I was on the highway going at approximately 60mph when the car without any warning reduced speed to first around 40mph and then to 20mph all within a matter of a few minutes, causing me to pull over to the side of the highway. Luckily, I wasn't injured. I exited the highway, called my insurance company Geico and had the vehicle …
Read full complaint
I was on the highway going at approximately 60mph when the car without any warning reduced speed to first around 40mph and then to 20mph all within a matter of a few minutes, causing me to pull over to the side of the highway. Luckily, I wasn't injured. I exited the highway, called my insurance company Geico and had the vehicle towed to the dealership where I leased this brand new vehicle from just about 7 months ago on a 2year lease. The dealer was kind enough to provide a smaller loaner vehicle but had no idea when my car would be returned, as there were others with similar failures ahead of me that were waiting for the part to arrive. Apparently, this is a known failure issue of the ICCU that Hyundai has done a poor job of addressing. I continue to make my lease payments while waiting for the part to arrive. In the meantime, I wanted to let the government know of my experience and how this could have had a disastrous effect on my family and other families with a similar build.
NHTSA ODI #11721136
Mileage unknown · Feb 27, 2026
Electrical SystemFuel/propulsion System
Drove 50 miles. Charged car at a supercharger. Unplugged car normally. Pushed start normally. Heard a light “pop” sound. Car would drive but with low acceleration. Warning lights came on. Then bright “stop now” lights and beeping. Then it died in the parking lot and would not start at all.
NHTSA ODI #11721050
Mileage unknown · Feb 27, 2026
Electrical SystemPower Train
The ICCU failed under normal utilization The vehicle went into limp mode which changes expected driving dynamics The dealer confirmed ICCU failure and the manufacturer has confirmed the vehicle is a lemon as per MA state law No warnings prior to the failure
NHTSA ODI #11721040
Mileage unknown · Feb 27, 2026
Electrical System
Turned on my car one day after charging and heard a 'pop' from the rear of the car, followed by warning lights activating on the dash and an electrical system error message. I had the car towed to the dealership (Santa Monica Hyundai) and they confirmed the issue was an ICCU component failure. There were no warning signs or issu…
Read full complaint
Turned on my car one day after charging and heard a 'pop' from the rear of the car, followed by warning lights activating on the dash and an electrical system error message. I had the car towed to the dealership (Santa Monica Hyundai) and they confirmed the issue was an ICCU component failure. There were no warning signs or issues before the failure. The dealership currently has no ETA for a fix.
NHTSA ODI #11720932
Mileage unknown · Feb 27, 2026
Electrical SystemFuel/propulsion System
My Ioniq5 experienced a failure of the Integrated Charging Control Unit (ICCU) while driving. There was a loud "pop" noise from the back seat that occurred while driving, and afterwards the car experienced an unexpected braking/deceleration and was unable to maintain a speed over ~30MPH. After the "pop" noise -- a "Check elect…
Read full complaint
My Ioniq5 experienced a failure of the Integrated Charging Control Unit (ICCU) while driving. There was a loud "pop" noise from the back seat that occurred while driving, and afterwards the car experienced an unexpected braking/deceleration and was unable to maintain a speed over ~30MPH. After the "pop" noise -- a "Check electric vehicle system" alert appeared on the dash, and an alert that the car had entered a limited power state also appeared a few minutes later. My safety was put at risk due to the car unexpectedly decelerating and then losing the ability to maintain speed while driving on a busy highway. Other's safety was put at risk due to my limited ability to maintain speed and not impede traffic. There was no warning's prior to the sudden failure to indicate there was anything wrong with the vehicle. The car needed to be towed to the dealer due to the limited state the car was put in. It was confirmed at the dealership that the ICCU had failed and needed to be replaced. It was also confirmed at the dealership that the replacement part was the same as what had failed, which is concerning for mine and other safety that this is at risk of occurring again.
NHTSA ODI #11720921
Mileage unknown · Feb 27, 2026
Electrical System
While driving, loud pop sound came from rear of car. No prior warning or lights before this. Car immediately displayed a check electrical vehicle system warning light. Luckily we were somewhere were we could pull over immediately. Towed to dealer and they determined it was the ICCU that popped. Due to the ICCU failure, we…
Read full complaint
While driving, loud pop sound came from rear of car. No prior warning or lights before this. Car immediately displayed a check electrical vehicle system warning light. Luckily we were somewhere were we could pull over immediately. Towed to dealer and they determined it was the ICCU that popped. Due to the ICCU failure, we could have completely lost car power if we didn't have somewhere to stop. Currently car is sitting at dealer with no ETA for getting fixed. Part is not available .
NHTSA ODI #11720895
Mileage unknown · Feb 26, 2026
Electrical System
The Integrated Charging Control Unit (ICCU) failed on [XXX]. An electrical system warning light appeared on the dashboard as soon as I turned on the vehicle; a review of the diagnostic code via the Hyundai Bluelink app indicated that the vehicle was unsafe to drive. It was towed to Napleton's Hyundai service center in Urbana, I…
Read full complaint
The Integrated Charging Control Unit (ICCU) failed on [XXX]. An electrical system warning light appeared on the dashboard as soon as I turned on the vehicle; a review of the diagnostic code via the Hyundai Bluelink app indicated that the vehicle was unsafe to drive. It was towed to Napleton's Hyundai service center in Urbana, Illinois. I was informed that the replacement parts were on a nationwide backorder. The repairs were finally completed on February 25, 2026. The repairs were covered under warranty; however, it was a disappointment and inconvenience for a practically new car to suffer a critical part failure and then to be out of commission for 50 days. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ICCU failure at 5308 miles. heard a loud pop while driving and 12v warning system errors
NHTSA ODI #11720506
Mileage unknown · Feb 25, 2026
Electrical System
I was driving on a 4 lane major artery on 12 / 30/2025 traveling approximately 50 mph. Heard a loud bang and car loss power and suddenly slowed. Vehicles behind me had to swerve to miss hitting me. The vehicle could move approximately 5 mph afterward. We pulled off the road onto a side road. We later found out the ICCU faile…
Read full complaint
I was driving on a 4 lane major artery on 12 / 30/2025 traveling approximately 50 mph. Heard a loud bang and car loss power and suddenly slowed. Vehicles behind me had to swerve to miss hitting me. The vehicle could move approximately 5 mph afterward. We pulled off the road onto a side road. We later found out the ICCU failed from the Hyundai dealership. It has been there since that date awaiting parts to repair
NHTSA ODI #11720364
Mileage unknown · Feb 24, 2026
Electrical System
ICCU unit failed on 1/27/26, vehicle entered limp mode and is unusable. This is affecting thousands of Hyundai Ioniq 5 autos, and probably others as well. Due to the widespread problem, Hyundai is unable to give an estimate on finding a replacement part.
Hyundai Motor America (Hyundai) is recalling certain 2025 Ioniq 5 and 2026 Ioniq 9 vehicles. The fasteners for the rear suspension may loosen and detach, which can result in a loss of vehicle control.
Consequence & remedy
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will inspect and replace the rear suspension fasteners and perform a rear vehicle alignment, as necessary, free of charge. Owner notification letters are expected to be mailed July 17, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 303. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 20, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2025-2026 IONIQ 5 and 2026 IONIQ 9 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.
Consequence & remedy
Consequence: An electrical short in the high voltage battery system increases the risk of a fire.
Remedy: Dealers will inspect and tighten the bus bar retention bolts and replace the battery system assembly, as necessary, free of charge. Owner notification letters were mailed April 3, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 294. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 7, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 vehicles. The seat belt retractors for the driver and front passenger seats may not be securely fastened.
Consequence & remedy
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and secure the seat belt retractors, as necessary, free of charge. Owner notification letters were mailed December 30, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 287. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 19, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 electric vehicles. Certain rear suspension alignment adjustment bolts may have been improperly tightened, which can cause a loss of vehicle stability control.
Consequence & remedy
Consequence: A loss of vehicle stability control increases the risk of a crash.
Remedy: Dealers will replace the adjustment bolts, align the wheels, and replace tires if necessary, free of charge. Owner notification letters were mailed October 10, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 284. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.
Consequence & remedy
Consequence: An electrical short in the high voltage battery system increases the risk of a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the recall remedy is complete. Dealers will inspect and repair the high voltage battery system, as necessary, free of charge. Owner notification letters were mailed August 25, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 280.
Hyundai Motor America (Hyundai) is recalling certain 2025 Hyundai IONIQ 5 vehicles. The right-side headlight may have an incorrect headlight aim label, which can result in improperly aimed headlights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Improperly aimed headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash.
Remedy: Hyundai will mail owners a corrected label with inspection and installation instructions. Owners may bring their vehicle to a dealer for the repair, free of charge. Owner notification letters were mailed July 15, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 279.
Hyundai Motor America (Hyundai) is recalling certain 2025 Hyundai IONIQ 5 "N" vehicles equipped with left-foot braking (LFB) and N e-shift features. The integrated electronic brake (IEB) and vehicle control unit (VCU) software may cause reduced braking performance when LFB is activated. Additionally, the vehicle may continue to accelerate after the pedal is released and the vehicle's N e-shift feature is engaged.
Consequence & remedy
Consequence: Reduced braking performance and unexpected, continued acceleration increase the risk of a crash.
Remedy: Owners are advised not to use the LFB or N e-Shift features until the remedy has been performed. The IEB and VCU software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed April 25, 2025. This recall replaces NHTSA recall number 25V-065. Vehicles repaired under the previous recall will need to have the new remedy completed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 277.
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 EV vehicles. The rear floor wiring harness may contain an open circuit, which can result in the rear side air bag not deploying as intended.
Consequence & remedy
Consequence: A rear side air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear floor wiring harness, as necessary, free of charge. Owner notification letters were mailed March 12, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 274.
Additional source detail variants (2)
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 EV vehicles. The rear floor wiring harness may contain an open circuit, which can result in the rear side air bag not deploying as intended.
Consequence: A rear side air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear floor wiring harness, as necessary, free of charge. Owner notification letters were mailed March 12, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 274.
Air Bags:side/window
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 EV vehicles. The rear floor wiring harness may contain an open circuit, which can result in the rear side air bag not deploying as intended.
Consequence: A rear side air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear floor wiring harness, as necessary, free of charge. Owner notification letters were mailed March 12, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 274.
Hyundai Motor America (Hyundai) is recalling certain 2025 Hyundai IONIQ 5 "N" vehicles equipped with a left-foot braking (LFB) feature. The integrated electronic brake (IEB) and vehicle control unit (VCU) software may cause reduced braking performance when LFB is activated.
Consequence & remedy
Consequence: Reduced braking performance can increase the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Owners who have not received the recall remedy are advised not to use the LFB feature until the updated remedy has been performed. Additionally, owners who have received the recall remedy are advised not to use the 'N' E-shift feature until the updated remedy has been performed. Dealers will update the IEB and VCU software, free of charge. Owner notification letters were mailed March 12, 2025. This recall is replaced by NHTSA recall number 25V-235. Vehicles already repaired under this recall will need to have the new remedy completed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 275.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2025 Hyundai Ioniq 5 Problems, Complaints & Recalls | Skip That Year
Illustration