NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
314 reports1,789 miles · Aug 14, 2008
Fuel System, Gasoline
TOOK A 375 MILE/ 8 HOUR TRIP. NEW 2008 HYUNDAI ELANTRA W/LESS THAN 1800 MILES. UPON EXITING EXPRESSWAY, ENGINE STRUGGLED, AS IF TRYING TO SHIFT TO NEXT GEAR, BUT BUCKED & HESITATED. AFTER STOPPED AT A RED LIGHT, PROCEEDED TO CROSS BUSY INTERSECTION. CAR SPUTTERED AND STALLED .CHECK ENGINE LIGHT CAME ON AND STAYED ON. 5 FAI…
Read full complaint
TOOK A 375 MILE/ 8 HOUR TRIP. NEW 2008 HYUNDAI ELANTRA W/LESS THAN 1800 MILES. UPON EXITING EXPRESSWAY, ENGINE STRUGGLED, AS IF TRYING TO SHIFT TO NEXT GEAR, BUT BUCKED & HESITATED. AFTER STOPPED AT A RED LIGHT, PROCEEDED TO CROSS BUSY INTERSECTION. CAR SPUTTERED AND STALLED .CHECK ENGINE LIGHT CAME ON AND STAYED ON. 5 FAILED ATTEMPTS TO RESTART BUT DID AFTER 9 MINUTES. MADE IT TO DESTINATION. LOCAL HYUNDAI SERVICE CENTER CLOSED. FORCED TO ATTEMPT TRIP BACK NEXT DAY. HAD TO DRIVE THROUGH VERY HEAVY TRAFFIC - INCLUDING THE GEORGE WASHINGTON BRIDGE, AND WINDING MOUNTAIN ROADS IN PA. CAR ACTED UP 3-4 TIMES, EACH TIME LOSING SPEED, SPUTTERING & BUCKING. WHILE NEVER ACTUALLY STALLED, COULD HAVE BEEN CATASTROPHIC. ACTED WORSE WHILE ACCELERATING - SOUNDED LIKE ENGINE CUTTING OUT. DROPPED IT OFF TO DEALERSHIP WHERE PURCHASED 8/10/08. NEXT DAY, INFORMED OF BROKEN FUEL PUMP. BEING REPLACED WITH A NEW ONE - READY TODAY, 8/14/08. AFTER READING SO MANY SIMILAR STORIES ON-LINE, I FELT I HAD TO INFORM YOU OF MY INCIDENT. I BELIEVE THERE NEEDS TO BE A RECALL - ESPECIALLY AS THERE ARE SO MANY 2008 ELANTRAS ON THE ROAD. HAD WE NEEDED TO MAKE AN EMERGENCY ESCAPE OF OUR STALLED CAR, IN NY TRAFFIC, WE WOULD HAVE LIKELY BEEN KILLED TRYING TO EXIT, AND PROBABLY BEEN RUN OVER BY A TRACTOR TRAILER HAD WE STAYED IN THE CAR. WE CERTAINLY WOULD NOT HAVE BEEN ABLE TO GET OUR CRATED PUPPY OUT OF THE BACK SEAT, AS A PARENT WOULD NOT BE ABLE TO RESCUE A BABY IN AN INFANT SEAT. THIS IS A SERIES OF TRAGEDIES WAITING TO HAPPEN!!!! I WILL STILL NOT FEEL CONFIDENT DRIVING MY 3 1/2 MONTH OLD CAR, AS MANY PEOPLE CONTINUE TO HAVE TROUBLE EVEN WITH REPLACED PARTS. I IMPLORE YOU TO PROBE DEEPER IN TO THIS MATTER AND HAVE HYUNDAI CORRECT THIS PROBLEM...BEFORE MANY PEOPLE BECOME A FATALITY STATISTIC! *TR
NHTSA ODI #10238137
25 miles · Aug 9, 2008
Fuel System, Gasoline
PURCHASED A NEW 2008 HYUNDAI ELANTRA. LEFT THE DEALERSHIP WITH THE NEW CAR AND AFTER DRIVING ABOUT 10 MILES, NOTICED THAT THE CAR WAS HESITATING AND COULD NOT INCREASE SPEED AND SHIFT TO THE NEXT HIGHER GEAR. THE CAR FINALLY SHIFTED TO THE FINAL GEAR AND ALL WAS WELL FOR ABOUT 10 MORE MILES; THEN THE CAR STARTED TO SLOW DOWN TO …
Read full complaint
PURCHASED A NEW 2008 HYUNDAI ELANTRA. LEFT THE DEALERSHIP WITH THE NEW CAR AND AFTER DRIVING ABOUT 10 MILES, NOTICED THAT THE CAR WAS HESITATING AND COULD NOT INCREASE SPEED AND SHIFT TO THE NEXT HIGHER GEAR. THE CAR FINALLY SHIFTED TO THE FINAL GEAR AND ALL WAS WELL FOR ABOUT 10 MORE MILES; THEN THE CAR STARTED TO SLOW DOWN TO THE POINT WHERE FEEDING GAS WAS NOT HELPING. THE CAR CRAWLED TO A STOP AT A FREEWAY EXIT (FORTUNATELY) AND I CONTACTED THE DEALER. THEY ARRANGED TOWING AND DELIVERED ME A LOANER. THE FUEL PUMP FAILED AFTER ONLY 20 MILES OF DRIVING THE NEW CAR. *TR
NHTSA ODI #10237560
3,500 miles · Aug 6, 2008
Fuel System, Gasoline
I HAVE A HYUNDAI ELANTRA WHICH ONE HAD 3500 MILES ON IT AND THE CARS FUEL PUMP WENT WHILE I WAS DIVING IT. JUST STARTED TO SPUTTER AND THE CHECK ENGINE LIGHT CAME ON. HAD TO HAVE IT TOW TO DEALERSHIP WHERE THEY REPLACED THE FUEL PUMP. *TR
NHTSA ODI #10237109
1,432 miles · Aug 5, 2008
Fuel System, Gasoline
MY 2008 ELANTRA SE WHICH I BOUGHT IN MAY HAS HAD TWO "EPISODES" OF STALLING. THE FIRST (OD 1100 MI) ON JULY 14 OCCURRED ON THE FREEWAY AND BEGAN AS A SLIGHT HESITATION THAT GOT PROGRESSIVELY WORSE SUCH THAT WE TOOK THE NEXT EXIT AND LIMPED HOME ON BACK ROADS. THE CHECK ENGINE LIGHT CAME ON AND THE CAR STALLED TWICE BEFORE WE F…
Read full complaint
MY 2008 ELANTRA SE WHICH I BOUGHT IN MAY HAS HAD TWO "EPISODES" OF STALLING. THE FIRST (OD 1100 MI) ON JULY 14 OCCURRED ON THE FREEWAY AND BEGAN AS A SLIGHT HESITATION THAT GOT PROGRESSIVELY WORSE SUCH THAT WE TOOK THE NEXT EXIT AND LIMPED HOME ON BACK ROADS. THE CHECK ENGINE LIGHT CAME ON AND THE CAR STALLED TWICE BEFORE WE FINALLY MADE IT HOME. THE NEXT DAY I WAS ABLE TO DRIVE IT TO THE DEALER ABOUT 5 MILES AWAY. THEIR DIAGNOSIS WAS A BAD OXYGEN SENSOR WHICH THEY DIDN'T HAVE IN STOCK. THEY SAID IT WOULD BE OK TO DRIVE THE CAR UNTIL THE NEW SENSOR ARRIVED. IT RAN FINE AND 3 DAYS LATER I TOOK IT IN TO HAVE THE SENSOR REPLACED. THEY RAN DIAGNOSTICS AGAIN AND SAID THE SENSOR WAS OK AND NEEDN'T BE REPLACED. THEY SAID MAYBE IT WAS BAD GAS OR VAPOR LOCK AND SENT ME ON MY WAY. THE CAR RAN FINE UNTIL THIS AFTERNOON (AUG 5) WHEN IT BEGAN HESITATING (OD 1432 MI) ON THE FREEWAY AND ONCE AGAIN I TOOK THE FIRST EXIT AND LIMPED HOME, UNABLE TO EXCEED 25 MPH, BUCKING ALL THE WAY. MY WIFE FOLLOWED ME TO THE DEALER AND FOR THE LAST MILE WERE UNABLE TO GO OVER 5 MPH (EMERGENCY FLASHERS ON). WE NEVER MADE IT AS THE ELANTRA SHUT DOWN COMPLETELY IN RUSH HOUR TRAFFIC AND I HAD TO GET OUT AND PUSH INTO A NEARBY PARKING LOT. I CALLED HYUNDAI ROADSIDE ASSISTANCE AND HAD THE CAR TRUCKED TO THE DEALER, ONLY ABOUT 4 BLOCKS AWAY. I UNDERSTAND NHTSA IS INVESTIGATING 07-08 ELANTRA STALLING COMPLAINTS AND WANTED TO ADD ANOTHER DATA POINT FOR YOUR CONSIDERATION. *TR
NHTSA ODI #10237104
1,586 miles · Aug 4, 2008
Air BagsCrashInjury
ON MAY 26 2008 MY WIFE AND I WERE INVOLVED IN AN ACCIDENT. ANOTHER CAR RAN THE RED LIGHT AND HIT US. MY WIFE AND I WERE INJURED AND OUR CAR WAS TOTALED. NONE OF THE AIRBAGS WENT OFF ON OUR BRAND NEW 2008 HYUNDAI ELANTRA. WE WERE LATER TOLD BY HYUNDAI THAT PASSENGER AIRBAGS DON'T ALWAYS GO OFF BECAUSE OF WEIGHT VARIATIONS IN SOME…
Read full complaint
ON MAY 26 2008 MY WIFE AND I WERE INVOLVED IN AN ACCIDENT. ANOTHER CAR RAN THE RED LIGHT AND HIT US. MY WIFE AND I WERE INJURED AND OUR CAR WAS TOTALED. NONE OF THE AIRBAGS WENT OFF ON OUR BRAND NEW 2008 HYUNDAI ELANTRA. WE WERE LATER TOLD BY HYUNDAI THAT PASSENGER AIRBAGS DON'T ALWAYS GO OFF BECAUSE OF WEIGHT VARIATIONS IN SOME ADULTS. MY WIFE IS 5' 4" AND HER WEIGHT IS NORMAL FOR HER HEIGHT. HYUNDAI NEVER TOLD US OF THIS POTENTIAL PROBLEM WITH AIRBAG DEPLOYMENT. THIS COMPANY SHOULD BE REQUIRED TO INFORM THE POTENTIAL BUYER LIMITATIONS INVOLVING SAFETY FEATURES! MANY UNSUSPECTING PEOPLE COULD BE SEVERELY INJURED WITHOUT THIS KNOWLEDGE. ALSO THIS INFORMATION SHOULD BE GIVEN TO THE POTENTIAL BUYER PRIOR TO PURCHASING THE VEHICLE NOT AFTER! WE PURCHASES A SECOND HYUNDAI ( 2008 TUCSON) AND THIS VEHICLE HAS HAD PROBLEMS WITH ITS PASSENGER AIRBAG - IN FACT IT WAS DURING THIS REPAIR THAT HYUNDAI INFORMED US OF THE WEIGHT ISSUE INVOLVING AIRBAGS. *TR UPDATED 01-26-09 *BF UPDATED 01/2609. *JB UPDATED 07/16/10.*JB
NHTSA ODI #10236945
400 miles · Aug 4, 2008
Fuel System, Gasoline
BRAND NEW CAR THAT AFTER THREE WEEKS OF OWNERSHIP STALLED IN THE MIDDLE OF THE ROAD. DEALERSHIP REPLACED AIR SENSORS, CAR STALLED AGAIN. FINALLY DETERMINED FUEL PUMP WAS BAD AND REPLACED FUEL PUMP FROM A CAR ON THE LOT, CAR STALLED AGAIN. FUEL PUMP REPLACED WITH NEW FUEL PUMP, CAR STILL STALLING. HAVE BROUGHT CAR IN 7 TIMES …
Read full complaint
BRAND NEW CAR THAT AFTER THREE WEEKS OF OWNERSHIP STALLED IN THE MIDDLE OF THE ROAD. DEALERSHIP REPLACED AIR SENSORS, CAR STALLED AGAIN. FINALLY DETERMINED FUEL PUMP WAS BAD AND REPLACED FUEL PUMP FROM A CAR ON THE LOT, CAR STALLED AGAIN. FUEL PUMP REPLACED WITH NEW FUEL PUMP, CAR STILL STALLING. HAVE BROUGHT CAR IN 7 TIMES NOW AND AM NOW BEING TOLD TO GO HOME WITH THE CAR BECAUSE THEY DON'T WANT TO LOOK AT IT. *TR
NHTSA ODI #10236893
1,115 miles · Aug 4, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. WHILE TURNING AT 15 MPH, THE VEHICLE SUDDENLY BEGAN TO LOSE POWER WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. INSTEAD OF ACCELERATING, THE ENGINE SLOWED DOWN, BUT NEVER LOST COMPLETE POWER. THE CONTACT PULLED THE VEHICLE OVER FOR APPROXIMATELY 20 MINUTES AND ATTEMPTED TO RESTART IT, B…
Read full complaint
TL*THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. WHILE TURNING AT 15 MPH, THE VEHICLE SUDDENLY BEGAN TO LOSE POWER WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. INSTEAD OF ACCELERATING, THE ENGINE SLOWED DOWN, BUT NEVER LOST COMPLETE POWER. THE CONTACT PULLED THE VEHICLE OVER FOR APPROXIMATELY 20 MINUTES AND ATTEMPTED TO RESTART IT, BUT WAS UNSUCCESSFUL. WHEN SHE PROCEEDED TO ACCELERATE, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT DROVE THE VEHICLE BACK TO HER RESIDENCE. THE FOLLOWING DAY THE VEHICLE WAS TOWED TO A DEALER AND THEY STATED THAT NOTHING WAS WRONG WITH THE VEHICLE; HOWEVER, THEY SUSPECTED THAT THE FAILURE COULD HAVE BEEN DUE TO THE FUEL QUALITY. THROUGH ONLINE RESEARCH, THE CONTACT FOUND NUMEROUS COMPLAINTS AND EVEN AN INVESTIGATION ON THE SAME FAILURE SHE IS EXPERIENCING. THE CURRENT AND FAILURE MILEAGES WERE 1,115.
NHTSA ODI #10236810
1,164 miles · Aug 1, 2008
Fuel System, Gasoline
I GOT INTO MY CAR 120 MILES FROM HOME AND NOTICED MY CHECK ENGINE LIGHT WAS ON. I CALLED MY DEALER WHERE I BOUGHT THE CAR FROM AND TOLD THEM. THEY MADE AN APPOINTMENT FOR ME TO BRING IT IN. I PROCEEDED TO TRAVEL BACK HOME 120 MILES AWAY AND WAS AT A LIGHT. THE LIGHT CHANGED I PUT MY FOOT ON THE PEDAL AND IT WENT 5 MILES AND …
Read full complaint
I GOT INTO MY CAR 120 MILES FROM HOME AND NOTICED MY CHECK ENGINE LIGHT WAS ON. I CALLED MY DEALER WHERE I BOUGHT THE CAR FROM AND TOLD THEM. THEY MADE AN APPOINTMENT FOR ME TO BRING IT IN. I PROCEEDED TO TRAVEL BACK HOME 120 MILES AWAY AND WAS AT A LIGHT. THE LIGHT CHANGED I PUT MY FOOT ON THE PEDAL AND IT WENT 5 MILES AND HOUR. I PULLED OVER CALLED THE 800 NUMBER ON THE CAR FOR HYUNDAI WAS TOLD THEY WOULD TOW THE CAR TO THE CLOSEST DEALER. I HAD NO PROBLEM WITH THAT BUT I WANTED TO KNOW HOW I COULD GET BACK HOME 120 MILES. THEY TOLD ME THE DEALER SHOULD GIVE ME A LOANER CAR. THEY WOULD NOT BECAUSE I DID NOT PURCHASE THE CAR FROM THEM..I CONTINUED TO TRY AND MAKE IT HOME AND THE CAR BROKE DOWN 30 MILES INTO THE DRIVE. CALLED THE DEALER I GOT THE CAR FROM AND THEY HAD A TOW TRUCK COME AND GET ME. THE FINAL PART OF THE STORY IS THAT IT WAS THE FUEL PUMP. THERE SHOULD BE A RECALL. I COULD HAVE KILLED MYSELF AND OTHERS IF I DID NOT STAY IN THE RIGHT HAND LANE. HYUNDAI WAS NOT A PLEASURE TO WORK WITH. I HAVE NOT EVEN HAD MY CAR 30 DAYS AND IT BROKE DOWN. *TR
NHTSA ODI #10236662
4,750 miles · Jul 27, 2008
Engine And Engine Cooling
MY 2008 HYUNDAI ELANTRA STARTED LOSING POWER AT 70 MPH, AND ALMOST STALLED ON THE HIGHWAY. I PULLED OFF THE ROAD AT THE NEXT EXIT AND THE CAR CONTINUED TO REDUCE SPEED. I SAFELY PARKED THE CAR, AND HAD TO HAVE THE CAR TOWED. I WAS 300 MILES AWAY FROM MY HOME. IF I HAD STALLED ON THE HIGHWAY IT WOULD HAVE BEEN EXTREMELY DANGE…
Read full complaint
MY 2008 HYUNDAI ELANTRA STARTED LOSING POWER AT 70 MPH, AND ALMOST STALLED ON THE HIGHWAY. I PULLED OFF THE ROAD AT THE NEXT EXIT AND THE CAR CONTINUED TO REDUCE SPEED. I SAFELY PARKED THE CAR, AND HAD TO HAVE THE CAR TOWED. I WAS 300 MILES AWAY FROM MY HOME. IF I HAD STALLED ON THE HIGHWAY IT WOULD HAVE BEEN EXTREMELY DANGEROUS. *TR
NHTSA ODI #10235951
3,455 miles · Jul 23, 2008
Engine And Engine Cooling
I HAVE A 2008 ELANTRA THAT STALLED ON JULY 21, 2008 ON THE NEW JERSEY TURNPIKE WHEN IT HAD 3,455 MILES. THE CAR DECELERATED SO QUICKLY THAT I WAS ALMOST REAR ENDED BY AN 18-WHEELER. A HALF HOUR EARLIER IT NEARLY STALLED IN AN INTERSECTION AND ALMOST CAUSED AN ACCIDENT. THE CHECK ENGINE LIGHT TURNED ON APPROXIMATELY 10 MINUTES BE…
Read full complaint
I HAVE A 2008 ELANTRA THAT STALLED ON JULY 21, 2008 ON THE NEW JERSEY TURNPIKE WHEN IT HAD 3,455 MILES. THE CAR DECELERATED SO QUICKLY THAT I WAS ALMOST REAR ENDED BY AN 18-WHEELER. A HALF HOUR EARLIER IT NEARLY STALLED IN AN INTERSECTION AND ALMOST CAUSED AN ACCIDENT. THE CHECK ENGINE LIGHT TURNED ON APPROXIMATELY 10 MINUTES BEFORE THE THE INTERSECTION INCIDENT AND 40 MINUTES BEFORE ALMOST BEING REAR ENDED BY THE TRUCK. A STATE TROOPER STOPPED TO MAKE SURE I WAS OKAY AND TO ESCORT ME TO THE TOLL BOTH / EXIT BUT I DON'T IMAGINE HE FILED A REPORT. I PUSH THE CAR OFF THE TURNPIKE EXIT AND HAD IT TOWED TO THE LOCAL HYUNDAI DEALER. THEY DIAGNOSED THE PROBLEM AS A FAILED FUEL PUMP AND REPLACED THE PART. THERE WAS NO ACCIDENT AND NO ONE WAS INJURED BUT THE POSSIBILITY OF INJURY WAS VERY REAL. *TR
NHTSA ODI #10235488
Official recalls
7Feb 4, 2020
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
Feb 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2008-2010 Elantra vehicles manufactured June 1, 2008, to April 30, 2010, and 2009-2010 Elantra Touring vehicles manufactured November 1, 2008, to April 30, 2010. The electronic power steering (EPS) electronic control unit (ECU) may sense a discrepancy in the steering input signals and, as a result, disable the steering power assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Hyundai will verify the proper operation of the Electronic Power Steering (EPS) and update the EPS control unit, free of charge. The recall began April 14, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 127.
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2009 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH NOVEMBER 1, 2008. THE FRONT PASSENGER SEATS IN THE VEHICLES CONTAIN A WEIGHT SENSOR DESIGNED TO DEACTIVATE THE RIGHT FRONTAL AIRBAG WHEN OCCUPANTS OF CERTAIN WEIGHTS OCCUPY THE SEAT. THE ELECTRICAL CONNECTOR FOR THE WEIGHT SENSOR IS LOCATED UNDER THE CENTER CONSOLE, BETWEEN THE FRONT SEATS. UNDER CERTAIN CIRCUMSTANCES THE CONNECTOR COULD BECOME CONTAMINATED AND MALFUNCTION SUCH THAT THE FRONT PASSENGER AIRBAG WILL DEPLOY REGARDLESS OF THE WEIGHT OF THE OCCUPANT.
Consequence & remedy
Consequence: THE FRONT PASSENGER AIR BAG COULD DEPLOY IN CRASHES IN WHICH IT SHOULD NOT DEPLOY, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT FROM THE DEPLOYED AIR BAG.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE WEIGHT CLASSIFICATION SYSTEM CONNECTOR TO PREVENT CONTAMINATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH AUGUST 29, 2007. THE DRIVER'S SEAT TRACK POSITION SENSOR DETERMINES THE SEAT'S FORE AND AFT POSITION AND ALLOWS THE DRIVER'S FRONTAL AIR BAG TO DEPLOY AT THE PRESSURE APPROPRIATE FOR THAT SEATING POSITION, WITH A LOWER PRESSURE DEPLOYMENT IN THE MOST FORWARD SEATING POSITIONS. THE AIR BAG CONTROL MODULE MAY RECEIVE AN UNSTABLE ELECTRICAL SIGNAL FROM THE SEAT TRACK POSITION SENSOR SUCH THAT, IN A CRASH THAT REQUIRES DRIVER FRONTAL AIRBAG DEPLOYMENT, THE DRIVER'S AIRBAG MAY DEPLOY AT THE HIGHER PRESSURE THAN INTENDED IF THE SEAT WAS POSITION IN ONE OF THE FORWARD POSITIONS IN WHICH A LOWER PRESSURE DEPLOYMENT IS INTENDED.
Consequence & remedy
Consequence: A HIGHER PRESSURE DEPLOYMENT THAN INTENDED INCREASES THE RISK OF INJURY RESULTING FROM AIRBAG DEPLOYMENT.
Remedy: DEALERS WILL REPROGRAM THE AIR BAG CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Dec 29, 2008
HYUNDAI DE PUERTO RICO (HPR) IS RECALLING 347 MY 2008 ELANTRA VEHICLES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER, UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: AS A RESULT, POOR ENGINE STARING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT AND LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE VEHICLE'S FUEL PUMP SUBASSEMBLY. THE RECALL BEGAN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT HPR AT 1-800-981-0188.
Aug 25, 2008
HYUNDAI IS RECALLING 65,000 MY 2008 ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: POOR ENGINE STARTING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP SUBASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE08044 · Engine Stalling - Fuel Pump Failure
Opened Jul 17, 2008 · Closed Sep 3, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Fuel System, Gasoline
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Illustration