Air Bags. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports1 fire reports3 injury reports

What owners actually said

131 reports

65,000 miles · Dec 17, 2012

Seats

Read full complaint

TL* THE CONTACT OWNS A 2007 HYUNDAI AZERA. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE REAR OF THE DRIVER'S SEAT WOULD MOVE FORWARD INDEPENDENTLY, PUSHING THE CONTACT INTO THE STEERING WHEEL. THE CONTACT HAD TO PLAY AROUND WITH THE SEAT ADJUSTMENT SWITCHES IN ORDER TO GET THE SEAT TO RECLINE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP FOR INSPECTION BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 65,000.

NHTSA ODI #10488960

26,100 miles · Oct 24, 2012

Seat Belts

Read full complaint

TL* THE CONTACT OWNS A 2007 HYUNDAI AZERA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE UNDER NHTSA CAMPAIGN ID NUMBER 10V007000 (SEAT BELTS:FRONT). THE VEHICLE WAS REPAIRED HOWEVER TWO MONTHS LATER, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR DIAGNOSIS WHERE THE CONTACT WAS ADVISED THAT THE FRONT PASSENGER SEAT TENSION SENSOR FAILED AND WAS NOT RELATED TO RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE CONTACT FELT AS THOUGH THE PART WAS THE SAME AS THE RECALL COMPONENT AND SHOULD HAVE BEEN INCLUDED IN THE RECALL CAMPAIGN. THE FAILURE MILEAGE WAS APPROXIMATELY 26,100. THE CURRENT MILEAGE WAS APPROXIMATELY 32,651.

NHTSA ODI #10482100

Mileage unknown · Oct 17, 2012

Air BagsStructure

Read full complaint

I HAVE A CRACK, OUT LINING THE FRONT AIRBAG ON THE PASSENGER SIDE DASH . IT IS GETTING BIGGER. MY DEALER SAYS THAT IT WON'T EMPLOY ON USE, BUT I DON'T FEEL SAFE. THEY SAID THAT TO FIX IT RIGHT IT WILL NEED TO HAVE A NEW AIRBAG PUT IN BECAUSE THEY WOULD HAVE TO DISENGAGE THE ONE THAT IS IN THERE. THAT WILL COST US BETWEEN $600.00 AND $700.00. I FEEL THAT, THIS IS A SAFETY ISSUED AND SHOULD BE THE MANUFACTURER RESPONSIBILITY . I HAVE GOTTEN ON LINE AND HAVE SEE SEVERAL OTHER PEOPLE WHO HAVE HAD THIS PROBLEM. MAYBE THERE SHOULD BE A RECALL ON THIS MATTER. I DO NOT HAVE THIS KIND OF MONEY TO GET THIS REPAIRED. COULD YOU GRANTEE ME THAT IT IS SAFE TO DRIVE THIS WAS. *TR

NHTSA ODI #10480839

80,000 miles · Oct 6, 2012

Air Bags

WHILE DRIVING ALONE AIR BAG LIGHT ON DASH PANEL CAME ON STAYS ON ALL THE TIME. DEALER CLAIMS NOT A WARRANTY OR RECALL RELATED PROBLEM QUOTE AROUND 1200.00 REPAIR. *TR

NHTSA ODI #10478867

68,000 miles · Oct 3, 2012

Power Train

Read full complaint

I PUSHED DOWN THE GAS TO TRY TO PASS SOMEONE AND THE TRANSMISSION WENT INTO NEUTRAL. I COULD NOT GET IT TO RE ENGAGE AND HAD TO COAST TO THE SIDE OF THE FREEWAY, ALMOST GETTING HIT BY THE DRIVER BEHIND ME. DEALER HAD THE CAR TWO DAYS AND SAID THEY COULD NOT DUPLICATE AND REFUSED TO REPAIR EVEN THOUGH 100K WARRANTY IS IN EFFECT.THIS HAPPENED TWICE BEFORE IN 2010 AND 2011. BOTH TIMES THE CAR WAS BROUGHT TO THE DEALER AND NOTHING DONE. I WAS TOLD BY THE MECHANIC THAT HYUNDAI COULD AUTHORIZE A "FLIGHT RECORDER" TO BE INSTALLED IN MY CAR SO WHEN IT HAPPENS NEXT THEY WOULD HAVE A RECORDING OF THE ISSUE. THE DEALER PROMISED TO CALL ME MONDAY BUT SO FAR NO CALL BACK AND NO AUTHORIZATION. MY WIFE WON'T DRIVE THE CAR AND I AM UNEASY WITH IT. SHE WAS GOING TO BUY A HYUNDAI SONATA, BUT NOW REFUSES TO DO SO AND IS TELLING HER COUSINS THE STORY SO THEY ARE ALSO SWITCHING TO TOYOTA. WHAT A SHAME. *TR

NHTSA ODI #10478527

35,000 miles · Sep 24, 2012

Air BagsSeat Belts

Read full complaint

TL* THE CONTACT OWNS A 2007 HYUNDAI AZERA. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 35,000. UPDATED 10/31/12*LJ THE CONSUMER ALSO STATED THE VEHICLE WAS RECALLED FOR A DEFECTIVE SEAT BELT. THE SEAT BELT WAS FIXED, NOT REPLACED. THE SEAT BELT WARNING LIGHT ILLUMINATED FOR THE SECOND TIME. THE DEALER THEN REPLACED THE SEAT BELT, BUT WITH THE SAME TYPE OF BELT. UPDATED 10/31/12

NHTSA ODI #10476821

125,800 miles · Sep 17, 2012

Air BagsElectrical SystemSeat Belts

PASSENGER AIR BAG LIGHT COMES ON, PASSENGER SEAT BELT LIGHT COMES ON WHEN NO ONE IS SITTING IN SEAT. THE MODULE WAS REPLACED ABOUT 75,000 MILES. *TR

NHTSA ODI #10475589

37,662 miles · Aug 20, 2012

Electronic Stability Control (esc)SteeringCrash

Read full complaint

A STEERING FAILURE OCCURRED AT ABOUT 50 MPH WHILE ENTERING A GENTLE CURVE TO THE LEFT. IT CAUSED THE CAR TO VEER TO THE LEFT. CAR LEFT THE TRAVEL LANE AND BRIEFLY ENTERED THE SMOOTHLY PAVED AND LEVEL SHOULDER OF THE DIVIDED ROADWAY. CORRECTION TO THE RIGHT TRIGGERED ESC SYSTEM. AT THAT POINT THE DRIVER INPUT TO STEERING AND BRAKES WERE OVERRIDDEN BY THE ESC SYSTEM. ESC SENT CAR STRAIGHT AHEAD BUT WE WERE ON A CURVE. THIS SENT THE CAR INTO THE GUARD RAIL ON THE RIGHT SIDE OF THE ROAD AFTER CROSSING BOTH LANES BECAUSE THE CAR WOULD NOT RESPOND TO STEERING WHEEL FORCES OR TO BRAKES. THE CAR LIGHTLY GRAZED THE GUARD RAIL CAUSING A SHALLOW DENT IN THE REAR FENDER. BODY DAMAGE WAS LIMITED TO THE REAR FENDER IN THIS CASE AND THE AIRBAGS DID NOT DEPLOY. WHY NOT? THIS IS, HOWEVER, A DEADLY TYPE OF FAILURE BECAUSE THE CAR SENDS YOU WHEREVER IT WANTS TO GO AND YOU CANNOT DO ANYTHING ABOUT IT. WE COULD HAVE BEEN SENT INTO ONCOMING TRAFFIC OR OVER THE SIDE OF A CLIFF. AS THE CAR FINALLY SLOWED, THE ESC SYSTEM EVENTUALLY SHUT ITSELF OFF AND WE COULD, ONCE AGAIN, STEER THE CAR. BUT, THIS WAS WAY TOO LATE TO PREVENT THE DAMAGE. THE CAR DID NOT FAIL IN A FAIL-SAFE MANNER. THIS EVENT WAS TRIGGERED BY A SUDDEN MECHANICAL FAILURE IN THE STEERING SYSTEM AS EVIDENCED BY VERY BADLY MISALIGNED FRONT WHEELS AND STEERING ANGLE ERRORS IN THE COMPUTER SYSTEM. TIRES DO NOT SHOW UNUSUAL WEAR FROM THE MISALIGNMENT BECAUSE IT HAPPENED SUDDENLY AT THE TIME OF THE INCIDENT. A HYUNDAI FIELD SERVICE ENGINEER INSPECTED THE CAR. HYUNDAI WILL NOT TELL US WHAT FAILED SO WE DO NOT KNOW ROOT CAUSE. IN FACT, HYUNDAI DENIES THERE WAS A STEERING FAILURE. CAR IS NOT SAFE TO DRIVE. *TR

NHTSA ODI #10471621

65,000 miles · Aug 10, 2012

Seat Belts

TL* THE CONTACT OWNS A 2007 HYUNDAI AZERA. THE CONTACT WAS TRAVELING 20 MPH WHEN THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER CONFIRMED THAT THE SEAT BELT TENSION SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,000 A…

Read full complaint

NHTSA ODI #10470151

34,000 miles · Aug 5, 2012

Seats

THE DRIVER SEAT WILL TILT FORWARD FOR NO REASON, PINNING THE DRIVER AGAINST THE STEERING WHEEL. AT ANY SPEED. THIS HAPPENS FREQUENTLY. *TR

NHTSA ODI #10469209

Official recalls

18V026000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Jan 9, 2018

Hyundai Motor America (Hyundai) is recalling certain 2006-2011 Hyundai Azera and 2006 Hyundai Sonata vehicles. Water may enter the Anti-lock Brake (ABS) Module and result in an electrical short .

Consequence & remedy

Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.

Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began on February 19, 2018. Owners may call Hyundai at 1-800-633-5151. Hyundai's number for this recall is 172.

16V630000 · Seats:front Assembly:power Adjust

Aug 31, 2016

Hyundai Motor Company (Hyundai) is recalling certain model year 2007-2008 Azera vehicles manufactured March 7, 2007 through August 14, 2007. In the affected vehicles, the power-adjustable front driver seat may unexpectedly move without the driver's input while the vehicle is being driven.

Consequence & remedy

Consequence: Unintentional movement of the driver's seat may affect the driver's ability to control the vehicle, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the power-adjustable seat switch, free of charge. The recall began October 28, 2016. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 150.

13V354000 · Suspension:rear

Aug 12, 2013

Hyundai is recalling certain model year 2006-2010 Sonata vehicles manufactured March 1, 2005, through January 21, 2010; and model year 2006-2011 Azera vehicles manufactured September 27, 2005, through November 22, 2010 originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt and water can enter portions of the rear crossmember, leading to corrosion of the crossmember steel. This may lead to detachment of one of the rear control arms.

Consequence & remedy

Consequence: Control arm separation may suddenly change the rear wheel alignment, affecting the handling of the vehicle, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will repair or replace the crossmember assembly. The recall began on October 8, 2013. Owners may contact Hyundai Customer Care Center at 1-800-633-5151. Hyundai's recall number is 113.

13V113000 · Exterior Lighting:brake Lights:switch

Apr 1, 2013

Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.

Consequence & remedy

Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.

10V007000 · Air Bags:frontal; Seat Belts:front

Jan 8, 2010

HYUNDAI DE PUERTO RICO IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 AZERA VEHICLES MANUFACTURED FROM SEPTEMBER 27, 2005, THROUGH OCTOBER 1, 2008. THE WIRING HARNESS FOR THE RIGHT FRONT SEAT BELT TENSION SENSOR MAY SUSTAIN DAMAGE AFTER REPEATED USE OF THE SEAT BELT. IF THE SEAT BELT TENSION SENSOR WIRING BECOMES DAMAGED THE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH NECESSITATING FRONT AIR BAG DEPLOYMENT.

Consequence & remedy

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL INSPECT AND REPLACE THE RIGHT FRONT SEAT BELT AND INSTALL A NEW SEAT BELT TENSION SENSOR WIRING HARNESS CLIP, IF NECESSARY, AND REROUTE THE RIGHT FRONT SEAT BELT TENSION SENSOR WIRING AND SECURE THE WIRING WITH A NEW HARNESS CLIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 8, 2010. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO 1-787-999-3333.

Additional source detail variants (2)

Seat Belts:front

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL INSPECT AND REPLACE THE RIGHT FRONT SEAT BELT AND INSTALL A NEW SEAT BELT TENSION SENSOR WIRING HARNESS CLIP, IF NECESSARY, AND REROUTE THE RIGHT FRONT SEAT BELT TENSION SENSOR WIRING AND SECURE THE WIRING WITH A NEW HARNESS CLIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 8, 2010. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO 1-787-999-3333.

Air Bags:frontal

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

09V497000 · Air Bags:frontal; Seat Belts:front

Dec 28, 2009

HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 AZERA VEHICLES MANUFACTURED FROM SEPTEMBER 27, 2005, THROUGH OCTOBER 1, 2008. THE WIRING HARNESS FOR THE RIGHT FRONT SEAT BELT TENSION SENSOR MAY SUSTAIN DAMAGE AFTER REPEATED USE OF THE SEAT BELT. IF THE SEAT BELT TENSION SENSOR WIRING BECOMES DAMAGED THE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH NECESSITATING FRONT AIR BAG DEPLOYMENT.

Consequence & remedy

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Additional source detail variants (2)

Seat Belts:front

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Air Bags:frontal

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

09V280000 · Exterior Lighting

Jul 21, 2009

HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.

Consequence & remedy

Consequence: ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.

Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.

09V122000 · Exterior Lighting:brake Lights:switch

Apr 15, 2009

HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.

Consequence & remedy

Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.

Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE13007 · Rear Control Arm Failure

Opened Mar 25, 2013 · Closed Aug 20, 2013

Status: closed (inferred from source dates) · Suspension:rear

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai) notified NHTSA that Hyundaiis conducting a safety recall (13V-354) involving approximately 239,000 vehicles involving model year (MY) 2006 through 2010 Hyundai Sonata vehicles (approximately 215,000)produced beginning on March 1, 2005 through January 21, 2010 and model year (MY) 2006 through 2011 Hyundai Azera vehicles (approximately 24,000) produced beginning on September 27, 2005 through November 22, 2010 that are registered in and operated or originally sold in the following 20 salt belt states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Hyundai will also inform dealers to inspect/repair vehicles that were previously registered in salt belt states but are currently registered elsewhere. Hyundai is conducting the recall to remedy a defect involving internal corrosion of the rear sub frame that may lead to separation of the rear upper/lower control arm(s) at their respective mounting points and/or separation of the axle from the transaxle where they meet.This could result in a loss of vehicle control and/or vehicle disablement which may increase the risk of a vehicle crash.In response to NHTSA?s Information Request (IR) letter, Hyundai stated the Azera vehicles utilizes the identical cross member and upper/lower rear control arm components as the subject (Sonata) vehicles.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Hyundai, ODI identified 19 non-duplicative reports alleging excessive corrosion of the rear sub frame. All of the complaint vehicles were either originally sold or registered at the time of the incident in one of the salt belt states.Of these 19 reports, 9 alleged either a suspension component separation or a fracture of the vehicle's rear cross member assembly.Similarly, ODI identified 8 warranty claims of rear sub frame replacement in data submitted by Hyundai due to excessive corrosion, all of which involved vehicles originally sold or operated in a salt belt state. Based on Hyundai's decision to conduct a safety recall, (13V-354) this investigation is closed.The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10535115, 10534110, 10525976, 10524726, 10521520, 10508368, 10505463, 10490073, 10486752, 10486435, 1048354, 10473922, and 10437887.

PE09003 · Stop Lamp Switch Failure

Opened Jan 14, 2009 · Closed Apr 24, 2009

Status: closed (inferred from source dates) · Electronic Stability Control; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Power Train:automatic Transmission:lever And Linkage:column Shift; Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:manual Transmission:column Shift Assembly; Power Train:manual Transmission:floor Shift Assembly; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:cruise Control

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.

Additional source detail variants (10)

Electronic Stability Control

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Power Train:automatic Transmission:lever And Linkage:column Shift

Power Train:automatic Transmission:lever And Linkage:floor Shift

Power Train:manual Transmission:column Shift Assembly

Power Train:manual Transmission:floor Shift Assembly

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Service Brakes, Hydraulic:pedals And Linkages

Vehicle Speed Control:cruise Control