NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
43 reportsClear category filterMileage unknown · Jul 1, 2025
Electrical System
We were exiting the off ramp heading North on [XXX], exit [XXX] and when we slowed to about 5 mph the car shut off completely. No electrical power and the car would not re-start. Heavy traffic was bearing down on us and we could not move. About 20 minutes later the power returned. It was the auto idle restart that malfunctioned,…
Read full complaint
We were exiting the off ramp heading North on [XXX], exit [XXX] and when we slowed to about 5 mph the car shut off completely. No electrical power and the car would not re-start. Heavy traffic was bearing down on us and we could not move. About 20 minutes later the power returned. It was the auto idle restart that malfunctioned, we believe. There was no warning. The situation was dangerous. We took it to the dealer in Vancouver, WA and they found no warning messages. They told us to take the car back and drive it and always manually turn off the auto idle restart and it would be safe. They said Honda temporarily suspended the engineering request until July 7, 2025 and until then we just wait. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11670634
Mileage unknown · May 24, 2025
Electrical SystemEngineFuel/propulsion System
Random misfires in engine cylinders, excessive jerking
NHTSA ODI #11662969
Mileage unknown · May 14, 2025
Electrical SystemForward Collision AvoidanceService BrakesCrash
My 2025 Honda Pilot’s Collision Mitigation Braking System and backup sensors have failed three times at low speed, resulting in collisions with objects directly behind or in front of the vehicle. These include a front collision with a tree, running over a small tricycle, and backing into a tree — all under 5 mph with sensors fu…
Read full complaint
My 2025 Honda Pilot’s Collision Mitigation Braking System and backup sensors have failed three times at low speed, resulting in collisions with objects directly behind or in front of the vehicle. These include a front collision with a tree, running over a small tricycle, and backing into a tree — all under 5 mph with sensors fully enabled. The system failed to detect or respond in any instance. This is a critical safety failure
NHTSA ODI #11660832
16,000 miles · Mar 18, 2025
Electrical SystemFuel System, Gasoline
The contact owns a 2025 Honda Pilot. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power in the middle of the road. The contact stated that after opening and closing the door, the vehicle was able to restart. After restarting the vehicle, the vehicle returned to normal funct…
Read full complaint
The contact owns a 2025 Honda Pilot. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power in the middle of the road. The contact stated that after opening and closing the door, the vehicle was able to restart. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the fuel injection electronic control unit (FI-ECU) required a software update. The vehicle was repaired, but the failure reoccurred. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V031000 (Fuel System, Gasoline, Electrical System); the VIN was included, but the vehicle was already repaired under the recall. The manufacturer was not notified of the failure. The failure mileage was 16,000.
NHTSA ODI #11648965
2,700 miles · Feb 11, 2025
Electrical System
The contact owns a 2025 Honda Pilot. The contact stated while driving 45 MPH in the rain, the Honda emblem became wet, and the driver assist features stopped working properly. The message displayed was sensor obstructed which may affect some of the driver assist features. The vehicle was taken to a dealer but was not diagnosed. …
Read full complaint
The contact owns a 2025 Honda Pilot. The contact stated while driving 45 MPH in the rain, the Honda emblem became wet, and the driver assist features stopped working properly. The message displayed was sensor obstructed which may affect some of the driver assist features. The vehicle was taken to a dealer but was not diagnosed. The manufacturer was made aware of the failure. The failure mileage was approximately 2,700.
NHTSA ODI #11641971
Mileage unknown · Feb 1, 2025
Electrical SystemUnknown Or Other
Hello, I am writing to report an issue I discovered with my new 2025 Honda Pilot EXL, which I purchased in October 2025. On January 5, 2025, while inspecting the engine, I noticed that the protective cover on the wiring harness was wrapped with black electrical tape. This tape was shredded and peeling away from the plastic pip…
Read full complaint
Hello, I am writing to report an issue I discovered with my new 2025 Honda Pilot EXL, which I purchased in October 2025. On January 5, 2025, while inspecting the engine, I noticed that the protective cover on the wiring harness was wrapped with black electrical tape. This tape was shredded and peeling away from the plastic pipe cover, likely due to heat or other factors. I was surprised and concerned to find such a low-quality material used in this location. The tape's deterioration raises concerns about potential damage to the wiring itself due to heat exposure. I am also worried about the long-term reliability and safety implications, including the possibility of a fire. I drove approximately 40 miles round trip to the Honda dealership where I purchased the vehicle. They dismissed my concerns, stating that this was "normal" and simply advised me to purchase more electrical tape from a home improvement store and re-wrap the harness myself. They refused to perform any repair or replacement. I question why Honda would not use heat-resistant tape in this engine compartment area, especially given the potential for high temperatures. Using a more robust, heat-resistant material would provide greater safety and prevent the current issue. I believe this is a design flaw that needs to be addressed.
NHTSA ODI #11640067
Mileage unknown · Jan 13, 2025
Electrical System
Backup Camera not functioning. Black screen when car is in reverse.
NHTSA ODI #11635715
Mileage unknown · Dec 22, 2024
Electrical SystemLane Departure
After two weeks of purchasing this vehicle the whole system just turn off. The first time it happens was on a Tuesday afternoon. I turn the vehicle off. As I return to the car a few minutes later I couldn't Start the car. Everything was off no power on, the lights were off, engine, doors where lock. waited an hour them the car e…
Read full complaint
After two weeks of purchasing this vehicle the whole system just turn off. The first time it happens was on a Tuesday afternoon. I turn the vehicle off. As I return to the car a few minutes later I couldn't Start the car. Everything was off no power on, the lights were off, engine, doors where lock. waited an hour them the car engine started up. Two days later the same issue again call the town truck for help. Two hours later the town truck arrive then the car started again. took it to the dealer but they didn't find anything. On the six time I left the car at the dealer for 3 weeks but they couldn't fix it again. 3 weeks later they think they fix the issue but nope same issues after picking up the car again. Please don't sell this vehicle to another person. I am returning the car but as a first time owner of honda I don't recommended.
NHTSA ODI #11632041
Mileage unknown · Dec 6, 2024
Electrical SystemEngineSteering
I was driving and I began slowing down as I approached a red light. My vehicle suddenly stopped. I was unable to turn the vehicle back on nor change the gear. When I would press the start button while pressing the brakes, some dash lights would turn on but again I was not able to change the gear. After several attempts of turnin…
Read full complaint
I was driving and I began slowing down as I approached a red light. My vehicle suddenly stopped. I was unable to turn the vehicle back on nor change the gear. When I would press the start button while pressing the brakes, some dash lights would turn on but again I was not able to change the gear. After several attempts of turning the car on, the car started and I was able to change gears to Drive. Approximately one or two blocks later, while in motion, the car abruptly stopped again. This time the dash displayed “Engine Oil Pressure Low” Stop Engine. Do not Drive”. The car was subsequently towed to a nearby Honda Dealership where an inspection was allegedly done and the issue was supposedly fixed. The service notes stated the vehicle was found with low oil levels and that no leak was found. They released the car back to me. Now, one week after I picked the car up from the Honda Service Department, I encountered the same issue again. While stopped in traffic, my vehicle shut down. I was unable to turn it back on nor change the gears. An orange steering wheel with an orange exclamation mark next to it popped up on the upper right hand corner of my dashboard along with a red battery logo below it. I was on the roadway unable to turn the car back on for approximately one hour. After continuous failed attempts to turn the car on and change the gear, at one point it turned back on and I was able to drive the car.
NHTSA ODI #11629353
Mileage unknown · Oct 5, 2024
Electrical SystemService BrakesSteering
New 2025 Pilot with about 3,000 miles, driving in Montana on a level dusty gravel road at about 5,000 feet altitude. Driving into the morning sun for about 20 minutes at a slow speed of about 30 mph all of a sudden multiple warnings flashed, engine, brakes, etc. Steering was stiff and brakes did not feel active, very stiff. …
Read full complaint
New 2025 Pilot with about 3,000 miles, driving in Montana on a level dusty gravel road at about 5,000 feet altitude. Driving into the morning sun for about 20 minutes at a slow speed of about 30 mph all of a sudden multiple warnings flashed, engine, brakes, etc. Steering was stiff and brakes did not feel active, very stiff. I just coasted to a stop on a desolate gravel road, no other traffic. The engine was still running, did not press on the gas for in large red letters the warning panel said "DO NOT DRIVE". The car was very dusty. If we had been on an Interstate at 70 mph that would have been an accident, with steering and brakes inhibited somehow? I shut OFF the engine, waited 10 minutes, started engine again and WARNINGS still active. Shut OFF engine and waited 20 minutes. Restarted engine and looked like warning were starting to clear, and steering and brakes felt normal again. With no WARNINGS showing I drove very slowly for many miles with no further occurrences. Slowly worked my way back across the country to Florida without any further failures. It appears to all be computer related, perhaps sensors failing and the computer shutting down what must be electrical steering and brake assist. At speeds with Interstate traffic, that condition will be an accident. There are no failure codes shown on the access panel. We have an appointment with our Honda service dealer, maybe they will be able to access a computer history to see the failure mode that caused loss of steering and brakes. The fact that a computer can impact those critical systems on a vehicle, is a serious safety issue. Prior to this incident, driving about 30 minutes on a dusty gravel road in Montana, some sensor must have been actuating the rear brake caliper, I could hear the scraping sound of pad on rotor, didn't sense the car slowing. The car was dusty, maybe sensors inhibited, the scraping lasted about 15 minutes, at least that it could be heard in the car. Could be a safety iss
NHTSA ODI #11618247
Official recalls
4Jun 12, 2025
Honda (American Honda Motor Co.) is recalling certain 2021-2025 Acura TLX, 2023-2025 Acura MDX, and 2023-2025 Honda Pilot vehicles. The brake pedal pivot pin was not secured properly, which can cause the pedal to shift out of position. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard numbers 108, "Lamps, Reflective Devices, and Associated Equipment" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: A brake pedal that shifts out of position can prevent the driver from applying the brakes as intended, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and replace the brake pedal assembly as necessary, free of charge. Owner notification letters were mailed July 29, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are FLX and XLY.
Feb 5, 2025
Honda (American Honda Motor Co.) is recalling certain 2025 Honda Pilot vehicles. The third-row passenger seat belt assembly may not function, due to incorrect routing that traps the seat belt behind the passenger side panel. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A non-functioning seat belt cannot properly restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and repair the seat belt routing as necessary, free of charge. Owner notification letters were mailed March 24, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is ZL4.
Jan 23, 2025
Honda (American Honda Motor Co.) is recalling certain 2022-2025 Acura MDX Type-S, 2023-2025 Honda Pilot, and 2021-2025 Acura TLX Type-S vehicles. A software error in the fuel injection electronic control unit (FI-ECU) may cause an engine stall or a loss of power.
Consequence & remedy
Consequence: An engine stall or loss of power can increase the risk of a crash or injury.
Remedy: Dealers will reprogram the FI-ECU software, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are EL1 and AL0.
Additional source detail variants (2)
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2022-2025 Acura MDX Type-S, 2023-2025 Honda Pilot, and 2021-2025 Acura TLX Type-S vehicles. A software error in the fuel injection electronic control unit (FI-ECU) may cause an engine stall or a loss of power.
Consequence: An engine stall or loss of power can increase the risk of a crash or injury.
Remedy: Dealers will reprogram the FI-ECU software, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are EL1 and AL0.
Fuel System, Gasoline:fuel Injection System
Honda (American Honda Motor Co.) is recalling certain 2022-2025 Acura MDX Type-S, 2023-2025 Honda Pilot, and 2021-2025 Acura TLX Type-S vehicles. A software error in the fuel injection electronic control unit (FI-ECU) may cause an engine stall or a loss of power.
Consequence: An engine stall or loss of power can increase the risk of a crash or injury.
Remedy: Dealers will reprogram the FI-ECU software, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are EL1 and AL0.
Nov 27, 2024
Honda (American Honda Motor Co.) is recalling certain 2023-2024 Passport and 2023-2025 Pilot vehicles. The fuel filler neck tube and fuel filler pipe may separate, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will inspect and repair the fuel filler neck tube and pipe as necessary, free of charge. Owner notification letters were mailed January 7, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is OKM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration