2006 Hummer H3

DESCRIPTION OF THE COMPLAINT: THE BLOWER ON MY 2006 HUMMER H3 STOPPED WORKING WHILE DRIVING DOWN THE HIGHWAY BURNT PLASTIC SMELL WHEN THE BLOWER STOPPED. BUT THE BLOWER NEVER WORKED AGAIN. I FOUND THAT THIS IS A HUGE ISSUE FOR NOT JUST HUMMER OWNERS, BUT OTHER GM VEHICLE OWNERS. THE RESISTOR AND PLASTIC CLIP WERE MELTED TOGETHER THIS RESISTOR FOR THE AC BLOWER IS LOCATED RIGHT UNDER THE GLOVE COMPARTMENT DAMAGE DANGER THIS ISSUE POSES. OTHER POSTS HTTP://WWW.HUMMERFORUMS.COM/FORUM. I HAD TO SPEND 325.00 AND SEE GM HAS MANY PROBLEMS CONCERNING THIS ISSUE ALOT ON THE TRUCK. *TR

MARCH 2012 - HUMMER LOCKED UP AND WILL NOT TURN OVER .. TOWED IT TO DEALERSHIP .. THEY REPLACE KEY IGNITION ALL OF APRIL MY HUMMER WILL SHUT DOWN .. 3 TIMES HAD IT JUMPED ... FOUND OUT IT WAS NOT THE BATTERY .. I WAS DRIVING WHEN THE HUMMER LOCKED UP .. IT WAS VERY SCARY ! 68,000 MILES ONLY ! CURRENTLY AT THE DEALERSHIP AGAIN 2 TWICE IN LESS THAN 2 MONTHS. *TR

VERY VERY COMMON PROBLEM WITH GM PRODUCTS AND EXCESSIVE PROBLEM WITH H3 HEATERS. YOU SMELL SOMETHING BURNING IN YOUR VEHICLE THEN YOUR HEATER FAN STARTS FLUCTUATING AND ULTIMATELY STOPS. THERE ARE REPORTS THAT THE DEALERSHIP WILL FIX THE BURNT PLUG, BUT IT WON'T FIX THE PROBLEM, IT'LL BURN UP AGAIN. NOW I HAVE NO HEATER IN JANUARY IN OHIO THIS SHOULD BE A RECALL !!!!!!!!! *TT

11/02/11 SMELL OF SOMETHING BURNING LOOKED UNDER DASH BLOWER RESISTOR AND PLUG MELTED TOGETHER HAD REPLACED ON 12/11/11 SMELT BURNING PLASTIC AGAIN HAD SAME PROBLEM BLOWER RESISTOR AND PLUG MELTED AGAIN FROM WHAT I UNDERSTAND IT IS A ON GOING PROBLEM IN THIS VEHICLE GM SHOULD BE RESPONSIBLE IN FIXING IT BEFORE THERE ARE MAJOR FIRE DAMAGE OR A DEATH. *TR

THE BLOWER ON MY 2006 HUMMER H3 STOPPED WORKING WHILE DRIVING DOWN THE HIGHWAY AND WE SMELLED A BURNT PLASTIC SMELL WHEN THE BLOWER STOPPED. THE SMELL EVENTUALLY WENT AWAY, BUT THE BLOWER NEVER WORKED AGAIN. I FOUND THAT THIS IS A HUGE ISSUE FOR NOT JUST HUMMER OWNERS, BUT OTHER GM VEHICLE OWNERS. THE RESISTOR AND PLASTIC CLIP WERE MELTED TOGETHER AND WHEN DISCONNECTED, FIRE DAMAGE WAS EVIDENT. THIS RESISTOR FOR THE AC BLOWER IS LOCATED RIGHT UNDER THE GLOVE COMPARTMENT AND LUCKILY NOTHING FLAMMABLE WAS CLOSE TO THIS WHEN IS BLEW WHILE DRIVING DOWN THE HIGHWAY. I ALSO HAVE PICTURES OF THE DAMAGE AND SUBSEQUENT DANGER THIS ISSUE POSES. OTHER POSTS OF PEOPLE SEEING THIS ISSUE. HTTP://WWW.HUMMERFORUMS.COM/FORUM/HUMMER-H3-17/AIR-CONDITIONING-PROBLEM-GRRR-16020/PAGE2/#POST264883. *TR

ON OCTOBER 30TH I SMELLED A FAINT SCENT OF SOMETHING BURNING INSIDE MY VEHICLE, BUT COULD NOT FIND ANYTHING. NOVEMBER 1ST WAS OUR FIRST COLD MORNING SO I STARTED MY CAR, AND HAD NO HEAT. THE SYSTEM WASN'T BLOWING, BUT THE HEATER A/C CONTROLS WERE LIT UP. SINCE I AM A MECHANIC, AND HAVE KNOWLEDGE I WENT RIGHT TO THE FUSE BOX IN THE ENGINE COMPARTMENT. THE FUSES WERE OK. I THEN WENT TO THE BLOWER RESISTOR PACK WHICH IS LOCATED UNDER THE GLOVE BOX. THE ORANGE POWER WIRE IN THE HARNESS WAS BURNT UP PRETTY GOOD, AND THE TERMINAL MOLDED INTO THE HARNESS PACK WAS ALSO BURNED UP PRETTY GOOD. I THEN WENT ONLINE TO GOOGLE THIS PROBLEM TO SEE HOW COMMON IT WAS, AND WAS SURPRISED TO SEE HOW MANY COMPLAINTS THERE ARE ABOUT THIS PROBLEM, NOT JUST REGARDING THE HUMMER LINE, BUT WITHIN GM VEHICLES ITSELF. I CALLED THE SERVICE TECH WHERE I HAVE MY WORK DONE, AND HE WAS VERY FAMILIAR WITH THIS FAILURE. *TR

AS I WAS DRIVING TO MY OFFICE FROM A LUNCH BREAK, MY A/C AND VENTILATION STOPPED WORKING, I TURNED THE ON AND OFF DIAL AND AIR NEVER CAME BACK ON, SHORTLY AFTER THAT A STRONG "BURNED" SMELL CAME FROM THE GLOVE BOX OF MY VEHICLE, I PULLED OVER AND NOTICED A LITTLE BIT OF SMOKE COMING FROM UNDERNEATH THE GLOVE BOX. I DID SOME RESEARCH ON THE INTERNED AND DISCOVERED IT WAS A BURNED OUT "VENT BLOWER RESISTOR" (AC DELCO PART# 15-80647) I HAVE SINCE REPLACED IT BUT IT STILL NOT WORKING. I HAVE THE BURNED PART IF EVER NEEDED, I MUST SAY I DON'T FEEL AT ALL SAFE WITH A SITUATION LIKE THIS AS IT HAS NEVER HAPPENED TO ME. I DECIDED TO INCLUDE MY COMPLAINT AS I HAVE SEEN MANY PEOPLE WITH THE SAME PROBLEMS ON THIS VEHICLE, A FIRE IS EMINENT AND SHOULD BE PREVENTED.

A/C HEATER MOTOR RESISTOR OVERHEATED CAUSING SMOKE THROUGHOUT THE PASSENGER COMPARTMENT ON THE HIGHWAY THIS IS THE THIRD REPLACEMENT OF THIS PART, THE WIRING OVERHEATS AND MELTS THE CONNECTORS THIS IS A VERY COMMON PROBLEM ON HUMMERS OF ALL TYPES. MY SISTER OWNS AN H3 AS WELL AND HAS HAD TO REPLACE THIS TWICE ON HER 2007 MODEL H3 DUE TO OVERHEATING AN MELTING THE CONNECTOR. IS GENERAL MOTORS GOING TO WAIT UNTIL THERE ARE NUMEROUS FATALITIES OR VEHICLE FIRES TO RECTIFY THIS ? A FIRE IN THE PASSENGER COMPARTMENT WHILE AT HIGHWAY SPEEDS IS DANGEROUS TO SAY THE LEAST