NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
386 reportsMileage unknown · Jan 28, 2026
EngineFuel/propulsion SystemPower Train
While stopped at a stop light, "check electrical system" warning flashed on instrument panel without any prior warning or malfunction. I was only able to move the car about 50 feet before all power and controls failed. I was in a middle lane and was barely able to move the car out of traffic. Tow truck driver with a large jump …
Read full complaint
While stopped at a stop light, "check electrical system" warning flashed on instrument panel without any prior warning or malfunction. I was only able to move the car about 50 feet before all power and controls failed. I was in a middle lane and was barely able to move the car out of traffic. Tow truck driver with a large jump start battery pack was able to give it enough power for me to crawl it onto their flatbed, my small lithium jumpstart pack was only enough to get the rest of its doors unlocked. Battery temperature was about 30 degrees F, state of charge 75 percent, had been driving from home less than 10 minutes, car had been sitting outside for a few days. Problem diagnosed as ICCU failure by dealer service department, now waiting on replacement part to complete repair.
NHTSA ODI #11713902
Mileage unknown · Jan 28, 2026
Electrical System
The car became inoperable after a "Check EV" warning appeared. The vehicle had to be towed to the dealership. Fortunately I was able to avoid an accident. The dealer tells me that the ICCU (Integrated Charge Controller Unit) failed which was part of an earlier recall that I took the car in to the dealer for and they only updated…
Read full complaint
The car became inoperable after a "Check EV" warning appeared. The vehicle had to be towed to the dealership. Fortunately I was able to avoid an accident. The dealer tells me that the ICCU (Integrated Charge Controller Unit) failed which was part of an earlier recall that I took the car in to the dealer for and they only updated software but now the related hardware has failed afterwards. This is something that is extremely unsafe if it happens while driving. Hyundai needs to correct this with an improved and safe ICCU.
NHTSA ODI #11713880
Mileage unknown · Jan 27, 2026
Electrical SystemPower Train
While driving my 2023 Ioniq5 I got a warning on the dashboard about losing power and immedately the car slowed itself down to about 15 MPH, once I was able to get to a safe spot to pull over I stopped the car and it would not start again. I had it towed to the dealer and it has been a week and the ICCU is still on backorder. …
Read full complaint
While driving my 2023 Ioniq5 I got a warning on the dashboard about losing power and immedately the car slowed itself down to about 15 MPH, once I was able to get to a safe spot to pull over I stopped the car and it would not start again. I had it towed to the dealer and it has been a week and the ICCU is still on backorder. No idea when I will have the car back.
NHTSA ODI #11713769
Mileage unknown · Jan 27, 2026
Electrical System
ICCU failure. All recalls had been performed prior to failure. Vehicle showed the following warnings: "12 volt battery low", "stop safely", "check electric vehicle system", "stop vehicle and check power supply". Replaced 12-volt battery, still showing error messages, unable to be driven, required a tow to the dealer. OBD-II sc…
Read full complaint
ICCU failure. All recalls had been performed prior to failure. Vehicle showed the following warnings: "12 volt battery low", "stop safely", "check electric vehicle system", "stop vehicle and check power supply". Replaced 12-volt battery, still showing error messages, unable to be driven, required a tow to the dealer. OBD-II scan showed error P1A9096, confirmed by dealer as an ICCU malfunction.
NHTSA ODI #11713655
Mileage unknown · Jan 27, 2026
Electrical System
The car stopped being able to charge on AC level 1 and level 2, only able to charge on DC Fast. Took it to the dealership and they diagnosed an ICCU failure, rendering it undriveable. The part is under warranty but is backordered. I have already been waiting for 14 days, and they have no update for when they'll get the part in.
NHTSA ODI #11713617
Mileage unknown · Jan 23, 2026
Unknown Or Other
ICCU Unit went bad in 2025. Car totally dead. Jumped, taken to dealership, about 1 week to fix ICCU and blown fuse. A couple months later car totally dead again. Now bad battery. I am concerned about driving anywhere now. Was stranded last time it totally died. 75 year old female, should not have to pay $699 a month for i…
Read full complaint
ICCU Unit went bad in 2025. Car totally dead. Jumped, taken to dealership, about 1 week to fix ICCU and blown fuse. A couple months later car totally dead again. Now bad battery. I am concerned about driving anywhere now. Was stranded last time it totally died. 75 year old female, should not have to pay $699 a month for iffy Ionic 5 and rent a dependable vehicle if I travel to visit friends and family.
NHTSA ODI #11712876
Mileage unknown · Jan 23, 2026
Power Train
The car had no power on Monday [XXX]. It was taken taken to Tasca Hyundai in Hartsdale NY. The service manager told me it was the ICCU and 12v battery. This had previously been repaired on 12/11/24 under recall according to Hyundai's own records. The current service manager has no idea when the part will be available, possibl…
Read full complaint
The car had no power on Monday [XXX]. It was taken taken to Tasca Hyundai in Hartsdale NY. The service manager told me it was the ICCU and 12v battery. This had previously been repaired on 12/11/24 under recall according to Hyundai's own records. The current service manager has no idea when the part will be available, possibly not for weeks. The car has been serviced according to Hyundai's maintenance schedule and recall notices. In fact the car went for maintenance one week prior to the part failure. No recall notice for this failure has been issued INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11712858
Mileage unknown · Jan 21, 2026
Electrical SystemUnknown Or Other
Hyundai model Ioniq 5 (all years and trim styles) have a known issue with ICCUs (Integrated Charging Control Unit) that fail. This component controls charging of the 12 volt battery, and in turn electrical systems. Hyundai replaced my ICCU, but I am concerned it may fail again, as the underlying issue does not seem to be known o…
Read full complaint
Hyundai model Ioniq 5 (all years and trim styles) have a known issue with ICCUs (Integrated Charging Control Unit) that fail. This component controls charging of the 12 volt battery, and in turn electrical systems. Hyundai replaced my ICCU, but I am concerned it may fail again, as the underlying issue does not seem to be known or addressed. When the ICCU fails, the vehicle can suddenly lose the ability to move. This can be extremely dangerous if the car is in motion and unable to safely pull over. Luckily, my ICCU failed in the middle of a parking lot. Many Ioniq 5 owners report this issue, some multiple times on multiple ICCUs.
NHTSA ODI #11712391
Mileage unknown · Jan 21, 2026
Electrical System
ICCU failed, leaving the car incapacitated and driver stranded. Car was towed to the dealership and repaired under warranty.
NHTSA ODI #11712385
Mileage unknown · Jan 20, 2026
Electrical SystemPower Train
Vehicle experienced sudden loss of power while driving at highway speed. While driving on the interstate at highway speed in dark, snowy, high-traffic conditions, the vehicle displayed a warning about an electrical system fault and instructed me to “stop safely.” The vehicle immediately lost some propulsion and ramped down spee…
Read full complaint
Vehicle experienced sudden loss of power while driving at highway speed. While driving on the interstate at highway speed in dark, snowy, high-traffic conditions, the vehicle displayed a warning about an electrical system fault and instructed me to “stop safely.” The vehicle immediately lost some propulsion and ramped down speed. We were only narrowly able to exit the highway before it would not move further. We were very lucky that no one hit us- it is extremely unsafe to drastically decrease speed on highway. Our family was in the car and it was very, very scary. We were able to use the heating system while parked for a few minutes before we lost all power completely. The vehicle was towed to a Hyundai dealership and is completely inoperable. The service manager stated the failure is consistent with a known ICCU (Integrated Charging Control Unit) failure. The dealership reports having many Ioniq vehicles with similar ICCU failures awaiting backordered parts, with no estimated repair timeline.
NHTSA ODI #11712173
Official recalls
4Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Feb 1, 2024
Hyundai Motor America (Hyundai) is recalling certain 2023 IONIQ 5, IONIQ 6, and Genesis GV60 vehicles. The rear inner driveshaft may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the rear inner driveshaft, free of charge. Owner notification letters were mailed March 29, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 253(H), 017G(G).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration