway this morning and the windshield was cracked for no apparent reason. There were no visible chips near the crack. Crack extended from lower Driver's side corner upwards and across to almost the center-line. I also had to previously repair two chips in the windshield that did not appear t…
Read full complaint
I walked out to my vehicle in the driveway this morning and the windshield was cracked for no apparent reason. There were no visible chips near the crack. Crack extended from lower Driver's side corner upwards and across to almost the center-line. I also had to previously repair two chips in the windshield that did not appear to be from debris damage. It would appear that the windshield is defective as installed at the factory.
The rear windshield shattered unprovoked. This was only 3 weeks after being repaired for the same issue. This is the third time.
My back windshield shattered unprovoked once again. This is the second time.
At 12,800 miles, while parked, a 18'' to 24'' windshield crack spontaneously appeared originating from the lower, passenger side edge, sloping up towards driver side. Nothing came into contact with the glass, and no chipped starting point is visible.
While driving in heavy rains , check engine light comes up and vehicle starts vibrating. Once the vehicle is stopped and restarted the light & vibration goes away. This happened twice in 2 months ( July & aug 2021) and while driving in Interstate. I did report to the dealer/service manager after the first time and they were not …
Read full complaint
While driving in heavy rains , check engine light comes up and vehicle starts vibrating. Once the vehicle is stopped and restarted the light & vibration goes away. This happened twice in 2 months ( July & aug 2021) and while driving in Interstate. I did report to the dealer/service manager after the first time and they were not able to pull up any logs/codes from the vehicle computers. The second time, it happened, I took the photo of the same. First time it occured when I had about 17500 miles on the vehicle. Second time it was 19643 miles. Both times it was raining heavily and speed was between 40- 50 miles/hour
Steering wheel makes whirring sound when turned. Service department aknowledged the problem and replaced the worm gear in the steering shaft. Issue went away. Now about 5000 miles since repair the same issue is back.
No problems
On interstate highway in South Dakota in September 2020, a small pebble came off the road surface creating a small chip on front windshield. Within one hour the windshield had a crack horizontally covering the entire windshield. This caused a complete one day delay on our vacation trip as the windshield had to be replaced at a…
Read full complaint
On interstate highway in South Dakota in September 2020, a small pebble came off the road surface creating a small chip on front windshield. Within one hour the windshield had a crack horizontally covering the entire windshield. This caused a complete one day delay on our vacation trip as the windshield had to be replaced at a local Safelite location. Certainly the delay was an inconvenience but more important we are concerned about our safety. This occurred when vehicle was less than 2 months old. Now it is July, 2021 and on another interstate a small pebble came off the road and caused a small chip in the lower left windshield. Next day the small crack started to run requiring a compete windshield repair AGAIN. If a small pebble can do this immediate damage, I fear the entire windshield could shatter causing a major accident or at worst a fatality. Safelite and Travelers Insurance have all documentation regarding the two incidents.
The vehicle's air bag warning light on dash was noted to be intermittently illuminated when car being driven, and only when passenger is in front passenger seat. Car taken to dealer, air bag sensor in front seat to be replaced. Problem has persisted despite being repaired three times by the dealership. Error codes remain the sam…
Read full complaint
The vehicle's air bag warning light on dash was noted to be intermittently illuminated when car being driven, and only when passenger is in front passenger seat. Car taken to dealer, air bag sensor in front seat to be replaced. Problem has persisted despite being repaired three times by the dealership. Error codes remain the same or similar when checked by dealership. Repair records can be furnished on request.
Official recalls
526V034000 · Air Bags:side/window:curtain
Jan 22, 2026
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The side curtain air bags for third-row occupants may deploy improperly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: Improper side curtain air bag deployment increases the risk of injury during a crash.
Remedy: Dealers will install a protective film over the rear window and remove padding, as necessary free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning March 13, 2026. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 292. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 24, 2026.
25V607000 · Seat Belts: Rear/other:buckle Assembly; Seat Belts:front:buckle Assembly
Sep 11, 2025
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence & remedy
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Additional source detail variants (2)
Seat Belts: Rear/other:buckle Assembly
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Seat Belts:front:buckle Assembly
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
22V633000 · Trailer Hitches
Aug 18, 2022
Hyundai Motor America (Hyundai) is recalling 2020-2022 Palisade vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and wire extension kit, as necessary, free of charge. Owner notification letters were mailed May 18, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 235.
22V627000 · Visibility:windshield Wiper/washer:motor
Aug 15, 2022
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Palisade vehicles. The windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the driver-side windshield wiper arm, free of charge. Owner notification letters were mailed December 13, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 233.
19V802000 · Air Bags:side/window
Nov 7, 2019
Hyundai Motor America (Hyundai) is recalling certain 2020 Palisade vehicles. The mounting bolts used to secure the side curtain air bags may damage the side curtain air bags during deployment.
Consequence & remedy
Consequence: Damaged side curtain air bags may not inflate properly in the event of a crash, increasing the risk of injury.
Remedy: Hyundai will notify owners, and dealers will install a protective cover on the mounting bolts, free of charge. The recall began December 20, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 186.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE24021 · Inadvertent Seat Belt Unlatch
Opened Aug 7, 2024 · Closed Dec 12, 2025
Status: closed (inferred from source dates) · Seat Belts
On August 7, 2024, the Office of Defects Investigation (ODI) opened PE24021 to investigate complaints alleging inadvertent unlatching of seat belts in model year (MY) 2020-2023 Hyundai Palisade vehicles manufactured by Hyundai Motor America. The complaints alleged that, without warning, the seat belts sometimes inadvertently unlatch, increasing the risk of injury due to full loss of seat belt protection in the event of a crash. As a result of information exchanged as part of the investigation, on April 3, 2025, Hyundai initiated a warranty extension policy for seat belt buckles on model year 2020-2025 Palisade vehicles in the U.S. and Canada. Hyundai subsequently initiated a request for warranty parts returns to support further analysis by the buckle supplier, ZF Lifetec. The warranty extension (reference “Z06”) noted that certain 2020 – 2025 model year Palisade vehicles may experience abnormal seat belt buckle(s) operation. Hyundai extended the warranty coverage for the seat belt buckle under this condition to 15 years/150,000 miles (whichever occurs first) from the date of original retail delivery or date of first use. This action is valid for original and subsequent owners. On September 11, 2025, Hyundai filed recall 25V-607 for certain 2020-2025 Hyundai Palisade vehicles. Hyundai explained in its recall filing that the subject vehicles are equipped with seat belt buckle assemblies in the front row and second row outer seating positions that may contain out-of-specification components manufactured by the supplier. These components can cause interference within the latch channel, potentially increasing friction, particularly under cold ambient temperatures. Improperly produced seat belt buckles, combined with slow insertion of the seat belt tongue plate, may prevent the seat belt buckle from fully latching. The recall remedy is currently under development. In view of Hyundai’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.