NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
122 reportsClear category filter138,000 miles · Mar 30, 2026
Fuel System, GasolinePower Train
The contact owns a 2017 Honda Pilot. The contact stated that while driving at slower speeds, the transmission unexpectedly shifted to neutral(N) while the accelerator pedal was depressed. Several unknown warning lights were illuminated. Prior to the failure, the vehicle was taken to a local dealer for a fuel injector replacement…
Read full complaint
The contact owns a 2017 Honda Pilot. The contact stated that while driving at slower speeds, the transmission unexpectedly shifted to neutral(N) while the accelerator pedal was depressed. Several unknown warning lights were illuminated. Prior to the failure, the vehicle was taken to a local dealer for a fuel injector replacement. The vehicle was taken to a local dealer, where it was diagnosed and determined that the fuel pump and catalytic converter needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign: 23V858000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 138,000.
NHTSA ODI #11728022
Mileage unknown · Mar 21, 2026
EnginePower Train
Internal engine damage was determined by a Folsom Honda Dealer in California. The damage is originating from the primary rod bearings; Replacement of the short block is necessary. Folsom Honda also stated the vehicle will need Cams and Heads of the engine replace. Needless to say, this a major engine failure. The vehicle only …
Read full complaint
Internal engine damage was determined by a Folsom Honda Dealer in California. The damage is originating from the primary rod bearings; Replacement of the short block is necessary. Folsom Honda also stated the vehicle will need Cams and Heads of the engine replace. Needless to say, this a major engine failure. The vehicle only has 140K miles mainly freeway. Dealer estimated it will cost from 11K to 15K to repair the problem. We aware of Savannah Messenger V. American Honda Motor Co. Inc Lawsuit. We need help from you guys on this….. please advice Francisco Talavera [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11726078
Mileage unknown · Mar 12, 2026
Fuel/propulsion SystemPower Train
Vehicle: 2017 Honda Pilot Elite VIN: [XXX] Mileage at failure: 107,593 The 9-speed automatic transmission failed at approximately 107,593 miles. The repair cost $6,229.91 at an independent shop and included a full transaxle overhaul, replacement of the torque converter, transmission oil pump, and main control valve body. The ve…
Read full complaint
Vehicle: 2017 Honda Pilot Elite VIN: [XXX] Mileage at failure: 107,593 The 9-speed automatic transmission failed at approximately 107,593 miles. The repair cost $6,229.91 at an independent shop and included a full transaxle overhaul, replacement of the torque converter, transmission oil pump, and main control valve body. The vehicle previously had fuel injectors replaced under warranty at approximately 87,000 miles. I have opened a Honda goodwill reimbursement case (Case #16225384). I am filing this complaint to document the premature failure of critical powertrain components and support review for Honda goodwill assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11723932
Mileage unknown · Mar 6, 2026
Power Train
On [XXX], approximately 17 hours after purchasing this vehicle from a licensed dealer, the transmission began violently jerking, shuddering, and hesitating without warning while traveling at highway speed in Alabama. The sudden loss of smooth vehicle control created an immediate risk of collision with other vehicles. Diagnostic…
Read full complaint
On [XXX], approximately 17 hours after purchasing this vehicle from a licensed dealer, the transmission began violently jerking, shuddering, and hesitating without warning while traveling at highway speed in Alabama. The sudden loss of smooth vehicle control created an immediate risk of collision with other vehicles. Diagnostic evaluation at O'Reilly Auto Parts confirmed fault code P0741 — Torque Converter Clutch Circuit Performance or Stuck OFF. A subsequent Honda dealership evaluation confirmed this as a PERMANENT DTC, meaning the fault existed across multiple drive cycles prior to purchase and prior to the failure event. I am aware that Honda previously acknowledged this transmission defect in 2016-2017 Honda Pilots and extended the warranty to 150,000 miles. This vehicle failed at 152,848 miles.... just 2,848 miles beyond that threshold. Honda USA denied goodwill assistance based solely on mileage. A permanent fault code cannot be cleared by battery disconnect. The defect was pre-existing at time of sale. The dealer listed the vehicle as having "No Issues." The dangerous transmission behavior at highway speed represents a serious ongoing public safety risk for any owner of an affected vehicle. I am requesting formal investigation and recall consideration for this known defect. Two independent repair facilities have confirmed transmission replacement is required. Estimated repair cost: $5,374 to $7,000. We have parked this dangerous vehicle until we can find a way to INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11722599
Mileage unknown · Feb 16, 2026
Power Train
Transmission and torque converter, were effected on my car. Safety concerns were witness when wife was driving on freeway with our 4 kids and car was jerking and not going like it’s was suppose to. We drove to slow lane were we proceeded to destination slowly . Problem was detected when transmission light came on when my wife a…
Read full complaint
Transmission and torque converter, were effected on my car. Safety concerns were witness when wife was driving on freeway with our 4 kids and car was jerking and not going like it’s was suppose to. We drove to slow lane were we proceeded to destination slowly . Problem was detected when transmission light came on when my wife and sister in law were driving on freeway. America Honda didnt want to look into it due to it being out of there warranty-of 150,000. So we took it to a transmission shop. We’re he diagnosed the code for the torque converter. The warning light came on at 166,000 miles. Thats when we’re actually aware of the issue. We never received a letter or call from America Honda warranty regarding this issue.
NHTSA ODI #11718371
Mileage unknown · Feb 5, 2026
Power Train
I am submitting a safety complaint regarding a 2017 Honda Pilot experiencing a connecting rod bearing failure. Which has left my vehicle disabled. While driving on I-270 North, the vehicle suddenly made a loud “pop” noise and immediately lost power, creating a dangerous situation on a busy highway. Shortly afterward, the engine…
Read full complaint
I am submitting a safety complaint regarding a 2017 Honda Pilot experiencing a connecting rod bearing failure. Which has left my vehicle disabled. While driving on I-270 North, the vehicle suddenly made a loud “pop” noise and immediately lost power, creating a dangerous situation on a busy highway. Shortly afterward, the engine developed a very loud knocking noise, consistent with internal engine failure. The vehicle does not need to reproduce the concern, as multiple technicians were able to immediately hear the knocking upon inspection. The issue is constant and clearly present. There were no warning lights, no check engine light, and no prior indications of failure before the incident occurred. This sudden failure without warning presents a serious safety risk, especially at highway speeds. The vehicle has been regularly inspected and serviced, including services performed in dealership settings. The vehicle is currently available for inspection if needed. I am aware that similar model years have been affected by connecting rod bearing issues, and I believe this vehicle should be included or further investigated due to the sudden and dangerous nature of the failure.
NHTSA ODI #11715999
120,000 miles · Feb 5, 2026
Power Train
The contact owns a 2017 Honda Pilot. The contact stated that while driving between with the RPM between 2,000 and 2,500, the vehicle bucked. There was no warning light illuminated. The vehicle was taken to the dealer, where a transmission triple flush was performed; however, the failure recurred within 1-2 months. The vehicle wa…
Read full complaint
The contact owns a 2017 Honda Pilot. The contact stated that while driving between with the RPM between 2,000 and 2,500, the vehicle bucked. There was no warning light illuminated. The vehicle was taken to the dealer, where a transmission triple flush was performed; however, the failure recurred within 1-2 months. The vehicle was taken to an independent mechanic, where the transmission was serviced several times; however, the failure reoccurred. Transmission fluid was added to the vehicle; however, the failure persisted. The dealer was notified of the failure and advised the contact that another diagnostic test was needed. The vehicle was not repaired. The contact related the failure to TSB: 16-091 (Judder from the Torque Converter Lock-Up Clutch); however, the model year was not included. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 120,000.
NHTSA ODI #11715955
Mileage unknown · Jan 13, 2026
Power Train
I received a letter from Honda regarding a warranty extension on the torque converter of my 2017 Honda Pilot. When I took the vehicle into the dealership, their senior technician confirmed the mechanical issues happening with the vehicle are aligned with the description of the concerns outlined in the warranty extension. The onl…
Read full complaint
I received a letter from Honda regarding a warranty extension on the torque converter of my 2017 Honda Pilot. When I took the vehicle into the dealership, their senior technician confirmed the mechanical issues happening with the vehicle are aligned with the description of the concerns outlined in the warranty extension. The only element of the extension condition that was not happening was a code popping up on the screen. When I asked what conditions would need to take place for the code to pop up, they stated the torque converter would seize up while driving and cause the vehicle to be a hazard to those in the vehicle. When I explained this to Honda, they continued to deny the repair since the code did not populate. I am asking the NHTSA to look into this matter as I assume the purpose of the warranty extension was to repair an issue that could cause serious injury to the inhabitants of the vehicle, and not to rely on an electronic error code to pop up. Thank You
NHTSA ODI #11710654
Mileage unknown · Dec 14, 2025
Electrical SystemEnginePower Train
Transmission locked up and had to be replaced April 8 of 2025. I was blessed it did not lock up while I was driving, but did as soon as I pulled in my driveway. While driving that evening I had some issue with it not downshifting. When stopped in driveway could not restart the car. Had to have a special tow truck take it to the …
Read full complaint
Transmission locked up and had to be replaced April 8 of 2025. I was blessed it did not lock up while I was driving, but did as soon as I pulled in my driveway. While driving that evening I had some issue with it not downshifting. When stopped in driveway could not restart the car. Had to have a special tow truck take it to the repair shop. I never got a warning light regarding the transmission needing to be checked. I had issues prior to the lock up, engine revving, gearshifting too late. Obvious transmissions issue. As I never got a warning light no code would show to have it repaired. I took it to the honda dealer for repair. After the replacement with another 9 cyclinder transmission the autoshut off is problematics causing me to stall out when stopping at lights and intersections. I had a previous experience with the 1999 honda odyessy and had 3 transmissions replaced. I am concerned about my safety as I could only replace it with another Honda 9 cylinder transmission.
NHTSA ODI #11704976
Mileage unknown · Dec 3, 2025
Power Train
I took my vehicle (2017 Honda pilot) to a Honda dealer in Selma, TX to have a pre-road trip checkup. They performed mileage related maintenance and assured me the vehicle was ready for my 2200 mile road trip. 600 miles into the trip, I stopped for gas. As I put the car in park, I received multiple errors on the driver's info pan…
Read full complaint
I took my vehicle (2017 Honda pilot) to a Honda dealer in Selma, TX to have a pre-road trip checkup. They performed mileage related maintenance and assured me the vehicle was ready for my 2200 mile road trip. 600 miles into the trip, I stopped for gas. As I put the car in park, I received multiple errors on the driver's info panel. "1.Emissions system problem. 2.Transmission system problem. 3.Stop driving when safe. Transmission problem. See manual." Without any warning there was complete and sudden failure of the transmission. The car is available for inspection at a Honda dealer in Little Rock, AR where they ran diagnostics and found a list of problems. Apparently the Honda dealer in TX saw at least one of the errors and deleted it without informing me. If the transmission had failed while I was driving on the highway, average speeds of 70 mph, it could have caused a fatal accident. Right now the failed transmission has only been inspected by the Honda service dept in Little Rock, AR. There were no warnings from the vehicle to the driver prior to the complete and sudden failure whatsoever. After the failure the power train was locked in park. Drive, reverse, and neutral could not be engaged. I understand the mileage on the vehicle is high, but it is a grave safety concern when a major component of a vehicle can fail without reason or warning.
NHTSA ODI #11702762
Official recalls
4Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration