NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
134 reportsClear category filter69,500 miles · Nov 20, 2020
Service BrakesUnknown Or Other
1. I HAD A ROUTINE OIL CHANGE A FEW WEEKS AGO AND I WAS TOLD BY HONDA DEALER IN SAN LUIS OBISPO,CA THAT MY BRAKES WERE IN GOOD SHAPE. BUT I NOTICED THAT WHEN I AM DRIVING IN THE HIGHWAY AT AROUND 70 MPH THEN APPLY BRAKES, THE CAR SHAKES. I BROUGHT IT BACK TO HONDA AND THEY THINK IT IS THE ROTOR AND FIXED IT YESTERDAY. THE OTHE…
Read full complaint
1. I HAD A ROUTINE OIL CHANGE A FEW WEEKS AGO AND I WAS TOLD BY HONDA DEALER IN SAN LUIS OBISPO,CA THAT MY BRAKES WERE IN GOOD SHAPE. BUT I NOTICED THAT WHEN I AM DRIVING IN THE HIGHWAY AT AROUND 70 MPH THEN APPLY BRAKES, THE CAR SHAKES. I BROUGHT IT BACK TO HONDA AND THEY THINK IT IS THE ROTOR AND FIXED IT YESTERDAY. THE OTHER NEW PROBLEM IS THE ALARM THAT KEPT GOING OFF RANDOMLY WHEN THE CAR IS PARKED AND LOCKED. WHEN I PICKED UP MY CAR AFTER THE OIL CHANGE A FEW WEEKS AGO, THE TECHNICIAN DID NOT MENTION ANY PROBLEMS WITH MY ALARM GOING OFF WHILE MY CAR WAS AT THE DELEARSHIP. I WENT BACK TO THE HONDA DEALER FOR DIAGNOSTIC TEST YESTERDAY AND THEY RECOMMEND REPLACING THE KEYLESS ACCESS CONTROL UNIT. THIS WILL COST CLOSE TO $ 1000 DIAGNOSTIC, PARTS AND LABOR. I AM TOLD IF I DO NOT REPLACE THE CONTROL UNIT, THE PROBLEM CAN GET WORSE WHERE MY CAR WON'T START ANYMORE. SO I HAVE NO CHOICE BUT REPLACE IT. SO I BROUGHT MY CAR JUST FOR ROUTINE OIL CHANGE WEEKS AGO AND NOW I HAVE PROBLEM WITH ROTOR AND CONTROL UNIT THAT COST ME $ 502.72 YESTERDAY AND ANOTHER $700 PLUS DOLLARS TO REPLACE THE CONTROL UNIT. FOR THE CONTROL UNIT TO FAIL IN JUST 3 YEARS, SUGGESTS IT MAY BE DEFECTIVE TO BEGIN WITH OR VERY POOR QUALITY. UNFORTUNATELY IT JUST WENT OUT OF WARRANTY. I AM REPORTING THIS IN CASE THIS IS A COMMON PROBLEM FOR HONDA PILOT THAT THE MANUFACTURER NEEDS TO ADDRESS AND FIX.
NHTSA ODI #11375625
40,000 miles · Nov 3, 2020
Unknown Or Other
KEYLESS START SYSTEM ERROR STARTED TO APPEAR AS SOON AS THE 3 YEARS WARRANTY WAS OVER! THE ERROR WOULD GO ON BUT THE CAR DOES TURN ON. LATELY, IT WOULD TAKE SEVERAL PRESSES ON THE BUTTON AND IT APPEARS TO WORK BETTER IF THE FOB IS CLOSE TO THE BUTTON. THE WALK AWAY LOCK HAS NOT WORKED SINCE THE KEYLESS START SYSTEM ERROR BEGAN.…
Read full complaint
KEYLESS START SYSTEM ERROR STARTED TO APPEAR AS SOON AS THE 3 YEARS WARRANTY WAS OVER! THE ERROR WOULD GO ON BUT THE CAR DOES TURN ON. LATELY, IT WOULD TAKE SEVERAL PRESSES ON THE BUTTON AND IT APPEARS TO WORK BETTER IF THE FOB IS CLOSE TO THE BUTTON. THE WALK AWAY LOCK HAS NOT WORKED SINCE THE KEYLESS START SYSTEM ERROR BEGAN. THIS HAPPENS WHEN START THE CAR.
NHTSA ODI #11372905
41,400 miles · Sep 30, 2020
Unknown Or Other
WHEN STOPNIDLE ENGAGES (AT A STOP LIGHT FOR EXAMPLE) WHEN YOU LET OFF THE BRAKE AND IT WOULD NORMALLY START BACK UP IT COMPLETELY SHUTS DOWN. TELLS YOU TO SHIFT INTO PARK. IT IS EXTREMELY SCARY TO BE SITTING THERE AT A LIGHT AND YOUR CAR IS TOTALLY DEAD. I WAS ON A 2 LANE ROAD, STOPPED AT A STOP LIGHT AND LET OFF THE BREAK TO RE…
Read full complaint
WHEN STOPNIDLE ENGAGES (AT A STOP LIGHT FOR EXAMPLE) WHEN YOU LET OFF THE BRAKE AND IT WOULD NORMALLY START BACK UP IT COMPLETELY SHUTS DOWN. TELLS YOU TO SHIFT INTO PARK. IT IS EXTREMELY SCARY TO BE SITTING THERE AT A LIGHT AND YOUR CAR IS TOTALLY DEAD. I WAS ON A 2 LANE ROAD, STOPPED AT A STOP LIGHT AND LET OFF THE BREAK TO RE-ENGAGE AND GO BUT NOTHING. HAD TO SHIFT TO PARK, KEEP FOOT ON BRAKE AND RE-START. PRAYING I DON'T GET REAR ENDED. CAR HAS 41K ON IT AND AT 35K DEALERSHIP REPLACED THE BATTERY CAUSE IT WOULD CUT OUT WHEN IT RE STARTED BUT NEVER HAD SHIFT COMPLETELY DOWN LIKE TODAY. IT WAS JUST A AT THE DEALERSHIP FOR OIL CHANGE 5 DAYS AGO. 2017 PILOT ELITE. I BOUGHT BRAND NEW JUST UNDER 3 YRS AGO. *TR
NHTSA ODI #11362082
Mileage unknown · Sep 28, 2020
Unknown Or Other
KEYLESS START SYSTEM PROBLEM ERROR MESSAGE ON DASH. WE ARE THE ORIGINAL OWNER SINCE DECEMBER 2016, THIS ISN'T COVERED BEYOND 3 YEAR WARRANTY. IT'S INTERMITTENT, SOMETIMES IT GOES AWAY AND MESSAGE COMES BACK WITHIN 24 HOURS. I DO NOT RECALL THE EXACT DATE WHEN IT FIRST OCCURS, IT IS AN ESTIMATED DATE.
NHTSA ODI #11361648
35,000 miles · Sep 13, 2020
Electrical SystemEngineUnknown Or Other
WHILE TRAVELING SOUTH ON I-95 FROM BALTIMORE, MD TO WASHINGTON D.C., NEAR KENILWORTH AVENUE, THE ENGINE IDLE SHUTOFF ON MY 2017 HONDA PILOT TOURING ENGAGED WHEN I WAS FORCED TO STOP DUE TO A TRAFFIC SLOWDOWN. WHEN I TOOK MY FOOT OFF THE BRAKE, INSTEAD OF RESTARTING AS IT SHOULD HAVE, ALL OF THE WARNING LIGHTS CAME ON AND THE EN…
Read full complaint
WHILE TRAVELING SOUTH ON I-95 FROM BALTIMORE, MD TO WASHINGTON D.C., NEAR KENILWORTH AVENUE, THE ENGINE IDLE SHUTOFF ON MY 2017 HONDA PILOT TOURING ENGAGED WHEN I WAS FORCED TO STOP DUE TO A TRAFFIC SLOWDOWN. WHEN I TOOK MY FOOT OFF THE BRAKE, INSTEAD OF RESTARTING AS IT SHOULD HAVE, ALL OF THE WARNING LIGHTS CAME ON AND THE ENGINE STALLED. I SHIFTED INTO "PARK", ENGAGED MY EMERGENCY FLASHERS, AND ATTEMPTED TO RESTART THE ENGINE SEVERAL TIMES WITHOUT SUCCESS. WHILE STOPPED, I WAS NEARLY REAR-ENDED SEVERAL TIMES BECAUSE TRAFFIC STARTED MOVING AS SOON AS I TOOK MY FOOT OFF THE BRAKE. I WAS IN A CENTER LANE AND UNABLE TO EXIT THE VEHICLE OR MOVE IT FROM TRAFFIC. I WAS FINALLY ABLE TO GET RESTARTED AFTER A FEW MINUTES AND SEVERAL MORE TRIES. I HAD PREVIOUSLY HAD THE VEHICLE IN FOR ISSUES WITH THE ENGINE IDLE SHUTOFF AND THE DEALER HAD REPLACED THE BATTERY, WHICH I THOUGHT HAD FIXED THE PROBLEM. WHEN I TOOK IT IN THIS TIME IT HAPPENED THEY SAY THE BATTERY IS GOOD AND "CANNOT DUPLICATE THE PROBLEM". THERE IS A BROAD BASE OF INTERNET POSTINGS FOR THIS PROBLEM ON 2016 - 2018 PILOT ELITE AND TOURING VEHICLES, WITH THE 9 SPEED TRANSMISSION. THERE IS NO WAY TO PERMANENTLY TURN THIS FEATURE OFF AND I BELIEVE IT REPRESENTS A SERIOUS SAFETY HAZARD, ESPECIALLY FOR HIGHWAY TRAVEL.
NHTSA ODI #11354764
40,000 miles · Jul 2, 2020
EngineUnknown Or Other
IDLE STOP SYSTEM SENSOR FAIL.. WHEN CAN STOPS THE ENGINE SHUTS OFF BUT I DID NOT CAME BACK ON!! A LOT OF LIGHTS CAME ON WITH INSTRUCTIONS WHILE I WAS AT A BUSY LIGHT.. WENT TO THE DEALER AND IT WAS CLOSE TO $1,000 FOR THE REPAIR.. THEY SAID ITS A KNOWN ISSUE.. PLEASE DO A RECALL. *TR
NHTSA ODI #11337102
41,319 miles · Jun 13, 2020
Unknown Or Other
GOING UPHILL SUV HESITATES BETWEEN 1000 AND 2000 RPM'S. FEELS WITHOUT POWER. ONLY WAY TO AVOID IT IS TO PRESS THE PEDAL ALL THE WAY DOWN TO MAKE IT RESPOND. IT'S BEEN DOING IT FOR THREE MONTHS. MOST RECENT TIME THAT IT WAS FELT, WAS TODAY. *TR
NHTSA ODI #11328695
40,000 miles · May 22, 2020
Electrical SystemEngineUnknown Or Other
THIS IS IN REGARDS TO THE IDLE STOP "FEATURE" OF THE HONDA PILOT. WHEN THE VEHICLE COMES TO A FULL STOP, THE ENGINE CUTS OFF IN ORDER TO SAVE FUEL LIKE IT'S SUPPOSED TO. HOWEVER, WHEN IT IS TIME TO MOVE AGAIN, THE VEHICLE RANDOMLY STALLS CAUSING THE CAR TO COMPLETELY TURN OFF. THIS CAN BE POTENTIALLY FATAL AS THE BRAKES THEN DO …
Read full complaint
THIS IS IN REGARDS TO THE IDLE STOP "FEATURE" OF THE HONDA PILOT. WHEN THE VEHICLE COMES TO A FULL STOP, THE ENGINE CUTS OFF IN ORDER TO SAVE FUEL LIKE IT'S SUPPOSED TO. HOWEVER, WHEN IT IS TIME TO MOVE AGAIN, THE VEHICLE RANDOMLY STALLS CAUSING THE CAR TO COMPLETELY TURN OFF. THIS CAN BE POTENTIALLY FATAL AS THE BRAKES THEN DO NOT ENGAGE FULLY (CAR IS OFF) AND A MESSAGE APPEARS IN CONSOLE SAYING "TO START ENGINE: PRESS BRAKE AND PUSH (ENGINE ON)" . THIS IS MOST DEFINITELY A SAFETY ISSUE ESPECIALLY IF THIS HAPPENS IN THE MIDDLE OF TRAFFIC. HONDA SAYS IT IS NOT COVERED UNDER ANY WARRANTY. THIS BEHAVIOR IS RANDOM AND UNPREDICTABLE. *TR
NHTSA ODI #11325536
40,000 miles · May 14, 2020
EngineUnknown Or Other
VEHICLE HESITATION BETWEEN 1ST AND 2ND AT 1000 TO 2000 RPM'S. LOOSING POWER... *TR
NHTSA ODI #11324588
Mileage unknown · Feb 11, 2020
Unknown Or Other
MY CAR JERKS OFTEN WHEN ACCELERATING, ESPECIALLY AROUND 12MPH. I HAVE TOOK MY CAR TO THE DEALERS MANY TIMES. THE MOST RECENT ONE IS FOUR DAYS AGO. THE DEALER SAID THE CAR IS OPERATING AS DESIGNED, AND THE JERKS IS DUE TO THE 9-SPEED TRANSMISSION. I CAN'T AGREE WITH IT. IT IS NOT SAFE WHEN THE CAR SUDDENLY HOP FORWARD.
NHTSA ODI #11308617
Official recalls
4Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration