TL* THE CONTACT OWNS A 2005 HUMMER H2. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED AND A MESSAGE APPEARED STATING THAT THE AIR BAG NEEDED TO BE SERVICED. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSI…
Read full complaint
TL* THE CONTACT OWNS A 2005 HUMMER H2. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED AND A MESSAGE APPEARED STATING THAT THE AIR BAG NEEDED TO BE SERVICED. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 130,000. THE VIN WAS UNAVAILABLE.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ODI UPGRADED THIS INVESTIGATION AT THE CONCLUSION OF PE04-080.THE ALLEGED DEFECT INVOLVES THE FAILURE OF THE STEERING KNUCKLE AT THE LOWER BALL JOINT BOSS, RESULTING IN A SEPARATION OF THE LOWER BALL JOINT FROM THE KNUCKLE.A LOWER BALL JOINT SEPARATION COULD RESULT IN A LOSS OF STEERING AND/OR A DISABLED VEHICLE. IT APPEARS THAT THE FRACTURES OF H2 STEERING KNUCKLES CAN BE ATTRIBUTED TO WHEEL/TIRE COLLISION FORCES BEING TRANSFERRED DIRECTLY TO THE STEERING KNUCKLE.THE ORIGINAL KNUCKLE DESIGN APPEARS TO BE SUFFICIENT FOR THE H2 APPLICATION.EVIDENCE FROM INSPECTED VEHICLES, PHOTOGRAPHS, POLICE REPORTS AND EDR DATA INDICATES COLLISION IMPACT EVENTS PLACED STRESS ON THE STEERING KNUCKLE CAUSING IT TO FRACTURE.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH REGARD TO THE SUBJECT COMPONENT.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THIS ISSUE IF WARRANTED.
2005 Hummer H2 Problems, Complaints & Recalls | Skip That Year
Illustration