WHEN AN ADULT PASSENGER WAS IN THE FRONT SEAT AN INDICATOR ILLUMINATED WHICH STATED THAT PASSENGER'S SIDE AIR BAG WAS OFF. CONSUMER CONTACTED THE DEALER, WHO INDICATED THAT THIS VEHICLE WAS NOT PART OF NHTSA RECALL 03V322000 CONCERNING AIR BAG FAILURE. *AK CONSUMERS WIFE WHO IS ABOUT 130LBS EXPERIENCES THIS ISSUE WHEN IN …
Read full complaint
WHEN AN ADULT PASSENGER WAS IN THE FRONT SEAT AN INDICATOR ILLUMINATED WHICH STATED THAT PASSENGER'S SIDE AIR BAG WAS OFF. CONSUMER CONTACTED THE DEALER, WHO INDICATED THAT THIS VEHICLE WAS NOT PART OF NHTSA RECALL 03V322000 CONCERNING AIR BAG FAILURE. *AK CONSUMERS WIFE WHO IS ABOUT 130LBS EXPERIENCES THIS ISSUE WHEN IN THE PASS. SEAT. DRIVING AROUND CORNERS OR UP HILLS TURNS THE BAG ON AND OFF. THE DEALER CAN NOT FIX THE ISSUE.CW
NHTSA ODI #10061518
470 miles · Feb 26, 2004
Air Bags
PASSENGER'S SIDE AIR BAG SENSOR IS NOT WORKING PROPERLY. THE PASSENGER-SIDE FRONT SEAT IS SUPPOSED TO HAVE A SENSOR THAT ACTIVATES THE AIR BAG SYSTEM WHEN SOMEONE OVER 56 POUNDS IN WEIGHT SITS IN THAT SEATING POSITION. HOWEVER, THIS IS NOT THE CASE. THE AIR BAG SYSTEM SENSOR WILL INTERMITTENTLY OPERATE CORRECTLY. CONSUMER WA…
Read full complaint
PASSENGER'S SIDE AIR BAG SENSOR IS NOT WORKING PROPERLY. THE PASSENGER-SIDE FRONT SEAT IS SUPPOSED TO HAVE A SENSOR THAT ACTIVATES THE AIR BAG SYSTEM WHEN SOMEONE OVER 56 POUNDS IN WEIGHT SITS IN THAT SEATING POSITION. HOWEVER, THIS IS NOT THE CASE. THE AIR BAG SYSTEM SENSOR WILL INTERMITTENTLY OPERATE CORRECTLY. CONSUMER WAS ADVISED THAT HER VEHICLE'S IDENTIFICATION NUMBER IS OUTSIDE OF THE SCOPE OF THE SAFETY RECALL (CAMPAIGN NO. 03V-322). *AL *MJJ
NHTSA ODI #10057236
3 miles · Feb 24, 2004
Air Bags
THE AIR BAG OFF LIGHT ILLUMINATED WHEN THERE WAS A PASSENGER IN THE SEAT. THE SEAT SENSORS WAS REPLACED, HOWEVER IT DID NOT RESOLVE THE PROBLEM. THE CONSUMER GAVE THE FIRST ELANTRA BACK TO THE DEALER AND WAS GIVEN A REPLACEMENT SAME MODEL AND YEAR, BUT THE PROBLEM EXISTED IN THAT CART AS WELL. *AK *JB
NHTSA ODI #10055607
Mileage unknown · Feb 19, 2004
Air Bags
AT THE TIME OF PURCHASE, CONSUMER NOTICED THE PASSENGER AIR BAG OFF LIGHT WAS NOT FUNCTIONING PROPERLY. *LA THE OCCUPANT CLASSIFICATION SENSOR INCORRECTLY INTERPRETED THE ABSENCE OF A SEATED ADULT WHEN AN ADULT IN FACT OCCUPIED THE SEAT. THIS CAUSED THE PASSENGER AIRBAG OFF INDICATOR TO ILLUMINATE AND IN THE EVEN OF A CRASH THE…
Read full complaint
AT THE TIME OF PURCHASE, CONSUMER NOTICED THE PASSENGER AIR BAG OFF LIGHT WAS NOT FUNCTIONING PROPERLY. *LA THE OCCUPANT CLASSIFICATION SENSOR INCORRECTLY INTERPRETED THE ABSENCE OF A SEATED ADULT WHEN AN ADULT IN FACT OCCUPIED THE SEAT. THIS CAUSED THE PASSENGER AIRBAG OFF INDICATOR TO ILLUMINATE AND IN THE EVEN OF A CRASH THE AIRBAG WOULD NOT DEPLOY . THE CONSUMER STATED SEVERAL VEHICLES WERE RECALL FOR THE PROBLEM IN THE PAST. (RECALL #03V322000). THE CONSUMER TOOK THE VEHICLE TO THE DEALER ON SEVERAL OCCASIONS. THE FIRST TIME THE DEALER WAS UNABLE TO ADDRESS THE PROBLEM AND THEY STATED THE HAD TO CONSULT WITH THE MANUFACTURER. THE SECOND TIME THE PASSENGER AIRBAG SENSOR WAS REPLACED AND WAS REPORTED TO BE WORKING PROPERLY WITH 60LB WEIGHT IN THE SEAT. THE THIRD TIME THE DEALER RECEIVED AN EXTRA SENSITIVE SENSOR FROM THE MANUFACTURER. THE FOURTH TIME THE CONSUMER CONTACTED THE DEALER AND STATED THERE HAD BEEN NO CHANGE. THE DEALER INFORMED THE CONSUMER THE PART WAS REPLACED WITH THE NEWEST THAT THERE WAS AND THERE WOULD BE NO FURTHER ASSISTANCE. *JB
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence & remedy
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON NOVEMBER 15, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence & remedy
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST, IT WAS DETERMINED THAT FUEL TAN DAMAGE COULD OCCUR. ON CERTAIN PASSENGER VEHICLES, A VAPOR TUBE HOSE CLAMP THAT IS LOCATED NEAR THE FUEL TANK MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP EARS AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE HOSE CLAMP EAR AND THE FUEL TANK. THE VAPOR TUBE HOSE CLAMP EAR WAS FOUND TO BE MISPOSITIONED AND FACING TOWARD THE FUEL TANK.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, DAMAGE TO THE VEHICLE COULD CAUSE THE MISPOSITIONED CLAMP TO PUNCTURE THE FUEL TANK CAUSING FUEL LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56.4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. HOWEVER, THE OCCUPANT CLASSIFICATION SENSOR MAY INCORRECTLY INTERPRET THAT A SEATED ADULT IS AN INFANT SEAT AND DEACTIVATE THE PASSENGER AIR BAG IF SOMEONE HEAVIER THAN 56.4 POUNDS WHO IS SEATED WITH ONE LEG RESTING ON THE OUTBOARD OR INBOARD EDGE OF THE SEAT; WITH LEGS SPREAD; OR POSITIONED OFF-CENTER TOWARD THE CENTER CONSOLE AND WITH HIS OR HER ARM LEANING ON THE CONSOLE.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.
Remedy: THE OCCUPANT CLASSIFICATION SENSOR WILL BE REPROGRAMMED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Fuel System, Gasoline:storage:tank Assembly
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Illustration