NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
95 reportsClear category filterMileage unknown · Jul 17, 2020
Electrical SystemUnknown Or Other
MY INFOTAINMENT CENTER AND DASHBOARD SPEEDOMETER HAVE BEEN GOING OUT FOR THE PAST THREE MONTHS WHILE I DRIVE. LOOKING ONLINE THIS WAS AN ISSUE WITH THE 2019 MODELS AND NO SOLUTION TO THE PROBLEM WAS MADE. I WAS NOT INFORMED WHEN PURCHASING THE VEHICLE THAT THESE ISSUES EXISTED AND WHEN TAKING IT INTO THE DEALERSHIP NO LONG TE…
Read full complaint
MY INFOTAINMENT CENTER AND DASHBOARD SPEEDOMETER HAVE BEEN GOING OUT FOR THE PAST THREE MONTHS WHILE I DRIVE. LOOKING ONLINE THIS WAS AN ISSUE WITH THE 2019 MODELS AND NO SOLUTION TO THE PROBLEM WAS MADE. I WAS NOT INFORMED WHEN PURCHASING THE VEHICLE THAT THESE ISSUES EXISTED AND WHEN TAKING IT INTO THE DEALERSHIP NO LONG TERM FIX TO THE PROBLEM IS OFFERED. I PURCHASED THIS VEHICLE FOR THE NAVIGATION AND DVD OPTIONS THAT I NOW AM NOW ABLE TO USE YET I STILL PAY THE PAYMENT FOR THEM. TO ME HONDA IS NEGLIGENT BECAUSE THEY ARE AWARE OF THE PROBLEM YET THEY HAVE NOT FIXED IT WHEN I CALL ABOUT DOING ANYTHING TO IT I AM TOLD THEY HAVE TO EXPERIENCE THE PROBLEM WHILE DRIVING IT WHICH COULD TAKE SECONDS OR IT COULD TAKE A WEEK THEN THEY OFFER NO TIME TABLE ON HOW LONG IT WILL TAKE TO FIX IT. THEY ALSO DO NOT OFFER A COURTESY VEHICLE WHILE THEY FIX THE DEFECT. NO RECALLS HAVE BEEN ISSUED FOR THIS PROBLEM EITHER THIS PROBLEM CAN OCCUR ON ANY TYPE OF ROAD AT ANY TIME DRIVING OR PARKED. THE LAST TIME IT WAS ON WAS 7/12/2020 AND IT HAS BEEN OFF SINCE
NHTSA ODI #11339959
3,500 miles · Jul 14, 2020
Electrical SystemElectronic Stability Control (esc)Unknown Or Other
I BOUGHT A 2020 NEW HONDA PILOT ELITE ON OCTOBER 2, 2019 WITH 245 MILES ON IT. I BROUGHT MY PILOT ELITE INTO THE DEALERSHIP ON DECEMBER 26, 2019 AFTER DISCOVERING A POPPING NOISE WHICH SOUNDED LIKE A FIRECRACKER GOING OFF THAT SEEMED TO BE BETWEEN THE WINDSHIELD AND DASH WHILE DRIVING.MILEAGE WAS AT 3,956 AT THIS TIME. ON JAN…
Read full complaint
I BOUGHT A 2020 NEW HONDA PILOT ELITE ON OCTOBER 2, 2019 WITH 245 MILES ON IT. I BROUGHT MY PILOT ELITE INTO THE DEALERSHIP ON DECEMBER 26, 2019 AFTER DISCOVERING A POPPING NOISE WHICH SOUNDED LIKE A FIRECRACKER GOING OFF THAT SEEMED TO BE BETWEEN THE WINDSHIELD AND DASH WHILE DRIVING.MILEAGE WAS AT 3,956 AT THIS TIME. ON JANUARY 17, 2020, I BROUGHT MY HONDA PILOT INTO THE DEALERSHIP AGAIN. IT DEVELOPED A POPPING NOISE AGAIN BETWEEN THE WINDSHIELD AND DASH SOUNDING LIKE A FIRECRACKER GOING OFF WHEN I WAS DRIVING. ON FEBRUARY 5, 2020, THE HONDA PILOT WAS ONCE AGAIN BROUGHT BACK IN. IT WAS POPPING AND CRACKING THIS TIME IN THE AUDIO UNIT BUT NOW ALSO DOOR LOCKS WE'RE MAKING NOISE WHEN IN STATIONARY OR WHILE DRIVING. THE CONTROL PANEL HAD ALSO SHUT OFF A COUPLE TIMES WHERE YOU ONLY SAW A DARK SCREEN AND IT WOULD REBOOT. ON JULY 14TH, AFTER HEARING THIS LOUD POPPING NOISE FOR A COUPLE MONTHS NOW WHILE DRIVING, I HAVE TAKEN IT BACK TO THE DEALERSHIP. IT IS WORSE WHEN YOU GO AROUND ANY TYPE OF CURVES OR ON BUMPY ROADS. IF THE ROAD IS COMPLETELY STRAIGHT AND SMOOTH, I DO NOT HAVE THIS PROBLEM. THIS WHOLE ORDEAL IS SCARY BECAUSE IT IS A HUGE DISTRACTION FOR ME AND I FEAR FOR MY SAFETY. I HAVE BEEN TOLD BY THE SERVICE ADVISOR AGAIN TODAY THAT HONDA IS AWARE AND WORKING ON THIS ISSUE. HE STATED A RECALL IS COMING OUT FOR IT AS WELL AS THE ODYSSEY AND PASSPORT BUT THEY ARE MAKING THE PARTS FOR IT BEFORE THEY RECALL IT. HE SAID THEY CAN PUT A BAND-AID ON IT IN THE MEANTIME UNTIL THE PART CAN BE MADE. SINCE THIS IS THE 2ND TIME IN THE LAST 6 MONTHS I HAVE BEEN TOLD THIS, I'M WORRIED THEY ARE COVERING UP THE ISSUE AND WAITING FOR MY WARRANTY TO BE UP. ALSO, THE SENSOR THAT TELLS YOU WHEN A VEHICLE OR OBJECT IS CLOSE TO YOU IS FAULTY. I WILL BE DRIVING WITH NOTHING AROUND ME AND IT TELLS ME TO BRAKE AND GOES INTO ITS 'SAFETY MODE' WHICH HAS CAUSED ME TO ALMOST HAVE A WRECK.
NHTSA ODI #11339277
5,500 miles · Jul 12, 2020
Electrical SystemUnknown Or Other
WHILE DRIVING ON THE HIGHWAY AT 75 MPH THE SPEAKERS MADE A TERRIBLE POPPING EVEN THOUGHT THE AUDIO SYSTEM WAS OFF AND THEN ENTIRE DASH SCREEN WITH THE SPEEDOMETER WENT OUT AND REBOOTED SO I HAD NO IDEA WHAT SPEED I WAS GOING FOR 10 SECONDS. . WE HAD CRUISE CONTROL ON AND THE WHOLE SYSTEM WENT HAYWIRE. IT WAS BEYOND SCARY. THE CA…
Read full complaint
WHILE DRIVING ON THE HIGHWAY AT 75 MPH THE SPEAKERS MADE A TERRIBLE POPPING EVEN THOUGHT THE AUDIO SYSTEM WAS OFF AND THEN ENTIRE DASH SCREEN WITH THE SPEEDOMETER WENT OUT AND REBOOTED SO I HAD NO IDEA WHAT SPEED I WAS GOING FOR 10 SECONDS. . WE HAD CRUISE CONTROL ON AND THE WHOLE SYSTEM WENT HAYWIRE. IT WAS BEYOND SCARY. THE CAR DOESN'T FEEL SAFE TO DRIVE.
NHTSA ODI #11338894
1,650 miles · Jul 2, 2020
Unknown Or OtherVehicle Speed Control
IT STARTED WITH A POPPING SOUND COMING FROM SPEAKERS, THE INFO SCREEN WOULD THEN SHUT DOWN AND YOU WOULD BE UNABLE TO DETERMINE YOUR SPEED AND HAVE NO USE OF BACKUP CAMERA. AFTER THIS OCCURING 6 OR 8 TIMES (THE CAR HAS LESS THAN 2000 MILES) THE DISPLAY WILL NO LONGER EVEN COME ON. I HAVE LEFT WITH THE DEALER TODAY TO REPAIR. THI…
Read full complaint
IT STARTED WITH A POPPING SOUND COMING FROM SPEAKERS, THE INFO SCREEN WOULD THEN SHUT DOWN AND YOU WOULD BE UNABLE TO DETERMINE YOUR SPEED AND HAVE NO USE OF BACKUP CAMERA. AFTER THIS OCCURING 6 OR 8 TIMES (THE CAR HAS LESS THAN 2000 MILES) THE DISPLAY WILL NO LONGER EVEN COME ON. I HAVE LEFT WITH THE DEALER TODAY TO REPAIR. THIS PROBLEM OCCURED AT RANDOM TIMES, I WAS DRIVING EACH TIME RESULTING IN NO USE OF INSTRUMENTS FOR SPEED OF BACKUP CAMERA.
NHTSA ODI #11337181
400 miles · Jun 28, 2020
Unknown Or Other
WHEN YOU DRIVE THE CAR AFTER 2 OR 3 DAYS THERE IS CLICKING NOISE COMING FROM THE FRONT WHEN I TURN LEFT AND WHEN I HIT BREAKS AND WHEN THE VEHICLE IS SLOWING DOWN AND SOMETIMES IF I DRIVE STRAIGHT THE I HEARD THE NOISE. I CHECKED WITH DEALER BUT THEY COULDN'T FIND WHAT THE PROBLEM IS. SOMETIMES WHEN I SHIFT GEAR FROM PARKING TO …
Read full complaint
WHEN YOU DRIVE THE CAR AFTER 2 OR 3 DAYS THERE IS CLICKING NOISE COMING FROM THE FRONT WHEN I TURN LEFT AND WHEN I HIT BREAKS AND WHEN THE VEHICLE IS SLOWING DOWN AND SOMETIMES IF I DRIVE STRAIGHT THE I HEARD THE NOISE. I CHECKED WITH DEALER BUT THEY COULDN'T FIND WHAT THE PROBLEM IS. SOMETIMES WHEN I SHIFT GEAR FROM PARKING TO DRIVE I HEARD NOISE. THE DEALER TOLD ME THAT IS BECAUSE YOU ARE NOT DRIVING EVERY DAY THAT MIGHT THE PROBLEM OF CLICKING NOISE.
NHTSA ODI #11331327
634 miles · Jun 21, 2020
Electrical SystemUnknown Or OtherVehicle Speed Control
IT FIRST STARTED A COUPLE WEEKS BEFORE THIS WITH A CRACKLING IN THE SPEAKERS. THEN IT WOULDN'T PLAY ANYTHING PLUGGED INTO THE USB. THEN ON THE 20TH IT WOULDN'T PLAY THE RADIO. IT WOULD SAY RADIO UNAVAILABLE. THEN WHEN TRYING TO ACCESS THE RADIO, IT WOULD SAY NETWORK COMMUNICATION LOST AND EVERYTHING WOULD GO BLACK. NO SPEEDOMETE…
Read full complaint
IT FIRST STARTED A COUPLE WEEKS BEFORE THIS WITH A CRACKLING IN THE SPEAKERS. THEN IT WOULDN'T PLAY ANYTHING PLUGGED INTO THE USB. THEN ON THE 20TH IT WOULDN'T PLAY THE RADIO. IT WOULD SAY RADIO UNAVAILABLE. THEN WHEN TRYING TO ACCESS THE RADIO, IT WOULD SAY NETWORK COMMUNICATION LOST AND EVERYTHING WOULD GO BLACK. NO SPEEDOMETER, NO GAUGES, NOTHING. IT WOULD THEN RESTART THE SYSTEM. THEN THE BLUETOOTH STOPPED WORKING. NOW IT JUST CONSTANTLY LOSES NETWORK COMMUNICATION, BLANKS OUT AND RESTARTS. IT DID IT ABOUT 8 TIMES IN MY 10 MINUTE DRIVE HOME. I GOT A VIDEO OF IT WHILE SOMEONE ELSE WAS DRIVING BUT IT WON'T LET ME UPLOAD IT. IT HAPPENS AT ALL SPEEDS, EVEN BEING STOPPED AT A LIGHT.
NHTSA ODI #11329921
5,600 miles · Jun 17, 2020
EquipmentUnknown Or Other
VEHICLE ENTERTAINMENT (RADIO) SYSTEM CRACKLES AND POPS THROUGH THE SPEAKERS CONNECTED TO IT. CONNECTED PHONE CALLS SOMETIMES DROPS OR YOUR VOICE IS UNABLE TO BE HEARD BY THE PERSON YOU ARE SPEAKING TO. SATELLITE RADIO SOUNDS THROUGH SYSTEM ALSO CRACKLE AND POP AND SOMETIMES FADE OUT. THESE THINGS HAVE HAPPENED WHILE THE VEHICLE …
Read full complaint
VEHICLE ENTERTAINMENT (RADIO) SYSTEM CRACKLES AND POPS THROUGH THE SPEAKERS CONNECTED TO IT. CONNECTED PHONE CALLS SOMETIMES DROPS OR YOUR VOICE IS UNABLE TO BE HEARD BY THE PERSON YOU ARE SPEAKING TO. SATELLITE RADIO SOUNDS THROUGH SYSTEM ALSO CRACKLE AND POP AND SOMETIMES FADE OUT. THESE THINGS HAVE HAPPENED WHILE THE VEHICLE IS IN MOTION AND HAVE HAPPENED WHILE STATIONARY. *TR
NHTSA ODI #11329484
1,000 miles · May 19, 2020
Electrical SystemUnknown Or Other
I BOUGHT THIS 2020 HONDA PILOT TOURING OCT 2019. I NOTICED THE POPPING IN THE SPEAKERS AFTER HAVING THE CAR A MONTH MAYBE. I ALSO NOTICED DVD ISSUES AND CONNECTION PROBLEMS. EVERY SINGLE TIME I GET IN MY CAR I HEAR POPPING NOISES THROUGHOUT THE SPEAKERS. OCCASIONALLY I HAVE "LOST NETWORK CONNECTION" AND ONCE MY WHOLE DASH/SPEEDO…
Read full complaint
I BOUGHT THIS 2020 HONDA PILOT TOURING OCT 2019. I NOTICED THE POPPING IN THE SPEAKERS AFTER HAVING THE CAR A MONTH MAYBE. I ALSO NOTICED DVD ISSUES AND CONNECTION PROBLEMS. EVERY SINGLE TIME I GET IN MY CAR I HEAR POPPING NOISES THROUGHOUT THE SPEAKERS. OCCASIONALLY I HAVE "LOST NETWORK CONNECTION" AND ONCE MY WHOLE DASH/SPEEDOMETER WENT BLACK. IT ONLY CAME BACK ON 3 DAYS LATER WHEN I TOOK IT TO THE DEALERSHIP. LEITH HONDA IN SOUTHERN PINES/ABERDEEN, NC ACTED "SURPRISED" WITH THESE ISSUES. THEY SAID THEY HAD NEVER SEEN A SPEEDOMETER GO OUT. I DON'T BELIEVE THEM. I'VE HEARD ONE OF THE DOCTORS IN THE AREA RAISED CANE IN THE DEALERSHIP AND THEY REPLACED HIS HONDA PILOT WITH A NEW ONE. THIS POPPING IN THE SPEAKERS, DVD ISSUES, AND OTHER MAJOR ELECTRICAL PROBLEMS ARE VERY DISTRACTING AND THEREFORE DANGEROUS. I HAVE VIDEOS OF THE POPPING AND PICTURES OF EVERYTHING ELSE. UNFORTUNATELY THE VIDEOS WILL NOT UPLOAD TO THIS SAFETY COMPLAINT. EVIDENTLY THIS HAS BEEN GOING ON SINCE 2017ISH. I WOULD HAVE NEVER PURCHASED THIS PILOT IF I'D KNOWN THERE WERE ELECTRICAL ISSUES!!!! WORSE $41,000 CASH I HAVE EVER SPENT! SHAME ON HONDA FOR NOT CORRECTING THE PROBLEM AND CONTINUING TO SELL PROBLEM AUTOMOBILES TO CUSTOMERS! PLEASE CONSIDER THESE ELECTRICAL PROBLEMS AS A DANGER. WE NEED OUR AUTOMOBILES REPAIRED BY HONDA BEFORE SOMETHING TERRIBLE HAPPENS ON THE HIGHWAYS! *TR
NHTSA ODI #11325209
14,000 miles · May 19, 2020
Electrical SystemUnknown Or Other
PROBLEMS WITH THE COMPUTERS INCLUDING DASH BOARD INFORMATION AND INFOTAINMENT SYSTEM. PREVIOUSLY HEARD "POPPING NOISES" AND HAD INTERMITTENT BLACK OUTS. I WENT TO START MY VEHICLE AFTER WORK AND BOTH SCREENS WERE BLACK AND WOULD NOT COME ON. THIS MEANS ALL FUNCTIONS OF THESE TWO SCREENS ABSENT; I HAD NO SPEEDOMETER, NO ODOMETER,…
Read full complaint
PROBLEMS WITH THE COMPUTERS INCLUDING DASH BOARD INFORMATION AND INFOTAINMENT SYSTEM. PREVIOUSLY HEARD "POPPING NOISES" AND HAD INTERMITTENT BLACK OUTS. I WENT TO START MY VEHICLE AFTER WORK AND BOTH SCREENS WERE BLACK AND WOULD NOT COME ON. THIS MEANS ALL FUNCTIONS OF THESE TWO SCREENS ABSENT; I HAD NO SPEEDOMETER, NO ODOMETER, NO LANE MITIGATION, NO SENSOR BRAKING, NO CRUISE, NO RADIO, NO BLUE TOOTH, NO GPS, NO MAINTENANCE LIGHTS'ETC. I HAD A GAS GAUGE AND A H/C GAUGE THAT DID FUNCTION. *TR
NHTSA ODI #11325097
3,619 miles · Apr 28, 2020
Unknown Or Other
REAR WINDOW EXPLODED. VEHICLE WAS PARKED ON THE STREET AND WAS GOING TO PUT IN DRIVEWAY. OPENED DRIVER SIDE DOOR, GOT IN VEHICLE, CLOSE DOOR, REAR WINDOW EXPLODED.
NHTSA ODI #11322508
Official recalls
11Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Mar 11, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Passport and Pilot vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Overcured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation, which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash or injury.
Remedy: Honda will notify owners, and dealers will inspect all four tires and replace them as necessary, free of charge. The recall began April 22, 2021. Owners may contact American Honda Motor Co. customer service at 1-888-234-2138. Honda's number for this recall is UA2.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence & remedy
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Feb 6, 2020
Honda (American Honda Motor Co.) is recalling certain 2020 Passport and Pilot vehicles. The certification label may have been printed with ink that can be wiped away with a solvent, removing the Gross Axle Weight Rating (GAWR) and Gross Vehicle Weight Rating (GVWR) information.
Consequence & remedy
Consequence: If the operator is unable to refer to the label information, the vehicle may be overloaded, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the certification label, free of charge. The recall began March 24, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is B6T.
Oct 31, 2019
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Pilot and 2019 Passport vehicles. The front frame left and right side upper members may not have been welded completely to the unibody. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 219, "Windshield Zone Intrusion."
Consequence & remedy
Consequence: In the event of a crash, incomplete body welding may provide inadequate protection to occupants, increasing the risk of an injury.
Remedy: Honda will notify owners, and dealers will inspect the vehicle for missing welds, free of charge. If the vehicle is identified as missing welds, the dealer will offer to repurchase the vehicle or provide a similar replacement vehicle. Owner notification began November 6 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is X6J.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration