Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 296 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 225 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports2 injury reports
What owners actually said
296 reports
Mileage unknown · Apr 28, 2026
Electrical System
While backing out of my driveway at less than 5 mph, I heard a sudden loud pop noise from the rear of the vehicle, immediately followed by a dashboard warning: 'Check Electric Vehicle System.' Since I was still in my driveway, I was able to safely park and exit the vehicle. There were no injuries and no other vehicles or propert…
Read full complaint
While backing out of my driveway at less than 5 mph, I heard a sudden loud pop noise from the rear of the vehicle, immediately followed by a dashboard warning: 'Check Electric Vehicle System.' Since I was still in my driveway, I was able to safely park and exit the vehicle. There were no injuries and no other vehicles or property were involved. The vehicle was undriveable and required towing to the dealership. The dealer diagnosed the failure as a defective Integrated Charging Control Unit (ICCU) and replaced the unit. The vehicle was out of service for approximately 6 days.
NHTSA ODI #11734383
Mileage unknown · Apr 28, 2026
Electrical SystemFuel/propulsion System
While driving on [XXX] , I heard a 'pop' towards the rear of the car. A dashboard warning appeared notifying me of an electrical fault. The car went into 'limp' mode, which allowed me to drive no faster than around 25 mph. Fortunately, I was within a half mile of my home, so I was able to do a U turn and return home. I calle…
Read full complaint
While driving on [XXX] , I heard a 'pop' towards the rear of the car. A dashboard warning appeared notifying me of an electrical fault. The car went into 'limp' mode, which allowed me to drive no faster than around 25 mph. Fortunately, I was within a half mile of my home, so I was able to do a U turn and return home. I called a tow truck, which towed the car to the local Hyundai dealer in Lebanon, NH. This was a Saturday in February, 2026, so dealer inspection did not occur until the following Monday. The dealer confirmed that the problem was a failed ICCU assembly and the associated high voltage fuse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11734318
Mileage unknown · Apr 25, 2026
Electrical System
ICCU blew while driving and immediately slowed me to 45 mph
NHTSA ODI #11733719
Mileage unknown · Apr 24, 2026
Electrical System
Vehicle shut down with minimal warning due to “integrated charging control unit” failure. Vehicle left my wife stranded on rural road. Current mileage is 12k.
NHTSA ODI #11733713
Mileage unknown · Apr 24, 2026
Electrical System
ICCU failed and blew high power fuse. Car displayed warning and only drove slowly. I went to the selling dealer and they confirmed the ICCU and fuse failure.
NHTSA ODI #11733575
Mileage unknown · Apr 22, 2026
Electrical SystemFuel/propulsion System
I was driving on the highway when the car suddenly flashed a “check power supply” warning and then immediately shut down. I was traveling approximately 55 mph when the car came to a sudden stop and I was almost rear-ended as a consequence. I was not rear ended because I had a wide shoulder to immediately pull over onto, but if t…
Read full complaint
I was driving on the highway when the car suddenly flashed a “check power supply” warning and then immediately shut down. I was traveling approximately 55 mph when the car came to a sudden stop and I was almost rear-ended as a consequence. I was not rear ended because I had a wide shoulder to immediately pull over onto, but if this had happened in a location without a shoulder, it likely would have caused an accident.
NHTSA ODI #11733134
Mileage unknown · Apr 20, 2026
Electrical System
Vehicle unexpectedly ceased to work. A loud pop sound then a message to check electrical system. Vehicle reverted to “limp mode” leaving me at a max of 15 mph. Terribly unsafe and extremely, concerningly widespread ICCU failure across Hyundai EV models For 5+ years is unacceptable
NHTSA ODI #11732472
Mileage unknown · Apr 16, 2026
Fuel/propulsion SystemVehicle Speed Control
I was driving my vehicle on a freeway with 3 passengers when i heard a muffled pop or thud from behind me. A rear passenger confirmed that it came from beneath the rear seat towards the left side of the car. The vehicle speed immediately dropped to less than 40 mph and a warning message appeared on the dash "Check electri…
Read full complaint
I was driving my vehicle on a freeway with 3 passengers when i heard a muffled pop or thud from behind me. A rear passenger confirmed that it came from beneath the rear seat towards the left side of the car. The vehicle speed immediately dropped to less than 40 mph and a warning message appeared on the dash "Check electric vehicle system". I later noticed a red battery icon appear on the left of the dash. I pulled over after leaving the freeway and attempted to resolve the issue by turning off the car, then restarting it. The notice and red battery icon still appeared. I feel that this sudden reduction in speed is a safety issue because I could have been driving at a higher speed (65-70 vs 45-50). Following cars may not have been able to stop in time, or I cuold have been forced to attempt to get off the road by entering lanes with vehicles travelling at a much faster speed. I was about 5 miles away from home on the start of a 400 mile trip so decided to turn around. Back at home I discovered that a new DTC code had been thrown during or after this event - P1A9096. I transferred to another person's cart to complete the trip, and on return arranged for the car to be transported to a manufacturer recommended dealership to check the issue. The Dealership service department conducted diagnostic tests and determined that the issue was caused by an ICCU failure. The have placed an order for a replacement ICCU unit and fuse. Prior to this event there had been no dash light warnings or trouble codes thrown.
Car charged as scheduled overnight 3/28/26 but was dead the morning of 3/29/26 and when it was jumped gave error "Battery overheated, please stop and exit vehicle" and "check electrical system" - vehicle has been in shop for 16 days, no diagnosis except that it "probably" needs a HV battery.
NHTSA ODI #11731464
Mileage unknown · Apr 12, 2026
Electrical System
I heard a loud pop and my car died and was undriveable in about 5 minutes. Told it was my iccu failure and fuse popping. Apparently this is a common issue. I was almost killed as I was kn thr interstate and needed to be towed. Nothing worked
Hyundai Motor America (Hyundai) is recalling certain 2025 Ioniq 5 and 2026 Ioniq 9 vehicles. The fasteners for the rear suspension may loosen and detach, which can result in a loss of vehicle control.
Consequence & remedy
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will inspect and replace the rear suspension fasteners and perform a rear vehicle alignment, as necessary, free of charge. Owner notification letters are expected to be mailed July 17, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 303. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 20, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2025-2026 IONIQ 5 and 2026 IONIQ 9 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.
Consequence & remedy
Consequence: An electrical short in the high voltage battery system increases the risk of a fire.
Remedy: Dealers will inspect and tighten the bus bar retention bolts and replace the battery system assembly, as necessary, free of charge. Owner notification letters were mailed April 3, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 294. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 7, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 vehicles. The seat belt retractors for the driver and front passenger seats may not be securely fastened.
Consequence & remedy
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and secure the seat belt retractors, as necessary, free of charge. Owner notification letters were mailed December 30, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 287. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 19, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 electric vehicles. Certain rear suspension alignment adjustment bolts may have been improperly tightened, which can cause a loss of vehicle stability control.
Consequence & remedy
Consequence: A loss of vehicle stability control increases the risk of a crash.
Remedy: Dealers will replace the adjustment bolts, align the wheels, and replace tires if necessary, free of charge. Owner notification letters were mailed October 10, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 284. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.
Consequence & remedy
Consequence: An electrical short in the high voltage battery system increases the risk of a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the recall remedy is complete. Dealers will inspect and repair the high voltage battery system, as necessary, free of charge. Owner notification letters were mailed August 25, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 280.
Hyundai Motor America (Hyundai) is recalling certain 2025 Hyundai IONIQ 5 vehicles. The right-side headlight may have an incorrect headlight aim label, which can result in improperly aimed headlights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Improperly aimed headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash.
Remedy: Hyundai will mail owners a corrected label with inspection and installation instructions. Owners may bring their vehicle to a dealer for the repair, free of charge. Owner notification letters were mailed July 15, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 279.
Hyundai Motor America (Hyundai) is recalling certain 2025 Hyundai IONIQ 5 "N" vehicles equipped with left-foot braking (LFB) and N e-shift features. The integrated electronic brake (IEB) and vehicle control unit (VCU) software may cause reduced braking performance when LFB is activated. Additionally, the vehicle may continue to accelerate after the pedal is released and the vehicle's N e-shift feature is engaged.
Consequence & remedy
Consequence: Reduced braking performance and unexpected, continued acceleration increase the risk of a crash.
Remedy: Owners are advised not to use the LFB or N e-Shift features until the remedy has been performed. The IEB and VCU software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed April 25, 2025. This recall replaces NHTSA recall number 25V-065. Vehicles repaired under the previous recall will need to have the new remedy completed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 277.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 EV vehicles. The rear floor wiring harness may contain an open circuit, which can result in the rear side air bag not deploying as intended.
Consequence & remedy
Consequence: A rear side air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear floor wiring harness, as necessary, free of charge. Owner notification letters were mailed March 12, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 274.
Additional source detail variants (2)
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 EV vehicles. The rear floor wiring harness may contain an open circuit, which can result in the rear side air bag not deploying as intended.
Consequence: A rear side air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear floor wiring harness, as necessary, free of charge. Owner notification letters were mailed March 12, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 274.
Air Bags:side/window
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 EV vehicles. The rear floor wiring harness may contain an open circuit, which can result in the rear side air bag not deploying as intended.
Consequence: A rear side air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear floor wiring harness, as necessary, free of charge. Owner notification letters were mailed March 12, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 274.
Hyundai Motor America (Hyundai) is recalling certain 2025 Hyundai IONIQ 5 "N" vehicles equipped with a left-foot braking (LFB) feature. The integrated electronic brake (IEB) and vehicle control unit (VCU) software may cause reduced braking performance when LFB is activated.
Consequence & remedy
Consequence: Reduced braking performance can increase the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Owners who have not received the recall remedy are advised not to use the LFB feature until the updated remedy has been performed. Additionally, owners who have received the recall remedy are advised not to use the 'N' E-shift feature until the updated remedy has been performed. Dealers will update the IEB and VCU software, free of charge. Owner notification letters were mailed March 12, 2025. This recall is replaced by NHTSA recall number 25V-235. Vehicles already repaired under this recall will need to have the new remedy completed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 275.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2025 Hyundai Ioniq 5 Problems, Complaints & Recalls | Skip That Year
Illustration